潍柴配件图册WP6.200E40

潍柴配件612600061403 水泵总成612600061498 水泵总成612600061405 8PK多楔带612600061501 风扇托架加黄油装置612600061406 压板612600061505 风扇612600061412 支架板612600061507 风扇托架总成612600061415 涨紧轮总成612600061509 风扇612600061426 水泵总成612600061510 张紧轮总成612600061428 风扇托架总成612600061513 风扇612600061433 风扇托架总成612600061514 风扇612600061438 风扇托架总成612600061515 双温控开关612600061440 8PK多楔带612600061517 风扇连接盘612600061445 8PK多楔带612600061520 水泵总成612600061450 中间法兰612600061521 皮带轮612600061453 多楔带612600061526 电控硅油离合器风扇总成612600061454 φ590环形风扇612600061530 张紧轮总成612600061460 惰轮支架612600061532 水泵总成612600061464 多楔带612600061560 多楔带612600061465 多楔带612600061563 三角皮带612600061466 水泵总成612600061566 风扇托架总成612600061467 中间法兰612600061569 风扇托架总成612600061470 皮带轮612600061574 水泵总成612600061476 水泵总成612600061575 惰轮支架612600061477 水泵总成612600061576 电磁风扇离合器612600061478 水泵总成612600061578 10PK多楔带612600061479 水泵总成612600061580 多楔带612600061480 风扇连接盘612600061581 水泵总成612600061482 皮带轮612600061586 电磁离合器用线束612600061489 三速电磁风扇离合器612600061588 护风带总成612600061491 电磁离合器用线束612600061603 水泵总成612600061493 双温控开关612600061611 水泵总成612600061494 风扇托架总成612600061652 双温控开关。

前言为使WP6NG-2系列天然气发动机在使用、维修等工作上的方便特编绘本图册，以供用户在使用中查阅参考。

图册基本上给出天然气发动机相关零部件的图形、相互关系；件号、数量Quan.、适用于发动机的型号、规格标准、中文名称、英文名称等列于明细表栏内。

随着技术和生产的不断发展，天然气发动机变型将增多，故本图册的内容将有所更新及变化，不再另行通知，特请用户注意。

2013.05FOREWORDThe illustrated parts manual is specially prepared for customers to facilitate the use of WP6NG-2 series natural gas engine in operation and maintenance.The parts list includes the pictures and correlations of parts of natural gas engine. Part No., quantity, model, DIN/FremdfabrNr.,Chinese designation, English designation and so forth are written in the detail list.With the development of technology and manufacture, the models of the natural gas engine will increase; therefore the manual will be revised in time. Please attention to our revised version.2013.05符号及说明1、本图册包括的4种机型为：WP6NG210E40, WP6NG240E40，WP6NG210E50, WP6NG240E502、DIN 德国标准3、NO5斯太尔企业标准Symbol and Indication 1、4 models are included in the illustrated parts manual as follows:WP6NG210E40, WP6NG240E40,WP6NG210E50, WP6NG240E502、DIN German Industry Standard3、NO5Steyr manufacturer standard目录Contents➢气缸盖部件Cylinder Head Subassembly1➢活塞连杆组件Piston and Rod Subassembly3➢混合器总成Mixer Subassembly 5➢低压滤清器与热交换器部件Low Pressure Fuel Filter And Heat Exchanger Subassembly6➢FMV与点火线圈部件FMV And Ignition Coil Subassembly8➢进气管部件Air Intake Pipe Subassembly10➢电磁阀部件Solenoid Valve Subassembly12➢稳压器部件Manostat Subassembly13➢高压滤清器部件High Pressure Fuel Filter Subassembly14➢减压器部件Regulator Subassembly15➢信号发生器总成Signal Generator Subassembly16➢燃气管Gas Pipe18➢增压器进、出水管Turbocharger Coolant Inlet And Outlet Pipe19➢废气控制阀及进、出气管Waste Gate Control Valve And Inlet And Outlet Pipe20➢指针Index21➢电器控制箱组件Electric Control Box Subassembly22➢传感器部件Sensor Subassembly23➢水管接头Water Pipe Tie-In24➢备件箱中燃气管Gas Pipe In Spare Parts Box25➢线束及接插件Harness And Connectors26➢电子脚踏板及接插件Foot Pedal And Connectors27➢催化转化器Catalyst28✧附表1：燃气管规格统计表Table 1: Gas pipe StatisticsⅠ✧附表2：ECU线束统计表Table 2: ECU Harness StatisticsⅡ✧附表3：催化转化器统计表Table 3: Catalyst StatisticsⅡ气缸盖部件Cylinder Head Subassembly序号Pos.件号Part No.数量Quan.规格标准DIN/FremdfabrNr.