630故障分析(英文版) (version 1)

图 １ ６ ０ 举升 控 制 图 ３Ｅ
２１ ０ ２年 第 １ 期
矿
用
汽
车
・１ ・ ７
★ 使 用与 维修 ★
陷 。由于举升 先导 油 回油管 与制动 系统 回油合 为一
个通 路 ， 举升 情况下 ， 升控制 油在 举升 限位 电磁 阀 举 的控制 下 ， 升控制 油 直接 回液压 油箱 ， 举 没有 经过 回 油 总管 。这样 举升 控 制 阀 的举 升 腔 无 压力 ， 于迫 对 降腔 的控 制 油 回油 经 举 升控 制先 导 阀 ， 返 回到 回 再 油 总管 ， 然后 回液 压油 箱 。这 样 回油途经 路线 过长 ， 中途且 受到 制 动 回油 的 阻滞 ， 致 回 油 不 畅 、 敏 导 不 捷 。致使 举 升控制 阀 的举升 腔和动 力下 降腔 产生 压 力差 。举升 限位 电磁 阀起 作 用 的 瞬 间 ， 升 控 制 阀 举 在 压差 的影 响下 ， 突 然 移 位 至动 力 下 降 状态 。此 会 时 ， 机操控 举升 卸货 时瞬 间箱斗 回落 ， 司 司机 为满 足
保护 电路 的功能 。
发 生率 比较 频 繁 的 ５ ＃、７ 车上 改 装 进 行 观 察 ５ ５ 卡 运 行 。经过 ４个 多 月 的运 行 发 现使 用 性 能 非 常 可 观， 举升 限位 方 面 的故 障从 根 本 上 得 到 了控 制 。然 后对 ５ ６台 ６０ ３ Ｅ设 备 举 升 限 位进 行 改 造 。到 目前
图 ３ 改 造 后 的 线 路 图
１ Ｌ １ ７ｌ ２
表层为 ４ ０ｍ左右的黄土层， 黄土粘度高， 粘附性强。 对于运输黄土的 ６０ ３Ｅ矿用 自卸卡车而言， 在装载过 程 中会有大量黄 土粘附在汽车箱 斗 内， 在卸 土时不 能

老车故障码D701,Immobilizer:ECU-BCM Communication Line Data Error 1,钥匙防盗系统:ECU-BCM 通信线路数据错误1 D702,Immobilizer:ECU-BCM Communication Line Data Error 2,钥匙防盗系统:ECU-BCM 通信线路数据错误2 D704,Immobilizer:ECU-BCM Communication Line Data Error 3,钥匙防盗系统:ECU-BCM 通信线路数据错误3 D708,Immobilizer:No ECM Request,钥匙防盗系统:无ECM 请求D901,Immobilizer:Immobilizer Power Short to Ground,钥匙防盗系统:钥匙防盗系统电源与搭铁电路短路D902,Immobilizer:Immobilizer Power Short to Battery,钥匙防盗系统:钥匙防盗系统电源与蓄电池短路D904,Immobilizer:Immobilizer Output Signal Open/Short(Ground),钥匙防盗系统:钥匙防盗系统输出信号断路/短路(搭铁)D908,Immobilizer:Immobilizer Output Signal Short to Battery.,钥匙防盗系统:钥匙防盗系统输出信号与蓄电池短路.D910,Immobilizer:Immobilizer Input Signal Open/Short(Ground),钥匙防盗系统:钥匙防盗系统输入信号断路/短路(搭铁)D920,Immobilizer:Immobilizer Input Signal Short to Battery.,钥匙防盗系统:钥匙防盗系统输入信号与蓄电池短路.D940,Immobilizer:Immobilizer Antenna Coil Malfunction,钥匙防盗系统:钥匙防盗系统天线线圈故障P32,Ignition Output(Battery Short),点火开关输出(蓄电池短路)P32-1,Ignition Output(OC/SC Ground),点火开关输出(OC/SC搭铁)P33,Idle Speed Control Adaption,怠速控制适应P34,Idle Speed Control Actuator Short to Battery,怠速控制执行器与蓄电池短路P34-1,Idle Speed Control Actuator Open / Short to Ground,怠速控制执行器断路/ 与搭铁电路短路P46,A/C Relay Short to Battery,空调继电器与蓄电池短路P46-1,A/C Relay Open or Short to Ground,空调继电器电路与搭铁电路断路或短路P67,Cooling Fan Relay Short to Battery,冷却风扇继电器与蓄电池短路P67-1,Cooling Fan Relay Open or Short to Ground,冷却风扇继电器断路或与搭铁短路P86,No Answer From VIM (Line Open),VIM无应答(电路断路)P86-1,VIM Error Answer (Mismatching),VIM故障应答(不匹配)PXX,Potentionmeter,电位计PXX-1,A/F Ratio Correction,A/F 比(空燃比)校正PXX-2,Engine Coolant Temperature Signal Circuit Short to Battery,发动机冷却水温信号电路与蓄电池短路PXX-3,Engine Coolant Temperature Signal Circuit Open/Short to Ground,发动机冷却水温信号电路断路/与搭铁电路短路E5,CAS Reference Mark,CAS 参考标记M33,ISC Valve,ISC 阀MXX,Engine Coolant Temperature Signal(A/T),发动机冷却水温度信号(A/T)XX,Timing Overflow,正时过大XX-1,Illegal Interrupt,非法中断XX-10,Accelerometer Bias,加速表偏离XX-11,Accelerometer Continuity,加速表连续XX-2,Watchdog Failure,监测器故障XX-3,A/D Error,A/D 故障XX-4,Parameter Xsum Fail,参数Xsum 错误XX-5,Threshold Xsum Fail,界限Xsum 故障XX-6,Threshold Load Fail,界限负荷故障XX-7,Accelerometer 1st St.,加速表1st St.XX-8,Accelerometer Rail,加速杆XX-9,Accelerometer Temp,加速表温度00,Crash Data Stored,碰撞数据储存00-1,Crash Data Stored(Int),碰撞数据储存(Int)00-2,Crash Data Stored H,碰撞数据储存H00-3,Crash Occurred,碰撞产生0001,Power Seat ECU Malfunction,电动座椅ECU 故障0002,Power Seat Slide Motor Malfunction,电动座椅滑动电机故障0003,Power Seat Front Height Motor-Malfunction,电动座椅前高度电机-故障0004,Power Seat Right Rear Height Motor-Malfunction,电动座椅右后高度电机-故障0005,Power Seat Recline Motor-Malfunction,电动座椅倾斜电机-故障0006,Power Tilt ECU-Malfunction,动力倾斜ECU-故障0007,Steering Tilt Motor-Malfunction,转向倾斜电机-故障0008,Steering Tilt Position Sensor,转向倾斜位置传感器001-1,TCCU Module,TCCU 块0010,Steering Telescopic Motor-Malfunction,转向伸缩式电机-故障0011,Telescopic Sensor-Malfunction,伸缩传感器-故障0011-1,Hard/Soft Valve,硬/软阀0012,Keyless Entry Communication Malfunction,遥控器通信故障0013,Multifunction