冶金钢铁行业英文词汇

钢铁⾏业专业英⽂词汇(aluminium) killed steel （铝）镇静钢1b 磅abbreviation 缩写abrasion-resistant 耐磨损的A-C vector driver 交流向量驱动access 使⽤或进⼊之途径，通路accessibility 可达性，可接近性accessory (attachment)accommodate 供应accomplish 完成accumulator 活套accuraccy 准确性，精密性ACFM average cubic feet per minite 平均⽴⽅英尺/分钟1⽴⽅英尺=35.3147⽴⽅⽶acid concentrate 酸浓缩acid contaminate waste water 酸污染废⽔acid fume 酸雾acoustic 听觉的、声学的actual 真实的actuate 开动,使动作,作⽤,励磁acuator 调节器,激活器,执⾏机构adapter 联接器，接合器adequate 充⾜，适当adjacent 邻近的administration ⾏政管理AGC automatic guage controlagency 机构agitation 摇动air box 风箱air compressor 空⽓压缩机air duct 风管，通风管道air oven 热空⽓⼲燥炉algorithm 计算法align 使成⼀条直线，对准，校直alignment 调整，排成直线alkaline 碱的、含碱的alkalinity 碱度allowance 许可，承认，余量alpha/numberic 字母数字混合编排的alternate 交替altitude ⾼度alumize 铝化，渗铝ambience 环境温度ammonia 氨⽓anchor 锚，固定器，⽀座ancillary 辅助的,附属的angle bar 三⾓铁annealing pickle lineannealing treatmentANSI American National Standards Institute美国国家标准协会anticipate 先做，盼望anti-finger steel plate 耐指纹钢板antirust oil 防锈油appertain 所属appliance 器具applicable 适⽤的applicator roll 涂覆辊appropriate 适当的approve 批准，认可，赞成archival 档案的arrangement 排列，布置，配置，装配，安装as-built drawing 竣⼯图ASC automatic shape controlassembly 部件，组件，装置，组装assembly parts 组合件assessment 评价assistance 帮助assume 假定atomize 雾化attain 到达，得到authorize 批准，授权automatic coil bending station 带钢⾃动打捆站auxiliary 辅助的availibility 有⽤的，可资应⽤性，利⽤率，有效性axis 轴back tension 反张⼒back-up roll ⽀撑辊backward curve type fan 后曲叶⽚式风机backward-inclined type fanbaffle plate 挡板banding strap 捆带base frame 底座base strip(plate)batch annealing 罩式退⽕battery limit 界区bay 跨beam 光线，横梁，照射bearing 轴承bearing chockbearing race 轴承座圈bearing-load-distribution 轴承载荷分布bed plate 底板，地脚板（轧机）belt wrapper ⽪带助卷机bench levelbench mark ⽔准点,基准bilateral tradebillet ⽅坯bite 辊缝，咬⼊bivalent ⼆价bladder ⽓囊blade ⼑峰bloom ⼤钢坯、钢锭、初轧⽅坯board 配电盘board chair 董事长bogie 转向架boiler 锅炉，汽锅，蒸煮器boiling steelborer 镗床brace （⽀持，拉紧，振奋）斜撑，⽀柱，系杆，⼿摇钻brake 煞车器，掣动，煞车breaker roll 破鳞辊bridle set 张紧装置bright annealing 光亮退⽕bronze 青铜bronze bushing 青铜轴套BTU British Thermal Unit 英国热量单位 1BTU=262Kbuckle 中间浪,皱,纹buffer 缓冲器bumper 保险杠、消⾳器buna 丁（⼆烯）钠（聚）橡胶，布纳橡胶bundle （光、维管、波）束、捆、扎burr,flash ⽑刺bush(ing) 轴套，轴衬，衬⽡，（电）绝缘套管butt welding 对焊by means of ⽤、、、的办法cable rack 电缆架calcium 钙calibration 标准、校准caliper 卡尺、卡盘；制动卡盘callout 插图的编号calorific ⽣热的cam 凸轮，;偏⼼轮，样板，靠模，仿形板cam roller 凸轮辊camber 翘曲镰⼑弯carbon block 碳精块carbon dioxidecarbon monoxidecarriage 搬运车carry over table 运输辊道carryover-conveyor 转换运输机cartridge 卡盘,暗盒cascade 级联，⼩落瀑casing 套罩、箱外壳、套管cast 熔炼，铸造，铸件，[冶]浇注，铸锭，炉次cast iron 铸铁casting 浇铸catalogue ⽬录，编⽬录catalytic 催化的catenary 悬索，[压]（带钢）垂度，弛度caustic 腐蚀性的cell 光电元件central pipe 中⼼缩孔(缩管)centrifuge 离⼼ceramic 陶瓷chain conveyor 链式运输机check valve 逆⽌阀，⽌回阀chemical constitution 化学成分chloride 氯化物chop 碎断chrome 铬chronological 编年的chute 槽，斜槽，滑槽，溜槽circuit breaker 断路开关，断路器circular shear 圆盘剪circumference force 切向⼒civil work ⼟建clading,film 镀层clam 夹具，台虎钳，钳⼦，夹⼦clamp ⽼虎钳，钳clearance 余隙，间隙，清除，扫除，许可clutch 离合器coarse 粗糙的coefficient 率，系统coil break 横褶纹coil centering 带卷定⼼coil peeler 带卷直头机cold drawn 冷拔Cold Laminator 冷覆膜机cold rolled stripcold tandem millcollapse （坍，崩溃），回缩collapsible 折叠的，胀缩的colour coated stripcolumn 柱⼦，栏，塔，蒸馏塔，萃取塔，吸咐塔combustion 燃烧comment 评注，批评commission 使⽤(试运转)compatible 兼容的compensate 补偿，均衡，校正，（⾦属，合⾦的）调质compensator 膨胀圈,膨胀接头compliance 顺从concentrically 同轴的concrete 混凝⼟condenstate 冷凝，回流conductivity 传导率，电导率，传导性，导电性，导热率conduit box 接线盒consective 连接作⽤consideration 考虑consistent ⼀致的console 控制台，仪表板consortium 合伙constrain 强迫、压制、束缚、约束construct 构造物，建造，构成consume ⽤尽，毁灭contamination 污染、玷污、放射性污染、混淆contour 轮廓线,外形,等⾼线contract 合同，协议contractor ⽴契⼈，承包商control cubicle 控制柜control valve 操纵阀，控制阀convection 对流conversion 转变conversion coating 转换层（辊涂后）convertor 转炉conveyor 运输机，输送机，传送机，移送机coordination 调整,配合corrosive 腐蚀性的corrugate ⽡楞、波纹council 委员会，政务会coupling section 连接部分cover plate 盖板CPL continuous pickling line 连续酸洗⽣产线cradle ⽀架，摇架cradle rolls 托卷辊crate ⼤板条箱，⽤⼤板条箱装crimping 皱褶，波纹crop shear 切头剪cross-tie 枕⽊，轨距，连杆，横向拉杆，横⽊curcuit 电路，回路，系统，流程，循环customs inspection 海关检查cutting gap 剪切间隙CVC continuous variable crown 连续可变凸度cyclone 旋风,离⼼除尘cylinder block 缸组，缸体dam up 筑坝，阻⽌damper 阻尼,缓冲,减震器,风门DC bus 直流母线debrics 碎⽚、屑deburring 去飞边，去⽑刺，去⽑边decarburization 脱碳deck 盖，甲板，桥⾯，台⾯dedicate 供奉，奉献deflector 导向挡板degree of finish,smoothness 光洁度deionize water ⽆离⼦⽔，脱离⼦⽔deliberate 考虑、斟酌delivery coil car 出⼝带卷⼩车delve 挖掘、钻研denominate 命名depict 描绘、描述depletion 消耗，排除deploy 展开、部署、调度deposition 沉积，沉淀，析出designation strip 名牌、标签detergent 清洁剂、除垢剂dethreading 甩尾deviation 偏差,漂移dew point 露点diagnostic 有助于诊断diaphragm 隔板、挡板、孔板differential 微分discharge pipe 排出管disconnect 拆开，使分开（离）disconnected-switch 隔离开关discreeet 考虑周到的，谨慎的discrepancy 不同disengage 解脱，松开Disk Brake 盘式制动器dismantling stooldissipation 消散,消耗,损耗distill 蒸馏除去distribution thansformer 配电变压器dividing shear 切分剪downpayment 定⾦drainage 排⽔,阴沟draw off 抽取，排泄drive spindle 传动轴drop separatordrum 圆筒，⿎drum shear 滚筒剪duct 管道ductile 可延伸的ductile iron casting 球墨铸铁件due time 到期durability 耐久duty-cycle ⼯作循环，⼯作周期dynamically balanced 动平衡economic benefiteddy-current test 涡流探伤edge drop 边部减薄EDM=Electron Discharge Machining 放电加⼯EDPM 三元⼄丙橡胶elaborate 详细拟定elapse 过去、消逝elastic constantelastic deformation 弹性畸变electrical room 主电室elevation ⾼度，⾼处，提升，正⾯图，⽴式图elevator 升降机，电梯elongation percentage 延伸率embed 安插，埋置Embosser 热压花机empiric 根据经验的emptying 沉淀物emulsion 乳剂encapsulation 密封、包胶enclosed speed reducer 全封闭的减速机enclosure 套，盒，箱，包围，围绕，封⼊，外壳endless belt 两头对接的环带endurance 耐久⼒endurance limit (fatigu limit ) 持久极限，疲劳极限engage （齿轮）啮合，使紧密联接ensure 保证entry guid ⼊⼝导轨EPOXY Resin (EP) 环氧树脂equalizer 均衡器equivalent 当量，等效值erection schedule 安装进度erection supervision assistance 制造监理ergonomic ⼈体⼯学、⼯效学、⼈与机械控制ethernet 以太⽹evaporator 蒸发器eveness 均整性evolve 发展、进化、离析、引申excavation 挖掘excentricity 偏⼼exclusion 排斥exert 发挥,尽⼒expanding cylinder 膨胀缸expansible coil preparatory coiler 胀缩卷筒式带材预卷机explosion 爆炸explosion proof lighting 防爆照明extractor 提取、萃取器、抽提塔extrusion 挤压fabricate 构造、建造、杜撰fabricate 建造fabricated steel construction 预制钢结构Fabricated Frame 预制钢结构facilitate 使变的容易的，促进factor 系数，因素，因⼦，因数，乖数feed table 进料盘feed-forward 前馈ferritic 铁素体ferrous 含铁的、铁素体的festoom 花彩、垂花饰fillet （模型或芯盒上的）圆⾓条，倒圆⾓，嵌条finishing coat ⾯漆finishing machining 精加⼯finite element method 有限元法fittings 配件，连接件，零件，器材，仪器fixture 设备，夹具，装置器flange 法兰flap ⽚状悬物,舍阀,舍flattener roll 矫直辊flexible 伸缩⾃如的，柔性的float valve 浮筒阀flowrate 流量，流速FLT full load torquefluctuation 波动、摆动flue gas 烟⽓fluid 流体fluorocarbon 碳氟化合物flying crank shear 曲柄式飞剪FOB freight on board 离岸价格foil 压薄、薄⽚forged 锻造的fork lift 叉车foundation 地基，基础fracture 破裂、断⼝friction 摩擦friction factorFSIR full spectrum infraredfuel 燃料fulcrum ⽀点fused switch 熔断开关galvanized sheetgangway 通道,过桥gap 辊缝gasket 衬垫，垫圈gauge 规格，估计，量规计gear case 减速箱壳gear rack 齿条girder 梁,垳架gloss range 光泽度范围gradient 梯度granite 花岗岩grate 铁栅栏，格栅grease lubrication ⼲油润滑grid 栅格grinder,grinding machine 磨床grit blast, spray sand 喷砂，喷丸groove 凹槽gross 总重grounding cables 接地线grout 灌浆guard 保卫，防护，挡板gutter 阴沟、⽔槽hand railing 扶⼿，栏杆hand-over position 交接区harmonic 谐波headquarter 总部、司令部heat expantionheating furnace 加热炉helical 螺旋的，螺线，螺旋线（⾯，形，状）helid 氦化物heoprene 氯丁（⼆烯）橡胶hermetical 密封的herringbone ⼈字形hierarchical 阶级的high dynamically loaded bolt ⾼强螺栓high order ⾼位,⾼次high pressure hot waterhinge 铰链、铰接histogram 直⽅图historical 史学的hoist 起重机hold-down roll 压紧辊homogeneity 同质、均匀性、齐次homogeneous 同族的、单⼀的、同次的hood 罩，盖，帽，烟罩，通风，橱horn 警报器hose 软管，⽤软管引⽔hot rolled striphousehold [electrical] appliance 家电housing 框架HTR High Tech Rolling humidity 潮湿hung 悬挂了hydralic bolt tightener 液压扳⼦hydralic screwdown 液压压下hydraulic accummilator 蓄能器hydraulic cylinder 油缸hydridehydrochloric acid 盐酸hydrogen 氢⽓hydrostatic lubrication 静液压润滑hypalon 氯磺化聚⼄烯橡胶hypothesis 假设hysteresis 滞后I.D. indetification idle roller 空转轮，惰轮ignition hood 点⽕器immersion cell 沉浸槽impact 撞击impart 分给impeller 推动者（器）叶轮impinging flow 射流in accordance with 依据inaccessible 达不到的，难接近的incorporate 合并indication 表⽰，象征indispensable 不可缺少individually 单独地inductive 电感，归纳（法）的inert gas arc welding 惰性⽓体保护(弧)焊inertia 惯性，惯量infrared ray 红外线ingot （铸）锭inhibit 制⽌，禁⽌initiate 引发，使⼊会，开始inlet side ⼊⼝侧inspection 视察，检查instrumentation 器械操作，仪器，仪表insulation 绝缘，绝热integrate 整合，集成intensity 强度，强烈，剧烈interchangeability 可交换性，互换性intercom 室内对讲对话，内部通信装置interconnecting piping 连通管路interface 接⼝interlock 连索互结intermediate roll 中间辊interrogate 询问、质问intervention 介⼊、调停、⼲涉inverter 换流器，变换器，反相器，转换开关ionize 电离isolating transformer 隔离变压器isolation transformer 隔离变压器jack scraw 千⽄顶螺杆，起重螺杆joint shaft 接轴junction box 汇接室，分线箱，接线盒，套管，连轴器keeper plate 轧辊轴承座压板kick off meeting ⾸次会议L/C lisence credit 信⽤证laminar 层⽚、叶⽚lap welder 搭接焊lateral 侧⾯的layout 布置，规划，设计lean gas 贫（瘦、⼲、废）（煤）⽓least square 最⼩⼆乘ledge 横档，壁架levelling instrument ⽔准仪light-gauge 薄尺⼨lightning 雷,闪电limb of electromagnet 电磁铁铁⼼limit switch 极限开关，终点开关linkage 连接，链系，联动装置，杠杆机构liquid nitrogen 液氮lithium chloride 氯化锂load cell 测压仪，测⼒计，发送器loading skid 装载滑轨lockout relay 连锁继电器longitudinal 轴向的，长度的lower limit of strengthLPG liquefied petroleum gas 液化⽯油⽓machinical propertymagnitude ⼤⼩，数量，等级make-up air 补给空⽓malfunction 不正常⼯作、动作失调mandrel diameter 芯轴直径manhole （检修⽤）⼈孔，检查孔，舱⼝manifold 集管,多头导管marine 海的，海（磨、冲）蚀martensitic 马⽒体masher 捣碎mashine steel 机械（零件）⽤钢(0.2-0.3C) mass moment of inertia 质量惯性矩mass ratio 始末质量⽐mass/volume flow control (VFC)质量流控制matrix 矩阵，发源地，模型mature 成熟的measuring staff(rod) 测量棒mechanism 机构，机械装置，机理melting point 熔点metallurgy 冶⾦学metastable 亚稳定mezzaine 夹层、中层楼mica 云母mild steel 低碳钢mill length 轧制长度miller 铣床misalignment （中⼼线）未对准，不重合，mitigate 减轻、缓和moment 矩,动量Monorail Structure 单轨结构件Morgoil bearing 油膜轴承mortar 灰浆Mota 锡基⾼强度轴承合⾦mould typemounting 装置MTBF mean time between failure平均故障影响时间muffler 消声器multiple 多重的，复合的，倍数naphthalene 萘NEMA National Electrical Manufacturers Association（美国）全国制造商协会neoprene 氯丁橡胶、氯丁⼆烯niobium[nai5EubiEm] 铌nip 咬⼊、辊隙nipple 喷嘴,螺纹接套nitrile 丁腈橡胶nom 公（标）称nominal value 额定值、标称值normalise 正⽕notch 缸⼝，刻痕，凹槽，嘴⼦numeric 数字，数值，分数，不可通约数obstruction 阻碍、妨碍occupational 职业的off-load 卸载optimum 最好条件option 挑选物，选择，选择权organic 有机的orifice 洞，孔orifice meter 孔板流量计O-ring seal 圆环密封ovality 椭圆度oven inner liner 加热炉内衬over picklingoverhead craneoverhung 悬垂的overlap 重叠overspill 溢出，溢出物，溢流，[机]排出润滑油overwind 上开卷oxideoxygenp.f. power factor 功率因数packing 包扎，打捆，填料，衬料pad 底垫，衬垫，垫料，垫⽚，垫圈padlock 挂锁paint 漆panel 板，盘，屏，开关板，控制板，配电盘parabolic 抛物线parallel 平⾏的，相同的parameter tableparticulate 粒⼦parting shearpass 孔型,轧槽,道次pass line 轧线patent 专利pay-off coiler 开卷机pay-off cradle 开卷箱座pay-off drum 开卷机卷筒pay-off housing 开卷机机架pay-off reel 开卷机penertation 渗透permanent 永久的permit [环保](废物排放)许可证perpendicular 直⽴的，垂直的personnel ⼈员，职员pertiment 适当的、贴切的、相应的petroleum ⽯油phenolic (苯)酚photocell 光电元件photo-electric 光电（效应）的PI diagram piping and instruments diagram pickling bath 酸洗槽piling 打桩pillar ⽀柱、墩pillow block 枕垫、垫块pilot flame 引燃⽕⾆pilot valve 导阀,辅助阀,控制阀pin 针，销，细杆，旧棒pinion 传动齿轮，⼩齿轮piston rod 活塞杆pivot 轴尖、枢轴pivotable guide table 绕枢轴旋转的导板台planer 刨床plasticityplatform 场，平台，站台，装卸台plausibility 似乎合理plot 绘图、曲线、地块plug 塞⼦ply 层，厚度plywood 夹板，层板pneumatic ⽓动polypropylene 聚丙烯polyurethane 聚氨基甲酸（⼄）酯portuguese 葡萄⽛的（⼈）positive 明确的，正的，阳性的PP pressure-proof 耐压的PP plastic product 塑料制品pre-assembly method 预置装配法precise 精确的preliminary 初步，开端pressductor 压⼒传送器pressure reducer 减压阀pressure switch 压⼒开关，压⼒继电器pressurization 加压prevail 成功，流⾏，胜过primer 底漆primer base 底漆涂料prior 在先的procurement 采购,获得profile 板形property 性质proprietary 专利的province 职权范围provision 供应，规定，预备proximity switch 接近开关PTFE 聚四氟⼄烯pulley 滑轮,滚筒purchase 换取，购买purge 吹扫、清洁pushbotton 按钮，电钮pvc (polyvingl chloride ) 聚氯⼄烯quarter 1/4 浪quench 淬⽕quenching and temperingrack 架⼦，齿轨rack-and-pinion 齿轮齿条rate 估价，⽐率rated 额定的，标准的reaction equation 反应⽅程式reactive power ⽆功功率recess 凹进处，凹⼝，凹槽，退⼑槽recovered acid 回收的酸rectifier [电]整流器，检波器recuperate 回收、余热利⽤redundant system 冗余系统reel mandrel 卷筒reflective 反射的regressive 回归regulation 规则，管理regulator 调节器，调节装置，稳定器reinforced concret 钢筋混凝⼟relative humidity 相对湿度release 释出，解除联锁断开relief valve 安全阀，保险阀remote I/O rack 远程输⼊／输出机柜removal 移动reserve volume 储备量reservior 容器、贮⽔池、⽔箱residul error 残留误差resistance of deformationresonant frequency 谐振频率responsibility 任务，责任rest ⽀撑retention 保留，滞留（物）retract 伸缩revamping 修补、改造reversible 可逆的rewind 重卷，重绕ridge 屋脊、⼭脊rigid 刚性rigidity 刚性rinse 冲洗，轻冼RMS root mean square value均⽅根，有效值roll barrel 滚⾝roll bearing 轧辊轴承roll neck 辊颈roll wear 轧辊磨损roller bearing 滚柱轴承roller chain 辊⼦链rolling radius 轧制半径rolling schedule 轧制程序表rolling solution 轧制⼯艺润滑冷却液rolling speedrolling stock 机动车辆,轧制⽑坯rope pulley 绳轮rough machining 粗加⼯roughness 粗糙度rubber lining 橡胶衬⾥saddle 马鞍，鞍状物safety coupling 安全连轴器safety guard 安全设施，保险板sample preparetion 取样sanitary 公共卫⽣的,消毒的,公共厕所satisfactory 今⼈满意的saturation 浸透，饱合，饱合状态scaffold 脚⼿架scale exhaust 除鳞scale layer 鳞层schematic drawing ⽰意图,结构图,原理图scrap bucket 废料⽃（槽）scratch 擦痕screw down 螺旋压下机构screw jack 螺旋千⽄顶scrubber 洗涤器seal 封闭seamless ⽆缝的，整拉的sectional steel 型钢segment ⼸形体，扇形体，段，节，⽚seismic coefficient 地震系数self-commuted ⾃换向self-tuning ⾃调seperating disc 分离圆盘service factorService Hoist 电葫芦shallow tank 浅槽shield 防护，屏蔽，护罩shield gasshift 移动shim 垫⽚shock absorber 减震器shrink 收缩，退缩，缩⽔shroud 罩shuttering 模板shuttle 棱，来回移动sickle shaped 镰⼑弯side guide 侧导轨side trimming 齐边side-set cylinder 横移液压缸sight 观察silicon dioxidesilicone modified polyester 硅改性树脂sinter plant 烧结⼚skew 斜、不对称Skew/Synchromous Run Controlskid 刹车，刹着车滑⾛slab casting 板坯连铸slabing 板坯sleeve 套筒slice 薄⽚slide vavle 滑阀sliding base 导向轨座（机座可以沿其移动）sliding frame 滑座sling 吊索slitting shear 纵切slope 坡道，斜⾯，坡度，斜度sludge 淤泥、残渣SMPS switch-mode power supply开关电源snubber roll 缓冲辊,减震辊,抱辊soleniod valve 电磁阀solution treatment 固溶处理spangle 锌花spare part 备件spark-ignited 电⽕花点⽕specific weight ⽐重specification 规格，说明书spectrum 谱、光谱speed cone 变速锥spindle carrier 接轴托架spindle nose 轴头spiral conveyor 螺旋型运输机splash 飞溅splice 接合、拼合split-out 分交spray-off 喷射spring equation 弹跳⽅程sprocket 链（星）轮、链轮铣⼑squeezing roll 挤⼲滚stage 步骤，时期，阶段stagger 交错、间隔stainless steel construction 不锈钢结构stairway 楼梯stand-by 备⽤。

钢铁行业常用英语词汇钢铁行业常用英语词汇Austenitic Stainless Steel 奥氏体不锈钢Ball Bearing Steel Strip 滚珠轴承钢带Ball Race Steel 滚珠轴承圈钢Ball-Bearing Steel 滚珠轴承钢Band Steel 带钢Banding Steel 带钢; 箍钢Bar Steel 棒钢; 条钢Bearing Quality Steel 滚珠钢Bearing Steel 轴承钢Abrasion-Resistant Steel 耐磨钢forge 锻造press 压锻alumina 铝cast iron 铸铁cast iron ingot 铸铁锭soft iron 软铁pig iron 生铁wrought iron 熟铁iron ingot 铁锭round iron 圆铁scrap iron 废铁steel 钢stainless steel 不锈钢electric steel 电工钢,电炉钢high-speed steel 高速钢moulded steel 铸钢refractory steel 热强钢,耐热钢alloy steel 合金钢plate, sheet 薄板tinplate, tin 马口铁finished product 成品,产品semifinished product 半成品,中间产品metal strip, metal band 铁带,钢带billet 坯锭,钢坯profiled bar 异型钢材shape, section 型钢angle iron 角钢wire 线材ferronickel 镍铁fusion, melting, smelting 熔炼refining 精炼heating 加热preheating 预热tempering 回火temper 回火hardening 淬水annealing 退火reduction 还原cooling 冷却decarbonization, decarburization 脱碳coking 炼焦carburization 渗碳case hardening 表面硬化cementation 渗碳nitriding渗氮alloy 合金rolling 轧制drawing 拉拔extrusion 挤压wiredrawing 拉丝forging 锻造turning 车削milling 铣削machining, tooling 加工arc welding 电弧焊electrolysis 电解blowhole 气孔Aluminium-steel Cable 钢铝电缆Aluminized Steel 涂铝钢Aluminum Nickel Steel 铝镍钢Angle Steel Ruler 钢角尺Annealed Sheet Steel 退火薄钢板Annealed Steel 退火钢; 韧钢Cold-Strip Steel 冷轧带钢Cold-Strip Steel Rolling Mill 冷轧带钢机; 带钢冷轧机Cold-Worked Steel 冷作钢Cold-Working Steel 冷作钢Color Stainless Steel 彩色不锈钢Colored Stainless Steel 彩色不锈钢Common Straight Carbon Steel 普通碳素钢Complex Alloy Steel 多元合金钢; 合金钢Carbon Construction Steel碳素结构钢Carbon Tool Steel碳素工具钢Alloy Construction Steel合金结构钢Alloy Tool Steel合金工具钢High Speed Tool Steel高速工具钢Spring Steel弹簧钢Stainless & Heat Resisting Steel不锈耐热钢Bearing Steel轴承钢Ibeam工字钢Round Steel普通圆钢Channel槽钢Flat Steel Bar扁钢Equal Angle Steel等边角钢Unequal Angle Steelh不等边角钢Hbeam型钢Billet,Bloom钢坯Steel Plate中厚钢板Hot Rolled Steel Coil热轧钢板（卷）Cold Rolled Steel Sheel or Coil冷轧钢板（卷）Galvanized Steel Coil镀锌钢板（卷）Steel Strip钢带Wire Rod Coil线材Seamless Steel Pipe无缝钢管Pressure Pipe高压管Basic Pig Iron炼钢生铁foundry Pig Iron铸造生铁Steel Wire Rope钢丝绳Carbon Steel Plate 碳素钢板; 碳素钢板和型材Carbon Tool Steel 碳工具钢; 碳素工具钢Carbon-Containing Alloy Steel 含碳合金钢Carbon-Free Stainless Steel 无碳不锈钢Carbon-Free Steel 无碳钢Carburizing Steel 碳钢Cast Iron Electrode With Steel Core 钢芯铸铁焊条Cast Stainless Steel 铸造不锈钢Chilled Hardened Steel 淬火钢Clad Sheet Steel 包层薄钢板Clad Steel 包层钢; 双层钢; 双金属钢Clad Steel Plate 复合钢板Cladding Steel Sheet 复合钢板Clean Steel 纯净钢; 洁净钢Coated Steel 镀层钢板Coating Steel Pipe 镀锌钢管Cobalt High Speed Steel 钴高速钢Cobalt-Chromium Steel 钴铬钢Coiled Steel 成卷带钢Cold Forging Steel 冷锻钢Cold Pressed Steel 冷压钢Cold Reduced Steel 马口铁卷板Cold Rolled Ribbed Steel Bar 冷轧竹节钢筋Cold Rolled Sheet Steel 冷轧薄钢板Cold Twisted Steel Bar 冷扭钢筋Cold-Banded Steel Pipe 冷箍钢管Cold-Drawn Steel 冷拔钢; 冷拉钢Cold-Drawn Steel Pipe 冷拉钢管Cold-Drawn Steel Tube 冷拉钢管Cold-Finished Steel 冷加工精整钢Cold-Pressed Sheet Steel 冷压薄钢板Cold-Pressed Steel Plate 冷压钢板Cold-Pressing Quality Steel 冷弯钢Cold-Roll Steel Sheets 冷轧钢板Cold-Rolled (Cold Rolled) Steel 冷轧。

采矿mining地下采矿underground mining露天采矿open cut mining, open pit mining, surface mining采矿工程mining engineering选矿（学）mineral dressing, ore beneficiation, mineral processing矿物工程mineral engineering冶金（学）metallurgy过程冶金（学）process metallurgy提取冶金（学）extractive metallurgy化学冶金（学）chemical metallurgy物理冶金（学）physical metallurgy金属学Metallkunde冶金过程物理化学physical chemistry of process metallurgy冶金反应工程学metallurgical reaction engineering冶金工程metallurgical engineering钢铁冶金（学）ferrous metallurgy, metallurgy of iron and steel有色冶金(学)nonferrous metallurgy真空冶金(学)vacuum metallurgy等离子冶金(学)plasma metallurgy微生物冶金(学)microbial metallurgy喷射冶金(学)injection metallurgy钢包冶金(学)ladle metallurgy二次冶金(学)secondary metallurgy机械冶金(学)mechanical metallurgy焊接冶金(学)welding metallurgy粉末冶金(学)powder metallurgy铸造学foundry火法冶金(学)pyrometallurgy湿法冶金(学)hydrometallurgy电冶金(学)electrometallurgy氯冶金(学)chlorine metallurgy矿物资源综合利用engineering of comprehensive utilization of mineral resources中国金属学会The Chinese Society for Metals中国有色金属学会The Nonferrous Metals Society of China2 采矿采矿工艺mining technology有用矿物valuable mineral冶金矿产原料metallurgical mineral raw materials矿床mineral deposit特殊采矿specialized mining海洋采矿oceanic mining, marine mining矿田mine field露天矿山surface mine地下矿山underground mine矿井shaft矿床勘探mineral deposit exploration矿山可行性研究mine feasibility study矿山规模mine capacity矿山生产能力mine production capacity矿山年产量annual mine output矿山服务年限mine life矿山基本建设mine construction矿山建设期限mine construction period矿山达产arrival at mine full capacity开采强度mining intensity矿石回收率ore recovery ratio矿石损失率ore loss ratio工业矿石industrial ore采出矿石extracted ore矿体orebody矿脉vein海洋矿产资源oceanic mineral resources矿石ore矿石品位ore grade岩石力学rock mechanics岩体力学rock mass mechanics3 选矿选矿厂concentrator, mineral processing plant 工艺矿物学process mineralogy开路open circuit闭路closed circuit流程flowsheet方框流程block flowsheet产率yield回收率recovery矿物mineral粒度particle size粗颗粒coarse particle细颗粒fine particle超微颗粒ultrafine particle粗粒级coarse fraction细粒级fine fraction网目mesh原矿run of mine, crude精矿concentrate粗精矿rough concentrate混合精矿bulk concentrate最终精矿final concentrate尾矿tailings粉碎comminution破碎crushing磨碎grinding团聚agglomeration筛分screening, sieving分级classification富集concentration分选separation手选hand sorting重选gravity separation, gravity concentration 磁选magnetic separation电选electrostatic separation浮选flotation化学选矿chemical mineral processing自然铜native copper铝土矿bauxite冰晶石cryolite磁铁矿magnetite赤铁矿hematite假象赤铁矿martite钒钛磁铁矿vanadium titano-magnetite铁燧石taconite褐铁矿limonite菱铁矿siderite镜铁矿specularite硬锰矿psilomelane软锰矿pyrolusite铬铁矿chromite黄铁矿pyrite钛铁矿ilmennite金红石rutile萤石fluorite高岭石kaolinite菱镁矿magnesite重晶石barite石墨graphite石英quartz方解石calcite石灰石limestone白云石dolomite石膏gypsum硼砂borax石棉asbestos蛇纹石serpentine阶段破碎stage crushing粗碎primary crushing中碎secondary crushing细碎fine crushing对辊破碎机roll crusher粉磨机pulverizer震动筛vibrating screen筛网screen cloth筛孔screen opening筛上料oversize筛下料undersize粗磨coarse grinding细磨fine grinding球磨机ball mill衬板liner分级机classifier自由沉降free setting沉积sedimentation石灰lime松油pine oil硫化钠sodium sulfide硅酸钠（水玻璃）sodium silicate, water glass过滤filtration过滤机filter给矿，给料feeding给矿机feeder在线分析仪on line analyzer在线粒度分析仪on line size analyzer超声粒度计ultrasonic particle sizer, supersonic particle sizer4 冶金过程物理化学4.1 冶金过程热力学冶金过程热力学thermodynamics of metallurgical processes 统计热力学statistical thermodynamics不可逆过程热力学thermodynamics of irreversible processes 化学热力学chemical thernodynamics表面热力学surface thermodynamics合金热力学thermodynamics of alloys冶金热力学数据库thermodynamics databank in metallurgy单元系single-componentsystem多元系multicomponent system均相系统homogeneous system广度性质extensive property强度性质intensive property过程process等温过程isothermal process等压过程isobaric process等容过程isochoric process绝热过程adiabatic process可逆过程reversible process不可逆过程irreversible process自发过程spontaneous process自理过程physical process化学过程chemical process冶金过程metallurgical process化学反应chemical reaction化合反应combination reaction分解反应decomposition reaction置换反应displacement reaction可逆反应reversible reaction不可逆反应irreversible reaction电化学反应electrochemical reaction多相反应multiphase reaction固态反应solid state reaction气一金(属)反应gas-metal reaction渣一金（属）反应slag-metal reaction 平衡equilibrium化学平衡chemical equilibrium相平衡phase equilibrium热力学平衡thermodynamic equilibrium 亚稳平衡metastable equilibrium热力学函数thermodynamic function偏摩尔量partial molar quantity总摩尔量integral molar quantity标准态standard state焓enthalpy生成焓enthalpy of formation反应焓enthalpy of reaction熵entropy吉布斯能Gibbs energy生成吉布斯能Gibbs energy of formation 反应吉布斯能Gibbs energy of reaction溶解吉布斯能Gibbs energy of solution吉布斯能函数Gibbs energy function化学位chemical potential热化学thermochemistry热效应heat effect热容heat capacity熔化热heat of fusion汽化热heat of vaporization升华热heat of sublimation相变热heat of phase transformation放热反应exothermic reaction吸热反应endothermic reaction赫斯定律Hess’s law相律phase rule相图phase diagram一元相图single-component phase diagram二元相图binary-component phase diagram三元相图ternary-component phase diagram液相线liquidus固相线solidus共晶点eutectic point杠杆规则lever rule溶液solution溶质solute溶剂solvent固溶体solid solution溶液浓度concentration of solution摩尔分数mole fraction冶金熔体metallurgical melt金属熔体metal melt(炉)渣,熔渣slag熔盐molten salt, fused salt理想溶液ideal solution真实溶液real solution正规溶液regular solution活度activity活度系数activity coefficient拉乌尔定律Raoult’s law亨利定律Henry’s law纯物质标准态pure substance standard质量１％溶液标准(态)1 mass% solution standard无限稀溶液参考态reference state of infinityly dilute solution 相互作用系数interaction coefficient化学反应等温式chemical reaction isotherm吉布斯～亥姆霍兹方程Gibbs-Helmholtz equation质量作用定律law of mass action平衡常数equilibrium constant平衡值equilibrium value直接还原direct reduction间接还原indirect reduction金属热还原metallothermic reduction选择性氧化selective oxidation渣碱度basicity of slag光学破度optical basicity酸性氧化物acid oxide碱性氧化物basicoxide两性氧化物amphoteric泡沫渣foaming slag熔渣的分子理论molecular theory of slag熔渣的离子理论ionization theory of slag脱氧平衡deoxidation equilibrium脱氧常数deoxidation constant熔渣脱硫desulfurization by slag气态脱硫desulfurization in the gaseous state硫分配比sulfur partition ratio硫化物容量sulfide capacity氧化脱磷dephosphorization under oxidizing atmosphere磷分配比碳一氧平衡carbon-oxygen equilibrium真空脱碳vacuum decarburization去气degassing去除非金属夹杂(物)elimination of nonmetallic inclusion非金属夹杂(物)变形form modification of nonmetallic inclusion 脱硅desiliconization脱锰demanganization分配平衡distribution law化学气相沉积chemical vapor deposition(CVD)4.2 冶金过程动力学微观动力学microkinetics化学动力学chemical kinetics反应途径reaction path反应机理reaction mechanism基元反应elementary reaction平行反应parallel链反应chain reaction总反应overall reaction反应速率reaction rate反应速率常数reaction rate constant反应级数reaction order零级反应zero order reaction一级反应first order reaction二级反应second order reactionn级反应nth order reaction碰撞理论collision theory活化能activation energy表现活化能apparent activation energy阿伦尼乌斯方程Arrhenius equation半衰期half-life宏观动力学macrokinetics冶金过程动力学kinetics of metallurgical