中文名称Chinese Designation英文名称English Designation112164698241气门锁夹Air Lock Folder212164645121气门弹簧座Valve Spring Seat301222009121气门弹簧Valve Spring Y401222051122气门弹簧Valve Spring51303779161气门摇臂Rocker Arm60110772412Q43116轴用弹簧挡圈Shaft Circlip 7130331071气缸盖Cylinder Head 8130267011气缸盖垫片Cylinder Head Gasket 9121596066进气门Upper Connecting Rod Bearing 101330397786进气阀座Lower Cnnecting Rod Bearing 11121596086排气门Exhaust Valve 12130556616排气阀座Exhaust Valve Seat 131********进气门导管Into The Valve Guide 14130268646排气门导管Exhaust Valve Catheter活塞连杆组件Piston and Rod Subassembly序号Pos.件号Part No.数量Quan.规格标准DIN/FremdfabrNr.中文名称Chinese Designation英文名称English Designation11302670361梯形桶面环Trapezoidal Buckets Surface Ring21302234961扭曲锥面环Twisted Cone Ring31302670261油环Oil Ring41303310862活塞Piston5121513951211.5×2.3弹性挡圈Circlip6121523786活塞销Piston Pin 7130383956连杆衬套Connecting Rod Bushing 8130532816连杆体Connecting Rod Body 9130565096连杆上瓦Link On the Tile 10130561106连杆下瓦Link Under the Tile 111216704712连杆螺栓Connecting Rod Bolt 12130532826连杆盖Connecting Rod Cap混合器总成Mixer Subassembly序号 Pos.件号 Part No. 数量 Quan. 规格标准DIN/FremdfabrNr.中文名称Chinese Designation英文名称English Designation 1 612600190277 1 1 放气接头 Vent Connector 2 610800190009 1 1 燃气接头 Gas Connector 3 13052075 1 1 混合器体 Mixer Body 4 610800190008 2 2 喷射管 Injection Pipe 5 130520761 1喉管Throat Pipe低压滤清器与热交换器部件Low Pressure Fuel Filter And Heat Exchanger Subassembly序号Pos.件号Part No.数量Quan.规格标准DIN/FremdfabrNr.中文名称Chinese Designation英文名称EnglishDesignation11305823222水管接头Water Pipe Connector261260019029633M16×1.5空心螺栓Hollow Bolt3130556641190°焊接弯头90°Welding Elbow461080019028211燃气管Gas Pipe561080019026911热交换器Heat Exchanger61305822911热交换器安装板Heat Exchanger Bracket79001269000144Q341C101型六角螺母HexagonNut861260019073211滤清器总成Filter Assembly96108001902801燃气管Gas Pipe 106108001902901水管Water Pipe 1161260019030112软管卡箍Clamp 126108001902731滤清器座Filter Seat 136108001902701节温器ThermostatFMV与点火线圈部件FMV And Ignition Coil Subassembly序号Pos.件号Part No.数量Quan.规格标准DIN/FremdfabrNr.中文名称Chinese Designation英文名称English Designation16126001902456点火线圈Ignition Coil 29001127006312M5×25六角头螺栓Six Hexagon Head Bolts 39001221001812M5GB/T61701型六角螺母HexagonNut 4130582531点火线圈支架Ignition Coil Bracket 5130582271安装板Bracket 6130503822线束支架Harness Bracket 7900130500092M8×16GB/T70.1-8.8-Zn.D内六角圆柱头螺钉Hexagon Socket Cap Screw 8900122100222M8GB/T61701型六角螺母HexagonNut 9130582671三通接头Three Way Tie-in 10900130500092M8×16GB/T70.1-8.8-Zn.D内六角圆柱头螺钉Hexagon Socket Cap Screw 11900122100222M8GB/T61701型六角螺母HexagonNut 126108001900501FMV支架FMV Bracket 13900130500063M6×16GB/T70.1-8.8-Zn.D内六角圆柱头螺钉Hexagon Socket Cap Screw 14900122100193M6GB/T61701型六角螺母HexagonNut 15900038623653Q218B0665内六角圆柱头螺钉Hexagon Socket Cap Screw 16900122100193M6GB/T61701型六角螺母Hexagon Nut 176108001900311八喷嘴FMV FMV进气管部件Air Intake Pipe Subassembly序号Pos.件号Part No.数量Quan.规格标准DIN/FremdfabrNr.中文名称Chinese Designation英文名称English Designation1130342461电子节气门Electric Throttle 2130329571进气弯管Intake Connecting Pipe 3900130500014M10*20-12.9 GB70内六角圆柱头螺钉Hexagon Socket Cap Screw 4011105604M8*20-12.9 GB70内六角圆柱头螺钉Hexagon Socket Cap Screw 56108001900103混合器垫片Mixer Gasket 6130342481进气温度和压力传感器T/MAP sensor 7900135500091Q218B0620内六角圆柱头螺钉Hexagon Socket Cap Screw 8130504151废气旁通阀进气管支架Exhaust Relief Valve Intake Pipe Bracket 9130503822线束支架Harness Bracket 10011105604M8*20-12.9 GB70内六角圆柱头螺钉Hexagon Socket Cap Screw 11130504341进气弯管Intake Elbow电磁阀部件Solenoid Valve Subassembly序号Pos.