ECU Malfunction,多功能ECU 故障0014,ETACS-ECU Malfunction,ETACS-ECU 故障0015,Instrument Panel-ECU Malfunction,仪表板-ECU 故障0016,Drive Door Module(LH) Malfunction,驾驶席车门模块(LH)故障0017,Room Mirror Motor-Malfunction,室内后视镜电机-故障0018,Room Mirror Sensor-Malfunction,室内后视镜传感器-故障0019,Crash Sensor Malfunction,碰撞传感器故障01,Engine Speed(Np) Sensor,发动机速度(Np)传感器01-08,Driver Airbag Resistance Circuit Short to Ground (1st stage) H,驾驶席安全气囊电阻电路与搭铁电路短路(1级) H01-1,Untaught Transponder,未登录发射器01-11,Accelerometer Error,加速表故障01-2,Ignition System,点火系统01-3,Transponder Communication Error,发射器通信故障01-4,ADU Fault,ADU 故障01-6,ADU Fault H,ADU 故障H01-7,Driver Airbag Resistance Circuit Short to Ground (1st stage),驾驶席安全气囊电阻电路与搭铁电路短路(1级)01-8,Actuator System,执行器系统010-1,Shift Motor,换档电机011-1,Magnetic S/Clutch,电磁S/离合器02,Isolation Solenoid Circuit Open,隔离电磁阀电路断路02-1,ECM Communication Link Malfunction,ECM 通信连接故障02-10,Driver Airbag Resistance Circuit Short to Battery (1st stage) H,驾驶席安全气囊电阻电路与蓄电池短路(1级) H02-11,CPU Error,CPU 故障02-12,FCVC Request Signal Error,FCVC 请求信号故障02-2,Crankshaft Position Sensor A Circuit,曲轴位置传感器A 电路02-4,Distributor Ne Signal,分电器Ne 信号02-5,Engine Speed Signal,发动机速度信号02-6,Engine Speed(TDC) Sensor,发动机速度(TDC)传感器02-7,Engine Speed Signal,发动机速度信号02-9,Driver Airbag Resistance Circuit Short to Battery (1st stage),驾驶席安全气囊电阻电路与蓄电池短路(1级) 0215,1st Cylinder Detect Sensor,1st 气缸检测传感器0216,Idle-Up Solenoid 1,快怠速电磁阀10217,Second Lock Solenoid Malfunction,二次锁止电磁阀故障03,Dump Solenoid Circuit Open,清除电磁阀电路断路03-1,Distributor G1 Signal,分电器G1 信号03-2,ECM Communication Error,ECM 通信故障03-3,ETACS RF Communication Error,ETACS RF 通信故障03-4,Fuel Pump Relay,燃油泵继电器03-5,Driver Airbag Circuit open,驾驶席安全气囊电路断路03-6,Camshaft Position Sensor,凸轮轴位置传感器04,Solenoid Valve Switch Close,电磁阀开关关闭04-1,Distributor G2 Signal,分电器G2 信号04-2,ETACS C/S Communication Error,ETACS C/S 通信故障04-3,Immobilizer Antenna-Open,钥匙防盗系统天线-断路04-4,Idle Speed Control Actuator (Opening Coil),怠速控制执行器(打开线圈)04-5,Driver Airbag Circuit short,驾驶席安全气囊电路短路04-6,IP0: Ground Leakage,IP0: 搭铁电压泄漏04-7,Driver Squib Open,0416,Idle-Up Solenoid 2,快怠速电磁阀20417,Liquid/Vapor Relay Malfunction,液气态继电器故障05,Driver Squib Short,05-1,IP0: V Battery Leakage,IP0: 电源电压泄漏05-2,Knock Sensor/Control Unit,爆震传感器/控制模块05-3,BCM Internal Fault or EEPROM,BCM 间歇故障或EEPROM05-7,Low Side Driver Error,低侧驾驶席故障0552,Power Steering Switch-Low Input,动力转向开关-低电压输入06,Rear Wheel Speed Sensor. Signal Sudden Change,后轮速传感器信号突变06-1,ECM Request Signal Error,ECM 请求信号故障06-2,EMS not Detected,EMS 未检测到06-7,Driver Airbag Circuit,驾驶席安全气囊电路07,Isolation Solenoid Circuit Short,隔离电磁阀电路短路07-1,Passenger Airbag Circuit Open,助手席安全气囊电路断路07-4,VIN Error,VIN 错误07-5,Passenger Airbag Circuit,助手席安全气囊电路0704,BCM :Brake Lamp Malfunction,BCM :倒车灯故障0704-1,Brake Lamp Malfunction,制动灯故障0708,BCM :Brake Fuse Open,BCM :制动器保险丝断路0708-1,Brake Fuse Open,制动保险丝断路0710,BCM irection Lamp Malfunction,BCM :转向灯故障0742-b,Torque Converter Clutch System B,液力变矩器离合器系统B0763,Shift Solenoid #3 Electrical,电子式换档电磁阀#308,Passenger Squib Open,08-1,Dump Solenoid Circuit Short,清除电磁阀电路短路08-2,Passenger Airbag Circuit Short,助手席安全气囊电路短路0816,Idle-Up Solenoid 3,快怠速电磁阀309,Speed Sensor Circuit Open,速度传感器电路断路09-1,Water Temperature Sensor,水温度传感器09-2,Passenger Squib Short,09-3,Low Pressure Switch-Short Circuit,低压开关-电路短路09-4,Low Pressure Switch-Short Circuit H,低压开关-电路短路H0901,BCM :Rain Sensor Malfunction 1,BCM :雨量传感器故障10902,BCM :Rain Sensor Malfunction 2,BCM :雨量传感器故障20904,BCM :Rain Sensor Malfunction 3,BCM :雨量传感器故障30908,BCM :Wiper Stop Circuit Short to Battery,BCM :雨刮器停止电路与蓄电池短路0910,BCM :Wiper Stop Circuit Short to Ground,BCM :雨刮器停止电路与搭铁电路短路0A,Low Pressure Switch-Open Circuit,低压开关-电路断路0A-1,Low Pressure Switch-Open Circuit H,低压开关-电路断路H0B,Power