process 传输现象transport phenomena传质mass transfer传热heat transfer动量传输momentum transfer层流laminar flow湍流turbulent flow气泡gas bubble鼓泡bubbling射流jet液滴liquid droplet粘度viscosity边界层boundary layer流率flow rate通量flux扩散diffusion菲克第一扩散定律Fick’s 1st law of diffusion菲克第一扩散定律Fick’s 2nd law of diffusion扩散系数diffusion coefficient传质系数mass transfer coefficient热传导heat conduction热对流heat convection自然对流natural convection强制对流forced convection热辐射heat radiation导热率thermal conductivity传热系数heat transfer coefficient体内浓度bulk concentration未反应核模型unreacted core model扩散控制反应diffusion-controlled reaction化学控制反应chenical-controlled reaction混合控制反应mixed-controlled reaction相似原理priciple of similarity雷诺数Reynolds number固定床fiexed bed填充床packed bed移动床moving bed流态化床fluidized bed混合时间mixing time停留时间residence time, retention time催化catalysis催化剂catalyst表面能surface energy表面张力surface tension界面能interfacial energy界面张力interfacial tension润湿wetting表面活性物质surface-active substance吸收absorption吸附absorption4.3 冶金电化学冶金电化学metallurgical electrochemistry熔盐电化学electrochemistry of fused salts固态离子学solid state ionics电解质溶液electrolyte solution阳离子cation阴离子anion电导conductance电导率conductivity电阻resistance电极electrode阴极cathode阳极anode电镀electroplating固体电解质solid electrolyte稳定的氧化锆stablized zirconia氧传感器oxygen sensor硅传感器silicon sensor定氧测头oxygen probe定硅测头silicon probe4.4 冶金物理化学研究方法冶金物理化学研究方法research methods in metallurgical physical chemistry热电偶thermocouple量热计calorimeter热太平thermobalance热分析thermal analysis差热分析differential thermal analysis,DTA热重法thermogravimetry分子筛molecular sieve5 钢铁冶金5.1 炼焦炼焦coking高温炭化high temperature carbonization塑性成焦机理plastic mechanism of coke formation中间相成焦机理mesophase mechanism of coke formation 选煤coal preparation, coal washing配煤coal blending配煤试验coal blending test炼焦煤coking coal气煤gas coal肥煤fat coal瘦煤lean coal焦炉coke oven焦化室oven chamber焦饼coke cake结焦时间coking time周转时间cycle time装煤coal charging捣固装煤stamp charging推焦coke pushing焦炭熄火coke quenching干法熄焦dry quenching of coke焦台coke wharf装煤车larry car推焦机pushing machine拦焦机coke guide熄焦车quenching car焦炉焖炉banking for coke oven焦炭coke冶金焦metallurgical coke铸造焦foundry coke焦炭工业分析proximate analysis of coke焦炭元素分析ultimate analysis of coke焦炭落下指数shatter index of coke焦炭转鼓指数drum index of coke焦炭热强度hot strength of coke焦炭反应性coke reactivity焦炭反应后强度post-reaction strength of coke焦炭显微强度microstrength of coke焦炉煤气coke oven gas发热值calorific value煤焦油coal tar粗苯crude benzol苯benzene甲苯toluene二甲苯xylene苯并呋喃-茚树脂coumarone-indene resin精萘refined naphthalene精蒽refined anthracene煤[焦油]沥青coal tar pitch沥青焦pitch coke针状焦needle coke型焦formcoke5.2 耐火材料耐火材料refractory materials耐火粘土fireclay高岭土kaolin硬质粘土flint clay轻质粘土soft clay陶土pot clay蒙脱石montmorillonite叶蜡石pyrophyllite膨润土bentonite鳞石英tridymite方石英cristobalite砂岩sandstone耐火石firestone莫来石mullite氧化铝alumina烧结氧化铝sintered alumina电熔氧化铝fused alumina刚玉corundum红柱石andalusite蓝晶石kyanite,cyanite硅线石sillimanite橄榄石olivine方镁石periclase镁砂magnesia合成镁砂synthetic sintered magnesia电熔镁砂fused magnesia烧结白云石砂sintered dolomite clinker合成镁铬砂synthetic magnesia chromite clinker尖晶石spinel镁铬尖晶石magnesia chrome spinel,magnesiochromite硅藻土diatomaceous earth, infusorial earth蛭石vermiculite珍珠岩perlite碳化硅silicon carbide氮化硅silicon nitride氮化硼boron nitride粘土熟料chamotte熟料grog轻烧light burning,soft burning死烧dead burning,hard burning成型模注shaping moulding机压成型mechanical pressing等静压成型isostatic pressing摩擦压砖机friction press液压压砖机hydraulic press捣打成型ramming process熔铸成型fusion cast process砖坯强度green strength,dry strength隧道窑tunnel kiln回转窑rotary kiln倒焰窑down draught kiln耐火砖refractory brick标准型耐火砖standard size refractory brick 泡砂石quartzite sandstone酸性耐火材料acid refractory [material]硅质耐火材料siliceous refractory [material] 硅砖silica brick,dinas brick熔融石英制品fused quartz product硅酸铝质耐火材料aluminosillicate refractory 半硅砖semisilica brick粘土砖fireclay brick,chamotte brick石墨粘土砖graphite clay brick高铝砖high alumina brick硅线石砖sillimanite brick莫来石砖mullite brick刚玉砖corundum brick铝铬砖alumina chrome brick熔铸砖fused cast brick碱性耐火材料basic refractory [material]镁质耐火材料magnesia refractory [material] 镁砖magnesia brick镁铝砖magnesia alumina brick镁铬砖magnesia chrome brick镁炭砖magnesia carbon brick中性耐火材料neutral refractory [material]复合砖composite brick铝炭砖alumina carbon brick铝镁炭转alumina magnesia brick锆炭砖zirconia graphite brick镁钙炭砖magnesia clacia carbon brick长水口long nozzle浸入式水口immersion nozzle,submerged nozzle定径水口metering nozzle氧化铝-碳化硅-炭砖Al2O3-SiC-C brick透气砖gas permeable brick,porous brick滑动水口slide gate nozzle水口砖nozzle brick塞头砖stopper绝热耐火材料insulating refractory轻质耐火材料light weight refractory袖砖sleeve brick格子砖checker brick,chequer brick陶瓷纤维ceramic fiber耐火纤维refractory fiber耐火浇注料refractory castable耐火混凝土refractory concrete荷重耐火性refractoriness under load抗渣性slagging resistance耐磨损性abrasion resistance5.3 碳素材料[含]碳[元]素材料carbon materials无定形碳amorphous carbon金刚石diamond炭相[学]carbon micrography炭黑carbon black石油沥青petroleum pitch石油焦炭petroleum coke石墨化graphitization石墨化电阻炉electric resistance furnace for graphitization 石墨纯净化处理purification treatment of graphite炭砖carbon brick炭块carbon block碳化硅基炭块SiC-based carbon block炭电极carbon electrode连续自焙电极Soderberg electrode石墨电极graphite electrode超高功率石墨电极ultra-high power graphite electrode石墨电极接头graphite electrode nipple石墨电极接头孔graphite electrode socket plug 电极糊electrode paste石墨坩埚graphite crucible石墨电阻棒graphite rod resistor炭刷carbon brush高纯石墨high purity graphite5.4 铁合金铁合金ferroalloy硅铁ferrosilicon硅钙calcium silicon金属硅silicon metal锰铁ferromangnanese低碳锰铁low carbon ferromanganese硅锰silicomanganese金属锰manganese metal铬铁ferrochromium低碳铬铁low carbon ferrochromium微碳铬铁extra low carbon ferrochromium硅铬silicochromium金属铬chromium metal钨铁ferrotunsten钼铁ferromolybdenum钛铁ferrotitanium硼铁ferroboron铌铁ferroniobium磷铁ferrophosphorus镍铁ferronickel锆铁ferrozirconium硅锆silicozirconium稀土硅铁rare earth ferrosilicon稀土镁硅铁rare earth ferrosilicomagnesium成核剂nucleater孕育剂incubater,inoculant球化剂nodulizer蠕化剂vermiculizer中间铁合金master alloy复合铁合金complex ferroalloy电碳热法electro-carbothermic process电硅热法electro-silicothermic process铝热法aluminothermic process,thermit process 电铝热法electro-aluminothermic process开弧炉open arc furnace埋弧炉submerged arc furnace半封闭炉semiclosed furnace封闭炉closed furnace矮烟罩电炉electric furnace with low hood矮炉身电炉low-shaft electric furnace5.5 烧结与球团人造块矿ore agglomerates烧结矿sinter压块矿briquette球团[矿] pellet针铁矿goethite自熔性铁矿self-fluxed iron ore复合铁矿complex iron ore块矿lump ore粉矿ore fines矿石混匀ore blending配矿ore proportioning矿石整粒ore size grading返矿return fines储矿场ore stockyard矿石堆料机ore stocker匀矿取料机ore reclaimer熔剂flux消石灰slaked lime活性石灰quickened lime有机粘结剂organic binder烧结混合料sinter mixture烧结铺底料hearth layer for sinter烧结sintering烧结热前沿heat front in sintering烧结火焰前沿flame front in sintering渣相粘结slag bonding扩散粘结diffusion bonding带式烧结机Dwight-Lloyd sintering machine环式烧结机circular travelling sintering machine 烧结梭式布料机shuttle conveyer belt烧结点火料sintering ignition furnace烧结盘sintering pan烧结锅sintering pot烧结冷却机sinter cooler带式冷却机straight-line cooler环式冷却机circular cooler,annular cooler生球green pellet,ball生球长大聚合机理ball growth by coalescence生球长大成层机理ball growth by layering生球长大同化机理ball growth by assimilation精矿成球指数balling index for iron ore concentrates 生球转鼓强度drum strength of green pellet生球落下强度shatter strength of green pellet生球抗压强度compression strength of green pellet 生球爆裂温度cracking temperature of green pellet 圆筒造球机balling drum圆盘造球机balling disc竖炉陪烧球团shaft furnace for pellet firing带式机陪烧球团traveling grate for pellet firing链算机-回转窑陪烧球团grate-kiln for pellet firing 环式机陪烧球团circular gates for pellet firing冷固结球团cold bound pellet维式体wustite铁橄榄石fayalite铁尖晶石hercynite铁黄长石ferrogehlenite铁酸半钙calcium diferrite铁酸钙calcium ferrite铁酸二钙dicalcium ferrite锰铁橄榄石knebelite钙铁橄榄石kirschsteinite钙铁辉石hedenbergite钙铁榴石andradite钙长石anorthite钙镁橄榄石monticellite钙钛矿perovskite硅灰石wollastonite硅酸二钙dicalcium silicate硅酸三钙tricalcium silicate镁橄榄石forsterite镁黄长石akermanite镁蔷薇辉石manganolite钙铝黄长石gehlenite钛辉石titanaugite枪晶石cuspidine预还原球团pre-reduced pellet金属化球团metallized pellet转鼓试验drum test,tumbler test落下试验shatter test5.6 高炉炼铁炼铁iron making高炉炼铁[法] blast furnace process高炉blast furnace鼓风炉blast furnace炉料charge, burden矿料ore charge焦料coke charge炉料提升charge hoisting小车上料charge hoisting by skip吊罐上料charge hoisting by bucket皮带上料charge hoisting by belt conveyer装料charging装料顺序charging sequence储料漏斗hopper双料钟式装料two-bells system charging无料钟装料bell-less charging布料器distributor炉内料线stock line in the furnace探料尺gauge rod利用系数utilization coefficient冶炼强度combustion intensity鼓风blast风压blast pressure风温blast temperature鼓风量blast volume鼓风湿度blast humidity全风量操作full blast慢风under blowing休风delay喷吹燃料fuel injection喷煤coal injection喷油oil injection富氧鼓风oxygen enriched blast,oxygen enrichment 置换比replacement ratio喷射器injector热补偿thermal compensation焦比coke ratio,coke rate燃料比fuel ratio,fuel rate氧化带oxidizing zone风口循环区raceway蒸汽鼓风humidified blast混合喷吹mixed injection脱湿鼓风dehumidified blast炉内压差pressure drop in furnace煤气分布gas distribution煤气利用率gas utilization rate炉况furnace condition顺行smooth running焦炭负荷coke load,ore to coke ratio软熔带cohesive zone,softening zone渣比slag to iron ratio,slag ratio上部[炉料]调节burden conditioning下部[鼓风]调节blast conditioning高炉作业率operation rate of blast furnace 休风率delay ratio高炉寿命blast furnace campaign悬料hanging崩料slip沟流channeling结瘤scaffolding炉缸冻结hearth freeze-up开炉blow on停炉blow off积铁salamander炉型profile,furnace lines炉喉throat炉身shaft,stack炉腰belly炉腹bosh炉缸hearth炉底bottom炉腹角bosh angle炉身角stack angle有效容积effective volume工作容积working bolume铁口iron notch, slag notch渣口cinder notch, slag notch风口tuyere窥视孔peep hole风口水套tuyere cooler渣口水套slag notch cooler风口弯头tuyere stock热风围管bustle pipe堵渣机stopper泥炮mud gun,clay gun开铁口机iron notch drill铁水hot metal铁[水]罐iron ladle鱼雷车torpedo car主铁沟sow出铁沟casting house铁沟iron runner渣沟slag runner渣罐cinder ladle, slag ladle撇渣器skimmer冷却水箱cooling plate冷却壁cooling stave汽化冷却vaporization cooling热风炉hot blast stove燃烧室combustion chamber燃烧器burner热风阀hot blast valve烟道阀chimney valve冷风阀cold blast valve助燃风机burner blower切断阀burner shut-off valve旁通阀by-pass valve混风阀mixer selector valve送风期on blast of stove,on blast燃烧期on gas of stove, on gas换炉stove changing放散阀blow off valve内燃式热风炉Cowper stove外燃式燃烧炉outside combustion stove顶燃式热风炉top combustion stove炉顶放散阀bleeding valve放散管bleeder上升管gas uptake放风阀snorting valve均压阀equalizing valve高压调节阀septum valve炉顶高压elevated top pressure铸铁机pig-casting machine铸铁模pig mold冲天炉cupola水渣granulating slag水渣池granulating pit渣场slag disposal pit高炉煤气top gas,blast furnace gas高炉煤气回收topgas recovery,TGR非焦炭炼铁non-coke iron making直接还原炼铁[法]direct reduction iron making 直接还原铁directly reduced iron,DRI竖炉直接炼铁direct reduction in shaft furnace流态化炼铁fluidized-bed iron making转底炉炼铁rotary hearth iron making米德雷克斯直接炼铁[法]Midrex processHYL直接炼铁[法] HYL process克虏伯回转窑炼铁[法] Krupp rotary kiln iron-making 熔态还原smelting reduction铁溶法iron-bath process科雷克斯法COREX process生铁pig iron海绵铁sponge iron镜铁spiegel iron清铁法H-rion process5.7 炼钢钢steel炼钢steelmaking钢水liquid steel,molten steel钢semisteel沸腾钢rimming steel,rimmed steel镇静钢killed steel半镇静钢semikilled steel压盖沸腾钢capped steel坩埚炼钢法crucible steelmaking双联炼钢法duplex steelmaking process连续炼钢法continuous steelmaking process直接炼钢法direct steelmaking process混铁炉hot metal machine装料机charging machine装料期charging machine加热期heating period熔化期melting period造渣期slag forming period精炼期refining period熔清melting down脱氧deoxidation预脱氧preliminary dexidation还原渣reducing slag酸性渣acid slag碱性渣basic slag脱碳decarburization增碳recarburization脱磷dephosphorization回磷rephosphorization脱硫desulfurization回硫resulfurization脱氮denitrogenation过氧化overoxidation出钢tapping冶炼时间duration of heat出钢样tapping sample浇铸样casting sample不合格炉次off heat熔炼损耗melting loss铁损iron loss废钢scrap废钢打包baling of scrap造渣材料slag making materials添加剂addition reagent脱氧剂deoxidizer脱硫剂desulfurizer冷却剂coolant回炉渣return slag喷枪lance浸入式喷枪submerged lance钢包ladle出钢口top hole出钢槽pouring lining炉顶furnace roof炉衬furnace lining炉衬侵蚀lining erosion渣线slag line炉衬寿命lining life分区砌砖zoned lining补炉fettling热修hot repair喷补gunning火焰喷补flame gunning转炉converter底吹转炉bottom-blown converter酸性空气底吹转炉air bottom-blown acid converter碱性空气底吹转炉air bottom-blown basic converter侧吹转炉side-blown converter卡尔多转炉Kaldo converter氧气炼铁oxygen steelmaking氧气顶吹转炉top-blown oxygen converter,LI converter氧气底吹转炉bottom-blown oxygen converter quiet basic oxygen furnace,QBOF顶底复吹转炉top and bottom combined blown converter喷石灰粉顶吹氧气转炉法oxygen lime process底吹煤氧的复合吹炼法Klockner-Maxhutte steelmaking process,KMS 住友复合吹炼法Sumitomo top and bottom blowing process,STB LBE复吹法lance bubbling equilibrium process,LBE顶枪喷煤粉炼钢法Arved lance carbon injection process,ALCI蒂森复合吹炼法Thyssen Blassen Metallurgical process,TBM面吹surface blow软吹soft blow硬吹hard blow补吹reblow过吹overblow后吹after blow目标碳aim carbon终点碳end point carbon高拉碳操作catch carbon practice增碳操作recarburization practice单渣操作single-slag operation双渣操作double-slag operation渣乳化slag emulsion二次燃烧postcombustion吹氧时间oxygen blow duration吹炼终点blow end point倒炉turning down喷渣slopping喷溅spitting静态控制static control动态控制dynamic control氧枪oxygen lance氧枪喷孔nozzle of oxygen lance多孔喷枪multi-nozzle lance转炉炉体converter body炉帽upper cone炉口mouth,lip ring装料大面impact pad活动炉底removable bottom顶吹氧枪top blow oxygen lance副枪sublance多孔砖nozzle brick单环缝喷嘴single annular tuyere双环缝喷嘴double annular tuyere挡渣器slag stopper挡渣塞floating plug电磁测渣器electromagnetic slag detector废气控制系统off gas control system,OGCS平炉open-hearth furnace平炉炼钢open-hearth steelmaking冷装法cold charge practice热装法hot charge practice碳沸腾carbon boil石灰沸腾lime boil炉底沸腾bottom boil再沸腾reboil有效炉底面积effective hearth area酸性平炉acid open-hearth furnace碱性平炉basic open-hearth furnace固定式平炉stationary open-hearth furnace倾动式平炉tilting open-hearth furnace双床平炉twin-hearth furnace顶吹氧气平炉open-hearth furnace with roof oxygen lance蓄热室regenerator沉渣室slag pocket电炉炼钢electric steelmaking电弧炉electric arc furnace超高功率电弧炉ultra-high power electric arc furnace直流电弧炉direct current electric arc furnace双电极直流电弧炉double electrode direct current arc furnace 竖窑式电弧炉shaft arc furnace电阻炉electric resistance furnace工频感应炉line frequency induction furnace中频感应炉medium frequency induction furnace高频感应炉high frequency induction furnace电渣重熔electroslag remelting,ESR电渣熔铸electroslag casting,ESC电渣浇注Bohler electroslag tapping,BEST真空电弧炉重熔vacuum arc remelting,V AR真空感应炉熔炼vacuum induction melting,VIM电子束炉重熔electron beam remelting,EBR等离子炉重炼plasma-arc remelting,PAR水冷模电弧熔炼cold-mold arc melting等离子感应炉熔炼plasma induction melting,PIM等离子连续铸锭plasma progressive casting,PPC等离子凝壳铸造plasma skull casting,PSC能量优化炼钢炉energy optimizing furnace,EOF氧燃喷嘴oxygen-fuel burner氧煤助熔accelerated melting by coal-oxygen burner氧化期oxidation period还原期reduction period长弧泡沫渣操作弧长控制long arc foaming slag operation 白渣white slag电石渣carbide slag煤氧喷吹coal-oxygen injection炉壁热点hot spots on the furnace wall偏弧arc bias透气塞porous plug出钢到出钢时间tap-to-tap time虹吸出钢siphon tapping偏心炉底出钢eccentric bottom tapping,EBT中心炉底出钢centric bottom tapping,CBT侧面炉底出钢side bottom tapping,SBT滑动水口出钢slide fate tapping5.8 精炼、浇铸及缺陷铁水预处理hot metal pretreatment机械搅拌铁水脱硫法KR process torpedo desulfurization鱼雷车铁水脱磷torpedo dephosphorization二次精炼secondary refining钢包精炼ladle refining合成渣synthetic slag微合金化microalloying成分微调trimming钢洁净度steel cleanness钢包炉ladle furnace,LF直流钢包炉DC ladle furnace真空钢包炉LF-vacuum真空脱气vacuum degassing真空电弧脱气vacuum arc degassing,V AD真空脱气炉vacuum degassing furnace,VDF真空精炼vacuum refining钢流脱气stream degassing提升式真空脱气法Dortmund Horder vacuum degassing process,DH 循环式真空脱气法Ruhstahl-Hausen vacuum degassing process,RH 真空浇铸vacuum casting吹氧RH操作RH-oxygen blowing,RH-OB川崎顶吹氧RH操作RH-Kawasaki top blowing,RH-KTB喷粉RH操作RH-poowder blowing,TH-PB喷粉法powder injection process喷粉精炼injection refining蒂森钢包喷粉法Thyssen Niederhein process,TN瑞典喷粉法Scandinavian Lancer process,SL君津真空喷粉法vacuum Kimitsu injection process密封吹氩合金成分调整法composition adjustment by sealed argon bubbling,CAS吹氧提温CAS法CAS-OB process脉冲搅拌法pulsating mixing process,PM电弧加热电磁搅拌钢包精炼法ASEA-SKF process真空吹氧脱碳法vacuum oxygen decarburization process ,VOD 氩氧脱碳法argon-oxygen decarburization process,AOD蒸汽氧精炼法Creusot-Loire Uddelholm process,CLU无渣精炼slag free refining摇包法shaking ladle process铝弹脱氧法aluminium bullet shooting,ABS钢锭ingot铸锭ingot casting坑铸pit casting车铸car casting钢锭模ingot mold保温帽hot top下铸bottom casting上铸top casting补浇back pour,back feeding浇注速度pouring speed脱模ingot stripping发热渣exoslag防再氧化操作reoxidation protection连续浇注continuous casting连铸机continuous caster,CC,continuous casting machine,CCM 弧形连铸机bow-type continuous caster立弯式连铸机vertical-bending caster立式连铸机vertical caster水平连铸机horizontal caster小方坯连铸机billet caster大方坯连铸机bloom caster板坯连铸机slab caster薄板坯连铸机thin-slab casting薄带连铸机strip caster近终型浇铸near-net-shape casting单辊式连铸机single-roll caster单带式连铸机single-belt caster双带式连铸机twin-belt caster倾斜带式连铸机inclined conveyer type caster[连铸]流strand铸流间距strand distance注流对中控制stream centering control钢包回转台ladle turret中间包tundish回转式中间包swiveling tundish倾动式中间包tiltable tundish中间包挡墙weir and dam in tundish引锭杆dummy bar刚性引锭杆rigid dummy bar挠性引锭杆flexible dummy bar结晶器mold直型结晶器straight mold弧形结晶器curved mold组合式结晶器composite mold多级结晶器multi-stage mold调宽结晶器adjustable mold结晶器振动mold oscillation结晶器内钢液顶面meniscus,steel level钢液面控制技术steel level control technique 保护渣casting powder,mold powder凝壳shell液芯liquid core空气隙air gap一次冷却区peimary cooling zone二次冷却区secondary cooling zone极限冷却速度critical cooling rate浇铸半径casting radius渗漏bleeding拉坯速度casting speed拉漏breaking out振动波纹oscillation mark水口堵塞nozzle clogging气水喷雾冷却air mist spray cooling分离环separating ring拉辊withdrawal roll立式导辊vertical guide roll弯曲辊bending roll夹辊pinch roll矫直辊straightening roll驱动辊driving roll导向辊装置roller apron切割定尺装置cut-to-length device钢流保护浇注shielded casting practice多点矫直multipoint straightening电磁搅拌electromagnetic stirring,EMS浇注周期casting cycle多炉连浇sequence casting事故溢流槽emergercy launder菜花头cauliflower top钢锭缩头piped top表面缺陷surface defect。

钢铁冶金方面的词汇断续浇铸interruptedpouring 堆heap堆高机forklifttruck堆积密度packingdensity堆料场stockground堆料场stock-yard堆砂heapsand堆渣场slagtip堆重piledweight对合开放砂心盒splitopenendedcorebox对合模型，分割模型splitpattern对合模型板，分割模型板splitplate对合铸模splitmold对流convection对准alignment钝气inertgas钝气电弧熔接inert-gasarcwelding多边形筛polygonalscreen多段风口，多段风嘴multipletuyere多角形砂angularsand多孔塞porousplug多孔塞搅拌法porous-plugmethod多孔性，气孔率，气孔巢(铸疵)porosity多石英砂quartzosesand多水高岭土halloysite锇(Os)osmium鹅颈浇道，鹅颈管gooseneck而酸铸铁acidresistantcastiron耳轴，挂耳trunnion二次风口，二次风嘴secondarytuyere二次合金secondaryalloy二次空气secondaryair二钙硬化法Di-Calprocess二氧化锆zirconia二氧化碳造模法，碳酸气硬模法，CO2造模法carbondioxideprocess(CO2process)二氧化铁(FeO2)ferrousoxide二元合金binaryalloy发火合金pyrophoricalloys发热反应exothermicreaction发热覆盖?冒口用）exothermicshield发热冒口exothermicriser发热套筒exothermicsleeve发热性缩颈砂心（冒口用）exothermicbreakercore发热性缩孔防止粉exothermicantipipingpowder发生炉producer发生炉煤气powergas发生炉煤气producergas发生炉燃气，瓦斯generatorgas阀valve珐琅面，上釉glassysurface翻举装置rolloverandliftingdevice翻模rollingover翻模板rolloverboard翻模板rolloverplate翻箱索具beamandsling翻箱造模机rollovermoldingmachine翻转（壳模制造）peelback翻转，翻模rollover翻转顶销脱模机turnoverandpinliftmachine翻转式砂心机rockovercoremakingmachine翻转脱模式造模机frame-rollovermachine翻转脱模装置turn-drawdevice翻转造模机turnovermoldingmachine 钒(V)vanadium钒铁ferro-vanadium钒铸铁vanadiumcastiron反复冲击试验repair反复横断冲击试验repeatedimpacttest 反喇叭形浇口reversehorngate反射炉airfurnace反射炉reverberatoryfurnace反跳硬度计scleroscope反跳硬度试验reboundhardnesstest反跳硬度试验scleroscopehardnesstest 反斜度backdraft反应带reactionzone反应度reactivity反应模斜度inversedraft反应速率rateofreaction反转起模drawonturnover方锉squarefile方解石calcite方向性凝固directionalsolidification防尘面具，口罩respirator防护套管protectiontube防裂筋crackingstrip防裂片，散热片coolingfin防蚀anti-corrosion防缩暗冒口shrinkbob防缩剂，冒口保温用anti-pipingcompound 防缩孔粉剂pipeeliminator防缩冒口shrinkhead防缩冒口shrinker防锈anti-rust防锈剂rust-preventingagent防锈涂层rustpreventivecoating放射线检验radiographicinspection放射线检验radiographictesting放射线透视radioscopy放射线照片radiographicfilm放射线照像术radiography放射性同位素radioactiveisotope放样板layoutboard放置器set-downdevice非磁性铸铁non-magneticcastiron非焦性煤non-cokingcoal非金属夹杂物non-metallicinclusion非金属夹杂物sonims非均质组织heterogeneousstructure非破坏试验non-destructivetesting（NDT）非铁金属non-ferrousmetal非氧化气孔（银白色气孔）（铸疵）unoxidizedblowholes 飞边（铸件）feather飞边，闪光flash飞边清除flashremoval飞边现象（合模或模裂形成）finning飞灰fluxing肥粒铁，肥粒体ferrite肥粒铸铁ferriticcastiron沸腾boil沸腾boiling沸腾期boilingperiod肺尘埃沉着病pneumoconiosis费德曼组织（金相）Widmannstaettenstructure废（钢）片sheetscrap废电极electrodescrap废钢scrapsteel废料scrap废品率arateofrejects废品率，退件率，不良率rejectratio废品率，退件率，不良率rejectionrate，rejectatio 废气exhaustgas废气wastegas废热wasteheat废铁ironscrap废铁scrapiron废铸料castscrap分布distribution分部模型sectionpattern分部心型sectionalcore分层浇口sidestepgating分层进模口sidestepgate分层精炼法zonerefining分次式混合机batchmixer分次式火炉batchtypeannealingfurnace分次式磨粉机batchmill分次式配砂场batchsandplant分次式熔炉batchfurnace，batch-typefurnace) 分次退火炉periodicannealingfurnace分道砖runnercore分度盘dividingplate分度圈limb分段淬火interruptedquenching分段淬火stagehardening分段淬火stepquenching分段时效interruptedaging分段退火steppedannealing分级，刻度graduation。