件号Part No.数量Quan.规格标准DIN/FremdfabrNr.中文名称Chinese Designation英文名称EnglishDesignation16126001903361电磁阀Solenoid Valve 2130586402燃气接头Gas Connector36126001909971电磁阀支架Solenoid Valve Bracket46126001909952卡夹Clamp5900112700684M6×16GB六角头螺栓Six Hexagon Head Bolts6900143500034Q40306弹簧垫圈Spring WasherI 7900143300024Q40106平垫圈Plain Washer8900122100194M6GB/T61701型六角螺母Hexagon Nut稳压器部件Manostat Subassembly序号Pos.件号Part No.数量Quan.规格标准DIN/FremdfabrNr.中文名称Chinese Designation英文名称English Designation16126001905131稳压器Manostat 26126001903352燃气接头Gas Connector36126001909952卡夹Clamp46126001909941稳压器支架Manostat Bracket5900143500034Q40306弹簧垫圈Spring WasherI 6900143300024Q40106平垫圈Plain Washer7900122100194M6GB/T61701型六角螺母HexagonNut高压滤清器部件Fuel Filter Subassembly序号Pos.件号Part No.数量Quan.规格标准DIN/FremdfabrNr.中文名称Chinese Designation英文名称English Designation16126001903671滤清器支架Fuel Filter Bracket 2130556501高压燃气滤清器High Pressure Gas Filter 32螺栓3/8-16 UNC bolt 4900039302612Q40108平垫圈Plain Washer 900039311022Q40308弹簧垫圈Spring WasherI减压器部件ReductorSubassembly序号Pos.件号Part No.数量Quan.规格标准DIN/FremdfabrNr.中文名称Chinese Designation英文名称English Designation1130504481减压器Reductor 2130520681燃气接头Gas Connector 3130521151减压器支架Reductor Bracket信号发生器总成（13034858）Signal Generator Subassembly序号Pos.件号Part No.数量Quan.规格标准DIN/FremdfabrNr.中文名称Chinese Designation英文名称English Designation1130348541传感器垫块Sensor Bearer 2900130500264M5×8 GB/T70-8.8-Zn.D内六角圆柱头螺钉Hexagon Socket Cap Screw 39001423000745GB/T955波形弹性垫圈Wave Spring Washer 4130348461盖板Cover Plate 5900122200031M14×1.5 GB/T6171-H.Y1型六角螺母细牙Hexagon Nut, Fine Pitch Thread 690014170002114GB/T859-H.Y轻型弹簧垫圈Light Spring Washer7C62.40.03.20021传感器齿盘Signal Generator Plate 8130348471信号发生器壳体Signal Generator Housing 9900180100021M8×1 JB/T940.1直通式压注油杯Straight Hydraulic Grease Nipple 106126009800031接座Seat 119001602000126205 GB/T276深沟球轴承Ball Bearing 126126009800051轴承支管Bearing Spacer 131********信号发生器旋转轴Signal Generator Revolving Spindle 146126009800041压板Pressure Plate 15900130500274M5×12GB/T70.1-8.8-Zn.D内六角圆柱头螺钉Hexagon Socket Cap Screw 16130348531连接盘Connecting Plate 17900122200031M14×1.5 GB/T6171-H.Y1型六角螺母细牙Hexagon Nut, Fine Pitch Thread 1890014170002114GB/T859-H.Y轻型弹簧垫圈Light Spring Washer 11900122200031M14×1.5GB/T6171-H.Y1型六角螺母细牙Hexagon Nut, Fine Pitch Thread 1290014010003114GB/T93标准型弹簧垫圈Standard Spring Washer 131********连接盘Connecting Plate 146126009800041压板Pressure Plate 151********信号发生器旋转轴Signal Generator Revolving Spindle 166126009800051轴承支管Bearing Spacer 179001602000126205 GB/T276深沟球轴承Ball Bearing18900175200111B20×35×7GB/T9877.1内包骨架旋转轴唇形密封圈Oil Seal燃气管Gas Pipe序号Pos.件号Part No.数量Quan.规格标准DIN/FremdfabrNr.中文名称Chinese Designation英文名称EnglishDesignation1130582701200mm燃气管Gas Pipe 2130582721145mm燃气管Gas Pipe增压器进、出水管Turbocharger Water Inlet and OutletPipe序号Pos.件号Part No.数量Quan.规格标准DIN/FremdfabrNr.