Supply Ignition,电源点火开关0B-1,Firing Circuit Short to Ground,点火电路与搭铁电路短路0B-2,Firing Circuit Short to Ground H,点火电路与搭铁电路短路H0B01,BCM :CAN Error,BCM :CAN故障0B02,BCM :CAN Bus Off,BCM :CAN Bus Off0B04,BCM ow Voltage/Lin Communication Line(Rx),BCM :低压/Lin通信线(Rx)0B08,BCM ow Voltage/Lin Communication Line(Tx),BCM :低压/Lin通信线(Tx)0B10,BCM :CAN Timeout between BCM & DDM,BCM :BCM & DDM之间CAN 超时0B20,BCM :CAN Timeout between BCM & ADM,BCM :BCM & ADM之间CAN 超时0B40,BCM :CAN Timeout between BCM & PIC,BCM :BCM & PIC之间CAN 超时0B80,BCM :CAN Timeout between BCM & Seat,BCM : BCM & 座椅之间CAN 超时0C,Firing Circuit Malfunction,点火电路故障0C-1,Firing Circuit Malfunction H,点火电路故障H0D,SRS Service Reminder Indicator,SRS 维修提示器指示灯0D-1,SRS Service Reminder Indicator H,SRS 维修提示器指示灯H0E-1,ECU Error H,ECU 故障H0E-3,SRS Control Module H,SRS 控制模块H0F,Engine Malfunction Indication Lamp,发动机故障警告灯1,Left Front Sensor Error,左前传感器故障1-1,Main eft Front PSW Lin Error,主:左前PSW Lin 故障1-2,Main:Right Front WDW Lin Error,主:右前WDW电路故障1-3,Seat Slide Motor or Sensor Error,座椅滑动电机或传感器故障1-4,Tilt Motor or Sensor Error,倾斜电机或传感器故障10,Air Temp Sensor,空气温度传感器10-1,Left Front:SPW Motor Hall Sensor 1 Error,左前:SPW 电机霍尔传感器 1 故障10-11,MFI Control Relay,MFI 控制继电器10-2,Right Front:SPW Motor Hall Sensor 2 Error,右前:SPW 电机霍尔传感器2 故障10-3,Low Ignition Power Supply,点火开关电源电压低10-4,Low Ignition Power Supply(Int),点火开关电源电压低(Int)10-5,Speed Sensor Circuit Short/Malfunction,速度传感器电路短路/故障10-6,Injector #2,喷油嘴#210-7,SRSCM Parameter,SRSCM 参数10-8,SRSCM Parameter H,SRSCM 参数H100,Pretensioner Front-Driver Resistance Circuit Open,拉紧器前-驾驶席电阻电路断路100-1,Speed Sensor,速度传感器1001,Control Module or Checksum,控制模块或检测sum1001-2,Control Module or Checksum A,控制模块或检测sum A1002,No Start ,No Flame-Up A,不起动，不点火-Up A1002-1,No Start ,No Flame-Up,不起动，不点火-Up1002-2,No Start, No Flame-Up Even after Restart,不起动，不点火-重新启动后上升平稳1003,Flame-Out During Operation with No Further Flame-Up A,工作中燃烧停止A1003-1,Flame-Out During Operation with No Further Flame-Up,工作中燃烧停止1006,Flame Prior to Combustion Operation A,燃烧工作前点火A1006-1,Flame Prior to Combustion Operation,燃烧工作前点火101,Pretensioner Front-Driver Resistance Circuit Short,拉紧器前-驾驶席电阻电路短路101-1,Hub Solenoid Valve,轮毂电磁阀1013,3 Times Flame-Out During Heating Cycle A,加热周期A期间3次燃烧停止1013-1,3 Times Flame-Out During Heating Cycle,加热周期内3次燃烧停止1016,Ignition Signal Output,点火开关信号输出1017,A/C Cut Relay Malfunction,空调切断继电器故障102,Pretensioner Front-Driver Resistance Circuit Short to Battery,拉紧器前-驾驶席电阻电路与蓄电池短路103,Pretensioner Front-Driver Resistance Circuit Short to Ground,拉紧器前-驾驶席电阻电路与搭铁电路短路11,Left Front:SPW Motor Hall Sensor 2 Error,左前:SPW 电机霍尔传感器 2 故障11-11,Throttle Position Sensor-Short Circuit,节气门位置传感器-短路11-12,Right Front:SPW Normalization Error,右前:SPW 正常故障11-13,High Ignition Power Supply,点火开关电源供应信号过高11-14,High Ignition Power Supply(Int),点火开关电源供应信号过高(Int)11-16,Valve Relay Circuit Open,阀继电器电路断路11-17,Injector #1,喷油嘴#111-18,Airbag Unit Specification Mismatch,安全气囊模块参数不相匹配11-19,Power Supply Ignition H,电源点火开关H11-2,FIS(Front Impact Sensor)-Short,FIS(前碰撞传感器)-短路11-20,Clutch Coil,离合器线圈11-3,Accelerator Pedal Position Sensor Malfunction,加速踏板位置传感器故障11-4,TCS Control Module,TCS 控制模块11-6,Transaxle Control Module-Failsafe,变速器控制模块-失效保护11-7,Room Temperature Sensor-Open,室内温度传感器-断路11-8,G-Sensor,G-传感器11-9,Oxygen Sensor,氧传感器110,Selector Switch,换档开关12,Right Front:SPW Unit Error,右前:SPW 模块故障12-1,Accel Sensor,加速传感器12-13,Accessory Power Supply Fault,附加电源故障12-14,Accessory Power Supply Fault(Intermittent),附加电源故障(间歇故障)12-15,Insufficient Brake Fluid/Brake Pressure Low,制动液不足/制动压力低12-16,Valve Relay Circuit Short,阀继电器电路短路12-17,Unit Connector Assembling Incomplete,模块连接器总成不完整12-18,Left Front:SPW Normalization Error,左前:SPW 正常故障12-19,ABS Modulator,ABS 