i bar 工字铁i beam 工字钢i iron 工字铁i steel 工字铁ice point 冰点ideal diameter 理想直径ideal fluid 理想铃ideal gas 理想气体ideal lattice 理想晶格ideal quenching 理想淬火ideal solution 理想溶液idiomorphic crystal 自形结晶idle roll 空转辊ignitability 可燃性igniter 点火器ignition 点火ignition alloy 发火合金ignition furnace 点火炉ignition loss 灼烧损失ignition point 着火点ignition temperature 着火温度ignitron 水银整淋ilmenite 钛铁矿ilmenorutile 黑金红石ilvaite 黑柱石immersed arc 埋弧immersion coating 浸镀immersion plating 浸入电镀immersion test 浸没试验immersion type thermocouple 浸入式热电偶immiscibility 不溶混性immovable bed 固定层impact 冲击impact bend test 冲讳曲试验impact extrusion 冲环压impact load 冲缓载impact resistance 冲昏力impact screen 冲桓impact sintering 冲徽结impact strength 冲豢度impact stress 冲沪力impact test 冲辉验impact test piece 冲辉件impact testing machine 冲辉验机impact toughness 冲煌性impact value 冲坏impeller agitator 桨叶式搅拌机imperfect combustion 不完全燃烧imperfect dislocation 不完全位错imperfection 缺陷impermeability 不渗透性impregnated skeleton 浸渍骨架impression 压痕impulse forming 脉冲成形impulse hardening 冲徊化impulsive load 冲缓载impurity 杂质impurity atom 杂质原子impurity element 杂质元素inactive gas 惰性气体incidental element 杂质元素incipient crack 初裂inclined grate 斜炉栅inclined roll straightening machine 斜辊矫直机inclined throat shears 斜口剪切机inclusion 夹杂物inclusion cleanliness 夹杂物清结度inclusion line 夹杂物线inclusion morphology 夹杂物形态学inclusion stringer 线状夹杂物inclusions floating 夹杂物浮游inclusions source 夹杂物源incoherent boundary 非共格边界incoherent precipitate 非共格沉淀incombustibility 不燃性incomplete annealing 局部退火incomplete austenitizing 部分奥氏体化incomplete combustion 不完全燃烧incomplete fusion 不完全焊透incomplete penetration 不完全焊透incomplete quenching 不完全淬火incompressibility 不可压缩性incompressible fluid 不可压缩铃inconel 因科内尔镍铬铁耐热耐蚀合金incubation period 孕育期incubation time 孕育时间indentation 压痕indentation hardness 压痕硬度indentation method 压痕法independent component 独立组分indianite 埃洛石indicator element 指示元素indicolite 蓝电气石indigolite 蓝电气石indirect analysis 间接分析indirect arc furnace 间接电弧炉indirect reduction 间接还原indirect sintering 间接烧结indirect spot welding 单面点焊indissolubility 不溶性indium 铟indium chloride 氯化铟individual drive 单独传动individual particle 单颗粒individually driven roller 单独传动辊induced draught 吸入通风induction 感应induction brazing 感应钎接induction coil 感应线圈induction furnace 感应炉induction hardening 高频率淬火induction heating 感应加热induction quenching 高频率淬火induction stirring 电磁搅拌induction welding 感应焊接induction welding mill 感应焊管机inductor 感应器industrial alloy 工业合金industrial furnace 工业炉industrial iron 工业铁industrial waste water 工业污水industrial water 工业用水inert arc welding 惰性气体保护电焊inert atmosphere 惰性气氛inert electrode 惰性电极inert gas 惰性气体inertia 惯性inertia moment 惯性矩inertial force 惯性力infection 腐蚀影响infeed accumulator 入口贮料坑infiltrated composite material 溶浸复合材料infiltration 渗透;溶浸infiltration alloy 溶浸合金infiltration by overlay 叠置熔浸infiltration material 熔浸材料infinite fiber 连续纤维inflammability 可燃性inflammation 发火inflection 弯曲inflexion 弯曲inflexion point 回折点infrared pyrometer 红外线高温计infrared radiation 红外线辐射infrared rays 红外线infrared thermometry 红外线测温infusibility 不熔性infusorial earth 硅藻土ingate 浇口ingot 钢锭ingot bleeding 漏钢ingot bogie 送锭车ingot buggy 送锭车ingot butt 钢锭尾部ingot carrier 送锭车ingot casting 铸锭ingot corner segregation 钢锭角偏析ingot dogs 夹锭钳ingot head 钢锭头部ingot mold 锭模ingot pit 均热炉ingot pouring 铸锭ingot pusher 钢锭推出机ingot scalping 钢锭扒皮ingot shell 锭壳ingot stool 底盘ingot stripper 脱模机ingot stripping 脱模ingot structure 钢锭组织ingot tilting device 翻锭机ingot tipper 翻锭机ingot tongs 夹锭钳ingot tumbler 翻锭机ingot turner 钢锭转盘ingot turning device 钢锭转盘ingot yard 钢锭堆场ingotism 师状巨晶ingotting 铸块inherent grain size 固有晶粒度inhibitor 抑制剂;抗氧化剂inhomogeneity 不均质性inhomogeneity of structure 组织不均匀性inhomogeneous system 非均匀系initial creep 初蠕变initial hardness 初始硬度initial permeability 起始磁导率initial section 初始轧断面initial temperature of rolling 初始轧制温度initiation of crack 裂化开始injection 喷射injection burner 喷射烧嘴injection metallurgy 喷吹冶金injection molding 射压造型injection nozzle 喷嘴injector 喷射器inlet guide 进口导板inlet pipe 进气管inlet roll cone 进口辊圆锥inlet valve 进气阀inner cover 内罩inoculant 变质孕育剂inoculant alloy 球化剂合金inoculated cast iron 孕育铸铁inoculation 变质处理inoperative pass 闭口式孔型inorganic salt 无机盐inred process inred 加速还原法insert 垫insert die 插入模inside flash 内焊瘤inside weld 内焊缝insolubility 不溶性insoluble anode 不溶性阳极insoluble residue 不溶残渣insoluble salt 不溶性盐inspection 检查inspection hole 检查孔inspection skid 检查台inspissation 蒸浓instability 不稳定性installation 设备instantaneous cooling rate 瞬时冷却速度instantaneous heating rate 瞬时加热速度instantaneous strain 瞬间应变instrumental analysis 仪浦析instrumental error 仪企差insulating brick 隔热砖insulating layer 绝缘层insulating material 绝缘材料insulating refractory 隔热耐火材料insulation 绝缘insulator 绝缘体intake valve 进气阀integral quantity 积分热力学量integrated iron and steel works 钢铁联合工厂intensity 强度intensive quantity 强度量intensive reduction process inred 加速还原法interaction 相互酌interaction parameter 相互酌参数interannealed wire 中间退火线材interatomic distance 原子间距离interatomic spacing 原子间距离interchangeability 互换性interchangeable converter 可换转炉interchangeable vessel 可换转炉intercommunicating porosity 连通孔隙度intercooler 中间冷却器intercritical annealing 临界区退火intercrystalline brittleness 晶间脆性intercrystalline corrosion 晶间腐蚀intercrystalline crack 晶间裂纹intercrystalline failure 晶间破裂intercrystalline fracture 晶间断裂intercrystalline slip 晶界滑动interdendritic attack 枝晶间腐蚀interdendritic segregation 枝晶间偏析interdiffusion 相互扩散interelectrode distance 电极间距离interface 界面interface reaction 界面反应interfacial energy 界面自由能interfacial friction 边界摩擦interfacial tension 界面张力interfacial zone 界面区interference 干涉interference microscopy 干涉显微方法intergranular corrosion 晶间腐蚀intergranular crack 晶间裂纹intergranular failure 晶间破裂intergranular fracture 晶间断裂;晶间断口intergranular oxidation 晶间氧化intergranular structure 晶间组织intergrowth of crystals 结晶共生interlamellar spacing 层间距intermediate annealing 中间退火intermediate compound 中间化合物intermediate group 中间轧机组intermediate heating 中间加热intermediate layer 中间层intermediate mill 中间轧机intermediate phase 中间相intermediate product 中间产物intermediate reaction 中间反应intermediate roll 中间辊intermediate softening 中间退火intermediate stand 中间机架intermediate table 中间辊道intermediate train 中间轧机组intermetallic compound 金属间化合物intermittent arc 断续电弧intermittent fillet welding 间歇式角焊intermittent seam welding 断续滚焊intermittent weld 间断焊缝intermittent welding 间断焊internal chill 内冷铁internal coat 内部涂覆internal crack 内裂internal defect 内部缺陷internal displacement 内部位移internal energy 内能internal friction 内摩擦internal oxidation 内部氧化internal pressure 内压力internal resistance 内电阻internal strain 内应变internal stress 内应力interparticle spacing 粒子间距interphase 中间相;界面interphase boundary 相间边界interplanar spacing 晶面间距interrupted aging 阶段时效interrupted cooling 断续冷却interrupted quenching 断续淬火interstage annealing 中间退火interstand space 机座间距离interstand tension 机座间张力interstice 晶格原子间隙interstitial 间隙原子interstitial atom 间隙原子interstitial diffusion 间隙扩散interstitial element 间隙元素interstitial impurity 间隙杂质interstitial phase 间隙相interstitial site 间隙位置interstitial solid solution 间隙固溶体interval 区间intracrystalline rupture 穿晶断裂intrinsic energy 内藏能量intrinsic stacking fault 内巽错introduction of dummy bar 引锭杆插入invar 因瓦合金invariant system 不变系inverse annealing 倒逆退火inverse chill 反白口inverse segregation 反偏析inverted extrusion 反挤压investment casting 熔模铸造;熔模铸件investment molding 蜡模造型investment pattern 蜡模iodide 碘化物iodide refining 碘化物精炼iodine 碘ion activity 离子活度ion association 离子缔合ion bombardment 离子轰击ion concentration 离子浓度ion density 离子密度ion exchange 离子交换ion exchange capacity 离子交换能力ion exchange chromatography 离子交换色层法ion exchange column 离子交换柱ion exchange method 离子交换法ion exchange reaction 离子交换反应ion exchange resin 离子交换尸ion exchange separation 离子交换分离ion exchanger 离子交换剂ion implantation 离子注入ion mobility 离子迁移率ion nitriding 离子氮化ion pair 离子偶ion product 离子积ion radius 离子半径ionic bond 离子键ionic compound 离子化合物ionic conduction 离子传导ionic conductivity 离子传导性ionic crystal 离子晶体ionic lattice 离子晶格ionic linkage 离子键ionic migration 离子迁移ionic theory 离子学说ionic valency 离子价ionite membrane 离子交换膜ionization 电离ionization constant 电离常数ionization energy 电离能ionization equilibrium 电离平衡ionization heat 电离热ionization potential 电离势ionization state 电离状态ionization voltage 电离电压ionized atmosphere 离子气氛ionized layer 电离层iridium 铱iridium oxide 氧化铱iridosmine 铱锇合金iron 铁iron and steel industry 黑色冶金iron and steel scrap 废钢铁iron carbide 碳化铁iron carbon alloy 铁碳合金iron carbon diagram 铁碳状态图iron carbonate ore 铁碳酸盐矿石iron constantan thermocouple 铁铜镍热电偶iron foundry 铸适厂iron glance 镜铁矿iron loss 铁氧化损失;铁损iron manufacture 炼铁iron meteorites 铁陨石iron mine 铁矿山iron notch 出铁口iron ore 铁矿石iron ore briquette 铁矿石团块iron ore concentrate 铁精矿iron ore prereduction 铁矿石预还原iron ore sinter 铁矿石烧结矿iron pattern 铁模iron pipe 铁管iron powder 铁粉iron powder electrode 铁粉焊条iron protoxide 氧化亚铁iron runner 龙沟iron rust 铁锈iron sand 铁砂iron shot 铁丸iron wire 铁丝iron yield 铁收得率ironing 展薄拉伸ironmaking 炼铁ironstone 铁矿石ironworks 钢铁冶金工厂irradiation creep 辐照蠕变irradiation damageing 辐照损伤irradiation defect 辐照缺陷irradiation embrittlement 辐照脆化irradiation hardening 辐照硬化irregular powder 不规则状粉irregular section 变截面型材irregularity 不规则性irreversibility 不可逆性irreversible adsorption 不可逆吸着irreversible change 不可逆变化irreversible process 不可逆过程irreversible reaction 不可逆反应irrigated precipitator 湿式电收尘器ishikawaite 铁铌钇矿isobar 等压线isobaric change 等压变化isobaric line 等压线isochoric process 等容过程isochronal annealing 等时退火isolation 隔离isolator 绝缘体isomer 异构体isomerism 异构性isomorphism 同晶型isopotential surface 等位面isostatic mold 等静压模isostatic pressing 等静压制isothermal 等温线isothermal annealing 等温退火isothermal bath 等温浴isothermal change 等温变化isothermal curve 等温线isothermal extrusion 等温挤压isothermal forging 等温锻造isothermal growth 等温生长isothermal hardening 等温淬火isothermal heat treatment 等温热处理isothermal process 等温过程isothermal quenching 等温淬火isothermal section 等温截面isothermal sintering 等温烧结isothermal tempering 等温回火isothermal transformation 等温转变isothermal transformation curve 等温转变曲线isotope 同位素isotopic indicator 同位素指示剂isotopic tracer 同位素指示剂isotropic body 蛤同性体isotropy 蛤同性ixiolite 锰钽矿izod test 艾氏冲辉验。

钢铁工业中英文词汇表iron and steel industry 钢铁工业ironworks 铁厂foundry 铸造车间steelworks, steel mill 钢厂coking plant 炼焦厂electrometallurgy 电冶金学powder metallurgy 粉末冶金学blast furnace 鼓风炉mouth, throat 炉口hopper, chute 料斗stack 炉身belly 炉腰bosh 炉腹crucible 炉缸slag tap 放渣口taphole 出铁口,出渣口pig bed 铸床mould 铸模 (美作:mold)tuyere, nozzle 风口ingot mould 锭模 (美作:ingot mold) floor 平台hearth 炉底charger 装料机ladle 铁水包,钢水包dust catcher 除尘器washer 洗涤塔converter 转炉hoist 卷扬机compressor 压缩机tilting mixer 可倾式混铁炉regenerator 蓄热室heat exchanger 热交换器gas purifier 煤气净化器turbocompressor 涡轮压缩机burner 烧嘴cupola 化铁炉,冲天炉emptier 排空装置trough 铁水沟,排渣沟skip 料车rolling mill 轧机,轧钢机blooming mill 初轧机roller 辊bed 底座rolling-mill housing 轧机机架drawbench 拔管机,拉丝机drawplate 拉模板shaft furnace 竖炉refining furnace 精炼炉reverberatory furnace 反射炉hearth furnace 床式反射炉firebrick lining 耐火砖衬retort 反应罐muffle 马弗炉roof, arch 炉顶forge 锻造press 压锻pile hammer 打桩锤drop hammer 落锤die 拉模blowlamp 吹炬 (美作:blowtorch) crusher 破碎机iron ore 铁矿石coke 焦炭bauxite 铁钒土alumina 铝cryolite 冰晶石flux 熔剂limestone flux 石灰石溶剂haematite 赤铁矿 (美作:hematite) gangue 脉石cast iron 铸铁cast iron ingot 铸铁锭slag 炉渣soft iron 软铁pig iron 生铁wrought iron 熟铁iron ingot 铁锭puddled iron 搅炼熟铁round iron 圆铁scrap iron 废铁steel 钢crude steel 粗钢mild steel, soft steel 软钢,低碳钢hard steel 硬钢cast steel 坩埚钢,铸钢stainless steel 不锈钢electric steel 电工钢,电炉钢high-speed steel 高速钢moulded steel 铸钢refractory steel 热强钢,耐热钢alloy steel 合金钢plate, sheet 薄板corrugated iron 瓦垅薄钢板tinplate, tin 马口铁finished product 成品,产品semifinished product 半成品,中间产品ferrous products 铁制品coiled sheet 带状薄板bloom 初轧方坯metal strip, metal band 铁带,钢带billet 坯锭,钢坯shavings 剃边profiled bar 异型钢材shape, section 型钢angle iron 角钢frit 烧结wire 线材ferronickel 镍铁elinvar 镍铬恒弹性钢ferrite 铁氧体,铁醇盐cementite 渗碳体,碳化铁pearlite 珠光体charging, loading 装料,炉料fusion, melting, smelting 熔炼remelting 再熔化,重熔refining 精炼casting 出铁to cast 出铁tapping 出渣,出钢,出铁to insufflate, to inject 注入heating 加热preheating 预热tempering 回火temper 回火hardening 淬水annealing 退火reduction 还原cooling 冷却decarbonization, decarburization 脱碳coking 炼焦slagging, scorification 造渣carburization 渗碳case hardening 表面硬化cementation 渗碳fritting, sintering 烧结puddling 搅炼pulverization 粉化,雾化nitriding 渗氮alloy 合金floatation, flotation 浮选patternmaking 制模moulding 成型 (美作:molding)calcination 煅烧amalgamation 汞齐化rolling 轧制drawing 拉拔extrusion 挤压wiredrawing 拉丝stamping, pressing 冲压die casting 拉模铸造forging 锻造turning 车削milling 铣削machining, tooling 加工autogenous welding, fusion welding 氧炔焊arc welding 电弧焊electrolysis 电解trimming 清理焊缝blowhole 气孔材料科学 Material Science材料科学定义 Material Science Definition加工性能 Machinability强度 Strength抗腐蚀及耐用 Corrosion & resistance durability金属特性 Special metallic features抗敏感及环境保护 Allergic, re-cycling & environmental protection化学元素 Chemical element元素的原子序数 Atom of Elements原子及固体物质 Atom and solid material原子的组成、大小、体积和单位图表 The size, mass, charge of an atom, and is particles (Pronton,Nentron and Electron)原子的组织图 Atom Constitutes周期表 Periodic Table原子键结 Atom Bonding金属与合金 Metal and Alloy铁基合金 Ferrous Alloy铁及非铁金属 Ferrous & Non Ferrous Metal金属的特性 Features of Metal晶体结构 Crystal Pattern晶体结构，定向格子及单位晶格 Crystal structure, Space lattice & Unit cellX线结晶分析法 X – ray crystal analyics method金属材料的试验方法 The Method of Metal inspection不破坏检验 Non – destructive inspections渗透探伤法 Penetrate inspection磁粉探伤法 Magnetic particle inspection放射线探伤法 Radiographic inspection超声波探伤法 Ultrasonic inspection显微观察法 Microscopic inspection破坏的检验 Destructive Inspection冲击测试 Impact Test疲劳测试 Fatigue Test金属结晶格子 Metal space lattice格子常数 Lattice constant米勒指数 Mill's Index金相及相律 Metal Phase and Phase Rule固熔体 Solid solution置换型固熔体 Substitutional type solid solution插入型固熔体 Interstital solid solution金属间化物 Intermetallic compound金属变态 Transformation变态点 Transformation Point磁性变态 Magnetic Transformation同素变态 Allotropic Transformation合金平衡状态 Thermal Equilibrium相律 Phase Rule自由度 Degree of freedom临界温度 Critical temperture共晶 Eutectic包晶温度 Peritectic Temperature包晶反应 Peritectic Reaction包晶合金 Peritectic Alloy亚共晶体 Hypoeutetic Alloy过共晶体 Hyper-ectectic Alloy金属塑性 Plastic Deformation滑动面 Slip Plan畸变 Distortion硬化 Work Hardening退火 Annealing回复柔软 Crystal Recovery再结晶 Recrystallization金属材料的性能及试验 Properties & testing of metal化学性能 Chemical Properties物理性能 Physical Properties磁性 Magnetisum比电阻 Specific resistivity & specific resistance比重 Specific gravity & specific density比热 Specific Heat热膨胀系数 Coefficient of thermal expansion导热度 Heat conductivity机械性能 Mechanical properties屈服强度(降伏强度) (Yield strangth)弹性限度、阳氏弹性系数及屈服点 elastic limit, Yeung's module of elasticity to yield point 伸长度 Elongation断面缩率 Reduction of area钢铁的主要成份 The major element of steel钢铁用"碳"之含量来分类 Classification of Steel according to Carbon contents铁相 Steel Phases钢铁的名称 Name of steel纯铁体 Ferrite渗碳体 Cementitle奥氏体 Austenite珠光体及共释钢 Pearlite &Eutectoid 奥氏体碳钢 Austenite Carbon Steel 单相金属 Single Phase Metal共释变态 Eutectoid Transformation 珠光体 Pearlite亚铁释体 Hyppo-Eutectoid初释纯铁体 Pro-entectoid ferrite 过共释钢 Hype-eutectoid珠光体 Pearlite粗珠光体 Coarse pearlite中珠光体 Medium pearlite幼珠光体 Fine pearlite马氏体 mainite贝氏体 bainite物料科学Material Science物料科学定义Material Science Definition加工性能Machinability强度Strength抗腐蚀及耐用Corrosion & resistance durability金属特性Special metallic features抗敏感及环境保护Allergic, re-cycling & environmental protection化学元素Chemical element元素的原子序数Atom of Elements原子及固体物质Atom and solid material原子的组成、大小、体积和单位图表The size, mass, charge of an atom, and is particles (Pronton,Nentron and Electron) 原子的组织图Atom Constitutes周期表Periodic Table原子键结Atom Bonding金属与合金 Metal and Alloy铁及非铁金属Ferrous & Non Ferrous Metal金属的特性Features of Metal晶体结构 Crystal Pattern晶体结构，定向格子及单位晶格Crystal structure, Space lattice & Unit cellX 线结晶分析法X – ray crystal analyics method金属结晶格子 Metal space lattice格子常数 Lattice constant米勒指数 Mill's Index金相及相律 Metal Phase and Phase Rule固熔体 Solid solution置换型固熔体 Substitutional type solid solution插入型固熔体 Interstital solid solution金属间化物 Intermetallic compound金属变态Transformation变态点Transformation Point磁性变态Magnetic Transformation同素变态Allotropic Transformation合金平衡状态Thermal Equilibrium相律Phase Rule自由度Degree of freedom临界温度Critical temperture共晶Eutectic包晶温度 Peritectic Temperature包晶反应 Peritectic Reaction包晶合金 Peritectic Alloy亚共晶体 Hypoeutetic Alloy过共晶体 Hyper-ectectic Alloy金属的相融、相融温度、晶体反应及合金在共晶合金、固熔孻共晶合金及偏晶反应的比较Equilibrium Comparision金属塑性 Plastic Deformation滑动面 Slip Plan畸变 Distortion硬化 Work Hardening退火 Annealing回复柔软 Crystal Recovery再结晶 Recrystallization金属材料的性能及试验Properties & test ing of metal化学性能Chemical Properties物理性能Physical Properties颜色Colour磁性Magnetisum比电阻Specific resistivity & specific resistance比重Specific gravity & specific density比热Specific Heat热膨胀系数Coefficient of thermal expansion导热度Heat conductivity机械性能 Mechanical properties屈服强度(降伏强度) (Yield strangth)弹性限度、阳氏弹性系数及屈服点elastic limit, Yeung's module of elasticity to yield point伸长度Elongation断面缩率Reduction of area金属材料的试验方法The Method of Metal inspection不破坏检验Non – destructive inspections渗透探伤法Penetrate inspection磁粉探伤法Magnetic particle inspection放射线探伤法Radiographic inspection超声波探伤法Ultrasonic inspection显微观察法Microscopic inspection破坏的检验Destructive Inspection冲击测试Impact Test疲劳测试Fatigue Test潜变测试 Creep Test潜变强度Creeps Strength第壹潜变期Primary Creep第二潜变期Secondary Creep第三潜变期Tertiary Creep主要金属元素之物理性质Physical properties of major Metal Elements工业标准及规格–铁及非铁金属Industrial Standard – Ferrous & Non – ferrous Metal磁力 Magnetic简介 General软磁 Soft Magnetic硬磁 Hard Magnetic磁场 Magnetic Field磁性感应 Magnetic Induction透磁度 Magnetic Permeability磁化率 Magnetic Susceptibility (Xm)磁力(Magnetic Force)及磁场(Magnetic Field)是因物料里的电子(Electron)活动而产生抗磁体、顺磁体、铁磁体、反铁磁体及亚铁磁体Diamagnetism, Paramagnetic, Ferromagnetism,Antiferromagnetism & Ferrimagnetism抗磁体 Diamagnetism磁偶极子 Dipole负磁力效应 Negative effect顺磁体 Paramagnetic正磁化率 Positive magnetic susceptibility铁磁体 Ferromagnetism转变元素 Transition element交换能量 Positive energy exchange外价电子 Outer valence electrons化学结合 Chemical bond自发上磁 Spontaneous magnetization磁畴 Magnetic domain相反旋转 Opposite span比较抗磁体、顺磁体及铁磁体Comparison of Diamagnetism, Paramagnetic & Ferromagnetism 反铁磁体 Antiferromagnetism亚铁磁体 Ferrimagnetism磁矩 magnetic moment净磁矩 Net magnetic moment钢铁的主要成份The major element of steel钢铁用"碳"之含量来分类Classification of Steel according to Carbon contents铁相Steel Phases钢铁的名称Name of steel纯铁体Ferrite渗碳体Cementitle奥氏体 Austenite珠光体及共释钢Pearlite &Eutectoid奥氏体碳钢Austenite Carbon Steel单相金属Single Phase Metal共释变态Eutectoid Transformation珠光体 Pearlite亚铁释体Hyppo-Eutectoid初释纯铁体 Pro-entectoid ferrite过共释钢 Hype-eutectoid珠光体Pearlite粗珠光体 Coarse pearlite中珠光体 Medium pearlite幼珠光体 Fine pearlite磁性变态点 Magnetic Transformation钢铁的制造Manufacturing of Steel连续铸造法 Continuous casting process电炉 Electric furnace均热炉 Soaking pit全静钢 Killed steel半静钢 Semi-killed steel沸腾钢(未净钢) Rimmed steel钢铁生产流程 Steel Production Flow Chart钢材的熔铸、锻造、挤压及延轧The Casting, Fogging, Extrusion, Rolling & Steel熔铸 Casting锻造 Fogging挤压 Extrusion延轧 Rolling冲剪 Drawing & stamping特殊钢 Special Steel简介General特殊钢以原素分类Classification of Special Steel according to Element特殊钢以用途来分类Classification of Special Steel according to End Usage易车(快削)不锈钢Free Cutting Stainless Steel含铅易车钢Leaded Free Cutting Steel含硫易车钢Sulphuric Free Cutting Steel硬化性能Hardenability钢的脆性Brittleness of Steel低温脆性 Cold brittleness回火脆性 Temper brittleness日工标准下的特殊钢材Specail Steel according to JIS Standard铬钢–日工标准 JIS G4104Chrome steel to JIS G4104铬钼钢钢材–日工标准 G4105 62Chrome Molybdenum steel to JIS G4105镍铬–日工标准 G4102 63Chrome Nickel steel to JIS G4102镍铬钼钢–日工标准 G4103 64Nickel, Chrome & Molybdenum Steel to JIS G4103高锰钢铸–日工标准High manganese steel to JIS standard片及板材Chapter Four-Strip, Steel & Plate冷辘低碳钢片(双单光片)(日工标准 JIS G3141) 73 - 95Cold Rolled (Low carbon) Steel Strip (to JIS G 3141)简介General美材试标准的冷辘低碳钢片Cold Rolled Steel Strip American Standard – American Society for testing and materials (ASTM)日工标准JIS G3141 冷辘低碳钢片(双单光片)的编号浅释Decoding of cold rolled(Low carbon)steel strip JIS G3141材料的加工性能 Drawing abillity硬度 Hardness表面处理 Surface finish冷辘钢捆片及张片制作流程图表Production flow chart cold rolled steel coil sheet冷辘钢捆片及张片的电镀和印刷方法Cold rolled steel coil & sheet electro-plating & painting method冷辘(低碳)钢片的分类用、途、工业标准、品质、加热状态及硬度表End usages, industrial standard, quality, condition and hardness of cold rolled steel strip硬度及拉力 Hardness & Tensile strength test拉伸测试(顺纹测试)Elongation test杯突测试(厚度: 0.4 公厘至1.6 公厘，准确至0.1 公厘 3 个试片平均数)Erichsen test (Thickness: 0.4mm to 1.6mm, figure round up to 0.1mm)曲面(假曲率)Camber厚度及阔度公差 Tolerance on Thickness & Width平坦度(阔度大于500 公厘，标准回火)Flatness (width>500mm, temper: standard)弯度 Camber冷辘钢片储存与处理提示General advice on handling & storage of cold rolled steel coil & sheet防止生锈Rust Protection生锈速度表Speed of rusting焊接 Welding气焊 Gas Welding埋弧焊 Submerged-arc Welding电阻焊 Resistance Welding冷辘钢片(拉力: 30-32 公斤/平方米)在没有表面处理状态下的焊接状况Spot welding conditions for bared (free from paint, oxides etc) Cold rolled mild steelsheets(T/S:30-32 Kgf/ μ m2)时间效应(老化)及拉伸应变Aging & Stretcher Strains日工标准(JIS G3141)冷辘钢片化学成份Chemical composition – cold rolled steel sheet to JIS G3141冷辘钢片的"理论重量"计算方程式Cold Rolled Steel Sheet – Theoretical mass日工标准(JIS G3141)冷辘钢片重量列表Mass of Cold-Rolled Steel Sheet to JIS G3141冷辘钢片订货需知Ordering of cold rolled steel strip/sheet其它日工标准冷轧钢片(用途及编号)JIS standard & application of other cold Rolled Special Steel电镀锌钢片或电解钢片Electro-galvanized Steel Sheet/Electrolytic Zinc Coated Steel Sheet简介General电解/电镀锌大大增强钢片的防锈能力Galvanic Action improving Weather & Corrosion Resistance of the Base Steel Sheet上漆能力 Paint Adhesion电镀锌钢片的焊接Welding of Electro-galvanized steel sheet点焊Spot welding滚焊Seam welding电镀锌(电解)钢片Electro-galvanized Steel Sheet生产流程Production Flow Chart常用的镀锌钢片(电解片)的基层金属、用途、日工标准、美材标准及一般厚度Base metal, application, JIS & ASTM standard, and Normal thickness of galvanized steel sheet锌镀层质量 Zinc Coating Mass表面处理 Surface Treatment冷轧钢片 Cold-Rolled Steel Sheet/Strip热轧钢片 Hot-Rolled Sheet/Strip电解冷轧钢片厚度公差Thickness Tolerance of Electrolytic Cold-rolled sheet热轧钢片厚度公差Thickness Tolerance of Hot-rolled sheet冷轧或热轧钢片阔度公差Width Tolerance of Cold or Hot-rolled sheet长度公差 Length Tolerance理论质量 Theoretical Mass锌镀层质量(两个相同锌镀层厚度)Mass Calculation of coating (For equal coating)/MM锌镀层质量(两个不同锌镀层厚度)Mass Calculation of coating (For differential coating)/MM镀锡薄铁片(白铁皮/马口铁) (日工标准 JIS G3303)简介General镀锡薄铁片的构造Construction of Electrolytic Tinplate镀锡薄钢片(白铁皮/马日铁)制造过程Production Process of Electrolytic Tinplate锡层质量Mass of Tin Coating (JIS G3303-1987)两面均等锡层Both Side Equally Coated Mass两面不均等锡层Both Side Different Thickness Coated Mass级别、电镀方法、镀层质量及常用称号Grade, Plating type, Designation of Coating Mass & Common Coating Mass 镀层质量标记Markings & Designations of Differential Coatings硬度 Hardness单相轧压镀锡薄铁片(白铁皮/马口铁)Single-Reduced Tinplate双相辗压镀锡薄钢片(马口铁/白铁皮)Dual-Reduction Tinplate钢的种类 Type of Steel表面处理 Surface Finish常用尺寸 Commonly Used Size电器用硅 [硅] 钢片 Electrical Steel Sheet简介 General软磁材料 Soft Magnetic Material滞后回线 Narrow Hystersis矫顽磁力 Coercive Force硬磁材料 Hard Magnetic Material最大能量积 Maximum Energy Product硅含量对电器用的低碳钢片的最大好处The Advantage of Using Silicon low Carbon Steel晶粒取向(Grain-Oriented)及非晶粒取向(Non-Oriented)Grain Oriented & Non-Oriented电器用硅 [硅] 钢片的最终用途及规格End Usage and Designations of Electrical Steel Strip电器用的硅 [硅] 钢片之分类Classification of Silicon Steel Sheet for Electrical Use电器用钢片的绝缘涂层Performance of Surface Insulation of Electrical Steel Sheets晶粒取向电器用硅钢片主要工业标准International Standard – Grain-Oriented Electrical Steel Silicon Steel Sheet for Electrical Use晶粒取向电器用硅钢片 Grain-Oriented Electrical Steel晶粒取向，定取向芯钢片及高硼定取向芯钢片之磁力性能及夹层系数(日工标准及美材标准) Magnetic Properties and Lamination Factor of SI-ORIENT-CORE& SI-ORIENT-CORE-HI BElectrical Steel Strip (JIS and AISI Standard)。