中文名称Chinese Designation英文名称English Designation1011192432空心螺栓Hollow Bolt 2130387321增压器进水管Turbocharger Water Inlet Pipe 31305041311增压器水管螺座Turbocharger Water Pipe Bolt Holder 46126001902961空心螺栓Hollow Bolt 5130387351增压器进油管Turbocharger Lubrication Pipe 6130387331增压器回水管Turbocharger Water Outlet Pipe 7130503803管夹组件Pipe Clip Module废气控制阀及进、出气管Waste Gate Control Valve and Inlet and Outlet Pipe序号Pos.件号Part No.数量Quan.规格标准DIN/FremdfabrNr.中文名称Chinese Designation英文名称English Designation1130387471废气控制阀出气管Waste Gate Control Valve Outlet Pipe 2130341831废气控制阀Waste Gate Control Valve 3900130500472M4×8GB/T70.1-8.8-Zn.D内六角圆柱头螺钉Hexagon Socket Cap Screw 4900143300012Q40104平垫圈Plain Washer 5900143500012Q40304弹簧垫圈Spring WasherI6130504141废气控制阀支架Waste Gate Control Valve Bracket 7130387361废气控制阀进气管Waste Gate Control Valve Inlet Pipe指针Index序号 Pos.件号 Part No. 数量 Quan. 规格标准 DIN/FremdfabrNr.中文名称Chinese Designation英文名称English Designation1 .13050417 1 指针 Index 2900122100221M8 GB/T61701型六角螺母Hexagon Nut电器控制箱组件Electric Control Box Subassembly序号Pos.件号Part No.数量Quan.规格标准DIN/FremdfabrNr.中文名称Chinese Designation英文名称English Designation16126001903431电器控制箱Electric Control Box 2130341871点火模块ICM 3900038623274Q218B0625内六角圆柱头螺钉Hexagon Socket Cap Screw 4900143300024Q40106平垫圈Plain Washer 5900143500034Q40306弹簧垫圈Spring Washer 6900038712324Q340B061型六角螺母Hexagon Nut 76126001902471发动机控制模块ECM 8900038623653Q218B0665内六角圆柱头螺钉Hexagon Socket Cap Screw 9900143300023Q40106平垫圈Plain Washer 10900143500033Q40306弹簧垫圈Spring Washer 11900038712323Q340B061型六角螺母Hexagon Nut传感器组件Sensor Subassembly序号Pos.件号Part No.数量Quan.规格标准DIN/FremdfabrNr.中文名称Chinese Designation英文名称English Designation16126001902291机油温度压力传感器Oil Temperature And Pressure Sensor 26126001902431湿度传感器Humidity Sensor 36126001903462MAP传感器MAP Sensor 46126001903401湿度传感器座Humidity Sensor Seat 5130600724NGP传感器Nature Gas Pressure Sensor 6130600714NGT传感器Nature Gas Temperature Sensor 76126001902281水温传感器Water Temperature Sensor 813034188113034188氧传感器Universal Exhaust Gas Oxygen Sensor 96126001902423相位传感器Phase Sensor水管接头Water Pipe Tie -in序号 Pos.件号 Part No. 数量 Quan. 规格标准 DIN/FremdfabrNr.中文名称Chinese Designation英文名称English Designation 1 13058650 1 水管接头 Water Pipe Tie -in 2 13058271 1 汽化器取水接头 Carburetor Water Fittings 3 13055850 1 减压器取水接头 Reducer Water Fittings 4612600190309190°焊接弯头90°Welding Elbow备件箱中燃气管Gas Pipe In Spare Parts Box序号 Pos.件号 Part No.数量 Quan. 规格标准 DIN/FremdfabrNr. 中文名称Chinese Designation英文名称 EnglishDesignation1 1 两端180° 燃气管 Gas Pipe 两端90° 燃气管 Gas Pipe一端180°一端90°燃气管Gas Pipe备注：配套厂家可参照表1选购燃气管规格Notes ：The length of gas pipe can be determined according to the requirement of Lieferant.线束及接插件Harness and Connectors序号Pos.件号Part No.数量Quan.规格标准DIN/FremdfabrNr.中文名称Chinese Designation英文名称English Designation1130587111发动机线束Engine Harness 21ECU线束ECU Harness 3130586911套a set高压点火线总成Ignition Cable 46126001904921套a set整车接口接插件Vehicle Connector 备注：配套厂家可参照表2选购ECU线束Notes：The mating manufacturers can choose the length of ECUaccording to the requirement电子脚踏板及接插件Electronic Pedal And Connectors序号 Pos.件号 Part No. 数量 Quan. 规格标准 DIN/FremdfabrNr.中文名称Chinese Designation英文名称English Designation 1 13034193 1 35° 电子脚踏板 Electronic Pedal 2 13050439 1 45° 电子脚踏板 Electronic Pedal 36126001903631套 a set脚踏板接插件Foot Pedal Connector备注：配套厂家可根据要求选购电子脚踏板型号Notes ：The mating manufacturers can choose the type of electronic pedal according to the requirement催化转化器Purifier序号Pos.