调制器12-2,SCSV-A,SCSV-A12-21,TCM-First Gear Command Fail,TCM-1档控制故障12-23,Firing Circuit Short to Battery,点火电路与蓄电池短路12-24,Manifold Absolute Pressure/Barometric Pressure Circuit,进气歧管绝对压力/大气压压力电路12-26,Volume Air Flow Sensor,空气流量传感器12-3,Room Temperature Sensor-Short,室内温度传感器-短路12-4,Knee Squib Open,12-5,Alternator L-Terminal,交流发电机L- 端子12-6,LH or RH Impact Sensor-Open,左/右碰撞传感器-断路12-7,Manifold Absolute Pressure Sensor,进气歧管绝对压力传感器1245,Air Mix Feedback Open(Low)-Driver,温度门反馈电路断路(低压)-驾驶席1250-3,Direction Mode Feedback Short (High)-Driver,方向模式反馈电路短路(高压)-驾驶席老车故障码13,Left Front:SPW Unit Error,左前:SPW 模块故障13-1,Pulse Generator B-Failsafe,脉冲发生器B-失效保护13-10,Low Pressure Switch,低压开关13-11,Right Front:Motor Hall Sensor Count Dir.Error,右前:电机霍尔传感器反方向故障13-12,Control Module,控制模块13-13,Motor Relay Circuit Open,电机继电器电路断路13-14,Power Supply(ACC),电源(ACC)13-16,Excessive Decay,腐蚀严重13-17,Low Speed Limit,低速限制13-2,SCSV-B,SCSV-B13-21,Intake Air Temperature Sensor,进气温度传感器13-3,Throttle Position Sensor-Malfunction,节气门位置传感器-故障13-4,Engine Speed Signal,发动机速度信号13-5,EPS Solenoid Valve,EPS 电磁阀13-6,Knee Squib Short,13-8,LH and RH Impact Sensor-Open,左/右碰撞传感器-断路13-9,In-CAR Temperature Sensor Circuit Open,室内温度传感器电路断路14,Left Front:Motor Hall Sensor Counter Dir.Error,左前:电机霍尔传感器反方向异常14-10,Boost Pressure Sensor Circuit Malfunction,助力器传感器电路故障14-12,Redundant Brake,多余制动14-14,Right Front:Motor Thermal Protection Error,右前:电机热保护故障14-15,Motor Relay Circuit Short,电机继电器电路短路14-16,Ignition Low,点火开关电压低14-18,Throttle Position Sensor,节气门位置传感器14-2,SCSV-A(Failsafe),SCSV-A(失效保护)14-3,In-CAR Temperature Sensor Circuit Short,室内温度传感器电路短路14-5,Throttle Position Sensor-Abnormal Adjustment,节气门位置传感器-异常调整14-6,TCS On Switch,TCS On 开关14-7,Steering Angle Sensor,转向角传感器15,Left Front:Motor Thre.Protection Error,左前:电机热保护故障15-1,HO2S (Left),氧传感器(左)15-10,Control Switch,控制开关15-13,Capacitor Volt Low,电容器电压低15-2,SCSV-B(Failsafe),SCSV-B(失效保护)15-4,Traction Control Switch,牵引力控制开关15-6,Transmission Fluid Temperature Sensor Circuit Open,变速器液体温度传感器电路断路15-7,Right Front:Motor Holl Sensor Power Line Short,右前:电机霍尔传感器电源电路短路15-8,Wheel Speed Sensor,轮速传感器16,Left Front:Motor Hall Sensor Power Line Short,左前:电机霍尔传感器电源电路短路16-1,Transmission Fluid Temperature Sensor Circuit Short,变速器液体温度传感器电路短路16-12,Warning Lamp Short,警告灯短路16-3,PCSV(Failsafe),PCSV(失效保护)16-4,EGR Position Sensor,EGR 位置传感器16-5,Low Ignition Voltage,点火开关电压低16-6,Idle Speed Control Actuator (Closing Coil),怠速控制执行器(关闭线圈)16-7,Brake Switch Circuit,制动开关电路16-8,Power Supply System,电源系统16-9,Cancel Signal,取消信号1608,Dosing Pump Circuit Short to Ground A,定量泵电路与搭铁电路短路A1608-1,Dosing Pump Circuit Short to Ground,定量泵电路与搭铁电路短路1608-2,Dosing Pump: Short Circuit Against Ground,定量泵: 搭铁电路短路1609,Combustion Air Fan Circuit Short to Ground A,燃烧空气风扇电路与搭铁短路A1609-1,Combustion Air Fan Circuit Short to Ground,燃烧空气风扇电路与搭铁电路短路160A,Glow Plug Circuit Short to Ground A,预热塞电路与搭铁电路短路A160A-1,Glow Plug Circuit Short to Ground,预热塞电路与搭铁电路短路160B,Water Pump:Circuit Ground A,水泵:搭铁电路A160B-1,Water Pump:Circuit Ground,水泵:搭铁电路160B-2,Water Pump: Short Circuit Against Ground,水泵:搭铁电路短路160C,Vehicle Air Fan:Circuit Ground A,车辆空气风扇:搭铁电路A160C-1,Vehicle Air Fan:Circuit Ground,车辆空气风扇:搭铁电路160C-2,Vehicle Air Fan: Short Circuit Against Ground,车辆空气风扇: 搭铁电路短路17,Right Front:SPW Input Voltage Low,右前:SPW 输入电压低17-1,Feedback System,反馈系统17-2,Feedback System(Left),反馈系统(左)17-5,High Ignition Voltage,点火开关电压过高17-6,TCS Switch,TCS 开关1772,Selection Position,换档位置1780,Push-Pull Sensor,推-拉传感器18,Left Front:SPW Input Voltage Low,左前:SPW 输入电压低18-1,Feedback Solenoid Valve,反馈电磁阀18-2,Heater Relay2,加热器继电器218-3,Right Front:SPW Input Voltage High,右前:SPW 输入电压高18-4,Brake Switch Circuit,制动开关电路18-5,Injector #1,#3,喷油嘴#1,#318-6,Main