冶金科技英语必备词汇•turnout 产量、产额•total assets 总资产•Scientific development concept 科学发展观•development strategy 发展战略•variety 品种•specifications 规格•iron and steel industry 钢铁工业•design Production capacity 设计产台匕能匕•ton 吨•hot rolled sheet (coil) 热轧板(卷) •cold rolled sheet (coil) 冷轧板(卷) •hot rolled rebar 热轧带肋钢筋•angle steel 角钢•channel steel 槽车冈•narrow strip 窄带钢•converter 转炉•oxygen top-bottom blowing 氧气顶底复吹•hot metal mixer 混铁炉•4-strands caster 四流连铸机•ladle钢包•LF(Ladle Furnace)精炼炉•6-strands billet caster 六流方坯连铸机•hot metal desulphurization station 铁水炉外脱硫系统•extract 提炼•flux 熔化；焊剂；溶剂•ore 矿石•slag 炉渣•gangue 脉石•concentrate (矿)精矿•electrolysis 电解•hot blast stove 热风炉•blast furnace 高炉•BFG (blaster furnace gas) 高炉煤气•Iron oxide power 氧化铁粉•impurity 杂质•spring 弹簧•liner n 炉衬•silicon 硅•brick 砖，砖•refractory耐火的，耐熔的n.耐火材料•magnesia 氧化镁•dolomite 白云石•lime 石灰•open hearth 平炉•calcium 钙•raw material 原料•post-treatment 炉外精炼，后处理•electric-arc furnace 电弧炉•iron-bearing materials 含铁原料•fuel 燃料•oxide 氧化物•sulphide 硫化物•sulfur 硫carbonate 碳酸盐magnetite 磁铁矿hematite 赤铁矿limonite 褐铁矿siderite 菱铁矿hydrous 含水的reducible 可还原的soft coal 烟煤hard coal 无烟煤coal injection 喷煤sintering 烧结alloy 合金weld 焊接scrap废钢，废料soaking furnace 均热炉cast iron 铸铁lead 铅magnetic alloy 磁合金solar furnace太阳能炉solute溶质solution 溶解spangles 锌花density 密度elongation 延伸率gravity 比重power单位功率strength 强度volume体积weight重量spectroscopic analysis 光谱分析graphite 石墨spindle 轴splash 飞溅sponge iron 海绵铁spot welder 点焊机spray喷雾spray coating 喷涂spray cooling喷雾冷去却square ingot 方钢锭stand机座steam蒸汽steam pump蒸汽泵steel band 钢带steel bar 钢条steel construction 钢结构steel pipe 钢管steel tapping hole 出钢口steel tapping spout 出钢槽stockyard料场;成品库stopper 塞棒structural steel 结构钢valve阀门sulfur removal 脱硫superficial hardening 表面淬火support roll 支承辐surface hardness 表面硬度heat treatment 热处理property 性质tension 表面张力suspended particles 悬浮颗粒pig iron 生铁ore矿石crushing 破碎yield产率grinding 磨碎screening 筛分separation 分选hand sorting 手选limestone石灰石primary crushing 粗碎secondary rushing 中碎fine crushing 2田碎filter过滤机feeding给矿，给料chemical process 化学过程metallurgical process 冶金过程chemical reaction 化学反应direct reduction 直接还原indirect reduction 间接还原vacuum decarburization 真空脱碳surface tension 表面张力coking炼焦high temperature carbonization 高温炭化coal preparation, coal washing 洗煤coal blending 酉己煤coking coal 炼焦煤coke oven 焦炉coal charging 装煤refractory materials 耐火材料joint接头lump ore 块矿ore fines 粉矿coal injection 喷煤coke ratio, coke rate 焦比furnace condition 炉况throat炉喉bosh炉腹shaft 炉身belly炉腰hearth炉缸bottom炉底•bosh angle 炉腹角•stack angle 炉身角•iron notch, slag notch 铁口•slag runner 渣沟•tapping sample 出钢样•casting sample 浇铸样•coolant冷却剂•return slag 回炉渣•vacuum degassing 真空脱气•bending roll 弯曲辐•thin-slab casting薄板坯连铸机•liquid core 液芯•driving roll 驱动辐•blowhole 气孔•vertical guide roll 导辑•cast iron 铸铁•straightening roll 矫直辐•wrought iron 熟铁•reinforced bar steel 钢筋钢•hot metal pretreatment 铁水预处理•process scrap加工废钢，边角废料•deoxidation 脱氧，还原•sheared end切头，切尾•finished product 成品•contamination 污染，污染物•rejected material 废品，废料•fluorspar，萤石，氟石•circulate （使）运行，（使）循环•machinability机械加工性，切削性•fireproof 耐火的•blower 送风机•pipe输送管•acetylene 乙炔•electric arc welding 电弧焊oxyacetylene flame 氧炔焰forge锻造flat-die forging 平模锻造oxyhydrogen flame 氢氧焰grainy structure颗粒状结构tungsten 鸨thermal cutting 热切害Ubinder粘合剂shell molding 壳型铸造pressure 压，压力deformation 变形finishing area 精整区roughing rolls 粗轧机组marking做记号，做标记packing 包装stacking 堆垛deep-drawing 深冲，深压semis半成品的semi-finished 半制成品slab板坯，板材bloom初坯，大方坯，毛坯conveyor belt 输送皮带screen筛选pelletize使成颗粒状ignite点火refractory brick 耐火砖liquid slag液体［液态］炉渣stock house 料仓skimmer撇渣器gas cleaning equipment 高炉气净化装置slag pit 渣池skip car 料车brick lining 砖内衬•cast house出铁场，铸造浇铸场•blower house 鼓风机室•chutes 斜道•hot metal car铁水罐运输车•slag ladle 钢渣罐•hot blast热鼓风•cleaned gas 净化气•waste gas stack 废气烟囱•hot dirty furnace gas 高炉废气•combustion chamber （排渣式）燃烧室•molten iron 铁水•cold rolled steel sheets 冷轧薄板•hot rolled steel coil 热轧钢卷•pickled steel sheets 酸洗薄板•pickled carbon steel coil 酸洗碳钢卷•color coating & Galvanizing 涂镀•rolled steel coil 轧钢卷•stainless steel coil 不锈钢卷•picking 酸洗•cold rolling 冷轧•annealing 退火•color coated & Galvanized steel sheets 涂镀薄板•cold Annealed steel coil 冷轧退火卷•color coated & hot Galvanized steel coil彩涂热镀锌卷•stainless steel 不锈钢•Hot rolled Carbon steel 热轧普碳钢•cold-rolled steel sheets 冷轧钢板•cold-rolled steel strip 冷轧带钢•common straight carbon steel 普通碳素钢•galvanized steel coil 镀锌钢板•steel strip 车钢带mill轧机annealing furnace 罩式退火炉cold hard rolled coils 冷硬卷unwinding speed 开卷速度side trimmer 切边剪mill entry 轧机入口mill exit轧机出口rolling force 轧制力intermediate roll中间辐surface quality control technology 表面质量控制技术jet type pickling 喷射酸洗tension meter roll 张力计辐deflector roll 转向辐pickling tank 酸洗槽nozzle喷嘴water quench tank 水封槽submerged inner cover 侵入式内盖cover liften开盖装置waste acid 废酸acid supply piping 供酸管道rinse water 漂洗水scarp chopper 碎边剪tightness test 密封测试cooling hood 冷却罩flow meter 流量计vertical jig 立式夹钳three claw jig 三爪夹钳housing 牌坊tension meter looper 张力计活套semi-endless rolling 半无头轧制recristallized 再结晶的microstructure 组织iron-Carbide-Diagram 铁碳相图ladle turret钢包回转台tundish中间包mould结晶器pendulum shear 摆剪liquid Core Reduction (LCR) 液芯压下slab板坯electro Magnetic Brake ( EMBr)电磁制动submerged Entry Nozzle (SEN)® 入式水口strand铸流caster连铸机secondary cooling water 二冷水bending unit顶弯装置segment扇形段withdrawal/ straightener unit 拉矫机funnel漏斗dummy bar弓|锭杆nozzle喷嘴strip带钢profile 板形diameter 直径Wiper切水板heater力口热器BUR balancing支承辐平衡dynamic profile control (DPC) 动态凸度控制screw down system (SDS) 压下系统pump 泵water tank 水箱water catcher水收集器flow流量•stand control 机架控制•strip tracking 带钢跟踪•Continuously Variable Crown （CVC）工作辐窜辐•Profile. Contour and Flatness Control （PCFC）板形，凸度，平直度控制•roller hearth furnace 辐底式炉•side guides （SG）侧导•flatness平直度•looper 活套•Automatic Gauge Control （AGC）自动厚度控制•Work Roll Bending （WRB）弯辐•swivel辐缝调平•emergency stop 急停•descaler除鳞机•width宽度•main drive 主传动•tension 张力•emergency shear 事故剪•Low/High Pressure （LP/HP）低、高压•Finish Mill （FM）轧机区•roll change（RC）换辐•cool冷却•alarm报警•Drive Side （DS）传动侧•Operate Side （OS）操作侧•work roll （WR）工作辐•backup roll（BUR）支撑辐•bending force 弯辊力•roll force 轧制力•differentials roll force 轧制力偏差length长度Motor马达bearing 轴承edger立辊lubrication 润滑crown凸度back up roll data支承辑数据walking beam 步进梁strapping打捆机marking 喷印机conveyor运输链chute plate 斜槽板wrapper roll 助卷辐mandrel bearing夕卜支撑臂downcoiler （DC）地下卷取机laminar cooling （LC）层流冷去却yield屈服强度temperature 温度pinch roll夹送辐mandrel 卷筒cross spray 侧喷水stripper car 卸卷小车lift car 提升小车weighting machine 称重机revolution 转速torque扭矩Run Out Table （ROT）输出辐道sampling station 取样站auxiliary drive 辅助传动breast roll 机架辐thickness 厚度hold downroller 压紧辐uncooled head头部不冷却mandrel collapse 芯轴收缩reset复位lock锁定cradle roll 托辐corrected position 位置修正rod活塞杆piston 丫舌塞monitoring 监视winding 绕组fan风扇oil lube 油管threading 穿带recoiling 重卷hydraulic cylinder 液压缸elongation 延伸率work roll bender工作辐弯辐feed table进料平台surface roughness 表面粗糙度coilpreparation station 钢卷准备站entry side walking beam 入□步进梁pneumatic system 气动系统straightener 矫直机walking beam conveyor 步进梁式运输链constant pressure control 恒压力控制strap捆带hydraulic oil 液压油peeler开卷器coil-holder cradle 托卷鞍座conveying table 输送台device for measuring coil width and for coil vertical centering 钢卷宽度测量和垂直对中装置•entry coil car 入□运卷小车•roller-holder cradle 托卷辐snubber roll 缓冲辐scrap box 废料箱traversable single mandrel pay-off reel 横移式单卷筒开卷机guiding table废料导向台pusher plate 推板coil-holder car 托卷小车coil measuring device 钢卷检测系统chock clamp轴承座锁紧strip centering device 带钢对中装置entry equipment 入口设备exit equipment 出口设备traversable tension reel 横移式张力卷取机chain wrapper链式助卷器edge sensing device边部检测装置unload car卸卷小车constant position control 恒位置控制guillotine shear 切头剪HGC, balancing, crowning system 液压压下、平衡和弯辊系统vertical roller guides 立辑侧导end support arm 外支撑spindle coupling 联轴器coil weighing device 钢卷称重装置automatic marking machine 自动喷号机car to feed coil to rolling line 上卷小车back tension pinch roll 后张力夹送辐unwinding speed 开卷速度anticoil-break roller 防皱辐back-up polisher支承辐擦拭器stand protection机架保护装置•push-up roll 下压辐•strap head 打捆头•pass line adjusting device 轧制线调整系统•Hot Annealing & Pickling Line 热轧带退火酸洗机组•Cold Annealing and Picking Line 冷轧带退火酸洗机组•Cold rolled Annealing and PickingLine冷轧退火酸洗机组•Skin Pass Mill 平整机组•Tension Leveling Line 张力矫直(拉矫机)物料科学Material Science物料科学定义Material Science Definition加工性能Machinability强度Strength抗腐蚀及耐用Corrosion & resistance durability金属特性Special metallic features抗敏感及环境保护Allergic, re-cycling & environmental protection化学元素Chemical element元素的原子序数Atom of Elements原子及固体物质Atom and solid material原子的组成、大小、体积和单位图表The size, mass, charge of an atom, and is particles (Pronton,Nentron and Electron)原子的组织图Atom Constitutes周期表Periodic Table原子键结Atom Bonding金属与合金Metal and Alloy铁及非铁金属Ferrous & Non Ferrous Metal金属的特性Features of Metal晶体结构Crystal Pattern晶体结构，定向格子及单位晶格Crystal structure, Space lattice & Unit cellX线结晶分析法X - ray crystal analyics method金属结晶格子Metal space lattice格子常数Lattice constant米勒指数Mill's Index金相及相律Metal Phase and Phase Rule固熔体Solid solution置换型固熔体Substitutional type solid solution 插入型固熔体Interstital solid solution金属间化物Intermetallic compound金属变态Transformation变态点Transformation Point磁性变态Magnetic Transformation同素变态Allotropic Transformation合金平衡状态Thermal Equilibrium相律Phase Rule自由度Degree of freedom临界温度Critical temperture共晶Eutectic包晶温度Peritectic Temperature包晶反应Peritectic Reaction包晶合金Peritectic Alloy亚共晶体Hypoeutetic Alloy过共晶体Hyper-ectectic Alloy金属的相融、相融温度、晶体反应及合金在共晶合金、固熔孺共晶合金及偏晶反应的比较Equilibrium Comparision金属塑性Plastic Deformation滑动面Slip Plan畸变Distortion硬化Work Hardening退火Annealing回复柔软Crystal Recovery再结晶Recrystallization金属材料的性能及试验Properties & testing of metal化学性能Chemical Properties物理性能Physical Properties颜色Colour磁性Magnetisum比电阻Specific resistivity & specific resistance比重Specific gravity & specific density比热Specific Heat热膨胀系数Coefficient of thermal expansion导热度Heat conductivity机械性能Mechanical properties屈服强度(降伏强度)(Yield strangth)弹性限度、阳氏弹性系数及屈服点elastic limit, Yeung's module of elasticity to yield point 伸长度Elongation断面缩率Reduction of area金属材料的试验方法The Method of Metal inspection不破坏检验Non - destructive inspections渗透探伤法Penetrate inspection磁粉探伤法Magnetic particle inspection放射线探伤法Radiographic inspection超声波探伤法Ultrasonic inspection显微观察法Microscopic inspection破坏的检验Destructive Inspection冲击测试Impact Test疲劳测试Fatigue Test潜变测试Creep Test潜变强度Creeps Strength第壹潜变期Primary Creep 第二潜变期Secondary Creep 第三潜变期Tertiary Creep主要金属元素之物理性质Physical properties of major Metal Elements工业标准及规格-铁及非铁金属Industrial Standard - Ferrous & Non - ferrous Metal磁力Magnetic 简介General 软磁Soft Magnetic 硬磁Hard Magnetic 磁场Magnetic Field 磁性感应Magnetic Induction 透磁度Magnetic Permeability 磁化率Magnetic Susceptibility (Xm)磁力(Magnetic Force)及磁场(Magnetic Field)是因物料里的电子(Electron)活动而产生抗磁体、顺磁体、铁磁体、反铁磁体及亚铁磁体Diamagnetism, Paramagnetic, Ferromagnetism,Antiferromagnetism & Ferrimagnetism 抗磁体Diamagnetism 磁偶极子Dipole 负磁力效应Negative effect 顺磁体Paramagnetic正磁化率Positive magnetic susceptibility铁磁体Ferromagnetism 转变元素Transition element 交换能量Positive energy exchange 外价电子Outer valence electrons 化学结合Chemical bond自发上磁Spontaneous magnetization 磁畴Magnetic domain 相反旋转Opposite span 比较抗磁体、顺磁体及铁磁体Comparison of Diamagnetism, Paramagnetic & Ferromagnetism 反铁磁体Antiferromagnetism 亚铁磁体Ferrimagnetism 磁矩magnetic moment 净磁矩Net magnetic moment 钢铁的主要成份The major element of steel 钢铁用"碳”之含量来分类Classification of Steel according to Carbon contents铁相Steel Phases钢铁的名称Name of steel纯铁体Ferrite渗碳体Cementitle奥氏体Austenite 珠光体及共释钢Pearlite &Eutectoid奥氏体碳钢Austenite Carbon Steel单相金属Single Phase Metal共释变态Eutectoid Transformation珠光体Pearlite 亚铁释体Hyppo-Eutectoid初释纯铁体Pro-entectoid ferrite过共释钢Hype-eutectoid珠光体Pearlite粗珠光体Coarse pearlite中珠光体Medium pearlite幼珠光体Fine pearlite磁性变态点Magnetic Transformation钢铁的制造Manufacturing of Steel连续铸造法Continuous casting process电炉Electric furnace均热炉Soaking pit全静钢Killed steel半静钢Semi-killed steel沸腾钢（未净钢）Rimmed steel钢铁生产流程Steel Production Flow Chart钢材的熔铸、锻造、挤压及延轧The Casting, Fogging, Extrusion, Rolling & Steel熔铸Casting锻造Fogging挤压Extrusion延轧Rolling冲剪Drawing & stamping特殊钢Special Steel简介General特殊钢以原素分类Classification of Special Steel according to Element特殊钢以用途来分类Classification of Special Steel according to End Usage 易车（快削）不锈钢Free Cutting Stainless Steel含铅易车钢Leaded Free Cutting Steel含硫易车钢Sulphuric Free Cutting Steel硬化性能Hardenability钢的脆性Brittleness of Steel低温脆性Cold brittleness回火脆性Temper brittleness日工标准下的特殊钢材Specail Steel according to JIS Standard铭钢-日工标准JIS G4104Chrome steel to JIS G4104铭钼钢钢材-日工标准G4105 62Chrome Molybdenum steel to JIS G4105银铭-日工标准G4102 63Chrome Nickel steel to JIS G4102银铭钼钢-日工标准G4103 64Nickel, Chrome & Molybdenum Steel to JIS G4103高锰钢铸-日工标准High manganese steel to JIS standard片及板材Chapter Four-Strip, Steel & Plate冷辘低碳钢片(双单光片)(日工标准JIS G3141) 73 - 95Cold Rolled (Low carbon) Steel Strip (to JIS G 3141)简介General美材试标准的冷辘低碳钢片Cold Rolled Steel Strip American Standard - American Society for testing and materials (ASTM)日工标准JIS G3141冷辘低碳钢片(双单光片)的编号浅释Decoding of cold rolled(Low carbon)steel strip JIS G3141材料的加工性能Drawing abillity硬度Hardness表面处理Surface finish冷辘钢捆片及张片制作流程图表Production flow chart cold rolled steel coil sheet冷辘钢捆片及张片的电镀和印刷方法Cold rolled steel coil & sheet electro-plating & painting method 冷辘（低碳）钢片的分类用、途、工业标准、品质、加热状态及硬度表End usages, industrial standard, quality, condition and hardness of cold rolled steel strip硬度及拉力Hardness & Tensile strength test拉伸测试（顺纹测试）Elongation test杯突测试（厚度:0.4公厘至1.6公厘，准确至0.1公厘3个试片平均数）Erichsen test (Thickness: to , figure round up to ) 曲面(假曲率)Camber厚度及阔度公差Tolerance on Thickness & Width平坦度(阔度大于500公厘，标准回火)Flatness (width>500mm, temper: standard)弯度Camber冷辘钢片储存与处理提示General advice on handling & storage of cold rolled steel coil & sheet防止生锈Rust Protection生锈速度表Speed of rusting焊接Welding气焊Gas Welding埋弧焊Submerged-arc Welding电阻焊Resistance Welding冷辘钢片(拉力:30-32公斤/平方米)在没有表面处理状态下的焊接状况Spot welding conditions for bared (free from paint, oxides etc) Cold rolled mild steel sheets(T/S:30-32 Kgf/ R m2) 时间效应(老化)及拉伸应变Aging & Stretcher Strains日工标准（JIS G3141）冷辘钢片化学成份Chemical composition - cold rolled steel sheet to JIS G3141冷辘钢片的“理论重量”计算方程式Cold Rolled Steel Sheet - Theoretical mass日工标准（JIS G3141）冷辘钢片重量列表Mass of Cold-Rolled Steel Sheet to JIS G3141冷辘钢片订货需知Ordering of cold rolled steel strip/sheet其它日工标准冷轧钢片（用途及编号）JIS standard & application of other cold Rolled Special Steel电镀锌钢片或电解钢片Electro-galvanized Steel Sheet/Electrolytic Zinc Coated Steel Sheet简介General电解/电镀锌大大增强钢片的防锈能力Galvanic Action improving Weather & Corrosion Resistance of the Base Steel Sheet上漆能力Paint Adhesion电镀锌钢片的焊接Welding of Electro-galvanized steel sheet点焊Spot welding滚焊Seam welding电镀锌（电解）钢片Electro-galvanized Steel Sheet生产流程Production Flow Chart常用的镀锌钢片（电解片）的基层金属、用途、日工标准、美材标准及一般厚度Base metal, application, JIS & ASTM standard, and Normal thickness of galvanized steel sheet锌镀层质量Zinc Coating Mass表面处理Surface Treatment冷轧钢片Cold-Rolled Steel Sheet/Strip热轧钢片Hot-Rolled Sheet/Strip电解冷轧钢片厚度公差Thickness Tolerance of Electrolytic Cold-rolled sheet热轧钢片厚度公差Thickness Tolerance of Hot-rolled sheet冷轧或热轧钢片阔度公差Width Tolerance of Cold or Hot-rolled sheet长度公差Length Tolerance理论质量Theoretical Mass锌镀层质量（两个相同锌镀层厚度）Mass Calculation of coating （For equal coating）/MM锌镀层质量（两个不同锌镀层厚度）Mass Calculation of coating （For differential coating）/MM镀锡薄铁片（白铁皮/马口铁）（日工标准JIS G3303）简介General镀锡薄铁片的构造Construction of Electrolytic Tinplate镀锡薄钢片（白铁皮/马日铁）制造过程Production Process of Electrolytic Tinplate锡层质量Mass of Tin Coating （JIS G3303-1987）两面均等锡层Both Side Equally Coated Mass两面不均等锡层Both Side Different Thickness Coated Mass级别、电镀方法、镀层质量及常用称号Grade, Plating type, Designation of Coating Mass & Common Coating Mass 镀层质量标记Markings & Designations of Differential Coatings硬度Hardness单相轧压镀锡薄铁片（白铁皮/马口铁）Single-Reduced Tinplate双相辗压镀锡薄钢片（马口铁/白铁皮）Dual-Reduction Tinplate钢的种类Type of Steel表面处理Surface Finish常用尺寸Commonly Used Size电器用硅［硅］钢片Electrical Steel Sheet简介General软磁材料Soft Magnetic Material滞后回线Narrow Hystersis矫顽磁力Coercive Force硬磁材料Hard Magnetic Material最大能量积Maximum Energy Product硅含量对电器用的低碳钢片的最大好处The Advantage of Using Silicon low Carbon Steel晶粒取向(Grain-Oriented)及非晶粒取向(Non-Oriented)Grain Oriented & Non-Oriented电器用硅［硅］钢片的最终用途及规格End Usage and Designations of Electrical Steel Strip电器用的硅［硅］钢片之分类Classification of Silicon Steel Sheet for Electrical Use电器用钢片的绝缘涂层Performance of Surface Insulation of Electrical Steel Sheets晶粒取向电器用硅钢片主要工业标准International Standard - Grain-Oriented Electrical Steel Silicon Steel Sheet for Electrical Use晶粒取向电器用硅钢片Grain-Oriented Electrical Steel晶粒取向，定取向芯钢片及高硼定取向芯钢片之磁力性能及夹层系数(日工标准及美材标准)Magnetic Properties and Lamination Factor of SI-ORIENT-CORE& SI-ORIENT-CORE-HI B Electrical Steel Strip (JIS and AISI Standard) 退火Annealing电器用钢片用家需自行应力退火原因Annealing of the Electrical Steel Sheet退火时注意事项Annealing Precautionary碳污染Prevent Carbon Contamination热力应先从工件边缘透入Heat from the Laminated Stacks Edges提防过份氧化No Excessive Oxidation应力退火温度Stress -relieving Annealing Temperature晶粒取向电器用硅［硅］钢片-高硼(HI-B)定取向芯钢片及定取向芯钢片之机械性能及夹层系数Mechanical Properties and Lamination Factors of SI-ORIENT-CORE-HI-B and SI-ORIENT-CORE Grain Orient Electrical Steel Sheets晶粒取向电器用硅［硅］钢;片-高硼低硫(LS)定取向钢片之磁力及电力性能Magnetic and Electrical Properties of SI-ORIENT-CORE-HI-B-LS晶粒取向电器用硅［硅］钢片-高硼低硫(LS)定取向钢片之机械性能及夹层系数Mechanical Properties and Lamination Factors of SI-ORIENT-CORE-HI-B-LS 晶粒取向电器用硅(硅)钢片-高硼(HI-B)定取向芯钢片，定取向芯钢片及高硼低硫(LS)定取向芯钢片之厚度及阔度公差Physical Tolerance of SI-ORIENT-CORE-HI-B, SI-ORIENT-CORE, & SI-CORE-HI-B-LS Grain Oriented Electrical Steel Sheets晶粒取向电器用硅(硅)钢片-高硼(HI-B)定取向芯钢片，定取向芯钢片及高硼低硫(LS)定取向芯钢片之标准尺寸及包装Standard Forms and Size of SI-ORIENT-CORE-HI-B,SI-CORE, &SI-ORIENT-CORE-HI-B-LS Grain-Oriented Electrical Steel Sheets绝缘表面Surface Insulation非晶粒取向电力用钢片的电力、磁力、机械性能及夹层系数Lamination Factors of Electrical, Magnetic & Mechanical Non-Grain Oriented Electrical 电器及家电外壳用镀层冷辘［低碳］钢片Coated （Low Carbon） Steel Sheets for Casing,Electricals & Home Appliances 镀铝硅钢片Aluminized Silicon Alloy Steel Sheet 简介General镀铝硅合金钢片的特色Feature of Aluminized Silicon Alloy Steel Sheet用途End Usages抗化学品能力Chemical Resistance镀铝（硅）钢片-日工标准（JIS G3314）Hot-aluminum-coated sheets and coils to JIS G 3314镀铝（硅）钢片-美材试标准（ASTM A-463-77）35.7 JIS G3314镀热浸铝片的机械性能Mechanical Properties of JIS G 3314 Hot-Dip Aluminum-coated Sheets and Coils 公差Size Tolerance镀铝（硅）钢片及其它种类钢片的抗腐蚀性能比较Comparsion of various resistance of aluminized steel & other kinds of steel镀铝（硅）钢片生产流程Aluminum Steel Sheet, Production Flow Chart焊接能力Weldability镀铝钢片的焊接状态（比较冷辘钢片）Tips on welding of Aluminized sheet in comparasion with cold rolled steel strip钢板Steel Plate钢板用途分类及各国钢板的工业标准包括日工标准及美材试标准Type of steel Plate & Related JIS, ASTM and Other Major Industrial Standards钢板生产流程Production Flow Chart钢板订货需知Ordering of Steel Plate不锈钢Stainless Steel不锈钢的定义Definition of Stainless Steel不锈钢之分类，耐腐蚀性及耐热性Classification, Corrosion Resistant & Heat Resistance of Stainless Steel铁铭系不锈钢片Chrome Stainless Steel马氏体不锈钢Martensite Stainless Steel低碳马氏体不锈钢Low Carbon Martensite Stainless Steel含铁体不锈钢Ferrite Stainless Steel银铭系不锈钢Nickel Chrome Stainless Steel释出硬化不锈钢Precipitation Hardening Stainless Steel铁锰铝不锈钢Fe / Mn / Al / Stainless Steel不锈钢的磁性Magnetic Property & Stainless Steel不锈钢箔、卷片、片及板之厚度分类Classification of Foil, Strip, Sheet & Plate by Thickness表面保护胶纸Surface protection film不锈钢片材常用代号Designation of SUS Steel Special Use Stainless表面处理Surface finish.9mm厚之片)机械性能Mechanical Properties of Thin Stainless Steel(Thickness from to ) - strip/sheet 不锈钢片机械性能(301, 304, 631, CSP)Mechanical Properties of Spring use Stainless Steel不锈钢-种类，工业标准，化学成份，特点及主要用途Stainless Steel - Type, Industrial Standard, Chemical Composition, Characteristic & end usage of the most commonly used Stainless Steel不锈钢薄片用途例End Usage of Thinner Gauge不锈钢片、板用途例Examples of End Usages of Strip, Sheet & Plate不锈钢应力退火卷片常用规格名词图解General Specification of Tension Annealed Stainless Steel Strips耐热不锈钢Heat-Resistance Stainless Steel银铬系耐热不锈钢特性、化学成份、及操作温度Heat-Resistance Stainless Steel铬系耐热钢Chrome Heat Resistance Steel银铭耐热钢Ni - Cr Heat Resistance Steel超耐热钢Special Heat Resistance Steel抗热超级合金Heat Resistance Super Alloy耐热不锈钢比重表Specific Gravity of Heat - resistance steel plates and sheets stainless steel不锈钢材及耐热钢材标准对照表Stainless and Heat-Resisting Steels发条片Power Spring Strip发条的分类及材料Power Spring Strip Classification and Materials上链发条Wind-up Spring倒后擦发条Pull Back Power Spring圆面（"卜竹"）发条Convex Spring Strip拉尺发条Measure Tape魔术手环Magic Tape魔术手环尺寸图Drawing of Magic Tap定型发条Constant Torque Spring定型发条及上炼发条的驱动力Spring Force of Constant Torque Spring and Wing-up Spring定型发条的形状及翻动过程Shape and Spring Back of Constant Torque Spring定型发条驱动力公式及代号The Formula and Symbol of Constant Torque Spring边缘处理Edge Finish硬度Hardness高碳钢化学成份及用途High Carbon Tool Steel, Chemical Composition and Usage每公斤发条的长度简易公式The Length of 1 Kg of Spring Steel StripSK-5 & AISI-301 每公斤长的重量/公斤(阔100-200 公厘)Weight per one meter long (kg) (Width 100-200mm)SK-5 & AISI-301 每公斤之长度(阔100-200 公厘)Length per one kg (Width 100-200mm) SK-5 & AISI-301每公尺长的重量/公斤(阔2.0-10公厘)-10mm)SK-5 & AISI-301每公斤之长度(阔2.0-10公厘)-10mm)高碳钢片High Carbon Steel Strip分类Classification用组织结构分类Classification According to Grain Structure用含碳量分类-即低碳钢、中碳钢及高碳钢Classification According to Carbon Contains弹簧用碳钢片CarbonSteel Strip For Spring Use冷轧状态Cold Rolled Strip回火状态Annealed Strip淬火及回火状态Hardened & Tempered Strip/ Precision - Quenched Steel Strip贝氏体钢片Bainite Steel Strip弹簧用碳钢片材之边缘处理Edge Finished 淬火剂Quenching Media 碳钢回火Tempering 回火有低温回火及高温回火Low & High Temperature Tempering高温回火High Temperature Tempering退火Annealing完全退火Full Annealing扩散退火Diffusion Annealing低温退火Low Temperature Annealing中途退火Process Annealing球化退火Spheroidizing Annealing光辉退火Bright Annealing淬火Quenching时间淬火Time Quenching奥氏铁孺回火Austempering马氏铁体淬火Marquenching高碳钢片用途End Usage of High Carbon Steel Strip 冷轧高碳钢-日本工业标准Cold-Rolled (Special Steel) Carbon Steel Strip to JIS G3311 电镀金属钢片Plate Metal Strip 简介General 电镀金属捆片的优点Advantage of Using Plate Metal Strip金属捆片电镀层Plated Layer of Plated Metal Strip镀银Nickel Plated镀铭Chrome Plated镀黄铜Brass Plated基层金属Base Metal of Plated Metal Strip低碳钢或铁基层金属Iron & Low Carbon as Base Metal不锈钢基层金属Stainless Steel as Base Metal铜基层金属Copper as Base Metal黄铜基层金属Brass as Base Metal轴承合金Bearing Alloy简介General轴承合金-日工标准JIS H 5401Bearing Alloy to JIS H 5401锡基、铅基及锌基轴承合金比较表Comparison of Tin base, Lead base and Zinc base alloy for Bearing purpose易溶合金Fusible Alloy焊接合金Soldering and Brazing Alloy软焊Soldering Alloy软焊合金-日本标准JIS H 4341Soldering Alloy to JIS H 4341硬焊Brazing Alloy其它焊接材料请参阅日工标准目录Other Soldering Material细线材、枝材、棒材Chapter Five Wire, Rod & Bar线材/枝材材质分类及制成品Classification and End Products of Wire/Rod铁线（低碳钢线）日工标准JIS G 3532Low Carbon Steel Wires （ Iron Wire ） to JIS G 3532光线（低碳钢线），火线（退火低碳钢线），铅水线（镀锌低碳钢线）及制造钉用低碳钢线之代号、公差及备注Ordinary Low Carbon Steel Wire, Annealed Low Carbon Steel Wire, Galvanized low Carbon Steel Wire & Low Carbon Steel Wire for nail manufacturing - classification, Symbol of Grade, Tolerance and Remarks.机械性能Mechanical Properites锌包层之重量，铜硫酸盐试验之酸洗次数及测试用卷筒直径Weight of Zinc-Coating, Number of Dippings in Cupric Sulphate Test and Diameters of Mandrel Used for Coiling Test 冷冲及冷锻用碳钢线枝Carbon Steel Wire Rods for Cold Heading & Cold Forging (to JIS G3507)级别，代号及化学成份Classification, Symbol of Grade and Chemical Composition直径公差，偏圆度及脱碳层的平均深度Diameter Tolerance, Ovality and Average Decarburized Layer Depth冷拉钢枝材Cold Drawn Carbon Steel Shafting Bar枝材之美工标准，日工标准，用途及化学成份AISI, JIS End Usage and Chemical Composition of Cold Drawn Carbon Steel Shafting Bar 冷拉钢板重量表Cold Drawn Steel Bar Weight Table高碳钢线枝High Carbon Steel Wire Rod (to JIS G3506)冷拉高碳钢线Hard Drawn High Carbon Steel Wire(to JIS G3521, ISO-84580-1&2)化学成份分析表Chemical Analysis of Wire Rod线径、公差及机械性能(日本工业标准G 3521)Mechanical Properties (JIS G 3521)琴线(日本标准G3522)Piano Wires ( to G3522)级别，代号，扭曲特性及可用之线材直径Classes, symbols, twisting characteristic and applied Wire Diameters直径，公差及拉力强度Diameter, Tolerance and Tensile Strength裂纹之容许深度及脱碳层Permissible depth of flaw and decarburized layer 常用的弹簧不锈钢线-编号，特性，表面处理及化学成份StainlessSpring Wire - National Standard number, Charateristic, Surface finish & Chemical composition弹簧不锈钢线，线径及拉力列表Stainless Spring Steel, Wire diameter and Tensile strength of Spring Wire处理及表面状况Finish & Surface各种不锈钢线在不同处理拉力比较表Tensile Strength of various kinds of Stainless Steel Wire under Different Finish圆径及偏圆度之公差Tolerance of Wire Diameters & Ovality铭银不锈钢及抗热钢弹簧线材-美国材验学会ASTM A313 - 1987Chromium - Nickel Stainless and Heat-resisting Steel Spring Wire - ASTM A313-1987化学成份Chemical Composition机械性能Mechanical Properties305, 316, 321及347之拉力表Tensile Strength Requirements for Types 305, 316, 321 and 347A1S1-302贰级线材之拉力表Tensile Strength of A1S1-302 Wire日本工业标准-不锈钢的化学成份（先数字后字母排列）JIS - Chemical Composition of Stainless Steel （in order of number & alphabet）美国工业标准-不锈钢及防热钢材的化学成份（先数字后字母排列）AISI - Chemical Composition of Stainless Steel & Heat-Resistant Steel（in order of number & alphabet）易车碳钢Free Cutting Carbon Steels （to JIS G4804 ）化学成份Chemical composition圆钢枝，方钢枝及六角钢枝之形状及尺寸之公差Tolerance on Shape and Dimensions for Round Steel Bar, Square Steel Bar, HexagonalSteel Bar易车（快削）不锈钢Free Cutting Stainless Steel易车（快削）不锈钢种类Type of steel易车（快削）不锈钢拉力表Tensile Strength of Free Cutting Wires枝/棒无芯磨公差表（口）（口= 1/100 mm）Rod/Bar Centreless Grind Tolerance。