件号Part No.数量Quan.规格标准DIN/FremdfabrNr.中文名称Chinese Designation英文名称English Designation11普通两端带法兰Ordinary With Flange催化转化器Purifier21集成消音器不带法兰Integrated Silencer WithoutFlange催化转化器Purifier备注：配套厂家可参照表3选购催化转化器Notes：The mating manufacturers can refer to table 3 to choose the type of purifier附表1：燃气管规格统计表附表2：ECU线束统计表附表3：催化转化器统计表。

潍柴动力股份有限公司配件电子目录发布系统项目用户操作手册编制：EPC项目组生成日期：2013.06.12定稿日期：2013.06.20定稿版本：V0.21文档控制1.1修改记录编制日期编制人版本编制内容20130612 徐涛V0.1 初稿20130620 徐涛V0.2 内容修订1.2审查人序号姓名职位意见备注目录1 文档控制 (I)1.1修改记录 (I)1.2审查人 (I)2 登陆EPC 系统 (1)2.1登录前注意事项 (1)2.2登陆 (1)3 查询功能 (3)3.1首页查询 (3)3.2基本查询功能 (3)3.2.1 订货号查询 (3)3.2.2 发动机编码查询 (5)3.2.3 零件编码查询 (5)3.2.4 零件名称查询 (6)3.2.5 “全部”查询 (7)3.3高级搜索查询 (7)3.4本页搜索 (8)3.5模糊查询功能 (9)3.6零件用途反查 (12)3.7零件详情 (13)3.8零件替换关系 (14)3.9零件备注 (15)4 订购、收藏功能 (19)4.1零件订购功能 (19)4.1.1 加入清单功能 (19)4.1.2 删去清单零件 (20)4.1.3 批量删除功能 (21)4.1.4 导出购物车清单功能 (22)4.2零件收藏功能 (23)4.2.1 加入收藏夹功能 (23)4.2.2 删去收藏夹零件 (23)5 语言切换功能 (25)5.1语言切换 (25)6 发布控制功能 .......................................................................................................... 错误!未定义书签。

2登陆EPC 系统2.1登录前事项1)浏览器要求:系统支持IE7及以上版本IE浏览器（IE7、IE8、IE9），IE内核浏览器（世界之窗、搜狗、360安全浏览器等）。

非IE内核浏览器暂不支持（如chrome、firefox、360极速等）。

潍柴零件图册一、气缸体（一）Cylinder Block序号图号名称单位备注612600010669 欧曼气缸体总成件612600010815 欧曼气缸体总成件61500010373B 欧曼气缸体总成件612600011727 欧曼气缸体总成件612630010186 欧曼气缸体总成件1 612600010747 欧曼气缸体件1 612600010806 欧曼气缸体件1 61560010095B 欧曼气缸体件1 612600011725 欧曼气缸体件1 612600011611 欧曼气缸体件2 612600010646 欧曼曲轴箱件2 61500010366 欧曼曲轴箱件3 61500010344 欧曼气缸套件3 61800010125 欧曼气缸套件4 90003982121 欧曼碗形塞件5 90003989480 欧曼碗形塞件6 90003989204 欧曼碗形塞件7 61560010029 欧曼凸轮轴衬套件7 612600010990 欧曼凸轮轴衬套件8 90003901604A 欧曼圆柱销件9 81500010046 欧曼主轴瓦付9 61800010128 欧曼上主轴瓦付9 61800010132 欧曼下主轴瓦付10 81500010125 欧曼止推片付10 614050133 欧曼止推片付11 614010114 欧曼主轴承螺栓件12 90003802493 欧曼六角头螺栓件13 90003962050 欧曼内六角圆柱头螺塞件15 61000010134 欧曼密封圈件16 614010217 欧曼主轴承螺栓件17 612600070097 欧曼回油弯管件18 90003862428 欧曼内六角圆柱头螺钉件19 188250083 欧曼自锁垫圈件20 90003989215 欧曼碗形塞件21 90003989289 欧曼碗形塞件22 90003962621 欧曼空心螺栓件23 90003098015 欧曼复合密封垫圈件24 612600010659 欧曼喷嘴组件件24 61560010090 欧曼喷嘴组件件24 612600010750 欧曼喷嘴组件件25 90003909603 欧曼弹性圆柱销件26 61500010100 欧曼后油封件26 90003074487 欧曼后油封件27 90003989288 欧曼碗形塞件28 61460070011 欧曼主油道后螺塞件29 612600010735 欧曼复合垫圈件30 90003901604 欧曼圆柱销件31 61500010185S 欧曼气缸盖螺栓件31 61500040023 欧曼气缸盖螺栓件32 90003989210 欧曼碗形塞件33 90003909626 欧曼弹性圆柱销件二、气缸体（二）Cylinder Block序号图号名称单位备注1 612600010932 欧曼正时齿轮室件1 612600011040 欧曼正时齿轮室件1 612600011918 欧曼正时齿轮室件1 612600011776 欧曼正时齿轮室件2 61560010069 欧曼空压机齿轮盖件3 614010040 欧曼空压机齿轮盖垫片件4 612600010928 欧曼前油封座件5 61500010037 欧曼前油封件5 90003074473 欧曼前油封件6 61500010008A 欧曼凸轮轴齿轮盖件7 614010070 欧曼凸轮轴齿轮盖垫片件8 90003813429S 欧曼双头螺柱件9 90003932023 欧曼波形弹性垫圈件10 90003909626 欧曼弹性圆柱销件11 90003802576 欧曼六角头螺栓件12 90003932024 欧曼波形弹性垫圈件13 90003800571 欧曼六角头螺栓件14 90003931122 欧曼弹簧垫圈件16 90003862524 欧曼内六角圆柱头螺钉件17 90003932025 欧曼鞍形弹性垫圈件18 90003871252 欧曼1型六角螺母件19 90003813443S 欧曼双头螺柱件20 90003962051 欧曼轻型六角头圆柱螺塞件21 90003901507 欧曼圆柱销件22 90003802523 欧曼六角头螺栓件24 90003813628S 欧曼双头螺柱件25 90003888453 