Duty Solenoid Valve,主占空比电磁阀18-7,Feedback Solenoid Circuit Short to Battery,反馈电磁阀电路与蓄电池短路18-8,Feedback Solenoid Circuit Open/Short to Ground,反馈电磁阀电路断路/与搭铁短路18-9,Ignition High,点火开关电压高1818,Dosing Pump Circuit Open A,定量泵电路断路A1818-1,Dosing Pump Circuit Open,定量泵电路断路1818-2,Dosing Pump Circuit Open or Short to Battery,定量泵电路断路或与蓄电池短路1819,Combustion Air Fan Circuit Open or Short to Battery A,燃烧空气风扇电路断路或与蓄电池短路A 1819-1,Combustion Air Fan Circuit Open or Short to Battery,燃烧空气风扇电路断路或与蓄电池短路181A,Glow Plug Circuit Open A,预热塞电路断路A181A-1,Combustion Air Fan Circuit Open,燃烧空气风扇电路断路181A-2,Glow Plug Circuit Open,预热塞电路断路181B,Water Pump:Open Circuit A,水泵:电路断路A181B-1,Water Pump:Open Circuit,水泵:电路断路19,Left Front:SPW Input Voltage High,左前:SPW 输入电压高19-1,Defective Tone Wheel,有缺陷的信号轮19-2,Right Front:SPW Low Speed Error,右前:SPW 低速故障19-3,Reuse Error,再利用故障19-4,Injector #2,#4,喷油嘴#2,#41A05,Undervoltage A,过低电压A1A05-1,Undervoltage,过低电压1C04,Overvoltage A,电压过高A1C04-1,Overvoltage,电压过高1C07,Overheating<Water Temp.>125@C A,过热<水温>125@C A1C07-1,Overheating(Water Temp.>125℃),过热(水温>125℃)2,Right Front Sensor Error,右前传感器故障2-1,Main eft Rear PSW Lin Error,主:左后PSW 电路故障2-2,Main:Right Rear WDW Lin Error,主:右后WDW电路故障2-3,Seat Recline Motor or Sensor Error,座椅倾斜电机或传感器故障2-4,Telescope Motor or Sensor Error,伸缩电机或传感器故障20,Ignition Switch 2,点火开关220-1,Left Front:SPW Motor Low Speed Error,左前:SPW 电机低速故障20-2,Right Rear:SPW Motor Hall Sensor 1 Error,右后:SPW 电机霍尔传感器 1 故障20-3,Start Solenoid Valve,起动电磁阀20-4,Start Solenoid (Open/Short to Ground),起动电磁阀(断路/与搭铁电路短路)20-5,Radiator Cooling Fan,散热器风扇20-7,EEPROM Error,EEPROM 故障200,PAB Seat Belt Pretensioner Open,PAB 座椅安全带拉紧器断路2001,Control Module or Checksum H,控制模块或检测sum H2001-2,Control Module or Checksum F,控制模块或检测sum F2002,No Start ,No Flame-Up F,不起动，不点火e-Up F2002-1,No Start ,No Flame-Up H,不起动，不点火-Up H2002-2,No Start, No Flame-Up Even after Restart H,不起动，不点火-重新启动后上升平稳 H 2003,Flame-Out During Operation with No Further Flame-Up F,工作中燃烧停止F2003-1,Flame-Out During Operation H,工作中燃烧停止H2003-2,Flame-Out During Operation with No Further Flame-Up H,工作中燃烧停止H2006,Flame Prior to Combustion Operation F,燃烧工作前点火F2006-1,Flame Prior to Combustion Operation H,燃烧工作前点火H2006-2,Flame Prior to Combustion Operation H,燃烧工作前点火H201,PAB Seat Belt P/T Short,PAB 座椅安全带P/T 短路2013,3 Times Flame-Out During Heating Cycle F,加热周期F期间3次燃烧停止2013-1,3 Times Flame-Out During Heating Cycle H,加热周期F期间3次燃烧停止2015,Engine Load(MAP Sensor),发动机负荷(MAP 传感器)2016,Fuel Cut Solenoid,燃油切断电磁阀2017,Second Air Solenoid,二次进气电磁阀202,PAB Seat Belt Pretensioner Short to Battery,PAB 座椅安全带拉紧器与蓄电池短路203,PAB Seat Belt Pretensioner Short to Ground,PAB 座椅安全带拉紧器与搭铁电路短路21,Left Front Solenoid Circuit-Short to Battery,左前电磁阀电路-与蓄电池短路21-1,Main eft Rear PSW Lin Error,主:左后PSW 电路故障21-11,Right Rear:SPW Motor Hall Sensor 2 Error,右后:SPW 电机霍尔传感器 2 故障21-12,Open/Shorted Sensor-Left Front,左前传感器断路/短路21-13,Inlet Valve Right Front,右前输入阀21-14,Right Front Wheel Speed Sensor Continuity Fault,右前轮速传感器导通故障21-15,Input Voltage Low,输入电压低21-16,Set Switch On,设定开关On21-17,Left Rear:SPW Motor Hall Sensor 1 Error,左后:SPW 电机霍尔传感器1 故障21-18,Engine Coolant Temperature Sensor,发动机冷却水温度传感器21-19,21.Solenoid No.1 Open,21.