indication 缺点1.2.test specimen 试样3.bar 棒材4.stock 原料5.billet 方钢，钢方坯6.bloom 钢坯,钢锭7.section 型材8.steel ingot 钢锭9.blank 坯料，半成品10.cast steel 铸钢11.nodular cast iron 球墨铸铁12.ductile cast iron 球墨铸铁13.bronze 青铜14.brass 黄铜15.copper 合金16.stainless steel 不锈钢17.decarburization 脱碳18.scale 氧化皮19.anneal 退火20.process anneal 进展退火21.quenching 淬火22.normalizing 正火23.Charpy impact text 夏比冲击试验24.fatigue 疲乏25.tensile testing 拉伸试验26.solution 固溶办理27.aging 时效办理28.Vickers hardness 维氏硬度29.Rockwell hardness 洛氏硬度30.Brinell hardness 布氏硬度31.hardness tester 硬度计32.descale 除污，除氧化皮等33.ferrite 铁素体34.austenite 奥氏体35.martensite 马氏体36.cementite 渗碳体37.iron carbide 渗碳体38.solid solution 固溶体39.sorbite 索氏体40.bainite 贝氏体41.pearlite 珠光体42.nodular fine pearlite/ troostite 屈氏体43.black oxide coating 发黑44.grain 晶粒45.chromium 铬46.cadmium 镉47.tungsten 钨48.molybdenum 钼49.manganese 锰50.vanadium 钒51.molybdenum 钼52.silicon 硅53.sulfer/sulphur 硫54.phosphor/ phosphorus 磷55.nitrided 氮化的56.case hardening 外表硬化，外表淬硬57.air cooling 空冷58.furnace cooling 炉冷59.oil cooling 油冷60.electrocladding /plating 电镀61.brittleness 脆性62.strength 强度63.rigidity 刚性,刚度64.creep 蠕变65.deflection 挠度66.elongation 延长率67.yield strength 折服强度68.elastoplasticity 弹塑性69.metallographic structure 金相组织70.metallographic test 金相试验71.carbon content 含碳量72.induction hardening 感觉淬火73.impedance matching 感觉淬火74.hardening and tempering 调质75.crack 裂纹76.shrinkage 缩孔，松散77.forging 锻〔件〕78.casting 铸〔件〕79.rolling 轧〔件〕80.drawing 拉〔件〕81.shot blasting 喷丸〔办理〕82.grit blasting 喷钢砂〔办理〕83.sand blasting 喷砂〔办理〕84.carburizing 渗碳85.nitriding 渗氮86.ageing/aging 时效87.grain size 晶粒度88.pore 气孔89.sonim 夹砂90.cinder inclusion 夹渣ttice 晶格92.abrasion/abrasive/rub/wear/wearing resistance (property) 耐磨性93.spectrum analysis 光谱解析热办理94.heat/thermal treatment95.inclusion 夹杂物96.seGREgation 偏析97.picking 酸洗，酸浸98.residual stress 节余应力99.remaining stress 节余应力100.relaxation of residual stress 除掉节余应力101.stress relief 应力开释A R steel 高温度锰钢abnormal steel 失常钢; 非正常钢aluminium-steel cable 钢铝电缆aluminized steel 涂铝钢aluminum nickel steel 铝镍钢anchored steel trestle 锚固式钢栈桥angle steel ruler 钢角尺anisotropic steel 各向异性钢片anisotropy silicon steel 各向异性硅钢片annealed sheet steel 退火薄钢板annealed steel 退火钢; 韧钢anti-creeping angle steel 防爬角铁anticorrosive aluminium-coated steel wire防蚀镀铝钢丝arc-furnace steel 电炉钢arc-welded steel pipe 电弧焊接钢管area of steel 钢筋断面面积; 钢筋截面面积area of structural steel 型钢截面积Armco aluminized steel 阿姆柯渗铝钢armco aluminized steel 外表浸镀铝钢Armco stabilized steel 阿母柯稳固化钢Armco steel 阿姆柯软钢armco steel 不硬化钢austenilic Ni-Cr stainless steel 奥氏体镍铬不锈钢austenitic alloy steel 奥氏体合金钢austenitic chromium-nickel steel 奥氏体铬-镍钢austenitic clad steel 奥氏体复合钢austenitic heat-resistance steel 奥氏体耐热钢austenitic manganese steel 奥氏体锰钢; 哈德菲尔德锰钢austenitic stainless steel 奥氏体不锈钢austenitic steel 奥氏体钢automatic steel 易切削钢automatic(al) steel 易切削钢axle shaft steel 车轴钢axle steel 车轴钢钢铁业的英语词汇 1Carbon Steel Plate 碳素钢板; 碳素钢板和型材Carbon Tool Steel 碳工具钢; 碳素工具钢Carbon-Containing Alloy Steel 含碳合金钢Carbon-Free Stainless Steel 无碳不锈钢Carbon-Free Steel 无碳钢Carburizing Steel 碳钢Case-Hardened Steel 外表渗碳硬化钢; 渗碳钢Bolts & Nuts For Steel Slotted 角钢螺丝Cast Alloy Steel Piston 合金铸钢活塞Cast Iron Electrode With Steel Core 钢芯铸铁焊条Cast Stainless Steel 锻造不锈钢Cast Steel 铸钢件Cast Steel Plate 铸钢板Cast(Carbon) Steel 铸钢Cast-In Steel Bush 铸入钢套Casement Section Steel 窗框钢Cast-Steel 铸钢Cast-Steel Crossing 铸钢辙叉Cast-Steel Pipe 铸钢管Cast-Steel Separator 铸钢隔板; 铸钢横梁Cast-Steel Shot 钢砂Cast-Steel Yoke 铸钢轭Cellular Steel Floor 格型钢楼板Cement-And-Grouted Steel Bolt 钢筋沙浆锚杆Cemented Steel 外表硬化钢Cemented Templet Steel 渗碳样板钢Centra Steel 球状石墨铸钢Centrifugal Steel 离心铸钢Centrifuge(D) Steel 离心锻造钢Channel Steel 槽钢Channel-Section Steel 槽形钢Channeled-Steel Wheel Rim 槽钢制轮辋Checkered Steel Plate 花纹钢板Chemical Capped Steel 化学封顶钢Chilled Cast Steel 冷硬铸钢Chilled Hardened Steel 淬火钢Chilled Steel 淬火钢; 淬硬钢Chisel Steel 凿钢; 凿子钢Chrome Hardened Steel 铬硬化钢Chrome Steel 铬钢Chrome-Carbon Steel 铬碳钢Chrome-Manganese Nitrogen Steel 铬锰氮钢Chrome-Manganese-Silicon Alloy Steel 铬锰硅合金钢Chrome-Molybdenum Steel 铬钼钢Chrome-Nickel Steel 铬镍钢Chrome-Plated Steel Nozzle 镀铬钢喷管Chrome-Silicon Steel 铬硅钢Chrome-Tungsten Steel 铬钨钢Chrome-Vanadium Steel 铬钒钢Chromemanganese Steel 铬锰钢Chromium Nickel Steel 高强度耐蚀铬镍钢Chromium Stainless Steel 铬不锈钢Chromium Steel 铬钢Chromium-Molybdenum Steel 铬钼钢Chromium-Nickel Steel 铬镍钢Chromium-Plated Mild Steel Animal Chain 镀铬软钢动物链条Chromium-Tungstenvanadium Steel 铬钨钒钢Chromiummanganese Steel 铬锰钢Chromiumnickel Austenite Stainless Steel 铬镍奥氏体不锈钢Chromiumplated Thin-Walled Steel Cylinder Liner 钢质薄壁镀铬汽缸衬套Chromized Steel 渗铬钢Circular Steel Support 环形金属支架Clad Sheet Steel 包层薄钢板Clad Steel 包层钢; 双层钢; 双金属钢Clad Steel Plate 复合钢板Cladding Steel 包覆钢Cladding Steel Sheet 复合钢板Clean Steel 纯洁钢; 干净钢Closed Die Steel 闭锻模钢Coarse-Grained Steel 粗晶粒钢Coated Steel 镀层钢板Coating Steel Pipe 镀锌钢管Cobalt High Speed Steel 钴高速钢Cobalt-Chromium Steel 钴铬钢Coiled Steel 成卷带钢Cold Forging Steel 冷锻钢Cold Pressed Steel 冷压钢Cold Reduced Steel 马口铁卷板Cold Rolled Ribbed Steel Bar 冷轧竹节钢筋Cold Rolled Sheet Steel 冷轧薄钢板Cold Twisted Steel Bar 冷扭钢筋Cold-Banded Steel Pipe 冷箍钢管Cold-Drawn Steel 冷拔钢; 冷拉钢Cold-Drawn Steel Pipe 冷拉钢管Cold-Drawn Steel Tube 冷拉钢管Cold-Finished Steel 冷加工精整钢Cold-Pressed Sheet Steel 冷压薄钢板Cold-Pressed Steel Plate 冷压钢板Cold-Pressing Quality Steel 冷弯钢Cold-Roll Steel Sheets 冷轧钢板Cold-Rolled (Cold Rolled) Steel 冷轧钢Cold-Rolled Carbon Spring Steel 冷轧弹簧碳钢Cold-Rolled Carbon Steel 冷轴碳钢Cold-Rolled Steel Strip 冷轧带钢Cold-Shaping Steel 冷变形钢Cold-Short Steel 冷脆钢Cold-Steel 利器Cold-Strip Steel 冷轧带钢Cold-Strip Steel Rolling Mill 冷轧带钢机; 带钢冷轧机Cold-Worked Steel 冷作钢Cold-Working Steel 冷作钢Coldshort Steel 冷脆钢Color Stainless Steel 彩色不锈钢Colored Stainless Steel 彩色不锈钢Column With Steel Hooping 螺旋箍筋柱Combined Steel And Concrete Column 钢骨混凝土柱Comminuted Steel Shot 钢粉Common Straight Carbon Steel 一般碳素钢Complex Alloy Steel 多元合金钢; 合金钢碳素构造钢Carbon Construction Steel碳素工具钢合金构造钢合金工具钢高速工具钢Carbon Tool Steel Alloy Construction Steel Alloy Tool SteelHigh Speed Tool Steel弹簧钢Spring Steel不锈耐热钢Stainless & Heat Resisting Steel 轴承钢Bearing Steel工字钢一般圆钢Ibeam Round Steel槽钢Channel扁钢Flat Steel Bar等边角钢不等边角钢Equal Angle SteelUnequal Angle Steelh型钢Hbeam钢坯Billet,Bloom钢筋混凝土用变形钢筋窗框钢Window SashHigh Strength Deformed Steel Bar 中厚钢板Steel Plate热轧钢板〔卷〕冷轧钢板〔卷〕镀锌钢板〔卷〕钢带Steel Strip Hot Rolled Steel CoilCold Rolled Steel Sheel or Coil Galvanized Steel Coil线材Wire Rod Coil无缝钢管Seamless Steel Pipe锅炉管石油套管高压管Boiler TubePipe For Oil Field Pressure Pipe高压气瓶用管地质钻探用管Tube for High-Pressure Vessel Seamless Steel Pipe For Geological Drill In镀锌焊管Galvanized Welded Pipe 石油钻探杆Drill Pipe For Oil Field 铸铁管Cast Iron Pipe重轨Heavy Rail轻轨Light Rail炼钢生铁锻造生铁一般圆钢钉Basic Pig Ironfoundry Pig IronRound Nails for General Uses镀锌底碳钢丝Galvanized Low Carbon Steel Wire.钢丝绳Steel Wire Rope钢绞线Stranded Wire预应力混凝土钢丝窗纱Window ScreenSteel Wire For Prestressed Concrete车轮Wheel Tyre轮筛Wheel Circleiron and steel industry 钢铁工业ironworks 铁厂foundry 锻造车间steelworks,steel mill 钢厂cokingplant 炼焦厂electrometallurgy 电冶金学powder metallurgy 粉末冶金学blast furnace 鼓风炉mouth, throat 炉口hopper, chute 料斗stack 炉身belly 炉腰bosh 炉腹crucible 炉缸slag tap 放渣口taphole 出铁口,出渣口pig bed 铸床mould 铸模(美作:mold)tuyere, nozzle 风口ingot mould 锭模(美作:ingot mold) floor 平台hearth 炉底charger 装料机ladle 铁水包,钢水包dust catcher 除尘器washer 清洗塔converter 转炉hoist 卷扬机compressor 压缩机tilting mixer 可倾式混铁炉regenerator 蓄热室heat exchanger 热交换器gas purifier 煤气净化器turbocompressor 涡轮压缩机burner 烧嘴cupola 化铁炉,冲天炉emptier 排空装置trough 铁沟渠,排渣沟skip 料车rolling mill 轧机,轧钢机blooming mill 初轧机roller 辊bed 底座rolling-mill housing 轧机机架drawbench 拔管机,拉丝机drawplate 拉模板shaft furnace 竖炉refining furnace 精华炉reverberatory furnace 反射炉hearth furnace 床式反射炉firebrick lining 耐火砖衬retort 反响罐muffle 马弗炉roof, arch 炉顶forge 锻造press 压锻pile hammer 打桩锤drop hammer 落锤die 拉模blowlamp 吹炬(美作:blowtorch) crusher 裂开机iron ore 铁矿石coke 焦炭bauxite 铁钒土alumina 铝cryolite 冰晶石flux 熔剂limestone flux 石灰石溶剂haematite 赤铁矿(美作:hematite) gangue 脉石cast iron 铸铁cast iron ingot 铸铁锭slag 炉渣soft iron 软铁pig iron 生铁wrought iron 熟铁iron ingot 铁锭puddled iron 搅炼熟铁round iron 圆铁scrap iron 废铁steel 钢crude steel 粗钢mild steel, soft steel 软钢,低碳钢hard steel 硬钢cast steel 坩埚钢,铸钢stainless steel 不锈钢electric steel 电工钢,电炉钢high-speed steel 高速钢moulded steel 铸钢refractory steel 热强钢,耐热钢alloy steel 合金钢plate, sheet 薄板corrugated iron 瓦垅薄钢板tinplate, tin 马口铁finished product 成品,产品semifinished product 半成品,中间产品ferrous products 铁制品coiled sheet 带状薄板bloom 初轧方坯metal strip, metal band 铁带,钢带billet 坯锭,钢坯shavings 剃边profiled bar 异型钢材shape, section 型钢angle iron 角钢frit 烧结wire 线材ferronickel 镍铁elinvar 镍铬恒弹性钢ferrite 铁氧体,铁醇盐cementite 渗碳体,碳化铁pearlite 珠光体charging, loading 装料,炉料fusion, melting, smelting 熔炼remelting 再溶化,重熔refining精华casting 出铁to cast 出铁tapping 出渣,出钢,出铁to insufflate, to inject 注入heating 加热preheating 预热tempering 回火temper 回火hardening 淬水annealing 退火reduction 复原cooling 冷却decarbonization, decarburization 脱碳coking 炼焦slagging, scorification 造渣carburization 渗碳case hardening 外表硬化cementation 渗碳fritting,sintering 烧结puddling搅炼pulverization 粉化,雾化nitriding 渗氮alloy 合金floatation, flotation 浮选patternmaking 制模moulding 成型(美作:molding) calcination 煅烧amalgamation 汞齐化rolling 轧制drawing 拉拔extrusion 挤压wiredrawing 拉丝stamping, pressing 冲压die casting 拉模锻造forging 锻造turning 车削milling 铣削machining, tooling 加工autogenous welding, fusion welding氧炔焊arc welding 电弧焊electrolysis 电解trimming 清理焊缝blowhole 气孔钢铁业的英语词汇 2Abnormal Steel 失常钢; 非正常钢Aluminum-steel Cable 钢铝电缆Aluminized Steel 涂铝钢Aluminum Nickel Steel 铝镍钢Anchored Steel Trestle 锚固式钢栈桥Angle Steel Ruler 钢角尺Anisotropic Steel 各向异性钢片Anisotropy Silicon Steel 各向异性硅钢片Annealed Sheet Steel 退火薄钢板Annealed Steel 退火钢; 韧钢Anti-Creeping Angle Steel 防爬角铁Anticorrosive Aluminum-Coated Steel Wire 防蚀镀铝钢丝1.Arc-Furnace Steel 电炉钢Arc-Welded Steel Pipe 电弧焊接钢管Area Of Steel 钢筋断面面积; 钢筋截面面积Area Of Structural Steel 型钢截面积Armco Aluminized Steel 阿姆柯渗铝钢Armco Aluminized Steel 外表浸镀铝钢Armco Stabilized Steel 阿母柯稳固化钢Armco Steel 阿姆柯软钢Armco Steel 不硬化钢Austenitic Ni-Cr Stainless Steel 奥氏体镍铬不锈钢Austenitic Alloy Steel 奥氏体合金钢Austenitic Chromium-Nickel Steel 奥氏体铬-镍钢Austenitic Clad Steel 奥氏体复合钢Austenitic Heat-Resistance Steel 奥氏体耐热钢Austenitic Manganese Steel 奥氏体锰钢; 哈德菲尔德锰钢Austenitic Stainless Steel 奥氏体不锈钢Austenitic Steel 奥氏体钢Automatic Steel 易切削钢Automatic(Al) Steel 易切削钢Axle Shaft Steel 车轴钢Axle Steel 车轴钢Bain tic Steel 贝氏体钢Balanced Steel 半冷静钢Ball Bearing Steel Strip 滚珠轴承钢带Ball Race Steel 滚珠轴承圈钢Ball-Bearing Steel 滚珠轴承钢Bamboo Steel 竹节钢筋Band Steel 带钢Banding Steel 带钢; 箍钢Bar Steel 棒钢; 条钢Basic Bessemer Steel 碱性贝氏转炉钢Basic Bessemer Steel 碱性转炉钢Basic Bessemer Steel Converter 碱性转炉钢转炉Basic Converter Steel 碱性转炉钢Basic Electric Furnace Steel 碱性电炉钢Basic Open Hearth Steel 碱性平炉钢Battened Steel Column 双肢钢Beam Steel Plate 大梁钢板Beam With Compression Steel 双筋梁Bearing Quality Steel 滚珠钢Bearing Steel 轴承钢Bent Steel 挠曲钢筋Bessemer Low Carbon Steel 酸性转炉低碳钢Bessemer Mild Steel 贝色麦钢Bessemer Steel 贝色麦钢; 酸性钢Best Plough Steel Wire 铅淬火高强度钢丝Billet Steel 坯段钢; 钢坯; 短条钢Binary Steel 二元合金钢Black Mild Steel Carriage Bolt And Nut 黑铁马车螺丝闩Black Mild Steel Fish Bolt And Nut 黑铁鱼尾螺丝闩Black Mild Steel Flat Head Rivet 黑铁扁头铆钉Black Mild Steel Flat Head Tin men Rivet 黑铁号头铆钉Black Mild Steel Hexagonal Nut 黑铁六角螺丝帽Black Mild Steel Pan Head Rivet 黑铁锥头铆钉Black Mild Steel Round Head Rivet 黑铁圆头铆钉Black Mild Steel Square Nut 黑铁四方螺丝帽Black Steel Pipe 黑钢板Black Steel Sheet 黑钢皮Black Tin Steel 黑钢板Blister Steel 泡钢; 泡面钢Abnormal Structure Steel 失常组织钢Abrasion-Resistant Steel 耐磨钢Blue Steel 蓝钢Bluing Of Steel 钢加蓝Boiler Steel 锅炉钢; 锅炉钢板Boiler Steel Plate 锅炉钢板Boiling Steel 沸腾钢Bolting Steel 螺栓钢Blue Planished Steel 发蓝薄钢板Bloom Steel 初轧钢; 钢坯Boron Steel 硼钢Brass Fitting Of Steel Window 钢窗铜配件Brass-Plated Mild Steel Round Bead Wood Screw 镀黄铜圆头软钢木螺丝Brass-Plated Mild Steel Round Head Machine Screw 镀黄铜圆头软钢机器螺丝Brass-Plated Steel Wire 镀黄铜钢丝Brearley Steel 布里阿雷不锈钢; 布氏高铬钢Bridge Steel 桥梁钢Bright And Black Mild Steel Flat Head Tinmen Rivet 号头铆钉Bright Mild Steel Cotter Pin 光明软钢开尾销Bright Mild Steel Countersunk Head Wood Screw 光明软钢平头木螺丝Bright Mild Steel Hexagonal Nut 光明软钢六角螺丝帽Bright Mild Steel Hexagonal Nuts 六角光螺帽; 六角螺丝帽Bright Mild Steel Hexagonal Pressed Nut 光明软钢六角冲压螺丝帽Bright Mild Steel Round Head Wood Screw 光明软钢圆头木螺丝Bright-Drawn Free Cutting Steel 光拉自由切削钢Bright-Drawn Steel 光明拉拔钢材Bright-Finished Steel 光明精整钢Bristol Steel Belt Lacing 布瑞斯涛钢带接头Bronze Steel 镀青铜钢Building Of Steel Frame Construction 钢框架房屋Bulb Steel 球扁钢Bulb-Rail Steel 球头丁字钢Burned Steel 过烧钢Calorized Steel 涂铝钢; 渗化钢Calorizing Steel 铝化钢Capped Steel 加盖钢; 半冷静钢Carbon And Low-Alloy Steel Vessels 碳钢及低合金钢容器Carbon Content Of Steel 钢含碳量Carbon Molybdenum Steel 钼碳钢Carbon Steel 碳钢; 碳素钢Carbon Steel Covered Electrode 碳钢焊条Carbon Steel Plate2.中文名英文名质量描述6063 6063 Extrusion-pntd 镀漆6061 6061 Extrusion-pntd 镀漆生铝件Tense 含铁〈2% 生杂铝Mixed Cast 含铁〈2% 旧铝片Old Sheet-Taint/Tabor 干净铝片Tough-Taboo 干净切碎铝Shredded Aluminum 干净汽车切片铝Shredded Auto Aluminum 含铝70% 带铁铝Irony Aluminum 需注明含量356 轮毂铝356 Auto Wheels 干净铝水箱Aluminum Radiator 干净带皮铝线Acsr/Ins 需注明含量铜铝水箱Al/Cu Radiator 干净易拉罐UBC-Baled/Densified 干净铝变压器Aluminum Transformer铝壳马达Aluminum Case Motor1# 光明铜线#1 Bare Bright 干净1# 铜#1 Candy 含铜98% 2# 铜#2 Birch/Cliff 含铜94-96% 1# 火烧线#1 Burnt Wire 含铜〉97% 1# 铜米#1 Cu-chop1# 铜线缆#1 Insulated Wire 含铜72%2# 铜线缆#2 Insulated Wire 含铜50-55% 1#2# 混杂铜线缆#1#2 Mixed Wire 含铜65% 黄杂铜Yellow Brass-Honey 干净干净铜水箱Ocean Auto Radiator 干净(牛粪)切碎电机Shredded Pickings 含铜18-20% 混杂电机Electric Motors 含铜8-12% 304 炉料304 Sabot 18-8304 可利用料316 可利用料304 Reusable 板或杆316 Reusable 板或杆3.1、烧结sintering粉末或压坯在低于主要组分熔点的温度下的热办理，目的在于经过颗粒间的冶金联合以提升其强度。

钢铁冶金专业英语词汇目录1 总论 (1)2 采矿 (1)3 选矿 (1)4 冶金过程物理化学 (2)4.1 冶金过程热力学 (2)4.2 冶金过程动力学 (4)4.3 冶金电化学 (5)4.4 冶金物理化学研究方法 (5)5 钢铁冶金 (5)5.1 炼焦 (5)5.2 耐火材料 (6)5.3 碳素材料 (7)5.4 铁合金 (7)5.5 烧结与球团 (8)5.6 高炉炼铁 (9)5.7 炼钢 (10)5.8 精炼、浇铸及缺陷 (12)6 钢铁材料 (14)7 英译汉 (15)1 总论采矿mining地下采矿underground mining露天采矿open cut mining, open pit mining, surface mining采矿工程mining engineering选矿（学）mineral dressing, ore beneficiation, mineral processing矿物工程mineral engineering冶金（学）metallurgy过程冶金（学）process metallurgy提取冶金（学）extractive metallurgy化学冶金（学）chemical metallurgy物理冶金（学）physical metallurgy金属学Metallkunde冶金过程物理化学physical chemistry of process metallurgy冶金反应工程学metallurgical reaction engineering冶金工程metallurgical engineering钢铁冶金（学）ferrous metallurgy, metallurgy of iron and steel有色冶金(学)nonferrous metallurgy真空冶金(学)vacuum metallurgy等离子冶金(学)plasma metallurgy微生物冶金(学)microbial metallurgy喷射冶金(学)injection metallurgy钢包冶金(学)ladle metallurgy二次冶金(学)secondary metallurgy机械冶金(学)mechanical metallurgy焊接冶金(学)welding metallurgy粉末冶金(学)powder metallurgy铸造学foundry火法冶金(学)pyrometallurgy湿法冶金(学)hydrometallurgy电冶金(学)electrometallurgy氯冶金(学)chlorine metallurgy矿物资源综合利用engineering of comprehensive utilization of mineral resources中国金属学会The Chinese Society for Metals 中国有色金属学会The Nonferrous Metals Society of China2 采矿采矿工艺mining technology 有用矿物valuable mineral冶金矿产原料metallurgical mineral raw materials矿床mineral deposit特殊采矿specialized mining海洋采矿oceanic mining, marine mining矿田mine field矿山mine露天矿山surface mine地下矿山underground mine矿井shaft矿床勘探mineral deposit exploration矿山可行性研究mine feasibility study矿山规模mine capacity矿山生产能力mine production capacity矿山年产量annual mine output矿山服务年限mine life矿山基本建设mine construction矿山建设期限mine construction period矿山达产arrival at mine full capacity开采强度mining intensity矿石回收率ore recovery ratio矿石损失率ore loss ratio工业矿石industrial ore采出矿石extracted ore矿体orebody矿脉vein海洋矿产资源oceanic mineral resources矿石ore矿石品位ore grade岩石力学rock mechanics岩体力学rock mass mechanics3 选矿选矿厂concentrator, mineral processing plant工艺矿物学process mineralogy开路open circuit闭路closed circuit流程flowsheet方框流程block flowsheet产率yield回收率recovery矿物mineral粒度particle size粗颗粒coarse particle炼vacuum Kimitsu injection process君津真空喷粉法vacuum metallurgy真空冶金(学)vacuum oxygen decarburization process ,VOD 真空吹氧脱碳法vacuum refining真空精炼valuable mineral有用矿物vanadium titano-magne钒钛磁铁矿tite vaporization cooling汽化冷却vein矿脉vermicular cast iron蠕墨铸铁vermiculite蛭石vermiculizer蠕化剂vertical caster立式连铸机vertical guide roll立式导辊vertical-bending caster立弯式连铸机vibrating screen震动筛viscosity粘度weir and dam in tundish中间包挡墙welding metallurgy焊接冶金(学)wetting润湿white cast iron白口铸铁white slag白渣withdrawal roll拉辊wollastonite硅灰石working bolume工作容积wrought iron熟铁wustite维式体xylene二甲苯yield产率zero order reaction零级反应zirconia graphite brick锆炭砖zoned lining分区砌砖。

iron and steel industry 钢铁工业ironworks铁厂foundry 铸造车间steelworks, steel mill 钢厂coking plant 炼焦厂electrometallurgy电冶金学powder metallurgy粉末冶金学blast furnace 鼓风炉mouth, throat 炉口hopper, chute 料斗stack 炉身belly 炉腰bosh 炉腹crucible 炉缸slag tap 放渣口taphole 出铁口，出渣口pig bed 铸床mould 铸模（美作：mold）tuyere, nozzle 风口ingot mould 锭模（美作：ingot mold）floor 平台hearth 炉底charger装料机ladle 铁水包，钢水包dust catcher 除尘器washer 洗涤塔converter 转炉hoist 卷扬机compressor 压缩机tilting mixer 可倾式混铁炉regenerator 蓄热室heat exchanger 热交换器gas purifier 煤气净化器turbocompressor 涡轮压缩机burner 烧嘴cupola 化铁炉，冲天炉emptier 排空装置trough 铁水沟，排渣沟skip 料车rolling mill 轧机，轧钢机blooming mill 初轧机roller 辊bed 底座rolling-mill housing轧机机架drawbench 拔管机，拉丝机drawplate 拉模板shaft furnace 竖炉refining furnace 精炼炉reverberatory furnace 反射炉hearth furnace 床式反射炉firebrick lining耐火砖衬retort 反应罐muffle 马弗炉roof, arch 炉顶forge 锻造press 压锻pile hammer打桩锤drop hammer 落锤die拉模blowlamp 吹炬（美作：blowtorch）crusher破碎机iron ore 铁矿石coke 焦炭bauxite铁钒土alumina 铝cryolite 冰晶石flux 熔剂limestone flux 石灰石溶剂haematite 赤铁矿（美作：hematite）gangue 脉石cast iron铸铁cast iron ingot铸铁锭slag 炉渣soft iron软铁pig iron 生铁wrought iron 熟铁iron ingot 铁锭puddled iron 搅炼熟铁round iron 圆铁scrap iron 废铁steel 钢crude steel 粗钢mild steel, soft steel 软钢，低碳钢hard steel 硬钢cast steel 坩埚钢，铸钢stainless steel 不锈钢electric steel 电工钢，电炉钢high-speed steel 高速钢moulded steel 铸钢refractory steel 热强钢，耐热钢alloy steel 合金钢plate, sheet薄板corrugated iron 瓦垅薄钢板tinplate, tin 马口铁finished product 成品，产品semifinished product 半成品，中间产品ferrous products 铁制品coiled sheet 带状薄板bloom 初轧方坯metal strip, metal band 铁带，钢带billet 坯锭，钢坯shavings 剃边profiled bar 异型钢材shape, section 型钢angle iron 角钢frit 烧结wire 线材ferronickel 镍铁elinvar 镍铬恒弹性钢ferrite 铁氧体，铁醇盐cementite 渗碳体，碳化铁pearlite 珠光体charging, loading 装料，炉料fusion, melting, smelting 熔炼remelting 再熔化，重熔refining 精炼casting 出铁to cast 出铁tapping 出渣，出钢，出铁to insufflate, to inject 注入heating 加热preheating 预热tempering 回火temper 回火hardening淬水annealing 退火reduction 还原cooling 冷却decarbonization, decarburization脱碳coking 炼焦slagging, scorification造渣carburization 渗碳case hardening 表面硬化cementation 渗碳fritting, sintering 烧结puddling 搅炼pulverization 粉化，雾化nitriding 渗氮alloy 合金floatation, flotation 浮选patternmaking 制模moulding 成型（美作：molding）calcination 煅烧amalgamation 汞齐化rolling 轧制drawing 拉拔extrusion 挤压wiredrawing 拉丝stamping, pressing 冲压die casting 拉模铸造forging 锻造turning 车削milling 铣削machining, tooling 加工autogenous welding, fusion welding 氧炔焊arc welding 电弧焊electrolysis 电解trimming 清理焊缝blowhole 气孔。

钢铁工业中英文词汇表iron and steel industry 钢铁工业ironworks 铁厂foundry 铸造车间steelworks, steel mill 钢厂coking plant 炼焦厂electrometallurgy 电冶金学powder metallurgy 粉末冶金学blast furnace 鼓风炉mouth, throat 炉口hopper, chute 料斗stack 炉身belly 炉腰bosh 炉腹crucible 炉缸slag tap 放渣口taphole 出铁口,出渣口pig bed 铸床mould 铸模 (美作:mold)tuyere, nozzle 风口ingot mould 锭模 (美作:ingot mold) floor 平台hearth 炉底charger 装料机ladle 铁水包,钢水包dust catcher 除尘器washer 洗涤塔converter 转炉hoist 卷扬机compressor 压缩机tilting mixer 可倾式混铁炉regenerator 蓄热室heat exchanger 热交换器gas purifier 煤气净化器turbocompressor 涡轮压缩机burner 烧嘴cupola 化铁炉,冲天炉emptier 排空装置trough 铁水沟,排渣沟skip 料车rolling mill 轧机,轧钢机blooming mill 初轧机roller 辊bed 底座rolling-mill housing 轧机机架drawbench 拔管机,拉丝机drawplate 拉模板shaft furnace 竖炉refining furnace 精炼炉reverberatory furnace 反射炉hearth furnace 床式反射炉firebrick lining 耐火砖衬retort 反应罐muffle 马弗炉roof, arch 炉顶forge 锻造press 压锻pile hammer 打桩锤drop hammer 落锤die 拉模blowlamp 吹炬 (美作:blowtorch) crusher 破碎机iron ore 铁矿石coke 焦炭bauxite 铁钒土alumina 铝cryolite 冰晶石flux 熔剂limestone flux 石灰石溶剂haematite 赤铁矿 (美作:hematite) gangue 脉石cast iron 铸铁cast iron ingot 铸铁锭slag 炉渣soft iron 软铁pig iron 生铁wrought iron 熟铁iron ingot 铁锭puddled iron 搅炼熟铁round iron 圆铁scrap iron 废铁steel 钢crude steel 粗钢mild steel, soft steel 软钢,低碳钢hard steel 硬钢cast steel 坩埚钢,铸钢stainless steel 不锈钢electric steel 电工钢,电炉钢high-speed steel 高速钢moulded steel 铸钢refractory steel 热强钢,耐热钢alloy steel 合金钢plate, sheet 薄板corrugated iron 瓦垅薄钢板tinplate, tin 马口铁finished product 成品,产品semifinished product 半成品,中间产品ferrous products 铁制品coiled sheet 带状薄板bloom 初轧方坯metal strip, metal band 铁带,钢带billet 坯锭,钢坯shavings 剃边profiled bar 异型钢材shape, section 型钢angle iron 角钢frit 烧结wire 线材ferronickel 镍铁elinvar 镍铬恒弹性钢ferrite 铁氧体,铁醇盐cementite 渗碳体,碳化铁pearlite 珠光体charging, loading 装料,炉料fusion, melting, smelting 熔炼remelting 再熔化,重熔refining 精炼casting 出铁to cast 出铁tapping 出渣,出钢,出铁to insufflate, to inject 注入heating 加热preheating 预热tempering 回火temper 回火hardening 淬水annealing 退火reduction 还原cooling 冷却decarbonization, decarburization 脱碳coking 炼焦slagging, scorification 造渣carburization 渗碳case hardening 表面硬化cementation 渗碳fritting, sintering 烧结puddling 搅炼pulverization 粉化,雾化nitriding 渗氮alloy 合金floatation, flotation 浮选patternmaking 制模moulding 成型 (美作:molding)calcination 煅烧amalgamation 汞齐化rolling 轧制drawing 拉拔extrusion 挤压wiredrawing 拉丝stamping, pressing 冲压die casting 拉模铸造forging 锻造turning 车削milling 铣削machining, tooling 加工autogenous welding, fusion welding 氧炔焊arc welding 电弧焊electrolysis 电解trimming 清理焊缝blowhole 气孔材料科学 Material Science材料科学定义 Material Science Definition加工性能 Machinability强度 Strength抗腐蚀及耐用 Corrosion & resistance durability金属特性 Special metallic features抗敏感及环境保护 Allergic, re-cycling & environmental protection化学元素 Chemical element元素的原子序数 Atom of Elements原子及固体物质 Atom and solid material原子的组成、大小、体积和单位图表 The size, mass, charge of an atom, and is particles (Pronton,Nentron and Electron)原子的组织图 Atom Constitutes周期表 Periodic Table原子键结 Atom Bonding金属与合金 Metal and Alloy铁基合金 Ferrous Alloy铁及非铁金属 Ferrous & Non Ferrous Metal金属的特性 Features of Metal晶体结构 Crystal Pattern晶体结构，定向格子及单位晶格 Crystal structure, Space lattice & Unit cellX线结晶分析法 X – ray crystal analyics method金属材料的试验方法 The Method of Metal inspection不破坏检验 Non – destructive inspections渗透探伤法 Penetrate inspection磁粉探伤法 Magnetic particle inspection放射线探伤法 Radiographic inspection超声波探伤法 Ultrasonic inspection显微观察法 Microscopic inspection破坏的检验 Destructive Inspection冲击测试 Impact Test疲劳测试 Fatigue Test金属结晶格子 Metal space lattice格子常数 Lattice constant米勒指数 Mill's Index金相及相律 Metal Phase and Phase Rule固熔体 Solid solution置换型固熔体 Substitutional type solid solution插入型固熔体 Interstital solid solution金属间化物 Intermetallic compound金属变态 Transformation变态点 Transformation Point磁性变态 Magnetic Transformation同素变态 Allotropic Transformation合金平衡状态 Thermal Equilibrium相律 Phase Rule自由度 Degree of freedom临界温度 Critical temperture共晶 Eutectic包晶温度 Peritectic Temperature包晶反应 Peritectic Reaction包晶合金 Peritectic Alloy亚共晶体 Hypoeutetic Alloy过共晶体 Hyper-ectectic Alloy金属塑性 Plastic Deformation滑动面 Slip Plan畸变 Distortion硬化 Work Hardening退火 Annealing回复柔软 Crystal Recovery再结晶 Recrystallization金属材料的性能及试验 Properties & testing of metal化学性能 Chemical Properties物理性能 Physical Properties磁性 Magnetisum比电阻 Specific resistivity & specific resistance比重 Specific gravity & specific density比热 Specific Heat热膨胀系数 Coefficient of thermal expansion导热度 Heat conductivity机械性能 Mechanical properties屈服强度(降伏强度) (Yield strangth)弹性限度、阳氏弹性系数及屈服点 elastic limit, Yeung's module of elasticity to yield point 伸长度 Elongation断面缩率 Reduction of area钢铁的主要成份 The major element of steel钢铁用"碳"之含量来分类 Classification of Steel according to Carbon contents铁相 Steel Phases钢铁的名称 Name of steel纯铁体 Ferrite渗碳体 Cementitle奥氏体 Austenite珠光体及共释钢 Pearlite &Eutectoid 奥氏体碳钢 Austenite Carbon Steel 单相金属 Single Phase Metal共释变态 Eutectoid Transformation 珠光体 Pearlite亚铁释体 Hyppo-Eutectoid初释纯铁体 Pro-entectoid ferrite 过共释钢 Hype-eutectoid珠光体 Pearlite粗珠光体 Coarse pearlite中珠光体 Medium pearlite幼珠光体 Fine pearlite马氏体 mainite贝氏体 bainite物料科学Material Science物料科学定义Material Science Definition加工性能Machinability强度Strength抗腐蚀及耐用Corrosion & resistance durability金属特性Special metallic features抗敏感及环境保护Allergic, re-cycling & environmental protection化学元素Chemical element元素的原子序数Atom of Elements原子及固体物质Atom and solid material原子的组成、大小、体积和单位图表The size, mass, charge of an atom, and is particles (Pronton,Nentron and Electron) 原子的组织图Atom Constitutes周期表Periodic Table原子键结Atom Bonding金属与合金 Metal and Alloy铁及非铁金属Ferrous & Non Ferrous Metal金属的特性Features of Metal晶体结构 Crystal Pattern晶体结构，定向格子及单位晶格Crystal structure, Space lattice & Unit cellX 线结晶分析法X – ray crystal analyics method金属结晶格子 Metal space lattice格子常数 Lattice constant米勒指数 Mill's Index金相及相律 Metal Phase and Phase Rule固熔体 Solid solution置换型固熔体 Substitutional type solid solution插入型固熔体 Interstital solid solution金属间化物 Intermetallic compound金属变态Transformation变态点Transformation Point磁性变态Magnetic Transformation同素变态Allotropic Transformation合金平衡状态Thermal Equilibrium相律Phase Rule自由度Degree of freedom临界温度Critical temperture共晶Eutectic包晶温度 Peritectic Temperature包晶反应 Peritectic Reaction包晶合金 Peritectic Alloy亚共晶体 Hypoeutetic Alloy过共晶体 Hyper-ectectic