欧曼1型全金属六角锁紧螺母件27 90003098018 欧曼密封垫圈件28 612600010934 欧曼前油封座垫片件29 90003930271 欧曼平垫圈件30 90003802561 欧曼六角头螺栓件三、气缸体（三）Cylinder Block序号图号名称单位备注1 612600011654 欧曼机油冷却器盖件1 61800010112 欧曼机油冷却器盖件1 614010083B 欧曼机油冷却器盖件2 614010084B 欧曼机油冷却器盖垫片件3 615Q0170036 欧曼飞轮壳件3 612600010575 欧曼飞轮壳件3 612600011618 欧曼飞轮壳件4 1800210011 欧曼观察孔盖件5 612600011910 欧曼油标尺件5 612600010894 欧曼油标尺件5 612600010559 欧曼油标尺件5 612600010532 欧曼油标尺件5 612600010898 欧曼油标尺件5 612600011412 欧曼油标尺件5 612600010686 欧曼油标尺件5 612600012032 欧曼油标尺件5 612600011386 欧曼油标尺件6 欧曼油尺管组件件7 612600010638 欧曼橡胶管箍件8 612600010647 欧曼单管夹片件10 614010086 欧曼加油短管垫片件14 612600010611 欧曼机油加油管件15 612600010489 欧曼加油管盖总成件16 614010279 欧曼通风弯管件17 90003069303 欧曼垫片件18 612600010267 欧曼油气分离器组件件19 90003989336 欧曼软管卡箍件21 AZ1500010032 欧曼固定板件22 190003989301 欧曼软管卡箍件24 612600010445 欧曼单管夹子件25 90003802411 欧曼六角头螺栓件26 90003800467 欧曼六角头螺栓件26 90003800465 欧曼六角头螺栓件27 90003802424 欧曼六角头螺栓件29 90003962020 欧曼轻型六角头圆柱螺塞件31 90003802511 欧曼六角头螺栓件32 614010417 欧曼飞轮壳螺栓件32 61500010101 欧曼飞轮壳螺栓件34 90003871305 欧曼1型六角螺母件35 90003813527 欧曼双头螺柱件36 90003888452 欧曼2型全金属六角锁紧螺母件37 90003802321 欧曼六角头螺栓件38 90003862427 欧曼内六角圆柱头螺钉件39 90003901604 欧曼圆柱销件40 90003932023 欧曼波形弹性垫圈件41 90003098014 欧曼复合密封垫圈件42 90003931122 欧曼弹簧垫圈件43 90003931082 欧曼重型弹簧垫圈件44 90003936101 欧曼垫圈件四、曲轴飞轮Crankshaft and Flywheel序号图号名称单位备注61560020029 欧曼曲轴总成套61500020071 欧曼曲轴总成套612600020233 欧曼曲轴总成套612600020373 欧曼曲轴总成套1 61560020024 欧曼曲轴件1 61500020012 欧曼曲轴件1 612600020235 欧曼曲轴件2 614020038 欧曼曲轴齿轮件2 612600020234 欧曼曲轴齿轮件3 61500020070 欧曼法兰件4 90003901418 欧曼圆柱销件6 90003960569 欧曼普通平键件8 61560020010 欧曼减振器件8 61800020012 欧曼减振器件9 61560020016 欧曼皮带轮件9 61560020017 欧曼皮带轮件9 612600020210 欧曼皮带轮件9 61800061004 欧曼皮带轮件9 61800061002 欧曼皮带轮件10 615Q0170026 欧曼飞轮件10 612600020220 欧曼飞轮件10 612600020416 欧曼飞轮件11 612600020208 欧曼飞轮齿圈件12 90011620022 欧曼双头螺柱件14 90003871305 欧曼1型六角螺母件15 90003932024 欧曼波形弹性垫片件16 90003311416 欧曼球轴承件17 90003934310 欧曼孔用弹性挡圈件18 61500020046 欧曼六角头螺栓件19 81500060228 欧曼三角皮带件19 61500060217 欧曼三角皮带件五、活塞连杆Piston and Connecting Rod序号图号名称单位备注1 612600030011 欧曼活塞件1 612600030010 欧曼活塞件1 612600030017 欧曼活塞件1 612600030034 欧曼活塞件2 61560030013 欧曼活塞销件3 81560030012 欧曼活塞销挡圈件4 61560030047 欧曼梯形环件4 612600030035 欧曼梯形环件5 612600030019 欧曼锥面环件5 612600030036 欧曼锥面环件6 61560030045 欧曼油环件6 612600030037 欧曼油环件61500030009 欧曼连杆总成套61800030041 欧曼连杆总成套7 61500030008 欧曼连杆体件8 61500030022 欧曼连杆盖件9 61500030077 欧曼连杆衬套件10 61560030033 欧曼连杆轴瓦套10 61800030049 欧曼连杆轴瓦套11 612600030020 欧曼连杆轴瓦（上瓦）套12 81500030023 欧曼连杆螺栓件六、气缸盖Cylinder Head序号图号名称单位备注61560040058 欧曼气缸盖总成件612600040284 欧曼气缸盖总成件612600040296 欧曼气缸盖总成件612600040298 欧曼气缸盖分总成件1 61560040040B 欧曼气缸盖件1 612600040283 欧曼气缸盖件1 612600040282 欧曼气缸盖件612600040295 欧曼气缸盖件2 61560040057 欧曼进气门座件3 81560040037 欧曼排气门座件4 612600040113 欧曼气门导管件5 406060010 欧曼环状密封圈件6 612600040099 欧曼喷油器衬套件6 612600040235 欧曼喷油器衬套件7 90003989294 欧曼碗形塞件8 90003989277 欧曼碗形塞件9 90003989721 欧曼碗形塞件10 90003989725 欧曼碗形塞件11 61500040049 欧曼气缸盖衬垫件12 614040065 欧曼气缸盖罩件12 612600040149 欧曼气缸盖罩件13 614040021 欧曼气缸盖罩衬垫件14 61500040102 欧曼出水管件15 612600040233 欧曼管接头组件件16 61200040027 欧曼夹紧块件17 61200040034 欧曼带肩螺母件18 61500040012 欧曼吊环夹紧块件19 614010388 欧曼吊环螺钉件20 612600040114 欧曼气门阀杆密封套件21 61500040023 欧曼气缸盖主螺栓件22 61500040009 欧曼夹紧块件23 61200040023 欧曼夹紧块件24 90003800466 欧曼六角头螺栓件25 