电磁阀1号断路21-2,Throttle Position Sensor-Short Circuit,节气门位置传感器-短路电路21-20,LF Solenoid Circuit-Short to Battery,LF 电磁阀电路-与蓄电池短路21-21,Engine Coolant Temperature Circuit,发动机冷却水温度电路21-3,Evaporator Temperature Sensor Open(High),蒸发器温度传感器断路(高)21-4,Engine Coolant Temperature Circuit,发动机冷却水温度电路21-5,Solenoid No.1 Open,电磁阀1 断路21-6,Driver Airbag Short,驾驶席安全气囊电路短路21-8,Left Front Wheel Speed Sensor,左前轮速传感器21-9,Front Wheel Speed Sensor,前轮速传感器22,Left Rear:SPW Motor Hall Sensor 2 Error,左后:SPW 电机霍尔传感器 2 故障22-1,Throttle Position Sensor-Open Circuit,节气门位置传感器-电路断路22-10,Anti-Lock Brake System-Fail,防抱死制动系统-故障22-11,Right Front Wheel Speed Sensor,右前轮速传感器22-12,Left Front Solenoid Circuit-Short to Ground,左前电磁阀电路-与搭铁电路短路22-13,Right Rear:SPW Normalization Error,右后:SPW 正常故障22-14,Outlet Valve -Right Front,输出阀-右前22-15,Injector #4,喷油嘴#422-16,Right Front Wheel Speed Sensor Fault,右前轮速传感器故障22-17,Input Voltage High,输入电压高22-18,Slow Cut Solenoid Valve,切断电磁阀慢22-19,Fuel-Cut Valve(Open/Short to Ground),燃油-切断阀(断路/与搭铁电路短路)22-2,Evaporator Temperature Sensor Short(Low),蒸发器温度传感器短路(低)22-21,ABS Warning Lamp,ABS 警告灯22-212,22.Solenoid No.1 Short,22.电磁阀1号短路22-22,Resume Switch On,恢复开关On22-23,Passenger Configuration Fault,助手席配置故障22-24,LF Solenoid Circuit-Short to Ground,LF 电磁阀电路-与搭铁电路短路22-25,Left Front Height Sensor,左前高度调节传感器22-3,Front Height Sensor,前高度调节传感器22-5,Crankshaft Position Sensor,曲轴位置传感器22-7,Driver Airbag Open,驾驶席安全气囊电路断路22-8,Fuel-Cut Solenoid Valve,燃油-切断电磁阀22-9,Solenoid No.1 Short,电磁阀1 短路22-a,Idle Adaption,怠速适应23,Left Rear:SPW Normalization Error,左后:SPW 正常故障23-,RF Solenoid Circuit-Short Battery,RF 电磁阀电路-与蓄电池短路23-1,Solenoid No.2 Open,电磁阀2 断路23-10,Right Front Solenoid Circuit-Short Battery,右前电磁阀电路-与蓄电池短路23-11,Right Rear:SPW Unit Error,右后:SPW 模块故障23-12,Open/Shorted Sensor-Right Front,右前传感器断路/短路23-13,Inlet Valve Left Front,左前输入阀23-14,Injector #3,喷油嘴#323-17,Idle-Up Solenoid Valve,快怠速电磁阀23-18,ABS Warning Lamp Relay,ABS警告灯继电器23-19,Cancel Switch On,取消开关On23-20,Checksum Error,检测sum故障23-21,23.Solenoid No.2 Open,23.电磁阀2号断路23-22,Idle-Up Solenoid Valve,快怠速电磁阀23-23,Right Front Height Sensor,右前高度传感器23-3,Left Rear Wheel Speed Sensor,左后轮速传感器23-4,Rear Height Sensor,后高度传感器23-9,HO2S (Right),氧传感器(右)24,Left Rear:SPW Unit Error,左后:SPW 模块故障24-1,Right Rear Wheel Speed Sensor,右后轮速传感器24-10,Open/Shorted Sensor-Left Rear,左后传感器断路/短路24-11,Outlet Valve -Left Front,输出阀-左前24-13,ABS Power Relay,ABS电源继电器24-14,40km/h Over,高于40km/h24-15,Open/Shorted Sensor(Rear),传感器断路/短路(后)24-16,Parameter Table Error,参数表错误24-17,TPS Idle Switch Short Of Bad Adjustment,不良调整引起的TPS怠速开关短路24-18,24.Solenoid No.2 Short,24.电磁阀2号短路24-19,RF Solenoid Circuit-Short Ground,RF 电磁阀电路-与搭铁电路短路24-20,Second Air Solenoid Valve,二次进气电磁阀24-4,Feedback System(Right),反馈系统(右)24-6,Solenoid No.2 Short,电磁阀2 短路24-7,Right Front Solenoid Circuit-Short Ground,右前电磁阀电路-与搭铁电路短路24-8,Right Rear:Motor Hall Sensor Conut Dir.Error,右后:电机霍尔传感器反方向故障24-9,Open/Shorted Sensor-Right Rear,右后传感器断路/短路25,Left Rear:Motor Hall Sensor Counter Direction Error,左后:电机霍尔传感器计数器方向故障25-1,Kickdown Servo Switch-Open Circuit,强制将档伺服开关-电路断路25-10,Inlet Valve Right Rear,右后输入阀25-12,Q Adjusting Resister,Q 调节电阻器25-13,Left Front Wheel Speed Sensor Continuity Fault,左前轮速传感器导通故障25-15,40km/h Lower,低于40km/h25-16,Closed Throttle Position Switch-Short Circuit,关闭节气门位置开关-电路短路25-17,25.Solenoid No.3 Open,25.电磁阀3号断路25-18,Left Rear Solenoid Circuit-Short to Battery,左后电磁阀电路-与蓄电池短路25-19,Rear Wheel Sensor-Temporarily,后轮速传感器-暂时性25-2,Rear Wheel Sensor-Temporarily,后轮速传感器-暂时性25-3,Fuel Pressure Solenoid Valve,燃油压力电磁阀25-4,Solenoid No.3 Open,电磁阀3 断路25-6,Rear Pressure Sensor,后压力传感器25-7,Barometric Pressure Sensor Circuit,大气压力传感器电路25-8,Left Rear Solenoid Circuit-Short to Battery,左后电磁阀电路-与蓄电池短路25-9,Right Rear:Motor Thermal Protection Error,右后:电机热保护故障26,Left Rear:Motor Thermal Protection Error,左后:电机热保护故障26-1,Solenoid No.3 Short,电磁阀3 短路26-10,Outlet Valve -Right Rear,输出阀-右后26-11,Left Front Wheel Speed Sensor Fault,左前轮速传感器故障26-12,Wheel Speed Sensor Output Signal,轮速传感器输出信号26-13,26.Solenoid No.3 Short,26.