Alloy金属的相融、相融温度、晶体反应及合金在共晶合金、固熔孻共晶合金及偏晶反应的比较Equilibrium Comparision金属塑性 Plastic Deformation滑动面 Slip Plan畸变 Distortion硬化 Work Hardening退火 Annealing回复柔软 Crystal Recovery再结晶 Recrystallization金属材料的性能及试验Properties & test ing of metal化学性能Chemical Properties物理性能Physical Properties颜色Colour磁性Magnetisum比电阻Specific resistivity & specific resistance比重Specific gravity & specific density比热Specific Heat热膨胀系数Coefficient of thermal expansion导热度Heat conductivity机械性能 Mechanical properties屈服强度(降伏强度) (Yield strangth)弹性限度、阳氏弹性系数及屈服点elastic limit, Yeung's module of elasticity to yield point伸长度Elongation断面缩率Reduction of area金属材料的试验方法The Method of Metal inspection不破坏检验Non – destructive inspections渗透探伤法Penetrate inspection磁粉探伤法Magnetic particle inspection放射线探伤法Radiographic inspection超声波探伤法Ultrasonic inspection显微观察法Microscopic inspection破坏的检验Destructive Inspection冲击测试Impact Test疲劳测试Fatigue Test潜变测试 Creep Test潜变强度Creeps Strength第壹潜变期Primary Creep第二潜变期Secondary Creep第三潜变期Tertiary Creep主要金属元素之物理性质Physical properties of major Metal Elements工业标准及规格–铁及非铁金属Industrial Standard – Ferrous & Non – ferrous Metal磁力 Magnetic简介 General软磁 Soft Magnetic硬磁 Hard Magnetic磁场 Magnetic Field磁性感应 Magnetic Induction透磁度 Magnetic Permeability磁化率 Magnetic Susceptibility (Xm)磁力(Magnetic Force)及磁场(Magnetic Field)是因物料里的电子(Electron)活动而产生抗磁体、顺磁体、铁磁体、反铁磁体及亚铁磁体Diamagnetism, Paramagnetic, Ferromagnetism,Antiferromagnetism & Ferrimagnetism抗磁体 Diamagnetism磁偶极子 Dipole负磁力效应 Negative effect顺磁体 Paramagnetic正磁化率 Positive magnetic susceptibility铁磁体 Ferromagnetism转变元素 Transition element交换能量 Positive energy exchange外价电子 Outer valence electrons化学结合 Chemical bond自发上磁 Spontaneous magnetization磁畴 Magnetic domain相反旋转 Opposite span比较抗磁体、顺磁体及铁磁体Comparison of Diamagnetism, Paramagnetic & Ferromagnetism 反铁磁体 Antiferromagnetism亚铁磁体 Ferrimagnetism磁矩 magnetic moment净磁矩 Net magnetic moment钢铁的主要成份The major element of steel钢铁用"碳"之含量来分类Classification of Steel according to Carbon contents铁相Steel Phases钢铁的名称Name of steel纯铁体Ferrite渗碳体Cementitle奥氏体 Austenite珠光体及共释钢Pearlite &Eutectoid奥氏体碳钢Austenite Carbon Steel单相金属Single Phase Metal共释变态Eutectoid Transformation珠光体 Pearlite亚铁释体Hyppo-Eutectoid初释纯铁体 Pro-entectoid ferrite过共释钢 Hype-eutectoid珠光体Pearlite粗珠光体 Coarse pearlite中珠光体 Medium pearlite幼珠光体 Fine pearlite磁性变态点 Magnetic Transformation钢铁的制造Manufacturing of Steel连续铸造法 Continuous casting process电炉 Electric furnace均热炉 Soaking pit全静钢 Killed steel半静钢 Semi-killed steel沸腾钢(未净钢) Rimmed steel钢铁生产流程 Steel Production Flow Chart钢材的熔铸、锻造、挤压及延轧The Casting, Fogging, Extrusion, Rolling & Steel熔铸 Casting锻造 Fogging挤压 Extrusion延轧 Rolling冲剪 Drawing & stamping特殊钢 Special Steel简介General特殊钢以原素分类Classification of Special Steel according to Element特殊钢以用途来分类Classification of Special Steel according to End Usage易车(快削)不锈钢Free Cutting Stainless Steel含铅易车钢Leaded Free Cutting Steel含硫易车钢Sulphuric Free Cutting Steel硬化性能Hardenability钢的脆性Brittleness of Steel低温脆性 Cold brittleness回火脆性 Temper brittleness日工标准下的特殊钢材Specail Steel according to JIS Standard铬钢–日工标准 JIS G4104Chrome steel to JIS G4104铬钼钢钢材–日工标准 G4105 62Chrome Molybdenum steel to JIS G4105镍铬–日工标准 G4102 63Chrome Nickel steel to JIS G4102镍铬钼钢–日工标准 G4103 64Nickel, Chrome & Molybdenum Steel to JIS G4103高锰钢铸–日工标准High manganese steel to JIS standard片及板材Chapter Four-Strip, Steel & Plate冷辘低碳钢片(双单光片)(日工标准 JIS G3141) 73 - 95Cold Rolled (Low carbon) Steel Strip (to JIS G 3141)简介General美材试标准的冷辘低碳钢片Cold Rolled Steel Strip American Standard – American Society for testing and materials (ASTM)日工标准JIS G3141 冷辘低碳钢片(双单光片)的编号浅释Decoding of cold rolled(Low carbon)steel strip JIS G3141材料的加工性能 Drawing abillity硬度 Hardness表面处理 Surface finish冷辘钢捆片及张片制作流程图表Production flow chart cold rolled steel coil sheet冷辘钢捆片及张片的电镀和印刷方法Cold rolled steel coil & sheet electro-plating & painting method冷辘(低碳)钢片的分类用、途、工业标准、品质、加热状态及硬度表End usages, industrial standard, quality, condition and hardness of cold rolled steel strip硬度及拉力 Hardness & Tensile strength test拉伸测试(顺纹测试)Elongation test杯突测试(厚度: 0.4 公厘至1.6 公厘，准确至0.1 公厘 3 个试片平均数)Erichsen test (Thickness: 0.4mm to 1.6mm, figure round up to 0.1mm)曲面(假曲率)Camber厚度及阔度公差 Tolerance on Thickness & Width平坦度(阔度大于500 公厘，标准回火)Flatness (width>500mm, temper: standard)弯度 Camber冷辘钢片储存与处理提示General advice on handling & storage of cold rolled steel coil & sheet防止生锈Rust Protection生锈速度表Speed of rusting焊接 Welding气焊 Gas Welding埋弧焊 Submerged-arc Welding电阻焊 Resistance Welding冷辘钢片(拉力: 30-32 公斤/平方米)在没有表面处理状态下的焊接状况Spot welding conditions for bared (free from paint, oxides etc) Cold rolled mild steelsheets(T/S:30-32 Kgf/ μ m2)时间效应(老化)及拉伸应变Aging & Stretcher Strains日工标准(JIS G3141)冷辘钢片化学成份Chemical composition – cold rolled steel sheet to JIS G3141冷辘钢片的"理论重量"计算方程式Cold Rolled Steel Sheet – Theoretical mass日工标准(JIS G3141)冷辘钢片重量列表Mass of Cold-Rolled Steel Sheet to JIS G3141冷辘钢片订货需知Ordering of cold rolled steel strip/sheet其它日工标准冷轧钢片(用途及编号)JIS standard & application of other cold Rolled Special Steel电镀锌钢片或电解钢片Electro-galvanized Steel Sheet/Electrolytic Zinc Coated Steel Sheet简介General电解/电镀锌大大增强钢片的防锈能力Galvanic Action improving Weather & Corrosion Resistance of the Base Steel Sheet上漆能力 Paint Adhesion电镀锌钢片的焊接Welding of Electro-galvanized steel sheet点焊Spot welding滚焊Seam welding电镀锌(电解)钢片Electro-galvanized Steel Sheet生产流程Production Flow Chart常用的镀锌钢片(电解片)的基层金属、用途、日工标准、美材标准及一般厚度Base metal, application, JIS & ASTM standard, and Normal thickness of galvanized steel sheet锌镀层质量 Zinc Coating Mass表面处理 Surface Treatment冷轧钢片 Cold-Rolled Steel Sheet/Strip热轧钢片 Hot-Rolled Sheet/Strip电解冷轧钢片厚度公差Thickness Tolerance of Electrolytic Cold-rolled sheet热轧钢片厚度公差Thickness Tolerance of Hot-rolled sheet冷轧或热轧钢片阔度公差Width Tolerance of Cold or Hot-rolled sheet长度公差 Length Tolerance理论质量 Theoretical Mass锌镀层质量(两个相同锌镀层厚度)Mass Calculation of coating (For equal coating)/MM锌镀层质量(两个不同锌镀层厚度)Mass Calculation of coating (For differential coating)/MM镀锡薄铁片(白铁皮/马口铁) (日工标准 JIS G3303)简介General镀锡薄铁片的构造Construction of Electrolytic Tinplate镀锡薄钢片(白铁皮/马日铁)制造过程Production Process of Electrolytic Tinplate锡层质量Mass of Tin Coating (JIS G3303-1987)两面均等锡层Both Side Equally Coated Mass两面不均等锡层Both Side Different Thickness Coated Mass级别、电镀方法、镀层质量及常用称号Grade, Plating type, Designation of Coating Mass & Common Coating Mass 镀层质量标记Markings & Designations of Differential Coatings硬度 Hardness单相轧压镀锡薄铁片(白铁皮/马口铁)Single-Reduced Tinplate双相辗压镀锡薄钢片(马口铁/白铁皮)Dual-Reduction Tinplate钢的种类 Type of Steel表面处理 Surface Finish常用尺寸 Commonly Used Size电器用硅 [硅] 钢片 Electrical Steel Sheet简介 General软磁材料 Soft Magnetic Material滞后回线 Narrow Hystersis矫顽磁力 Coercive Force硬磁材料 Hard Magnetic Material最大能量积 Maximum Energy Product硅含量对电器用的低碳钢片的最大好处The Advantage of Using Silicon low Carbon Steel晶粒取向(Grain-Oriented)及非晶粒取向(Non-Oriented)Grain Oriented & Non-Oriented电器用硅 [硅] 钢片的最终用途及规格End Usage and Designations of Electrical Steel Strip电器用的硅 [硅] 钢片之分类Classification of Silicon Steel Sheet for Electrical Use电器用钢片的绝缘涂层Performance of Surface Insulation of Electrical Steel Sheets晶粒取向电器用硅钢片主要工业标准International Standard – Grain-Oriented Electrical Steel Silicon Steel Sheet for Electrical Use晶粒取向电器用硅钢片 Grain-Oriented Electrical Steel晶粒取向，定取向芯钢片及高硼定取向芯钢片之磁力性能及夹层系数(日工标准及美材标准) Magnetic Properties and Lamination Factor of SI-ORIENT-CORE& SI-ORIENT-CORE-HI BElectrical Steel Strip (JIS and AISI Standard)。

1. indication 缺陷2. test specimen 试样3. bar 棒材4. stock 原料5. billet 方钢，钢方坯6. bloom 钢坯,钢锭7. section 型材8. steel ingot 钢锭9. blank 坯料，半成品10. cast steel 铸钢11. nodular cast iron 球墨铸铁12. ductile cast iron 球墨铸铁13. bronze 青铜14. brass 黄铜15. copper 合金16. stainless steel不锈钢17. decarburization 脱碳18. scale 氧化皮19. anneal 退火20. process anneal 进行退火21. quenching 淬火22. normalizing 正火23. Charpy impact text 夏比冲击试验24. fatigue 疲劳25. tensile testing 拉伸试验26. solution 固溶处理27. aging 时效处理28. Vickers hardness维氏硬度29. Rockwell hardness 洛氏硬度30. Brinell hardness 布氏硬度31. hardness tester硬度计32. descale 除污，除氧化皮等33. ferrite 铁素体34. austenite 奥氏体35. martensite马氏体36. cementite 渗碳体37. iron carbide 渗碳体38. solid solution 固溶体39. sorbite 索氏体40. bainite 贝氏体41. pearlite 珠光体42. nodular fine pearlite/ troostite屈氏体43. black oxide coating 发黑44. grain 晶粒45. chromium 铬46. cadmium 镉47. tungsten 钨48. molybdenum 钼49. manganese 锰50. vanadium 钒51. molybdenum 钼52. silicon 硅53. sulfer/sulphur 硫54. phosphor/ phosphorus 磷55. nitrided 氮化的56. case hardening 表面硬化，表面淬硬57. air cooling 空冷58. furnace cooling 炉冷59. oil cooling 油冷60. electrocladding /plating 电镀61. brittleness 脆性62. strength 强度63. rigidity 刚性,刚度64. creep 蠕变65. deflection 挠度66. elongation 延伸率67. yield strength 屈服强度68. elastoplasticity 弹塑性69. metallographic structure 金相组织70. metallographic test 金相试验71. carbon content 含碳量72. induction hardening 感应淬火73. impedance matching 感应淬火74. hardening and tempering 调质75. crack 裂纹76. shrinkage 缩孔，疏松77. forging 锻（件）78. casting 铸（件）79. rolling 轧（件）80. drawing 拉（件）81. shot blasting 喷丸（处理）82. grit blasting 喷钢砂（处理）83. sand blasting 喷砂（处理）84. carburizing 渗碳85. nitriding 渗氮86. ageing/aging 时效87. grain size 晶粒度88. pore 气孔89. sonim 夹砂90. cinder inclusion 夹渣91. lattice晶格92. abrasion/abrasive/rub/wear/wearing resistance (property) 耐磨性93. spectrum analysis光谱分析94. heat/thermal treatment 热处理95. inclusion 夹杂物96. seGREgation 偏析97. picking 酸洗，酸浸98. residual stress 残余应力99. remaining stress 残余应力100. relaxation of residual stress 消除残余应力101. stress relief 应力释放A R steel 高温度锰钢abnormal steel 反常钢; 非正常钢aluminium-steel cable 钢铝电缆aluminized steel 涂铝钢aluminum nickel steel 铝镍钢anchored steel trestle 锚固式钢栈桥angle steel ruler 钢角尺anisotropic steel 各向异性钢片anisotropy silicon steel 各向异性硅钢片annealed sheet steel 退火薄钢板annealed steel 退火钢; 韧钢anti-creeping angle steel 防爬角铁anticorrosive aluminium-coated steel wire 防蚀镀铝钢丝arc-furnace steel 电炉钢arc-welded steel pipe 电弧焊接钢管area of steel 钢筋断面面积; 钢筋截面面积area of structural steel 型钢截面积Armco aluminized steel 阿姆柯渗铝钢armco aluminized steel 表面浸镀铝钢Armco stabilized steel 阿母柯稳定化钢Armco steel 阿姆柯软钢armco steel 不硬化钢austenilic Ni-Cr stainless steel 奥氏体镍铬不锈钢austenitic alloy steel 奥氏体合金钢austenitic chromium-nickel steel 奥氏体铬-镍钢austenitic clad steel 奥氏体复合钢austenitic heat-resistance steel 奥氏体耐热钢austenitic manganese steel 奥氏体锰钢; 哈德菲尔德锰钢austenitic stainless steel 奥氏体不锈钢austenitic steel 奥氏体钢automatic steel 易切削钢automatic(al) steel 易切削钢axle shaft steel 车轴钢axle steel 车轴钢钢铁业的英语词汇1Carbon Steel Plate 碳素钢板; 碳素钢板和型材Carbon Tool Steel 碳工具钢; 碳素工具钢Carbon-Containing Alloy Steel 含碳合金钢Carbon-Free Stainless Steel 无碳不锈钢Carbon-Free Steel 无碳钢Carburizing Steel 碳钢Case-Hardened Steel 表面渗碳硬化钢; 渗碳钢Bolts & Nuts For Steel Slotted 角钢螺丝Cast Alloy Steel Piston 合金铸钢活塞Cast Iron Electrode With Steel Core 钢芯铸铁焊条Cast Stainless Steel 铸造不锈钢Cast Steel 铸钢件Cast Steel Plate 铸钢板Cast(Carbon) Steel 铸钢Cast-In Steel Bush 铸入钢套Casement Section Steel 窗框钢Cast-Steel 铸钢Cast-Steel Crossing 铸钢辙叉Cast-Steel Pipe 铸钢管Cast-Steel Separator 铸钢隔板; 铸钢横梁Cast-Steel Shot 钢砂Cast-Steel Yoke 铸钢轭Cellular Steel Floor 格型钢楼板Cement-And-Grouted Steel Bolt 钢筋砂浆锚杆Cemented Steel 表面硬化钢Cemented Templet Steel 渗碳样板钢Centra Steel 球状石墨铸钢Centrifugal Steel 离心铸钢Centrifuge(D) Steel 离心铸造钢Channel Steel 槽钢Channel-Section Steel 槽形钢Channeled-Steel Wheel Rim 槽钢制轮辋Checkered Steel Plate 花纹钢板Chemical Capped Steel 化学封顶钢Chilled Cast Steel 冷硬铸钢Chilled Hardened Steel 淬火钢Chilled Steel 淬火钢; 淬硬钢Chisel Steel 凿钢; 凿子钢Chrome Hardened Steel 铬硬化钢Chrome Steel 铬钢Chrome-Carbon Steel 铬碳钢Chrome-Manganese Nitrogen Steel 铬锰氮钢Chrome-Manganese-Silicon Alloy Steel 铬锰硅合金钢Chrome-Molybdenum Steel 铬钼钢Chrome-Nickel Steel 铬镍钢Chrome-Plated Steel Nozzle 镀铬钢喷管Chrome-Silicon Steel 铬硅钢Chrome-Tungsten Steel 铬钨钢Chrome-Vanadium Steel 铬钒钢Chromemanganese Steel 铬锰钢Chromium Nickel Steel 高强度耐蚀铬镍钢Chromium Stainless Steel 铬不锈钢Chromium Steel 铬钢Chromium-Molybdenum Steel 铬钼钢Chromium-Nickel Steel 铬镍钢Chromium-Plated Mild Steel Animal Chain 镀铬软钢动物链条Chromium-Tungstenvanadium Steel 铬钨钒钢Chromiummanganese Steel 铬锰钢Chromiumnickel Austenite Stainless Steel 铬镍奥氏体不锈钢Chromiumplated Thin-Walled Steel Cylinder Liner 钢质薄壁镀铬汽缸衬套Chromized Steel 渗铬钢Circular Steel Support 环形金属支架Clad Sheet Steel 包层薄钢板Clad Steel 包层钢; 双层钢; 双金属钢Clad Steel Plate 复合钢板Cladding Steel 包覆钢Cladding Steel Sheet 复合钢板Clean Steel 纯净钢; 洁净钢Closed Die Steel 闭锻模钢Coarse-Grained Steel 粗晶粒钢Coated Steel 镀层钢板Coating Steel Pipe 镀锌钢管Cobalt High Speed Steel 钴高速钢Cobalt-Chromium Steel 钴铬钢Coiled Steel 成卷带钢Cold Forging Steel 冷锻钢Cold Pressed Steel 冷压钢Cold Reduced Steel 马口铁卷板Cold Rolled Ribbed Steel Bar 冷轧竹节钢筋Cold Rolled Sheet Steel 冷轧薄钢板Cold Twisted Steel Bar 冷扭钢筋Cold-Banded Steel Pipe 冷箍钢管Cold-Drawn Steel 冷拔钢; 冷拉钢Cold-Drawn Steel Pipe 冷拉钢管Cold-Drawn Steel Tube 冷拉钢管Cold-Finished Steel 冷加工精整钢Cold-Pressed Sheet Steel 冷压薄钢板Cold-Pressed Steel Plate 冷压钢板Cold-Pressing Quality Steel 冷弯钢Cold-Roll Steel Sheets 冷轧钢板Cold-Rolled (Cold Rolled) Steel 冷轧钢Cold-Rolled Carbon Spring Steel 冷轧弹簧碳钢Cold-Rolled Carbon Steel 冷轴碳钢Cold-Rolled Steel Strip 冷轧带钢Cold-Shaping Steel 冷变形钢Cold-Short Steel 冷脆钢Cold-Steel 利器Cold-Strip Steel 冷轧带钢Cold-Strip Steel Rolling Mill 冷轧带钢机; 带钢冷轧机Cold-Worked Steel 冷作钢Cold-Working Steel 冷作钢Coldshort Steel 冷脆钢Color Stainless Steel 彩色不锈钢Colored Stainless Steel 彩色不锈钢Column With Steel Hooping 螺旋箍筋柱Combined Steel And Concrete Column 钢骨混凝土柱Comminuted Steel Shot 钢粉Common Straight Carbon Steel 普通碳素钢Complex Alloy Steel 多元合金钢; 合金钢碳素结构钢 Carbon Construction Steel碳素工具钢 Carbon Tool Steel合金结构钢 Alloy Construction Steel合金工具钢 Alloy Tool Steel高速工具钢 High Speed Tool Steel弹簧钢 Spring Steel不锈耐热钢 Stainless & Heat Resisting Steel轴承钢 Bearing Steel工字钢 Ibeam普通圆钢 Round Steel槽钢 Channel扁钢Flat Steel Bar等边角钢 Equal Angle Steel不等边角钢 Unequal Angle Steelh型钢 Hbeam钢坯 Billet,Bloom钢筋混凝土用变形钢筋 High Strength Deformed Steel Bar 窗框钢 Window Sash中厚钢板 Steel Plate热轧钢板（卷） Hot Rolled Steel Coil冷轧钢板（卷） Cold Rolled Steel Sheel or Coil镀锌钢板（卷） Galvanized Steel Coil钢带 Steel Strip线材 Wire Rod Coil无缝钢管 Seamless Steel Pipe锅炉管 Boiler Tube石油套管 Pipe For Oil Field高压管 Pressure Pipe高压气瓶用管 Tube for High-Pressure Vessel地质钻探用管 Seamless Steel Pipe For Geological Drill In 镀锌焊管 Galvanized Welded Pipe石油钻探杆 Drill Pipe For Oil Field铸铁管 Cast Iron Pipe重轨 Heavy Rail轻轨 Light Rail炼钢生铁 Basic Pig Iron铸造生铁 foundry Pig Iron普通圆钢钉 Round Nails for General Uses镀锌底碳钢丝 Galvanized Low Carbon Steel Wire.钢丝绳 Steel Wire Rope钢绞线 Stranded Wire预应力混凝土钢丝 Steel Wire For Prestressed Concrete 窗纱 Window Screen车轮 Wheel Tyre轮筛 Wheel Circleiron and steel industry 钢铁工业ironworks 铁厂foundry 铸造车间steelworks, steel mill 钢厂coking plant 炼焦厂electrometallurgy 电冶金学powder metallurgy 粉末冶金学blast furnace 鼓风炉mouth, throat 炉口hopper, chute 料斗stack 炉身belly 炉腰bosh 炉腹crucible 炉缸slag tap 放渣口taphole 出铁口,出渣口pig bed 铸床mould 铸模(美作:mold) tuyere, nozzle 风口ingot mould 锭模(美作:ingot mold) floor 平台hearth 炉底charger 装料机ladle 铁水包,钢水包dust catcher 除尘器washer 洗涤塔converter 转炉hoist 卷扬机compressor 压缩机tilting mixer 可倾式混铁炉regenerator 蓄热室heat exchanger 热交换器gas purifier 煤气净化器turbocompressor 涡轮压缩机burner 烧嘴cupola 化铁炉,冲天炉emptier 排空装置trough 铁水沟,排渣沟skip 料车rolling mill 轧机,轧钢机blooming mill 初轧机roller 辊bed 底座rolling-mill housing 轧机机架drawbench 拔管机,拉丝机drawplate 拉模板shaft furnace 竖炉refining furnace 精炼炉reverberatory furnace 反射炉hearth furnace 床式反射炉firebrick lining 耐火砖衬retort 反应罐muffle 马弗炉roof, arch 炉顶forge 锻造press 压锻pile hammer 打桩锤drop hammer 落锤die 拉模blowlamp 吹炬(美作:blowtorch)crusher 破碎机iron ore 铁矿石coke 焦炭bauxite 铁钒土alumina 铝cryolite 冰晶石flux 熔剂limestone flux 石灰石溶剂haematite 赤铁矿(美作:hematite) gangue 脉石cast iron 铸铁cast iron ingot 铸铁锭slag 炉渣soft iron 软铁pig iron 生铁wrought iron 熟铁iron ingot 铁锭puddled iron 搅炼熟铁round iron 圆铁scrap iron 废铁steel 钢crude steel 粗钢mild steel, soft steel 软钢,低碳钢hard steel 硬钢cast steel 坩埚钢,铸钢stainless steel 不锈钢electric steel 电工钢,电炉钢high-speed steel 高速钢moulded steel 铸钢refractory steel 热强钢,耐热钢alloy steel 合金钢plate, sheet 薄板corrugated iron 瓦垅薄钢板tinplate, tin 马口铁finished product 成品,产品semifinished product 半成品,中间产品ferrous products 铁制品coiled sheet 带状薄板bloom 初轧方坯metal strip, metal band 铁带,钢带billet 坯锭,钢坯shavings 剃边profiled bar 异型钢材shape, section 型钢angle iron 角钢frit 烧结wire 线材ferronickel 镍铁elinvar 镍铬恒弹性钢ferrite 铁氧体,铁醇盐cementite 渗碳体,碳化铁pearlite 珠光体charging, loading 装料,炉料fusion, melting, smelting 熔炼remelting 再熔化,重熔refining 精炼casting 出铁to cast 出铁tapping 出渣,出钢,出铁to insufflate, to inject 注入heating 加热preheating 预热tempering 回火temper 回火hardening 淬水annealing 退火reduction 还原cooling 冷却decarbonization, decarburization 脱碳coking 炼焦slagging, scorification 造渣carburization 渗碳case hardening 表面硬化cementation 渗碳fritting, sintering 烧结puddling 搅炼pulverization 粉化,雾化nitriding 渗氮alloy 合金floatation, flotation 浮选patternmaking 制模moulding 成型(美作:molding) calcination 煅烧amalgamation 汞齐化rolling 轧制drawing 拉拔extrusion 挤压wiredrawing 拉丝stamping, pressing 冲压die casting 拉模铸造forging 锻造turning 车削milling 铣削machining, tooling 加工autogenous welding, fusion welding 氧炔焊arc welding 电弧焊electrolysis 电解trimming 清理焊缝blowhole 气孔钢铁业的英语词汇2Abnormal Steel 反常钢; 非正常钢Aluminum-steel Cable 钢铝电缆Aluminized Steel 涂铝钢Aluminum Nickel Steel 铝镍钢Anchored Steel Trestle 锚固式钢栈桥Angle Steel Ruler 钢角尺Anisotropic Steel 各向异性钢片Anisotropy Silicon Steel 各向异性硅钢片Annealed Sheet Steel 退火薄钢板Annealed Steel 退火钢; 韧钢Anti-Creeping Angle Steel 防爬角铁Anticorrosive Aluminum-Coated Steel Wire 防蚀镀铝钢丝1. Arc-Furnace Steel 电炉钢Arc-Welded Steel Pipe 电弧焊接钢管Area Of Steel 钢筋断面面积; 钢筋截面面积Area Of Structural Steel 型钢截面积Armco Aluminized Steel 阿姆柯渗铝钢Armco Aluminized Steel 表面浸镀铝钢Armco Stabilized Steel 阿母柯稳定化钢Armco Steel 阿姆柯软钢Armco Steel 不硬化钢Austenitic Ni-Cr Stainless Steel 奥氏体镍铬不锈钢Austenitic Alloy Steel 奥氏体合金钢Austenitic Chromium-Nickel Steel 奥氏体铬-镍钢Austenitic Clad Steel 奥氏体复合钢Austenitic Heat-Resistance Steel 奥氏体耐热钢Austenitic Manganese Steel 奥氏体锰钢; 哈德菲尔德锰钢Austenitic Stainless Steel 奥氏体不锈钢Austenitic Steel 奥氏体钢Automatic Steel 易切削钢Automatic(Al) Steel 易切削钢Axle Steel 车轴钢Bain tic Steel 贝氏体钢Balanced Steel 半镇静钢Ball Bearing Steel Strip 滚珠轴承钢带Ball Race Steel 滚珠轴承圈钢Ball-Bearing Steel 滚珠轴承钢Bamboo Steel 竹节钢筋Band Steel 带钢Banding Steel 带钢; 箍钢Bar Steel 棒钢; 条钢Basic Bessemer Steel 碱性贝氏转炉钢Basic Bessemer Steel 碱性转炉钢Basic Bessemer Steel Converter 碱性转炉钢转炉Basic Converter Steel 碱性转炉钢Basic Electric Furnace Steel 碱性电炉钢Basic Open Hearth Steel 碱性平炉钢Battened Steel Column 双肢钢Beam Steel Plate 大梁钢板Beam With Compression Steel 双筋梁Bearing Quality Steel 滚珠钢Bearing Steel 轴承钢Bent Steel 挠曲钢筋Bessemer Low Carbon Steel 酸性转炉低碳钢Bessemer Mild Steel 贝色麦钢Bessemer Steel 贝色麦钢; 酸性钢Best Plough Steel Wire 铅淬火高强度钢丝Billet Steel 坯段钢; 钢坯; 短条钢Binary Steel 二元合金钢Black Mild Steel Carriage Bolt And Nut 黑铁马车螺丝闩Black Mild Steel Fish Bolt And Nut 黑铁鱼尾螺丝闩Black Mild Steel Flat Head Rivet 黑铁扁头铆钉Black Mild Steel Flat Head Tin men Rivet 黑铁号头铆钉Black Mild Steel Hexagonal Nut 黑铁六角螺丝帽Black Mild Steel Pan Head Rivet 黑铁锥头铆钉Black Mild Steel Round Head Rivet 黑铁圆头铆钉Black Mild Steel Square Nut 黑铁四方螺丝帽Black Steel Pipe 黑钢板Black Steel Sheet 黑钢皮Black Tin Steel 黑钢板Blister Steel 泡钢; 泡面钢Abnormal Structure Steel 反常组织钢Abrasion-Resistant Steel 耐磨钢Blue Steel 蓝钢Boiler Steel 锅炉钢; 锅炉钢板Boiler Steel Plate 锅炉钢板Boiling Steel 沸腾钢Bolting Steel 螺栓钢Blue Planished Steel 发蓝薄钢板Bloom Steel 初轧钢; 钢坯Boron Steel 硼钢Brass Fitting Of Steel Window 钢窗铜配件Brass-Plated Mild Steel Round Bead Wood Screw 镀黄铜圆头软钢木螺丝Brass-Plated Mild Steel Round Head Machine Screw 镀黄铜圆头软钢机器螺丝Brass-Plated Steel Wire 镀黄铜钢丝Brearley Steel 布里阿雷不锈钢; 布氏高铬钢Bridge Steel 桥梁钢Bright And Black Mild Steel Flat Head Tinmen Rivet 号头铆钉Bright Mild Steel Cotter Pin 光亮软钢开尾销Bright Mild Steel Countersunk Head Wood Screw 光亮软钢平头木螺丝Bright Mild Steel Hexagonal Nut 光亮软钢六角螺丝帽Bright Mild Steel Hexagonal Nuts 六角光螺帽; 六角螺丝帽Bright Mild Steel Hexagonal Pressed Nut 光亮软钢六角冲压螺丝帽Bright Mild Steel Round Head Wood Screw 光亮软钢圆头木螺丝Bright-Drawn Free Cutting Steel 光拉自由切削钢Bright-Drawn Steel 光亮拉拔钢材Bright-Finished Steel 光亮精整钢Bristol Steel Belt Lacing 布瑞斯涛钢带接头Bronze Steel 镀青铜钢Building Of Steel Frame Construction 钢框架房屋Bulb Steel 球扁钢Bulb-Rail Steel 球头丁字钢Burned Steel 过烧钢Calorized Steel 涂铝钢; 渗化钢Calorizing Steel 铝化钢Capped Steel 加盖钢; 半镇静钢Carbon And Low-Alloy Steel Vessels 碳钢及低合金钢容器Carbon Content Of Steel 钢含碳量Carbon Molybdenum Steel 钼碳钢Carbon Steel 碳钢; 碳素钢Carbon Steel Covered Electrode 碳钢焊条Carbon Steel Plate2. 中文名英文名品质描述6063 6063 Extrusion-pntd 镀漆6061 6061 Extrusion-pntd 镀漆生铝件 Tense 含铁〈2%生杂铝 Mixed Cast 含铁〈2%旧铝片 Old Sheet-Taint/Tabor 干净新铝片 Tough-Taboo 干净切碎铝 Shredded Aluminum 干净汽车切片铝 Shredded Auto Aluminum 含铝70%带铁铝 Irony Aluminum 需标明含量356轮毂铝 356 Auto Wheels 干净铝水箱 Aluminum Radiator 干净带皮铝线 Acsr/Ins 需标明含量铜铝水箱 Al/Cu Radiator 干净易拉罐 UBC-Baled/Densified 干净铝变压器 Aluminum Transformer铝壳马达 Aluminum Case Motor1#光亮铜线 #1 Bare Bright 干净1#铜 #1 Candy 含铜98%2#铜 #2 Birch/Cliff 含铜94-96%1#火烧线 #1 Burnt Wire 含铜〉97%1#铜米 #1 Cu-chop1#铜线缆 #1 Insulated Wire 含铜72%2#铜线缆 #2 Insulated Wire 含铜50-55%1#2#混合铜线缆 #1#2 Mixed Wire 含铜65%黄杂铜 Yellow Brass-Honey 干净干净铜水箱 Ocean Auto Radiator 干净(牛粪)切碎电机 Shredded Pickings 含铜18-20%混合电机 Electric Motors 含铜8-12%304炉料 304 Sabot 18-8304可利用料 304 Reusable 板或杆316可利用料 316 Reusable 板或杆3. 1、烧结sintering粉末或压坯在低于主要组分熔点的温度下的热处理，目的在于通过颗粒间的冶金结合以提高其强度。