90003932023 欧曼波形弹性垫圈件七、配气机构Valve T rain序号图号名称单位备注1 61500050096 欧曼凸轮轴件1 612600050085 欧曼凸轮轴件1 612600050087 欧曼凸轮轴件2 614050053 欧曼凸轮轴正时齿轮件2 61800050144 欧曼凸轮轴正时齿轮件3 614050133 欧曼凸轮轴止推片件4 61560050044 欧曼中间齿轮轴件5 61560050053 欧曼中间齿轮总成件5 61800050098 欧曼中间齿轮总成件6 61560050058 欧曼轴件7 61560050045 欧曼挡板件8 90003120602 欧曼密封圈件9 61560050046A 欧曼盖板件10 614050119 欧曼气门摇臂座件10 612600050027 欧曼气门摇臂座件11 614050048 欧曼进气门摇臂件12 614050049 欧曼排气门摇臂件12 612600050059 欧曼排气门摇臂件13 61500050105 欧曼气门帽件14 61500050025 欧曼气门锁夹件15 61500050109 欧曼气门弹簧上座件16 61500050002 欧曼气门外弹簧件17 61500050001 欧曼气门内弹簧件18 614050017 欧曼进气门弹簧下座件19 612600050073 欧曼进气门件20 61500050032 欧曼气门挺柱件21 81500050070 欧曼气门推杆总成件22 614050010 欧曼气门间隙调整螺钉件23 2130050065 欧曼气门间隙调整螺母件24 61500040014 欧曼排气门弹簧下座件25 61560050041 欧曼排气门件25 612600050025 欧曼排气门件26 90003802655 欧曼六角头螺栓件27 61560050059S 欧曼六角头螺栓件28 90003862419 欧曼内六角圆柱头螺钉件29 90003813414S 欧曼双头螺柱件30 90003871252 欧曼1型六角螺母件31 90003932023 欧曼波形弹性垫圈件32 90003802411 欧曼六角头螺栓件33 90003802443S 欧曼六角头螺栓件34 90003901409 欧曼圆柱销件八、冷却系统Cooling System序号图号名称单位备注1 61560060050 欧曼水泵总成件1 61800061007 欧曼水泵总成件1 612600060569 欧曼水泵总成件3 612600060446 欧曼φ640环形风扇件3 612600060215 欧曼φ640环形风扇件3 612600060123 欧曼塑料风扇件￠670吸风3 612600060567 欧曼塑料风扇件4 614060024 欧曼水管接头垫片件5 61560060022A 欧曼水管接头件9 90003989308 欧曼软管卡箍件10 61000060276 欧曼胶管件11 614060135 欧曼节温器总成件11 61500060116 欧曼节温器总成件11 61800060172 欧曼节温器总成件12 612600060518 欧曼冷却水软管件13 614060008 欧曼水泵密封垫件16 614010040 欧曼空压机齿轮盖垫片件17 61560010069 欧曼空压机齿轮盖件18 61560060069 欧曼张紧轮总成件19 90011400001 欧曼六角法兰面螺栓件21 99100590009 欧曼右支架件23 90003802424 欧曼六角头螺栓件24 90003800467 欧曼六角头螺栓件25 90003888452 欧曼2型全金属六角锁紧螺母件26 90003888451 欧曼2型全金属六角锁紧螺母件27 90003932023 欧曼波形弹性垫圈件28 90003931102 欧曼弹簧垫圈件九、水泵Water Pump序号图号名称单位备注61560060050 欧曼水泵总成件61800061007 欧曼水泵总成件612600060569 欧曼水泵总成件1 61500060234 欧曼水泵体件2 61500060249 欧曼叶轮件3 61500060124 欧曼皮带轮件4 612600060539 欧曼水封总成件5 612600060584 欧曼水泵加黄油装置件6 61500060248 欧曼泵轴件7 61500060251 欧曼支撑套件8 612600060538 欧曼锥端紧定螺钉件9 90003310067 欧曼向心球轴承件10 90016040012 欧曼圆柱滚子轴承件11 61500060237 欧曼防护圈件十、张紧轮T ensioning Roller序号图号名称单位备注61560060069 欧曼张紧轮总成件1 61560060070 欧曼张紧轮件4 61560060074 欧曼防护圈件5 90016020017 欧曼深沟球轴承件6 61560060073 欧曼隔套件十一、机油泵Oil Pump序号图号名称单位备注AZ1500070021A 欧曼机油泵总成件61800071010 欧曼机油泵总成件6 614070055 欧曼机油泵垫片件7 61500070082 欧曼集滤器总成件7 612600070180 欧曼集滤器总成件7 61800070051 欧曼集滤器总成件7 612600070125 欧曼集滤器总成件8 614070078 欧曼垫片件9 614070061 欧曼机油泵中间齿轮件10 90003311410 欧曼向心球轴承件11 614070049 欧曼中间隔圈件12 90003934732 欧曼带凸齿的孔用挡圈件13 6140756 欧曼中间齿轮轴件14 614070155 欧曼密封圈件AZ1500070097 欧曼机油泵限压阀总成件15 AZ1500070096 欧曼阀体件16 407070032 欧曼限压阀件17 4139070059 欧曼弹簧件22 90003802578S 欧曼六角头螺栓件24 90003802523S 欧曼六角头螺栓件25 90003930271 欧曼平垫圈件26 90003862443 欧曼内六角圆柱头螺钉件28 90003931122 欧曼弹簧垫圈件【返回顶部】潍柴图册（二）北汽福田欧曼汽车配件网2011-10-14 12:39:18 作者:常小华来源:欧曼配件文字大小:[大][中][小]十二、机油滤清器和机油冷却器Oil Filter and Oil Cooler序号图号名称单位备注1 61500070051 欧曼机油滤清器底座组件件2 61000070005 欧曼旋转式机油滤芯总成件3 61500010334 欧曼机油冷却器（8片）件3 61800010113 欧曼机油冷却器芯总成(9片) 件4 81400010032 欧曼密封圈件5 90003962051 欧曼轻型六角头圆柱螺塞件7 614070068 欧曼安全阀弹簧件8 614070069 欧曼安全阀件AZ1500070097 欧曼主油道限压阀总成件9 AZ1500070096 欧曼阀体件12 4139070059 欧曼弹簧件13 407070034 欧曼弹簧座件14 AZ9003930012 欧曼弹性挡圈件15 90003862443 欧曼内六角圆柱头螺钉件16 90003932023 欧曼波形弹性垫圈件17 90003862482 欧曼内六角圆柱头螺钉件十三、喷油泵和高压油管Injection pump and