电磁阀3号短路26-14,Left Rear Solenoid Circuit-Short to Ground,左后电磁阀电路-与搭铁电路短路26-2,Kickdown Servo Switch-Short Circuit,强制将档伺服开关-电路短路26-3,Purge Control Solenoid Valve,净化控制电磁阀26-6,Rear Wheel Sensor-Permanently,后轮速传感器-永久性26-7,Left Rear Solenoid Circuit-Short to Ground,左后电磁阀电路-与搭铁电路短路26-8,Right Rear:Motor Holl Sensor Power Line Short,右后:电机霍尔传感器电源电路短路26-9,Missing Sensor-Left Front,缺少传感器-左前老车故障码2608,Dosing Pump Circuit Short to Ground F,定量泵电路与搭铁电路短路 F 2608-1,Dosing Pump Circuit Short to Ground H,定量泵电路与搭铁电路短路H2608-2,Dosing Pump: Short Circuit Against Ground H,定量泵: 搭铁电路短路H2609,Combustion Air Fan Circuit Short to Ground F,燃烧空气风扇电路与搭铁电路短路F 2609-1,Combustion Air Fan Circuit Short to Ground H,燃烧空气风扇电路与搭铁电路短路H 260A,Glow Plug Circuit Short to Ground F,预热塞电路与搭铁电路短路F260A-1,Glow Plug Circuit Short to Ground H,预热塞电路与搭铁电路短路H260B,Water Pump:Circuit Ground F,水泵:搭铁电路F260B-1,Water Pump:Circuit Ground H,水泵:搭铁电路H260B-2,Water Pump: Short Circuit Against Ground H,水泵: 搭铁电路短路H260C,Vehicle Air Fan:Circuit Ground F,车辆空气风扇:搭铁电路F260C-1,Vehicle Air Fan:Circuit Ground H,车辆空气风扇:搭铁电路H260C-2,Vehicle Air Fan: Short Circuit Against Ground H,车辆空气风扇: 搭铁电路短路H 27,Left Rear:Motor Hall Sensor Power Line Short,左后:电机霍尔传感器电源电路短路27-1,Ignition Pulse Line-Open Circuit,点火开关脉冲电路-断路27-2,Belt Pretensioner Front-Passenger Open,安全带预紧器前-助手席断路27-3,Right Rear Solenoid Circuit-Short Battery,右后电磁阀电路-与蓄电池短路27-4,Missing Sensor-Right Front,缺少传感器-右前27-5,Inlet Valve Left Rear,左后输入阀27-6,Right Rear:Spw Input Voltage Very Low,右后:Spw 输入电压过低28,Right Rear Solenoid Circuit-Short Ground,右后电磁阀电路-与搭铁电路短路28-1,Accelerator Switch-Short Circuit,加速踏板开关-电路短路28-10,EGR Valve(Short to Battery),EGR 阀(与蓄电池短路)28-11,EGR Valve(Open/Short to Ground),EGR 阀(断路/与搭铁短路)28-12,Left Rear:Spw Input Voltage Very Low,左后:Spw 输入电压非常低28-2,Belt Pretensioner Front-Driver Open,安全带预紧器前-驾驶席断路28-3,EGR Unit(Vacuum Side),EGR 模块(真空侧)28-4,EGR Unit,EGR 模块28-5,Right Rear:SPW Input Voltage Low,右后:SPW输入电压低28-6,Missing Sensor(Rear),缺少传感器(后)28-7,Missing Sensor-Left Rear,缺少传感器-左后28-8,Outlet Valve -Left Rear,输出阀-左后28-9,A/C Compressor,空调压缩机2818,Dosing Pump Circuit Open F,定量泵电路断路F2818-1,Dosing Pump Circuit Open H,定量泵电路断路H2818-2,Dosing Pump Circuit Open or Short to Battery H,定量泵电路断路或与蓄电池短路H2819,Combustion Air Fan Circuit Open or Short to Battery F,燃烧空气风扇电路断路或与蓄电池短路F 2819-1,Combustion Air Fan Circuit Open or Short to Battery H,燃烧空气风扇电路断路或与蓄电池短路H 281A,Glow Plug Circuit Open F,预热塞电路断路F281A-1,Combustion Air Fan Circuit Open H,燃烧空气风扇电路断路H281A-2,Glow Plug Circuit Open H,预热塞电路断路H281B,Water Pump:Open Circuit F,水泵:电路断路F281B-1,Water Pump:Open Circuit H,水泵:电路断路H281B-2,Water Pump: Open Circuit H,水泵: 电路断路H29,Left Rear:SPW Input Voltage Low,左后:SPW 输入电压低29-1,EGR Unit(Barometric Side),EGR 模块(气压侧)29-3,Flash Code,闪光器代码29-4,Right Rear:SPW Input Voltage High,右后:SPW 输入电压高29-5,Driver Configuration Fault,驾驶席配置故障29-6,Diag Init Short to Ground,诊断电路与搭铁电路短路29-7,Missing Sensor-Right Rear,缺少传感器-右后2A05,Undervoltage F,过低电压F2A05-1,Undervoltage H,过低电压H2C04,Overvoltage F,电压过高F2C04-1,Overvoltage H,电压过高H2C07,Overheating<Water Temp.>125@C F,过热<水温>125@C F2C07-1,Overheating(Water Temp.>125℃) H,过热(水温>125℃) H2C07-2,Overheating (Water Temperature > 125 °C) H,过热(水温> 125 °C) H3,Trunk Open Error,行李箱打开错误3-1,Main:Switch Module Lin Error,主:开关模块电路故障3-2,Main:RH Outside Mirror Horizontal Motor/Sensor Error,主:RH 左室外后视镜或水平电机/传感器故障3-4,Right Front Motor/Sensor Error,右前电机/传感器故障30-1,Left Rear:SPW Input Voltage High,左后:SPW 输入电压高30-2,Main:Right Outside Mirror Horizontal Motor/Sensor Error,主:右室外后视镜或水平电机/传感器故障30-4,Passenger Configuration Fault,助手席配置故障31,Left Rear:SPW Motor Low Speed Error,左后:SPW 电机低速故障31-10,Wheel Speed Sensor Right Front,右前轮速传感器31-11,Feedback System(Injection),反馈系统(喷射)31-12,Ignition Switch Signal,点火开关信号31-13,ACU Fault,ACU 故障31-14,31.Vehicle Speed Sensor,31.