钢铁冶金专业英语词汇目录1 总论 (1)2 采矿 (1)3 选矿 (1)4 冶金过程物理化学 (2)4.1 冶金过程热力学 (2)4.2 冶金过程动力学 (4)4.3 冶金电化学 (5)4.4 冶金物理化学研究方法 (5)5 钢铁冶金 (5)5.1 炼焦 (5)5.2 耐火材料 (6)5.3 碳素材料 (7)5.4 铁合金 (7)5.5 烧结与球团 (7)5.6 高炉炼铁 (8)5.7 炼钢 (10)5.8 精炼、浇铸及缺陷 (12)6 钢铁材料 (14)7 英译汉 (14)1 总论采矿mining地下采矿underground mining露天采矿open cut mining, open pit mining, surface mining采矿工程mining engineering选矿（学）mineral dressing, ore beneficiation, mineral processing矿物工程mineral engineering冶金（学）metallurgy过程冶金（学）process metallurgy提取冶金（学）extractive metallurgy化学冶金（学）chemical metallurgy物理冶金（学）physical metallurgy金属学Metallkunde冶金过程物理化学physical chemistry of process metallurgy冶金反应工程学metallurgical reaction engineering 冶金工程metallurgical engineering钢铁冶金（学）ferrous metallurgy, metallurgy of iron and steel有色冶金(学)nonferrous metallurgy真空冶金(学)vacuum metallurgy等离子冶金(学)plasma metallurgy微生物冶金(学)microbial metallurgy喷射冶金(学)injection metallurgy钢包冶金(学)ladle metallurgy二次冶金(学)secondary metallurgy机械冶金(学)mechanical metallurgy焊接冶金(学)welding metallurgy粉末冶金(学)powder metallurgy铸造学foundry火法冶金(学)pyrometallurgy湿法冶金(学)hydrometallurgy电冶金(学)electrometallurgy氯冶金(学)chlorine metallurgy矿物资源综合利用engineering of comprehensive utilization of mineral resources中国金属学会The Chinese Society for Metals中国有色金属学会The Nonferrous Metals Society of China2 采矿采矿工艺mining technology有用矿物valuable mineral冶金矿产原料metallurgical mineral raw materials 矿床mineral deposit 特殊采矿specialized mining海洋采矿oceanic mining, marine mining矿田mine field矿山mine露天矿山surface mine地下矿山underground mine矿井shaft矿床勘探mineral deposit exploration矿山可行性研究mine feasibility study矿山规模mine capacity矿山生产能力mine production capacity矿山年产量annual mine output矿山服务年限mine life矿山基本建设mine construction矿山建设期限mine construction period矿山达产arrival at mine full capacity开采强度mining intensity矿石回收率ore recovery ratio矿石损失率ore loss ratio工业矿石industrial ore采出矿石extracted ore矿体orebody矿脉vein海洋矿产资源oceanic mineral resources矿石ore矿石品位ore grade岩石力学rock mechanics岩体力学rock mass mechanics3 选矿选矿厂concentrator, mineral processing plant 工艺矿物学process mineralogy开路open circuit闭路closed circuit流程flowsheet方框流程block flowsheet产率yield回收率recovery矿物mineral粒度particle size粗颗粒coarse particle细颗粒fine particle超微颗粒ultrafine particle粗粒级coarse fraction细粒级fine fraction网目mesh原矿run of mine, crude精矿concentrate粗精矿rough concentrate混合精矿bulk concentrate最终精矿final concentrate尾矿tailings粉碎comminution破碎crushing磨碎grinding团聚agglomeration筛分screening, sieving分级classification富集concentration分选separation手选hand sorting重选gravity separation, gravity concentration 磁选magnetic separation电选electrostatic separation浮选flotation化学选矿chemical mineral processing自然铜native copper铝土矿bauxite冰晶石cryolite磁铁矿magnetite赤铁矿hematite假象赤铁矿martite钒钛磁铁矿vanadium titano-magnetite铁燧石taconite褐铁矿limonite菱铁矿siderite镜铁矿specularite硬锰矿psilomelane软锰矿pyrolusite铬铁矿chromite黄铁矿pyrite钛铁矿ilmennite金红石rutile萤石fluorite高岭石kaolinite菱镁矿magnesite重晶石barite石墨graphite石英quartz方解石calcite石灰石limestone白云石dolomite云母mica 石膏gypsum硼砂borax石棉asbestos蛇纹石serpentine阶段破碎stage crushing粗碎primary crushing中碎secondary crushing细碎fine crushing对辊破碎机roll crusher粉磨机pulverizer震动筛vibrating screen筛网screen cloth筛孔screen opening筛上料oversize筛下料undersize粗磨coarse grinding细磨fine grinding球磨机ball mill衬板liner分级机classifier自由沉降free setting沉积sedimentation石灰lime松油pine oil硫化钠sodium sulfide硅酸钠（水玻璃）sodium silicate, water glass过滤filtration过滤机filter给矿，给料feeding给矿机feeder在线分析仪on line analyzer在线粒度分析仪on line size analyzer超声粒度计ultrasonic particle sizer, supersonic particle sizer4 冶金过程物理化学4.1 冶金过程热力学冶金过程热力学thermodynamics of metallurgical processes统计热力学statistical thermodynamics不可逆过程热力学thermodynamics of irreversible processes化学热力学chemical thernodynamics表面热力学surface thermodynamics合金热力学thermodynamics of alloys冶金热力学数据库thermodynamics databank in metallurgy系system单元系single-componentsystem多元系multicomponent system均相系统homogeneous system广度性质extensive property强度性质intensive property过程process等温过程isothermal process等压过程isobaric process等容过程isochoric process绝热过程adiabatic process可逆过程reversible process不可逆过程irreversible process自发过程spontaneous process自理过程physical process化学过程chemical process冶金过程metallurgical process化学反应chemical reaction化合反应combination reaction分解反应decomposition reaction置换反应displacement reaction可逆反应reversible reaction不可逆反应irreversible reaction电化学反应electrochemical reaction多相反应multiphase reaction固态反应solid state reaction气一金(属)反应gas-metal reaction渣一金（属）反应slag-metal reaction 平衡equilibrium化学平衡chemical equilibrium相平衡phase equilibrium热力学平衡thermodynamic equilibrium 亚稳平衡metastable equilibrium热力学函数thermodynamic function偏摩尔量partial molar quantity总摩尔量integral molar quantity标准态standard state焓enthalpy生成焓enthalpy of formation反应焓enthalpy of reaction熵entropy吉布斯能Gibbs energy生成吉布斯能Gibbs energy of formation 反应吉布斯能Gibbs energy of reaction 溶解吉布斯能Gibbs energy of solution 吉布斯能函数Gibbs energy function 化学位chemical potential热化学thermochemistry热效应heat effect热容heat capacity熔化热heat of fusion汽化热heat of vaporization升华热heat of sublimation相变热heat of phase transformation放热反应exothermic reaction吸热反应endothermic reaction赫斯定律Hess’s law相律phase rule相图phase diagram一元相图single-component phase diagram二元相图binary-component phase diagram三元相图ternary-component phase diagram液相线liquidus固相线solidus共晶点eutectic point杠杆规则lever rule溶液solution溶质solute溶剂solvent固溶体solid solution溶液浓度concentration of solution摩尔分数mole fraction冶金熔体metallurgical melt金属熔体metal melt(炉)渣,熔渣slag熔盐molten salt, fused salt理想溶液ideal solution真实溶液real solution正规溶液regular solution活度activity活度系数activity coefficient拉乌尔定律Raoult’s law亨利定律Henry’s law纯物质标准态pure substance standard质量１％溶液标准(态)1 mass% solution standard 无限稀溶液参考态reference state of infinityly dilute solution相互作用系数interaction coefficient化学反应等温式chemical reaction isotherm吉布斯～亥姆霍兹方程Gibbs-Helmholtz equation 质量作用定律law of mass action平衡常数equilibrium constant平衡值equilibrium value直接还原direct reduction间接还原indirect reduction金属热还原metallothermic reduction选择性氧化selective oxidation渣碱度basicity of slag光学破度optical basicity酸性氧化物acid oxide碱性氧化物basicoxide两性氧化物amphoteric泡沫渣foaming slag熔渣的分子理论molecular theory of slag熔渣的离子理论ionization theory of slag脱氧平衡deoxidation equilibrium脱氧常数deoxidation constant熔渣脱硫desulfurization by slag气态脱硫desulfurization in the gaseous state硫分配比sulfur partition ratio硫化物容量sulfide capacity氧化脱磷dephosphorization under oxidizing atmosphere磷分配比碳一氧平衡carbon-oxygen equilibrium真空脱碳vacuum decarburization去气degassing去除非金属夹杂(物)elimination of nonmetallic inclusion非金属夹杂(物)变形form modification of nonmetallic inclusion脱硅desiliconization脱锰demanganization分配平衡distribution law化学气相沉积chemical vapor deposition(CVD)4.2 冶金过程动力学微观动力学microkinetics化学动力学chemical kinetics反应途径reaction path反应机理reaction mechanism基元反应elementary reaction平行反应parallel链反应chain reaction总反应overall reaction反应速率reaction rate反应速率常数reaction rate constant反应级数reaction order零级反应zero order reaction一级反应first order reaction 二级反应second order reactionn级反应nth order reaction碰撞理论collision theory活化能activation energy表现活化能apparent activation energy阿伦尼乌斯方程Arrhenius equation半衰期half-life宏观动力学macrokinetics冶金过程动力学kinetics of metallurgical process 传输现象transport phenomena传质mass transfer传热heat transfer动量传输momentum transfer层流laminar flow湍流turbulent flow气泡gas bubble鼓泡bubbling射流jet液滴liquid droplet粘度viscosity边界层boundary layer流率flow rate通量flux扩散diffusion菲克第一扩散定律Fick’s 1st law of diffusion菲克第一扩散定律Fick’s 2nd law of diffusion扩散系数diffusion coefficient传质系数mass transfer coefficient热传导heat conduction热对流heat convection自然对流natural convection强制对流forced convection热辐射heat radiation导热率thermal conductivity传热系数heat transfer coefficient体内浓度bulk concentration未反应核模型unreacted core model扩散控制反应diffusion-controlled reaction化学控制反应chenical-controlled reaction混合控制反应mixed-controlled reaction相似原理priciple of similarity雷诺数Reynolds number固定床fiexed bed填充床packed bed移动床moving bed流态化床fluidized bed混合时间mixing time停留时间residence time, retention time催化catalysis催化剂catalyst表面能surface energy表面张力surface tension界面能interfacial energy界面张力interfacial tension润湿wetting表面活性物质surface-active substance吸收absorption吸附absorption4.3 冶金电化学冶金电化学metallurgical electrochemistry熔盐电化学electrochemistry of fused salts固态离子学solid state ionics电解质溶液electrolyte solution阳离子cation阴离子anion电导conductance电导率conductivity电阻resistance电极electrode阴极cathode阳极anode电镀electroplating固体电解质solid electrolyte稳定的氧化锆stablized zirconia氧传感器oxygen sensor硅传感器silicon sensor定氧测头oxygen probe定硅测头silicon probe4.4 冶金物理化学研究方法冶金物理化学研究方法research methods in metallurgical physicalchemistry热电偶thermocouple量热计calorimeter热太平thermobalance热分析thermal analysis差热分析differential thermal analysis,DTA热重法thermogravimetry分子筛molecular sieve5 钢铁冶金5.1 炼焦炼焦coking 高温炭化high temperature carbonization塑性成焦机理plastic mechanism of coke formation 中间相成焦机理mesophase mechanism of coke formation选煤coal preparation, coal washing配煤coal blending配煤试验coal blending test炼焦煤coking coal气煤gas coal肥煤fat coal瘦煤lean coal焦炉coke oven焦化室oven chamber焦饼coke cake结焦时间coking time周转时间cycle time装煤coal charging捣固装煤stamp charging推焦coke pushing焦炭熄火coke quenching干法熄焦dry quenching of coke焦台coke wharf装煤车larry car推焦机pushing machine拦焦机coke guide熄焦车quenching car焦炉焖炉banking for coke oven焦炭coke冶金焦metallurgical coke铸造焦foundry coke焦炭工业分析proximate analysis of coke焦炭元素分析ultimate analysis of coke焦炭落下指数shatter index of coke焦炭转鼓指数drum index of coke焦炭热强度hot strength of coke焦炭反应性coke reactivity焦炭反应后强度post-reaction strength of coke焦炭显微强度microstrength of coke焦炉煤气coke oven gas发热值calorific value煤焦油coal tar粗苯crude benzol苯benzene甲苯toluene二甲苯xylene苯并呋喃-茚树脂coumarone-indene resin精萘refined naphthalene精蒽refined anthracene煤[焦油]沥青coal tar pitch沥青焦pitch coke针状焦needle coke型焦formcoke5.2 耐火材料耐火材料refractory materials耐火粘土fireclay高岭土kaolin硬质粘土flint clay轻质粘土soft clay陶土pot clay蒙脱石montmorillonite叶蜡石pyrophyllite膨润土bentonite鳞石英tridymite方石英cristobalite砂岩sandstone耐火石firestone莫来石mullite氧化铝alumina烧结氧化铝sintered alumina电熔氧化铝fused alumina刚玉corundum红柱石andalusite蓝晶石kyanite,cyanite硅线石sillimanite橄榄石olivine方镁石periclase镁砂magnesia合成镁砂synthetic sintered magnesia电熔镁砂fused magnesia烧结白云石砂sintered dolomite clinker合成镁铬砂synthetic magnesia chromite clinker尖晶石spinel镁铬尖晶石magnesia chrome spinel,magnesiochromite硅藻土diatomaceous earth, infusorial earth蛭石vermiculite珍珠岩perlite碳化硅silicon carbide氮化硅silicon nitride氮化硼boron nitride粘土熟料chamotte熟料grog 轻烧light burning,soft burning死烧dead burning,hard burning成型模注shaping moulding机压成型mechanical pressing等静压成型isostatic pressing摩擦压砖机friction press液压压砖机hydraulic press捣打成型ramming process熔铸成型fusion cast process砖坯强度green strength,dry strength隧道窑tunnel kiln回转窑rotary kiln倒焰窑down draught kiln耐火砖refractory brick标准型耐火砖standard size refractory brick泡砂石quartzite sandstone酸性耐火材料acid refractory [material]硅质耐火材料siliceous refractory [material]硅砖silica brick,dinas brick熔融石英制品fused quartz product硅酸铝质耐火材料aluminosillicate refractory 半硅砖semisilica brick粘土砖fireclay brick,chamotte brick石墨粘土砖graphite clay brick高铝砖high alumina brick硅线石砖sillimanite brick莫来石砖mullite brick刚玉砖corundum brick铝铬砖alumina chrome brick熔铸砖fused cast brick碱性耐火材料basic refractory [material]镁质耐火材料magnesia refractory [material]镁砖magnesia brick镁铝砖magnesia alumina brick镁铬砖magnesia chrome brick镁炭砖magnesia carbon brick中性耐火材料neutral refractory [material]复合砖composite brick铝炭砖alumina carbon brick铝镁炭转alumina magnesia brick锆炭砖zirconia graphite brick镁钙炭砖magnesia clacia carbon brick长水口long nozzle浸入式水口immersion nozzle,submerged nozzle 定径水口metering nozzle氧化铝-碳化硅-炭砖Al2O3-SiC-C brick透气砖gas permeable brick,porous brick滑动水口slide gate nozzle水口砖nozzle brick塞头砖stopper绝热耐火材料insulating refractory轻质耐火材料light weight refractory袖砖sleeve brick格子砖checker brick,chequer brick陶瓷纤维ceramic fiber耐火纤维refractory fiber耐火浇注料refractory castable耐火混凝土refractory concrete荷重耐火性refractoriness under load抗渣性slagging resistance耐磨损性abrasion resistance5.3 碳素材料[含]碳[元]素材料carbon materials无定形碳amorphous carbon金刚石diamond炭相[学]carbon micrography炭黑carbon black石油沥青petroleum pitch石油焦炭petroleum coke石墨化graphitization石墨化电阻炉electric resistance furnace for graphitization石墨纯净化处理purification treatment of graphite 炭砖carbon brick炭块carbon block碳化硅基炭块SiC-based carbon block炭电极carbon electrode连续自焙电极Soderberg electrode石墨电极graphite electrode超高功率石墨电极ultra-high power graphite electrode石墨电极接头graphite electrode nipple石墨电极接头孔graphite electrode socket plug电极糊electrode paste石墨坩埚graphite crucible石墨电阻棒graphite rod resistor炭刷carbon brush高纯石墨high purity graphite5.4 铁合金铁合金ferroalloy硅铁ferrosilicon硅钙calcium silicon 金属硅silicon metal锰铁ferromangnanese低碳锰铁low carbon ferromanganese硅锰silicomanganese金属锰manganese metal铬铁ferrochromium低碳铬铁low carbon ferrochromium微碳铬铁extra low carbon ferrochromium硅铬silicochromium金属铬chromium metal钨铁ferrotunsten钼铁ferromolybdenum钛铁ferrotitanium硼铁ferroboron铌铁ferroniobium磷铁ferrophosphorus镍铁ferronickel锆铁ferrozirconium硅锆silicozirconium稀土硅铁rare earth ferrosilicon稀土镁硅铁rare earth ferrosilicomagnesium成核剂nucleater孕育剂incubater,inoculant球化剂nodulizer蠕化剂vermiculizer中间铁合金master alloy复合铁合金complex ferroalloy电碳热法electro-carbothermic process电硅热法electro-silicothermic process铝热法aluminothermic process,thermit process 电铝热法electro-aluminothermic process开弧炉open arc furnace埋弧炉submerged arc furnace半封闭炉semiclosed furnace封闭炉closed furnace矮烟罩电炉electric furnace with low hood矮炉身电炉low-shaft electric furnace5.5 烧结与球团人造块矿ore agglomerates烧结矿sinter压块矿briquette球团[矿] pellet针铁矿goethite自熔性铁矿self-fluxed iron ore复合铁矿complex iron ore块矿lump ore粉矿ore fines矿石混匀ore blending配矿ore proportioning矿石整粒ore size grading返矿return fines储矿场ore stockyard矿石堆料机ore stocker匀矿取料机ore reclaimer熔剂flux消石灰slaked lime活性石灰quickened lime有机粘结剂organic binder烧结混合料sinter mixture烧结铺底料hearth layer for sinter烧结sintering烧结热前沿heat front in sintering烧结火焰前沿flame front in sintering渣相粘结slag bonding扩散粘结diffusion bonding带式烧结机Dwight-Lloyd sintering machine环式烧结机circular travelling sintering machine烧结梭式布料机shuttle conveyer belt烧结点火料sintering ignition furnace烧结盘sintering pan烧结锅sintering pot烧结冷却机sinter cooler带式冷却机straight-line cooler环式冷却机circular cooler,annular cooler生球green pellet,ball生球长大聚合机理ball growth by coalescence生球长大成层机理ball growth by layering生球长大同化机理ball growth by assimilation精矿成球指数balling index for iron ore concentrates生球转鼓强度drum strength of green pellet生球落下强度shatter strength of green pellet生球抗压强度compression strength of green pellet 生球爆裂温度cracking temperature of green pellet 圆筒造球机balling drum圆盘造球机balling disc竖炉陪烧球团shaft furnace for pellet firing带式机陪烧球团traveling grate for pellet firing链算机-回转窑陪烧球团grate-kiln for pellet firing 环式机陪烧球团circular gates for pellet firing冷固结球团cold bound pellet维式体wustite 铁橄榄石fayalite铁尖晶石hercynite铁黄长石ferrogehlenite铁酸半钙calcium diferrite铁酸钙calcium ferrite铁酸二钙dicalcium ferrite锰铁橄榄石knebelite钙铁橄榄石kirschsteinite钙铁辉石hedenbergite钙铁榴石andradite钙长石anorthite钙镁橄榄石monticellite钙钛矿perovskite硅灰石wollastonite硅酸二钙dicalcium silicate硅酸三钙tricalcium silicate镁橄榄石forsterite镁黄长石akermanite镁蔷薇辉石manganolite钙铝黄长石gehlenite钛辉石titanaugite枪晶石cuspidine预还原球团pre-reduced pellet金属化球团metallized pellet转鼓试验drum test,tumbler test落下试验shatter test5.6 高炉炼铁炼铁iron making高炉炼铁[法] blast furnace process高炉blast furnace鼓风炉blast furnace炉料charge, burden矿料ore charge焦料coke charge炉料提升charge hoisting小车上料charge hoisting by skip吊罐上料charge hoisting by bucket皮带上料charge hoisting by belt conveyer 装料charging装料顺序charging sequence储料漏斗hopper双料钟式装料two-bells system charging 无料钟装料bell-less charging布料器distributor炉内料线stock line in the furnace探料尺gauge rod利用系数utilization coefficient冶炼强度combustion intensity鼓风blast风压blast pressure风温blast temperature鼓风量blast volume鼓风湿度blast humidity全风量操作full blast慢风under blowing休风delay喷吹燃料fuel injection喷煤coal injection喷油oil injection富氧鼓风oxygen enriched blast,oxygen enrichment 置换比replacement ratio喷射器injector热补偿thermal compensation焦比coke ratio,coke rate燃料比fuel ratio,fuel rate氧化带oxidizing zone风口循环区raceway蒸汽鼓风humidified blast混合喷吹mixed injection脱湿鼓风dehumidified blast炉内压差pressure drop in furnace煤气分布gas distribution煤气利用率gas utilization rate炉况furnace condition顺行smooth running焦炭负荷coke load,ore to coke ratio软熔带cohesive zone,softening zone渣比slag to iron ratio,slag ratio上部[炉料]调节burden conditioning下部[鼓风]调节blast conditioning高炉作业率operation rate of blast furnace休风率delay ratio高炉寿命blast furnace campaign悬料hanging崩料slip沟流channeling结瘤scaffolding炉缸冻结hearth freeze-up开炉blow on停炉blow off积铁salamander炉型profile,furnace lines 炉喉throat炉身shaft,stack炉腰belly炉腹bosh炉缸hearth炉底bottom炉腹角bosh angle炉身角stack angle有效容积effective volume工作容积working bolume铁口iron notch, slag notch渣口cinder notch, slag notch风口tuyere窥视孔peep hole风口水套tuyere cooler渣口水套slag notch cooler风口弯头tuyere stock热风围管bustle pipe堵渣机stopper泥炮mud gun,clay gun开铁口机iron notch drill铁水hot metal铁[水]罐iron ladle鱼雷车torpedo car主铁沟sow出铁沟casting house铁沟iron runner渣沟slag runner渣罐cinder ladle, slag ladle撇渣器skimmer冷却水箱cooling plate冷却壁cooling stave汽化冷却vaporization cooling 热风炉hot blast stove燃烧室combustion chamber燃烧器burner热风阀hot blast valve烟道阀chimney valve冷风阀cold blast valve助燃风机burner blower切断阀burner shut-off valve旁通阀by-pass valve混风阀mixer selector valve送风期on blast of stove,on blast 燃烧期on gas of stove, on gas 换炉stove changing放散阀blow off valve内燃式热风炉Cowper stove外燃式燃烧炉outside combustion stove顶燃式热风炉top combustion stove炉顶放散阀bleeding valve放散管bleeder上升管gas uptake放风阀snorting valve均压阀equalizing valve高压调节阀septum valve炉顶高压elevated top pressure铸铁机pig-casting machine铸铁模pig mold冲天炉cupola水渣granulating slag水渣池granulating pit渣场slag disposal pit高炉煤气top gas,blast furnace gas高炉煤气回收topgas recovery,TGR非焦炭炼铁non-coke iron making直接还原炼铁[法]direct reduction iron making直接还原铁directly reduced iron,DRI竖炉直接炼铁direct reduction in shaft furnace流态化炼铁fluidized-bed iron making转底炉炼铁rotary hearth iron making米德雷克斯直接炼铁[法]Midrex processHYL直接炼铁[法] HYL process克虏伯回转窑炼铁[法] Krupp rotary kiln iron-making熔态还原smelting reduction铁溶法iron-bath process科雷克斯法COREX process生铁pig iron海绵铁sponge iron镜铁spiegel iron清铁法H-rion process5.7 炼钢钢steel炼钢steelmaking钢水liquid steel,molten steel钢semisteel沸腾钢rimming steel,rimmed steel镇静钢killed steel半镇静钢semikilled steel压盖沸腾钢capped steel坩埚炼钢法crucible steelmaking 双联炼钢法duplex steelmaking process连续炼钢法continuous steelmaking process 直接炼钢法direct steelmaking process混铁炉hot metal machine装料机charging machine装料期charging machine加热期heating period熔化期melting period造渣期slag forming period精炼期refining period熔清melting down脱氧deoxidation预脱氧preliminary dexidation还原渣reducing slag酸性渣acid slag碱性渣basic slag脱碳decarburization增碳recarburization脱磷dephosphorization回磷rephosphorization脱硫desulfurization回硫resulfurization脱氮denitrogenation过氧化overoxidation出钢tapping冶炼时间duration of heat出钢样tapping sample浇铸样casting sample不合格炉次off heat熔炼损耗melting loss铁损iron loss废钢scrap废钢打包baling of scrap造渣材料slag making materials添加剂addition reagent脱氧剂deoxidizer脱硫剂desulfurizer冷却剂coolant回炉渣return slag喷枪lance浸入式喷枪submerged lance钢包ladle出钢口top hole出钢槽pouring lining炉顶furnace roof炉衬furnace lining炉衬侵蚀lining erosion渣线slag line炉衬寿命lining life分区砌砖zoned lining补炉fettling热修hot repair喷补gunning火焰喷补flame gunning转炉converter转炉炼钢converter steelmaking底吹转炉bottom-blown converter酸性空气底吹转炉air bottom-blown acid converter碱性空气底吹转炉air bottom-blown basic converter侧吹转炉side-blown converter卡尔多转炉Kaldo converter氧气炼铁oxygen steelmaking氧气顶吹转炉top-blown oxygen converter,LI converter氧气底吹转炉bottom-blown oxygen converter quiet basic oxygen furnace,QBOF顶底复吹转炉top and bottom combined blown converter喷石灰粉顶吹氧气转炉法oxygen lime process底吹煤氧的复合吹炼法Klockner-Maxhutte steelmaking process,KMS住友复合吹炼法Sumitomo top and bottom blowing process,STBLBE复吹法lance bubbling equilibrium process,LBE顶枪喷煤粉炼钢法Arved lance carbon injection process,ALCI蒂森复合吹炼法Thyssen Blassen Metallurgical process,TBM面吹surface blow软吹soft blow硬吹hard blow补吹reblow过吹overblow后吹after blow目标碳aim carbon终点碳end point carbon高拉碳操作catch carbon practice增碳操作recarburization practice单渣操作single-slag operation 双渣操作double-slag operation渣乳化slag emulsion二次燃烧postcombustion吹氧时间oxygen blow duration吹炼终点blow end point倒炉turning down喷渣slopping喷溅spitting静态控制static control动态控制dynamic control氧枪oxygen lance氧枪喷孔nozzle of oxygen lance多孔喷枪multi-nozzle lance转炉炉体converter body炉帽upper cone炉口mouth,lip ring装料大面impact pad活动炉底removable bottom顶吹氧枪top blow oxygen lance副枪sublance多孔砖nozzle brick单环缝喷嘴single annular tuyere双环缝喷嘴double annular tuyere挡渣器slag stopper挡渣塞floating plug电磁测渣器electromagnetic slag detector废气控制系统off gas control system,OGCS平炉open-hearth furnace平炉炼钢open-hearth steelmaking冷装法cold charge practice热装法hot charge practice碳沸腾carbon boil石灰沸腾lime boil炉底沸腾bottom boil再沸腾reboil有效炉底面积effective hearth area酸性平炉acid open-hearth furnace碱性平炉basic open-hearth furnace固定式平炉stationary open-hearth furnace倾动式平炉tilting open-hearth furnace双床平炉twin-hearth furnace顶吹氧气平炉open-hearth furnace with roof oxygen lance蓄热室regenerator沉渣室slag pocket电炉炼钢electric steelmaking电弧炉electric arc furnace超高功率电弧炉ultra-high power electric arc furnace直流电弧炉direct current electric arc furnace双电极直流电弧炉double electrode direct current arc furnace竖窑式电弧炉shaft arc furnace电阻炉electric resistance furnace工频感应炉line frequency induction furnace中频感应炉medium frequency induction furnace 高频感应炉high frequency induction furnace电渣重熔electroslag remelting,ESR电渣熔铸electroslag casting,ESC电渣浇注Bohler electroslag tapping,BEST真空电弧炉重熔vacuum arc remelting,V AR真空感应炉熔炼vacuum induction melting,VIM 电子束炉重熔electron beam remelting,EBR等离子炉重炼plasma-arc remelting,PAR水冷模电弧熔炼cold-mold arc melting等离子感应炉熔炼plasma induction melting,PIM 等离子连续铸锭plasma progressive casting,PPC 等离子凝壳铸造plasma skull casting,PSC能量优化炼钢炉energy optimizing furnace,EOF 氧燃喷嘴oxygen-fuel burner氧煤助熔accelerated melting by coal-oxygen burner氧化期oxidation period还原期reduction period长弧泡沫渣操作弧长控制long arc foaming slag operation白渣white slag电石渣carbide slag煤氧喷吹coal-oxygen injection炉壁热点hot spots on the furnace wall偏弧arc bias透气塞porous plug出钢到出钢时间tap-to-tap time虹吸出钢siphon tapping偏心炉底出钢eccentric bottom tapping,EBT中心炉底出钢centric bottom tapping,CBT侧面炉底出钢side bottom tapping,SBT滑动水口出钢slide fate tapping5.8 精炼、浇铸及缺陷铁水预处理hot metal pretreatment机械搅拌铁水脱硫法KR process torpedo desulfurization 鱼雷车铁水脱磷torpedo dephosphorization二次精炼secondary refining钢包精炼ladle refining合成渣synthetic slag微合金化microalloying成分微调trimming钢洁净度steel cleanness钢包炉ladle furnace,LF直流钢包炉DC ladle furnace真空钢包炉LF-vacuum真空脱气vacuum degassing真空电弧脱气vacuum arc degassing,V AD真空脱气炉vacuum degassing furnace,VDF真空精炼vacuum refining钢流脱气stream degassing提升式真空脱气法Dortmund Horder vacuum degassing process,DH循环式真空脱气法Ruhstahl-Hausen vacuum degassing process,RH真空浇铸vacuum casting吹氧RH操作RH-oxygen blowing,RH-OB川崎顶吹氧RH操作RH-Kawasaki top blowing,RH-KTB喷粉RH操作RH-poowder blowing,TH-PB喷粉法powder injection process喷粉精炼injection refining蒂森钢包喷粉法Thyssen Niederhein process,TN 瑞典喷粉法Scandinavian Lancer process,SL君津真空喷粉法vacuum Kimitsu injection process 密封吹氩合金成分调整法composition adjustment by sealed argon bubbling,CAS吹氧提温CAS法CAS-OB process脉冲搅拌法pulsating mixing process,PM电弧加热电磁搅拌钢包精炼法ASEA-SKF process真空吹氧脱碳法vacuum oxygen decarburization process ,VOD氩氧脱碳法argon-oxygen decarburization process,AOD蒸汽氧精炼法Creusot-Loire Uddelholm process,CLU无渣精炼slag free refining摇包法shaking ladle process铝弹脱氧法aluminium bullet shooting,ABS钢锭ingot铸锭ingot casting坑铸pit casting车铸car casting钢锭模ingot mold保温帽hot top下铸bottom casting上铸top casting补浇back pour,back feeding浇注速度pouring speed脱模ingot stripping发热渣exoslag防再氧化操作reoxidation protection连续浇注continuous casting，Continuous Steel Casting连铸机continuous caster,CC,continuous casting machine,CCM弧形连铸机bow-type continuous caster立弯式连铸机vertical-bending caster立式连铸机vertical caster水平连铸机horizontal caster小方坯连铸机billet caster大方坯连铸机bloom caster板坯连铸机slab caster薄板坯连铸机thin-slab casting薄带连铸机strip caster近终型浇铸near-net-shape casting单辊式连铸机single-roll caster单带式连铸机single-belt caster双带式连铸机twin-belt caster倾斜带式连铸机inclined conveyer type caster [连铸]流strand铸流间距strand distance注流对中控制stream centering control钢包回转台ladle turret中间包tundish回转式中间包swiveling tundish倾动式中间包tiltable tundish中间包挡墙weir and dam in tundish引锭杆dummy bar刚性引锭杆rigid dummy bar挠性引锭杆flexible dummy bar结晶器mold直型结晶器straight mold弧形结晶器curved mold组合式结晶器composite mold多级结晶器multi-stage mold调宽结晶器adjustable mold 结晶器振动mold oscillation结晶器内钢液顶面meniscus,steel level钢液面控制技术steel level control technique 保护渣casting powder,mold powder凝壳shell液芯liquid core空气隙air gap一次冷却区peimary cooling zone二次冷却区secondary cooling zone极限冷却速度critical cooling rate浇铸半径casting radius渗漏bleeding拉坯速度casting speed拉漏breaking out振动波纹oscillation mark水口堵塞nozzle clogging气水喷雾冷却air mist spray cooling分离环separating ring拉辊withdrawal roll立式导辊vertical guide roll弯曲辊bending roll夹辊pinch roll矫直辊straightening roll驱动辊driving roll导向辊装置roller apron切割定尺装置cut-to-length device钢流保护浇注shielded casting practice多点矫直multipoint straightening电磁搅拌electromagnetic stirring,EMS浇注周期casting cycle多炉连浇sequence casting事故溢流槽emergercy launder菜花头cauliflower top钢锭缩头piped top表面缺陷surface defect内部缺陷internal defect缩孔shrinkage cavity中心缩孔center line shrinkage气孔blowhole表面气孔surface blowhole皮下气孔subskin blowhole针孔pinhole铸疤feather冷隔cold shut炼钢缺陷lamination发裂flake,hair crack。