车速传感器31-15,Exhaust Valve,排气阀31-3,Steering Angle Sensor-Open,转向角传感器-断路31-4,Transaxle Control Module,变速器控制模块31-5,Knock Sensor,爆震传感器31-6,Air Mixture Damper Position,温度门减震器位置31-7,Pulse Generator A-Open Circuit,脉冲发生器A-电路断路31-8,LF Wheel Speed Sensor-Air Gap,LF 轮速传感器-气隙31-9,Simultaneous Dropout/Right Front,同时丢码/右前31-A,Maximum RPM Surpassed,超过最大RPM32,RF Wheel Speed Sensor-Air Gap,RF 轮速传感器-气隙32-1,Steering Angle Sensor-Short,转向角传感器-短路32-10,Right Rear Wheel Speed Sensor Fault,右后轮速传感器故障32-11,Timing Overflow,正时过大32-2,2nd Air Solenoid Valve,二次空气电磁阀32-3,Pulse Generator B-Open Circuit,脉冲发生器B-电路断路32-4,TCM-First Gear Command,TCM-1档控制32-5,Damper Position Mode,减震器位置模式32-6,Erratic Sensor(LF),不稳定传感器(LF)32-7,Wheel Speed Sensor Left Front,左前轮速传感器32-8,TPS Sensor,TPS 传感器32-9,Right Rear Wheel Speed Sensor Continuity Fault,右后轮速传感器导通故障33,Steering Wheel Neutral Detect Sensor,方向盘空档检测传感器33-1,Cranking Signal Circuit-Short,曲轴信号电路-电路33-2,Steering Angle Sensor-Fail,转向角传感器-故障33-3,Throttle Position Valve,节气门位置阀33-4,Left Rear Wheel Speed Sensor-Air Gap,左后轮速传感器-气隙33-6,Feedback System(Injection Timing),反馈系统(喷射时间)33-8,Power Supply Low,电源电路与搭铁电路短路34,Right Rear Wheel Speed Sensor-Air Gap,右后轮速传感器-气隙34-1,Shift Switches,换档开关34-10,Power Supply High,电源电压高34-11,Watchdog Fault,监测器故障34-12,34.Shift Switches,34.换档开关34-2,Idle Speed Control Valve,怠速控制阀34-3,Steering Angle Sensor-Power,转向角传感器-电源34-4,Connector Shorting Bar-Fail,连接器短路片-故障34-5,Erratic Sensor(RF),不稳定传感器(RF)34-6,Engine Load Solenoid Valve,发动机负荷电磁阀34-8,Idle-Up Solenoid Valve 1 (Short to Battery),快怠速电磁阀1 (与蓄电池短路)34-9,Idle-Up Solenoid Valve 1 (Open/Short to Battery),快怠速电磁阀1 (断路/与蓄电池短路) 34-A,Idle Control Valve,怠速控制阀35-1,Engine Speed Signal,发动机速度信号35-10,Idle-Up Solenoid Valve 2 (Short to Battery),快怠速电磁阀2 (与蓄电池短路)。

[其它]必佳乐故障0001 ********-BUTTON STAYS IN 按钮持续按下MCB板上的微处理器检测到按钮被持续按着。

START 启动按钮 STOP 停车按钮 FSB 启动按钮的第二副公共触点SMPF 慢动找纬按钮的第二副公共触点 SMF 慢动向前按钮 SMR 慢动向后按钮 PFR 找纬向后按钮 PFF: 找纬向前按钮原因可能是按钮故障按钮的接线有故障64和65 按钮连线有问题 MCB板故障。

0010 ********-BUTTON PRESSED TRY AGAIN 按钮按下SMPF运动之前 START 启动按钮 STOP 停车按钮 FSB 启动按钮的第二副公共触点SMPF 慢动找纬按钮的第二副公共触点 SMF 慢动向前按钮 SMR 慢动向后按钮 PFR 找纬向后按钮 PFF: 找纬向前按钮原因可能是按钮故障按钮的接线有问题64和65按钮上的连线有问题 MCB板故障。

0012 RELEASE BUTTONS 松开按钮。

发出一个机器运动的指令后这项运动的按钮仍然被按下0013 MOTION DISABLED BY COMPUTER 计算机控制使运动失效。

织机受到主计算机控制而不能运动。

0014 ASP/ASO ACTION ABORTED TRY AGAIN ASP/ASO行动终止当启动按钮被按下ASP/ASO运动到达一个特定的角度位置ASP/ASO运动继续ASP/ASO位置太远/或找纬运动 - 2 -2002年4月版 ASP/ASO运动将会被中断ASP/ASO运动可能通过启动按钮再次执行。

0015 SPEED MONITORING : START UP TIME OUT 速度监控开车按钮按下原因可能是轴编码器的错误安装主马达负载过重轴编码器已损坏轴编码器与MCB板的连线故障52号 MCB板已损坏 DDMP板已损坏 PB板已损坏主马达已损坏。

0016 START UP REVERSE ROTATION 机器起动后原因可能是轴编码器的错误安装主马达负载过重轴编码器已损坏轴编码器与MCB板的连线故障52号 MCB板已损坏 DDMP板已损坏 PB板已损坏主马达已损坏。

关于630E卡车后悬挂球头经常性断裂的故障分析作者：关松栗飞王科懿来源：《西部论丛》2017年第12期摘要：本论文主要叙述了630E卡车后悬挂球头经常性断裂的故障现象，然后我们从后悬挂的组成及其连接情况入手，对其进行分析、不断地总结，最终得出导致该故障发生的主要原因有悬挂基座不平整、球头处润滑不良、悬挂基座上端面的污物未及时清理、悬挂调整不当、球头杆与基座孔之间的间隙过大，在解决问题过程中，我们应对症下药、具体问题具体分析，最终将故障及时排除。

关键词：630E 球头断裂Abstract；This paper mainly describes the fault phenomenon of the regular breakage of the rear suspension ball head of the 630E truck. Then we start with the composition and connection of the rear suspension， analyze it and summarize it continuously， and finally find the main reason leading to the failure. There are unsuspended suspension bases， poor lubrication at the ball head， dirt on the upper end of the suspension base is not cleared in time， suspension adjustment is improper， and the gap between the ball head stem and the base hole is too large. In the course of solving the problem，we have Coping with the specific drug problem and specific analysis of the problem will eventually rule out the failure.Keywords：630E ，Ball head，Fracture前言630E卡車主要承担着露天煤矿运输黄土、岩石以及煤炭的工作任务，其后悬挂结构较为简单，主要由缸筒、杆筒、铜碗、锁圈以及球头组成，上述任意结构一旦出现问题，都将直接影响卡车的正常运行。