钢铁冶金专业英语词汇目录1 总论 (1)2 采矿 (1)3 选矿 (1)4 冶金过程物理化学 (2)4.1 冶金过程热力学 (2)4.2 冶金过程动力学 (4)4.3 冶金电化学 (5)4.4 冶金物理化学研究方法 (5)5 钢铁冶金 (5)5.1 炼焦 (5)5.2 耐火材料 (6)5.3 碳素材料 (7)5.4 铁合金 (7)5.5 烧结与球团 (7)5.6 高炉炼铁 (8)5.7 炼钢 (10)5.8 精炼、浇铸及缺陷 (12)6 钢铁材料 (14)7 英译汉 (14)天天快乐1 总论采矿mining地下采矿underground mining露天采矿open cut mining, open pit mining, surface mining采矿工程mining engineering选矿（学）mineral dressing, ore beneficiation, mineral processing矿物工程mineral engineering冶金（学）metallurgy过程冶金（学）process metallurgy提取冶金（学）extractive metallurgy化学冶金（学）chemical metallurgy物理冶金（学）physical metallurgy金属学Metallkunde冶金过程物理化学physical chemistry of process metallurgy冶金反应工程学metallurgical reaction engineering 冶金工程metallurgical engineering钢铁冶金（学）ferrous metallurgy, metallurgy of iron and steel有色冶金(学)nonferrous metallurgy真空冶金(学)vacuum metallurgy等离子冶金(学)plasma metallurgy微生物冶金(学)microbial metallurgy喷射冶金(学)injection metallurgy钢包冶金(学)ladle metallurgy二次冶金(学)secondary metallurgy机械冶金(学)mechanical metallurgy焊接冶金(学)welding metallurgy粉末冶金(学)powder metallurgy铸造学foundry火法冶金(学)pyrometallurgy湿法冶金(学)hydrometallurgy电冶金(学)electrometallurgy氯冶金(学)chlorine metallurgy矿物资源综合利用engineering of comprehensive utilization of mineral resources中国金属学会The Chinese Society for Metals中国有色金属学会The Nonferrous Metals Society of China2 采矿采矿工艺mining technology有用矿物valuable mineral冶金矿产原料metallurgical mineral raw materials 矿床mineral deposit 特殊采矿specialized mining海洋采矿oceanic mining, marine mining矿田mine field矿山mine露天矿山surface mine地下矿山underground mine矿井shaft矿床勘探mineral deposit exploration矿山可行性研究mine feasibility study矿山规模mine capacity矿山生产能力mine production capacity矿山年产量annual mine output矿山服务年限mine life矿山基本建设mine construction矿山建设期限mine construction period矿山达产arrival at mine full capacity开采强度mining intensity矿石回收率ore recovery ratio矿石损失率ore loss ratio工业矿石industrial ore采出矿石extracted ore矿体orebody矿脉vein海洋矿产资源oceanic mineral resources矿石ore矿石品位ore grade岩石力学rock mechanics岩体力学rock mass mechanics3 选矿选矿厂concentrator, mineral processing plant 工艺矿物学process mineralogy开路open circuit闭路closed circuit流程flowsheet方框流程block flowsheet产率yield回收率recovery矿物mineral粒度particle size粗颗粒coarse particle细颗粒fine particle超微颗粒ultrafine particle粗粒级coarse fraction细粒级fine fraction网目mesh原矿run of mine, crude天天快乐精矿concentrate粗精矿rough concentrate混合精矿bulk concentrate最终精矿final concentrate尾矿tailings粉碎comminution破碎crushing磨碎grinding团聚agglomeration筛分screening, sieving分级classification富集concentration分选separation手选hand sorting重选gravity separation, gravity concentration 磁选magnetic separation电选electrostatic separation浮选flotation化学选矿chemical mineral processing自然铜native copper铝土矿bauxite冰晶石cryolite磁铁矿magnetite赤铁矿hematite假象赤铁矿martite钒钛磁铁矿vanadium titano-magnetite铁燧石taconite褐铁矿limonite菱铁矿siderite镜铁矿specularite硬锰矿psilomelane软锰矿pyrolusite铬铁矿chromite黄铁矿pyrite钛铁矿ilmennite金红石rutile萤石fluorite高岭石kaolinite菱镁矿magnesite重晶石barite石墨graphite石英quartz方解石calcite石灰石limestone白云石dolomite云母mica 石膏gypsum硼砂borax石棉asbestos蛇纹石serpentine阶段破碎stage crushing粗碎primary crushing中碎secondary crushing细碎fine crushing对辊破碎机roll crusher粉磨机pulverizer震动筛vibrating screen筛网screen cloth筛孔screen opening筛上料oversize筛下料undersize粗磨coarse grinding细磨fine grinding球磨机ball mill衬板liner分级机classifier自由沉降free setting沉积sedimentation石灰lime松油pine oil硫化钠sodium sulfide硅酸钠（水玻璃）sodium silicate, water glass过滤filtration过滤机filter给矿，给料feeding给矿机feeder在线分析仪on line analyzer在线粒度分析仪on line size analyzer超声粒度计ultrasonic particle sizer, supersonic particle sizer4 冶金过程物理化学4.1 冶金过程热力学冶金过程热力学thermodynamics of metallurgical processes统计热力学statistical thermodynamics不可逆过程热力学thermodynamics of irreversible processes化学热力学chemical thernodynamics表面热力学surface thermodynamics合金热力学thermodynamics of alloys冶金热力学数据库thermodynamics databank in metallurgy天天快乐系system单元系single-componentsystem多元系multicomponent system均相系统homogeneous system广度性质extensive property强度性质intensive property过程process等温过程isothermal process等压过程isobaric process等容过程isochoric process绝热过程adiabatic process可逆过程reversible process不可逆过程irreversible process自发过程spontaneous process自理过程physical process化学过程chemical process冶金过程metallurgical process化学反应chemical reaction化合反应combination reaction分解反应decomposition reaction置换反应displacement reaction可逆反应reversible reaction不可逆反应irreversible reaction电化学反应electrochemical reaction多相反应multiphase reaction固态反应solid state reaction气一金(属)反应gas-metal reaction渣一金（属）反应slag-metal reaction 平衡equilibrium化学平衡chemical equilibrium相平衡phase equilibrium热力学平衡thermodynamic equilibrium 亚稳平衡metastable equilibrium热力学函数thermodynamic function偏摩尔量partial molar quantity总摩尔量integral molar quantity标准态standard state焓enthalpy生成焓enthalpy of formation反应焓enthalpy of reaction熵entropy吉布斯能Gibbs energy生成吉布斯能Gibbs energy of formation 反应吉布斯能Gibbs energy of reaction 溶解吉布斯能Gibbs energy of solution 吉布斯能函数Gibbs energy function 化学位chemical potential热化学thermochemistry热效应heat effect热容heat capacity熔化热heat of fusion汽化热heat of vaporization升华热heat of sublimation相变热heat of phase transformation放热反应exothermic reaction吸热反应endothermic reaction赫斯定律Hess’s law相律phase rule相图phase diagram一元相图single-component phase diagram二元相图binary-component phase diagram三元相图ternary-component phase diagram液相线liquidus固相线solidus共晶点eutectic point杠杆规则lever rule溶液solution溶质solute溶剂solvent固溶体solid solution溶液浓度concentration of solution摩尔分数mole fraction冶金熔体metallurgical melt金属熔体metal melt(炉)渣,熔渣slag熔盐molten salt, fused salt理想溶液ideal solution真实溶液real solution正规溶液regular solution活度activity活度系数activity coefficient拉乌尔定律Raoult’s law亨利定律Henry’s law纯物质标准态pure substance standard质量１％溶液标准(态)1 mass% solution standard 无限稀溶液参考态reference state of infinityly dilute solution相互作用系数interaction coefficient化学反应等温式chemical reaction isotherm吉布斯～亥姆霍兹方程Gibbs-Helmholtz equation 质量作用定律law of mass action平衡常数equilibrium constant天天快乐平衡值equilibrium value直接还原direct reduction间接还原indirect reduction金属热还原metallothermic reduction选择性氧化selective oxidation渣碱度basicity of slag光学破度optical basicity酸性氧化物acid oxide碱性氧化物basicoxide两性氧化物amphoteric泡沫渣foaming slag熔渣的分子理论molecular theory of slag熔渣的离子理论ionization theory of slag脱氧平衡deoxidation equilibrium脱氧常数deoxidation constant熔渣脱硫desulfurization by slag气态脱硫desulfurization in the gaseous state硫分配比sulfur partition ratio硫化物容量sulfide capacity氧化脱磷dephosphorization under oxidizing atmosphere磷分配比碳一氧平衡carbon-oxygen equilibrium真空脱碳vacuum decarburization去气degassing去除非金属夹杂(物)elimination of nonmetallic inclusion非金属夹杂(物)变形form modification of nonmetallic inclusion脱硅desiliconization脱锰demanganization分配平衡distribution law化学气相沉积chemical vapor deposition(CVD)4.2 冶金过程动力学微观动力学microkinetics化学动力学chemical kinetics反应途径reaction path反应机理reaction mechanism基元反应elementary reaction平行反应parallel链反应chain reaction总反应overall reaction反应速率reaction rate反应速率常数reaction rate constant反应级数reaction order零级反应zero order reaction一级反应first order reaction 二级反应second order reactionn级反应nth order reaction碰撞理论collision theory活化能activation energy表现活化能apparent activation energy阿伦尼乌斯方程Arrhenius equation半衰期half-life宏观动力学macrokinetics冶金过程动力学kinetics of metallurgical process 传输现象transport phenomena传质mass transfer传热heat transfer动量传输momentum transfer层流laminar flow湍流turbulent flow气泡gas bubble鼓泡bubbling射流jet液滴liquid droplet粘度viscosity边界层boundary layer流率flow rate通量flux扩散diffusion菲克第一扩散定律Fick’s 1st law of diffusion菲克第一扩散定律Fick’s 2nd law of diffusion扩散系数diffusion coefficient传质系数mass transfer coefficient热传导heat conduction热对流heat convection自然对流natural convection强制对流forced convection热辐射heat radiation导热率thermal conductivity传热系数heat transfer coefficient体内浓度bulk concentration未反应核模型unreacted core model扩散控制反应diffusion-controlled reaction化学控制反应chenical-controlled reaction混合控制反应mixed-controlled reaction相似原理priciple of similarity雷诺数Reynolds number固定床fiexed bed填充床packed bed移动床moving bed流态化床fluidized bed天天快乐混合时间mixing time停留时间residence time, retention time催化catalysis催化剂catalyst表面能surface energy表面张力surface tension界面能interfacial energy界面张力interfacial tension润湿wetting表面活性物质surface-active substance吸收absorption吸附absorption4.3 冶金电化学冶金电化学metallurgical electrochemistry熔盐电化学electrochemistry of fused salts固态离子学solid state ionics电解质溶液electrolyte solution阳离子cation阴离子anion电导conductance电导率conductivity电阻resistance电极electrode阴极cathode阳极anode电镀electroplating固体电解质solid electrolyte稳定的氧化锆stablized zirconia氧传感器oxygen sensor硅传感器silicon sensor定氧测头oxygen probe定硅测头silicon probe4.4 冶金物理化学研究方法冶金物理化学研究方法research methods in metallurgical physicalchemistry热电偶thermocouple量热计calorimeter热太平thermobalance热分析thermal analysis差热分析differential thermal analysis,DTA热重法thermogravimetry分子筛molecular sieve5 钢铁冶金5.1 炼焦炼焦coking 高温炭化high temperature carbonization塑性成焦机理plastic mechanism of coke formation 中间相成焦机理mesophase mechanism of coke formation选煤coal preparation, coal washing配煤coal blending配煤试验coal blending test炼焦煤coking coal气煤gas coal肥煤fat coal瘦煤lean coal焦炉coke oven焦化室oven chamber焦饼coke cake结焦时间coking time周转时间cycle time装煤coal charging捣固装煤stamp charging推焦coke pushing焦炭熄火coke quenching干法熄焦dry quenching of coke焦台coke wharf装煤车larry car推焦机pushing machine拦焦机coke guide熄焦车quenching car焦炉焖炉banking for coke oven焦炭coke冶金焦metallurgical coke铸造焦foundry coke焦炭工业分析proximate analysis of coke焦炭元素分析ultimate analysis of coke焦炭落下指数shatter index of coke焦炭转鼓指数drum index of coke焦炭热强度hot strength of coke焦炭反应性coke reactivity焦炭反应后强度post-reaction strength of coke焦炭显微强度microstrength of coke焦炉煤气coke oven gas发热值calorific value煤焦油coal tar粗苯crude benzol苯benzene甲苯toluene二甲苯xylene苯并呋喃-茚树脂coumarone-indene resin天天快乐精萘refined naphthalene精蒽refined anthracene煤[焦油]沥青coal tar pitch沥青焦pitch coke针状焦needle coke型焦formcoke5.2 耐火材料耐火材料refractory materials耐火粘土fireclay高岭土kaolin硬质粘土flint clay轻质粘土soft clay陶土pot clay蒙脱石montmorillonite叶蜡石pyrophyllite膨润土bentonite鳞石英tridymite方石英cristobalite砂岩sandstone耐火石firestone莫来石mullite氧化铝alumina烧结氧化铝sintered alumina电熔氧化铝fused alumina刚玉corundum红柱石andalusite蓝晶石kyanite,cyanite硅线石sillimanite橄榄石olivine方镁石periclase镁砂magnesia合成镁砂synthetic sintered magnesia电熔镁砂fused magnesia烧结白云石砂sintered dolomite clinker合成镁铬砂synthetic magnesia chromite clinker尖晶石spinel镁铬尖晶石magnesia chrome spinel,magnesiochromite硅藻土diatomaceous earth, infusorial earth蛭石vermiculite珍珠岩perlite碳化硅silicon carbide氮化硅silicon nitride氮化硼boron nitride粘土熟料chamotte熟料grog 轻烧light burning,soft burning死烧dead burning,hard burning成型模注shaping moulding机压成型mechanical pressing等静压成型isostatic pressing摩擦压砖机friction press液压压砖机hydraulic press捣打成型ramming process熔铸成型fusion cast process砖坯强度green strength,dry strength隧道窑tunnel kiln回转窑rotary kiln倒焰窑down draught kiln耐火砖refractory brick标准型耐火砖standard size refractory brick泡砂石quartzite sandstone酸性耐火材料acid refractory [material]硅质耐火材料siliceous refractory [material]硅砖silica brick,dinas brick熔融石英制品fused quartz product硅酸铝质耐火材料aluminosillicate refractory 半硅砖semisilica brick粘土砖fireclay brick,chamotte brick石墨粘土砖graphite clay brick高铝砖high alumina brick硅线石砖sillimanite brick莫来石砖mullite brick刚玉砖corundum brick铝铬砖alumina chrome brick熔铸砖fused cast brick碱性耐火材料basic refractory [material]镁质耐火材料magnesia refractory [material]镁砖magnesia brick镁铝砖magnesia alumina brick镁铬砖magnesia chrome brick镁炭砖magnesia carbon brick中性耐火材料neutral refractory [material]复合砖composite brick铝炭砖alumina carbon brick铝镁炭转alumina magnesia brick锆炭砖zirconia graphite brick镁钙炭砖magnesia clacia carbon brick长水口long nozzle浸入式水口immersion nozzle,submerged nozzle 定径水口metering nozzle氧化铝-碳化硅-炭砖Al2O3-SiC-C brick天天快乐透气砖gas permeable brick,porous brick滑动水口slide gate nozzle水口砖nozzle brick塞头砖stopper绝热耐火材料insulating refractory轻质耐火材料light weight refractory袖砖sleeve brick格子砖checker brick,chequer brick陶瓷纤维ceramic fiber耐火纤维refractory fiber耐火浇注料refractory castable耐火混凝土refractory concrete荷重耐火性refractoriness under load抗渣性slagging resistance耐磨损性abrasion resistance5.3 碳素材料[含]碳[元]素材料carbon materials无定形碳amorphous carbon金刚石diamond炭相[学]carbon micrography炭黑carbon black石油沥青petroleum pitch石油焦炭petroleum coke石墨化graphitization石墨化电阻炉electric resistance furnace for graphitization石墨纯净化处理purification treatment of graphite 炭砖carbon brick炭块carbon block碳化硅基炭块SiC-based carbon block炭电极carbon electrode连续自焙电极Soderberg electrode石墨电极graphite electrode超高功率石墨电极ultra-high power graphite electrode石墨电极接头graphite electrode nipple石墨电极接头孔graphite electrode socket plug电极糊electrode paste石墨坩埚graphite crucible石墨电阻棒graphite rod resistor炭刷carbon brush高纯石墨high purity graphite5.4 铁合金铁合金ferroalloy硅铁ferrosilicon硅钙calcium silicon 金属硅silicon metal锰铁ferromangnanese低碳锰铁low carbon ferromanganese硅锰silicomanganese金属锰manganese metal铬铁ferrochromium低碳铬铁low carbon ferrochromium微碳铬铁extra low carbon ferrochromium硅铬silicochromium金属铬chromium metal钨铁ferrotunsten钼铁ferromolybdenum钛铁ferrotitanium硼铁ferroboron铌铁ferroniobium磷铁ferrophosphorus镍铁ferronickel锆铁ferrozirconium硅锆silicozirconium稀土硅铁rare earth ferrosilicon稀土镁硅铁rare earth ferrosilicomagnesium成核剂nucleater孕育剂incubater,inoculant球化剂nodulizer蠕化剂vermiculizer中间铁合金master alloy复合铁合金complex ferroalloy电碳热法electro-carbothermic process电硅热法electro-silicothermic process铝热法aluminothermic process,thermit process 电铝热法electro-aluminothermic process开弧炉open arc furnace埋弧炉submerged arc furnace半封闭炉semiclosed furnace封闭炉closed furnace矮烟罩电炉electric furnace with low hood矮炉身电炉low-shaft electric furnace5.5 烧结与球团人造块矿ore agglomerates烧结矿sinter压块矿briquette球团[矿] pellet针铁矿goethite自熔性铁矿self-fluxed iron ore复合铁矿complex iron ore块矿lump ore天天快乐粉矿ore fines矿石混匀ore blending配矿ore proportioning矿石整粒ore size grading返矿return fines储矿场ore stockyard矿石堆料机ore stocker匀矿取料机ore reclaimer熔剂flux消石灰slaked lime活性石灰quickened lime有机粘结剂organic binder烧结混合料sinter mixture烧结铺底料hearth layer for sinter烧结sintering烧结热前沿heat front in sintering烧结火焰前沿flame front in sintering渣相粘结slag bonding扩散粘结diffusion bonding带式烧结机Dwight-Lloyd sintering machine环式烧结机circular travelling sintering machine烧结梭式布料机shuttle conveyer belt烧结点火料sintering ignition furnace烧结盘sintering pan烧结锅sintering pot烧结冷却机sinter cooler带式冷却机straight-line cooler环式冷却机circular cooler,annular cooler生球green pellet,ball生球长大聚合机理ball growth by coalescence生球长大成层机理ball growth by layering生球长大同化机理ball growth by assimilation精矿成球指数balling index for iron ore concentrates生球转鼓强度drum strength of green pellet生球落下强度shatter strength of green pellet生球抗压强度compression strength of green pellet 生球爆裂温度cracking temperature of green pellet 圆筒造球机balling drum圆盘造球机balling disc竖炉陪烧球团shaft furnace for pellet firing带式机陪烧球团traveling grate for pellet firing链算机-回转窑陪烧球团grate-kiln for pellet firing 环式机陪烧球团circular gates for pellet firing冷固结球团cold bound pellet维式体wustite 铁橄榄石fayalite铁尖晶石hercynite铁黄长石ferrogehlenite铁酸半钙calcium diferrite铁酸钙calcium ferrite铁酸二钙dicalcium ferrite锰铁橄榄石knebelite钙铁橄榄石kirschsteinite钙铁辉石hedenbergite钙铁榴石andradite钙长石anorthite钙镁橄榄石monticellite钙钛矿perovskite硅灰石wollastonite硅酸二钙dicalcium silicate硅酸三钙tricalcium silicate镁橄榄石forsterite镁黄长石akermanite镁蔷薇辉石manganolite钙铝黄长石gehlenite钛辉石titanaugite枪晶石cuspidine预还原球团pre-reduced pellet金属化球团metallized pellet转鼓试验drum test,tumbler test落下试验shatter test5.6 高炉炼铁炼铁iron making高炉炼铁[法] blast furnace process高炉blast furnace鼓风炉blast furnace炉料charge, burden矿料ore charge焦料coke charge炉料提升charge hoisting小车上料charge hoisting by skip吊罐上料charge hoisting by bucket皮带上料charge hoisting by belt conveyer 装料charging装料顺序charging sequence储料漏斗hopper双料钟式装料two-bells system charging 无料钟装料bell-less charging布料器distributor炉内料线stock line in the furnace探料尺gauge rod天天快乐利用系数utilization coefficient冶炼强度combustion intensity鼓风blast风压blast pressure风温blast temperature鼓风量blast volume鼓风湿度blast humidity全风量操作full blast慢风under blowing休风delay喷吹燃料fuel injection喷煤coal injection喷油oil injection富氧鼓风oxygen enriched blast,oxygen enrichment 置换比replacement ratio喷射器injector热补偿thermal compensation焦比coke ratio,coke rate燃料比fuel ratio,fuel rate氧化带oxidizing zone风口循环区raceway蒸汽鼓风humidified blast混合喷吹mixed injection脱湿鼓风dehumidified blast炉内压差pressure drop in furnace煤气分布gas distribution煤气利用率gas utilization rate炉况furnace condition顺行smooth running焦炭负荷coke load,ore to coke ratio软熔带cohesive zone,softening zone渣比slag to iron ratio,slag ratio上部[炉料]调节burden conditioning下部[鼓风]调节blast conditioning高炉作业率operation rate of blast furnace休风率delay ratio高炉寿命blast furnace campaign悬料hanging崩料slip沟流channeling结瘤scaffolding炉缸冻结hearth freeze-up开炉blow on停炉blow off积铁salamander炉型profile,furnace lines 炉喉throat炉身shaft,stack炉腰belly炉腹bosh炉缸hearth炉底bottom炉腹角bosh angle炉身角stack angle有效容积effective volume工作容积working bolume铁口iron notch, slag notch渣口cinder notch, slag notch风口tuyere窥视孔peep hole风口水套tuyere cooler渣口水套slag notch cooler风口弯头tuyere stock热风围管bustle pipe堵渣机stopper泥炮mud gun,clay gun开铁口机iron notch drill铁水hot metal铁[水]罐iron ladle鱼雷车torpedo car主铁沟sow出铁沟casting house铁沟iron runner渣沟slag runner渣罐cinder ladle, slag ladle撇渣器skimmer冷却水箱cooling plate冷却壁cooling stave汽化冷却vaporization cooling 热风炉hot blast stove燃烧室combustion chamber燃烧器burner热风阀hot blast valve烟道阀chimney valve冷风阀cold blast valve助燃风机burner blower切断阀burner shut-off valve旁通阀by-pass valve混风阀mixer selector valve送风期on blast of stove,on blast 燃烧期on gas of stove, on gas 换炉stove changing天天快乐放散阀blow off valve内燃式热风炉Cowper stove外燃式燃烧炉outside combustion stove顶燃式热风炉top combustion stove炉顶放散阀bleeding valve放散管bleeder上升管gas uptake放风阀snorting valve均压阀equalizing valve高压调节阀septum valve炉顶高压elevated top pressure铸铁机pig-casting machine铸铁模pig mold冲天炉cupola水渣granulating slag水渣池granulating pit渣场slag disposal pit高炉煤气top gas,blast furnace gas高炉煤气回收topgas recovery,TGR非焦炭炼铁non-coke iron making直接还原炼铁[法]direct reduction iron making直接还原铁directly reduced iron,DRI竖炉直接炼铁direct reduction in shaft furnace流态化炼铁fluidized-bed iron making转底炉炼铁rotary hearth iron making米德雷克斯直接炼铁[法]Midrex processHYL直接炼铁[法] HYL process克虏伯回转窑炼铁[法] Krupp rotary kiln iron-making熔态还原smelting reduction铁溶法iron-bath process科雷克斯法COREX process生铁pig iron海绵铁sponge iron镜铁spiegel iron清铁法H-rion process5.7 炼钢钢steel炼钢steelmaking钢水liquid steel,molten steel钢semisteel沸腾钢rimming steel,rimmed steel镇静钢killed steel半镇静钢semikilled steel压盖沸腾钢capped steel坩埚炼钢法crucible steelmaking 双联炼钢法duplex steelmaking process连续炼钢法continuous steelmaking process 直接炼钢法direct steelmaking process混铁炉hot metal machine装料机charging machine装料期charging machine加热期heating period熔化期melting period造渣期slag forming period精炼期refining period熔清melting down脱氧deoxidation预脱氧preliminary dexidation还原渣reducing slag酸性渣acid slag碱性渣basic slag脱碳decarburization增碳recarburization脱磷dephosphorization回磷rephosphorization脱硫desulfurization回硫resulfurization脱氮denitrogenation过氧化overoxidation出钢tapping冶炼时间duration of heat出钢样tapping sample浇铸样casting sample不合格炉次off heat熔炼损耗melting loss铁损iron loss废钢scrap废钢打包baling of scrap造渣材料slag making materials添加剂addition reagent脱氧剂deoxidizer脱硫剂desulfurizer冷却剂coolant回炉渣return slag喷枪lance浸入式喷枪submerged lance钢包ladle出钢口top hole出钢槽pouring lining炉顶furnace roof炉衬furnace lining天天快乐炉衬侵蚀lining erosion渣线slag line炉衬寿命lining life分区砌砖zoned lining补炉fettling热修hot repair喷补gunning火焰喷补flame gunning转炉converter转炉炼钢converter steelmaking底吹转炉bottom-blown converter酸性空气底吹转炉air bottom-blown acid converter碱性空气底吹转炉air bottom-blown basic converter侧吹转炉side-blown converter卡尔多转炉Kaldo converter氧气炼铁oxygen steelmaking氧气顶吹转炉top-blown oxygen converter,LI converter氧气底吹转炉bottom-blown oxygen converter quiet basic oxygen furnace,QBOF顶底复吹转炉top and bottom combined blown converter喷石灰粉顶吹氧气转炉法oxygen lime process底吹煤氧的复合吹炼法Klockner-Maxhutte steelmaking process,KMS住友复合吹炼法Sumitomo top and bottom blowing process,STBLBE复吹法lance bubbling equilibrium process,LBE顶枪喷煤粉炼钢法Arved lance carbon injection process,ALCI蒂森复合吹炼法Thyssen Blassen Metallurgical process,TBM面吹surface blow软吹soft blow硬吹hard blow补吹reblow过吹overblow后吹after blow目标碳aim carbon终点碳end point carbon高拉碳操作catch carbon practice增碳操作recarburization practice单渣操作single-slag operation 双渣操作double-slag operation渣乳化slag emulsion二次燃烧postcombustion吹氧时间oxygen blow duration吹炼终点blow end point倒炉turning down喷渣slopping喷溅spitting静态控制static control动态控制dynamic control氧枪oxygen lance氧枪喷孔nozzle of oxygen lance多孔喷枪multi-nozzle lance转炉炉体converter body炉帽upper cone炉口mouth,lip ring装料大面impact pad活动炉底removable bottom顶吹氧枪top blow oxygen lance副枪sublance多孔砖nozzle brick单环缝喷嘴single annular tuyere双环缝喷嘴double annular tuyere挡渣器slag stopper挡渣塞floating plug电磁测渣器electromagnetic slag detector废气控制系统off gas control system,OGCS平炉open-hearth furnace平炉炼钢open-hearth steelmaking冷装法cold charge practice热装法hot charge practice碳沸腾carbon boil石灰沸腾lime boil炉底沸腾bottom boil再沸腾reboil有效炉底面积effective hearth area酸性平炉acid open-hearth furnace碱性平炉basic open-hearth furnace固定式平炉stationary open-hearth furnace倾动式平炉tilting open-hearth furnace双床平炉twin-hearth furnace顶吹氧气平炉open-hearth furnace with roof oxygen lance蓄热室regenerator沉渣室slag pocket电炉炼钢electric steelmaking天天快乐电弧炉electric arc furnace超高功率电弧炉ultra-high power electric arc furnace直流电弧炉direct current electric arc furnace双电极直流电弧炉double electrode direct current arc furnace竖窑式电弧炉shaft arc furnace电阻炉electric resistance furnace工频感应炉line frequency induction furnace中频感应炉medium frequency induction furnace 高频感应炉high frequency induction furnace电渣重熔electroslag remelting,ESR电渣熔铸electroslag casting,ESC电渣浇注Bohler electroslag tapping,BEST真空电弧炉重熔vacuum arc remelting,V AR真空感应炉熔炼vacuum induction melting,VIM 电子束炉重熔electron beam remelting,EBR等离子炉重炼plasma-arc remelting,PAR水冷模电弧熔炼cold-mold arc melting等离子感应炉熔炼plasma induction melting,PIM 等离子连续铸锭plasma progressive casting,PPC 等离子凝壳铸造plasma skull casting,PSC能量优化炼钢炉energy optimizing furnace,EOF 氧燃喷嘴oxygen-fuel burner氧煤助熔accelerated melting by coal-oxygen burner氧化期oxidation period还原期reduction period长弧泡沫渣操作弧长控制long arc foaming slag operation白渣white slag电石渣carbide slag煤氧喷吹coal-oxygen injection炉壁热点hot spots on the furnace wall偏弧arc bias透气塞porous plug出钢到出钢时间tap-to-tap time虹吸出钢siphon tapping偏心炉底出钢eccentric bottom tapping,EBT中心炉底出钢centric bottom tapping,CBT侧面炉底出钢side bottom tapping,SBT滑动水口出钢slide fate tapping5.8 精炼、浇铸及缺陷铁水预处理hot metal pretreatment机械搅拌铁水脱硫法KR process torpedo desulfurization 鱼雷车铁水脱磷torpedo dephosphorization二次精炼secondary refining钢包精炼ladle refining合成渣synthetic slag微合金化microalloying成分微调trimming钢洁净度steel cleanness钢包炉ladle furnace,LF直流钢包炉DC ladle furnace真空钢包炉LF-vacuum真空脱气vacuum degassing真空电弧脱气vacuum arc degassing,V AD真空脱气炉vacuum degassing furnace,VDF真空精炼vacuum refining钢流脱气stream degassing提升式真空脱气法Dortmund Horder vacuum degassing process,DH循环式真空脱气法Ruhstahl-Hausen vacuum degassing process,RH真空浇铸vacuum casting吹氧RH操作RH-oxygen blowing,RH-OB川崎顶吹氧RH操作RH-Kawasaki top blowing,RH-KTB喷粉RH操作RH-poowder blowing,TH-PB喷粉法powder injection process喷粉精炼injection refining蒂森钢包喷粉法Thyssen Niederhein process,TN 瑞典喷粉法Scandinavian Lancer process,SL君津真空喷粉法vacuum Kimitsu injection process 密封吹氩合金成分调整法composition adjustment by sealed argon bubbling,CAS吹氧提温CAS法CAS-OB process脉冲搅拌法pulsating mixing process,PM电弧加热电磁搅拌钢包精炼法ASEA-SKF process真空吹氧脱碳法vacuum oxygen decarburization process ,VOD氩氧脱碳法argon-oxygen decarburization process,AOD蒸汽氧精炼法Creusot-Loire Uddelholm process,CLU无渣精炼slag free refining摇包法shaking ladle process铝弹脱氧法aluminium bullet shooting,ABS钢锭ingot铸锭ingot casting天天快乐坑铸pit casting车铸car casting钢锭模ingot mold保温帽hot top下铸bottom casting上铸top casting补浇back pour,back feeding浇注速度pouring speed脱模ingot stripping发热渣exoslag防再氧化操作reoxidation protection连续浇注continuous casting，Continuous Steel Casting连铸机continuous caster,CC,continuous casting machine,CCM弧形连铸机bow-type continuous caster立弯式连铸机vertical-bending caster立式连铸机vertical caster水平连铸机horizontal caster小方坯连铸机billet caster大方坯连铸机bloom caster板坯连铸机slab caster薄板坯连铸机thin-slab casting薄带连铸机strip caster近终型浇铸near-net-shape casting单辊式连铸机single-roll caster单带式连铸机single-belt caster双带式连铸机twin-belt caster倾斜带式连铸机inclined conveyer type caster [连铸]流strand铸流间距strand distance注流对中控制stream centering control钢包回转台ladle turret中间包tundish回转式中间包swiveling tundish倾动式中间包tiltable tundish中间包挡墙weir and dam in tundish引锭杆dummy bar刚性引锭杆rigid dummy bar挠性引锭杆flexible dummy bar结晶器mold直型结晶器straight mold弧形结晶器curved mold组合式结晶器composite mold多级结晶器multi-stage mold调宽结晶器adjustable mold 结晶器振动mold oscillation结晶器内钢液顶面meniscus,steel level钢液面控制技术steel level control technique 保护渣casting powder,mold powder凝壳shell液芯liquid core空气隙air gap一次冷却区peimary cooling zone二次冷却区secondary cooling zone极限冷却速度critical cooling rate浇铸半径casting radius渗漏bleeding拉坯速度casting speed拉漏breaking out振动波纹oscillation mark水口堵塞nozzle clogging气水喷雾冷却air mist spray cooling分离环separating ring拉辊withdrawal roll立式导辊vertical guide roll弯曲辊bending roll夹辊pinch roll矫直辊straightening roll驱动辊driving roll导向辊装置roller apron切割定尺装置cut-to-length device钢流保护浇注shielded casting practice多点矫直multipoint straightening电磁搅拌electromagnetic stirring,EMS浇注周期casting cycle多炉连浇sequence casting事故溢流槽emergercy launder菜花头cauliflower top钢锭缩头piped top表面缺陷surface defect内部缺陷internal defect缩孔shrinkage cavity中心缩孔center line shrinkage气孔blowhole表面气孔surface blowhole皮下气孔subskin blowhole针孔pinhole铸疤feather冷隔cold shut炼钢缺陷lamination发裂flake,hair crack天天快乐。