Injection Pipes序号图号名称单位备注1 612600082115 欧曼波许喷油泵带K型调速器件1 612601080158 欧曼波许喷油泵带K型调速器件1 61560080302 欧曼波许喷油泵带K型调速器件1 61560080282 欧曼喷油泵总成件1 612601080168 欧曼喷油泵总成件1 612600081168 欧曼喷油泵总成件1 612600082116 欧曼BOSCH高压油泵件1 612600081116 欧曼喷油泵总成件1 612600087116 欧曼喷油泵总成件1 612601080219 欧曼喷油泵总成件1 612601080216 欧曼喷油泵总成件1 612600081162 欧曼喷油泵总成件1 612600083162 欧曼喷油泵总成件1 612600087162 欧曼喷油泵总成件1 612601080175 欧曼喷油泵总成件1 612601080162 欧曼喷油泵总成件1 612601080145 欧曼喷油泵总成件1 61560080304 欧曼高压油泵件1 612600081175 欧曼高压油泵件1 612601080176 欧曼喷油泵总成件1 612601080154 欧曼喷油泵总成件1 612600087176 欧曼喷油泵总成件1 612600081236 欧曼高压油泵件1 612600081235 欧曼高压油泵件1 612600081228 欧曼P8500喷油泵总成件1 612600082227 欧曼博世顶隙泵件1 612600080674 欧曼共轨喷油泵件2 612600080213 欧曼单向阀件3 612600080200 欧曼密封垫圈件4 81560080275 欧曼法兰组件件5 614080074 欧曼波许喷油泵托架件6 90003802650 欧曼六角头螺栓件7 90003931142 欧曼弹簧垫圈件8 90003901600 欧曼圆柱销件9 90003862566 欧曼内六角圆柱头螺钉件10 90003930271 欧曼平垫圈件11 612600080563 欧曼联轴器总成件12 61560080276 欧曼喷油器总成件12 61560080305 欧曼喷油器总成件12 612600080730 欧曼喷油器总成件12 612600080311 欧曼喷油器总成件12 612600080618 欧曼喷油器总成件13 614080082 欧曼垫圈件14 609070080 欧曼密封垫圈件15 61500080094A 欧曼紧固压板件16 612600080383 欧曼六角头螺栓件17 61500080090 欧曼空心螺栓件18 90003098018 欧曼复合密封垫圈件19 612600080568 欧曼高压油管组套19 612600080368 欧曼高压油管组套612600080633 欧曼第一缸高压油管件612600080634 欧曼第二缸高压油管件612600080635 欧曼第三缸高压油管件612600080636 欧曼第四缸高压油管件612600080637 欧曼第五缸高压油管件612600080638 欧曼第六缸高压油管件20 61560080172 欧曼支撑架件29 AZ1560070025 欧曼润滑油回油管总成件30 90003962621 欧曼空心螺栓件十四、油管Fuel Line序号图号名称单位备注1 614080295A 欧曼燃油滤清器总成件3 61560080094 欧曼燃油滤托架组件件4 AZ1560080017 欧曼燃油管件5 AZ1560080018 欧曼燃油管件6 612600080597 欧曼回油管总成件7 61560070012A 欧曼润滑油管总成件8 61560070011A 欧曼润滑油管总成件9 61560080284 欧曼空气管件10 90003802627 欧曼六角头螺栓件11 90003802523 欧曼六角头螺栓件12 90003932016 欧曼波形弹性垫圈件13 90003932024 欧曼波形弹性垫圈件14 90003930012 欧曼垫圈件15 90003962621 欧曼空心螺栓件16 90003962612 欧曼空心螺栓件17 Z61560070012 欧曼空心螺栓件18 90003962607 欧曼空心螺栓件19 90003962603 欧曼空心螺栓件20 609080037 欧曼空心螺栓件21 612600080200 欧曼密封垫圈件22 90003098012 欧曼复合密封垫圈件24 612600080201 欧曼密封垫圈件十五、联轴器Coupling序号图号名称单位备注1 81560080266 欧曼联轴器法兰件1 81560080275 欧曼联轴器法兰件2 61560080194 欧曼角度调节板件3 AZ1560080001 欧曼六角头螺栓件4 61560080219 欧曼弹性连接片件5 81560080271 欧曼垫圈件6 81560080273 欧曼衬套件7 90003802637 欧曼六角头螺栓件9 90003800160 欧曼六角头螺栓件10 90003871344 欧曼1型六角螺母件11 90003930282 欧曼小垫圈件十六、电气系统Electrical System序号图号名称单位备注1 612600090293 欧曼起动机件1 612600090210 欧曼起动机件2 615P00090002 欧曼拉紧块件3 61500090065 欧曼三角皮带件5 612600090353 欧曼1.5kW交流发电机件5 612600098155 欧曼1.5kW交流发电机件5 612600090401 欧曼发电机件11 90003935125 欧曼平垫圈件12 90003800571 欧曼六角头螺栓件13 90003932025 欧曼鞍形弹性垫圈件14 90003871305 欧曼1型六角螺母件15 61500090018 欧曼拉紧螺栓件17 61500090051 欧曼压力传感器件18 614090067 欧曼水温表传感器件20 612600080275 欧曼复合密封垫圈件21 90003098014 欧曼复合密封垫圈件24 90003888452 欧曼2型全金属六角锁紧螺母件33 90003930261 欧曼平垫圈件十七、火焰预热系统Flame Starter System序号图号名称单位备注1 612600090080 欧曼温度传感器件1 614090067 欧曼温度传感器件2 612600090082 欧曼电磁阀件3 612600090081 欧曼火焰预热电热塞件7 90003962607 欧曼空心螺栓件8 81560080212 欧曼空心螺栓件9 609E110070 欧曼联接螺栓件13 612600090075 欧曼角形支架件十八、进气系统Air Intake System（STEYR）序号图号名称单位备注1 612600111809 欧曼进气管件1 612600111808 欧曼进气管件1 612600111732 欧曼进气管件2 90003962014 欧曼六角头螺塞件3 90003098010 欧曼复合密封垫圈件4 61500110024 欧曼进气管垫片件5 90003800465 欧曼六角头螺栓件7 614110064 欧曼进气管紧固螺栓件8 90003800497 欧曼六角头螺栓件9 90003932023 欧曼波形弹性垫圈件10 61560116227 欧曼废气涡轮增压器件10 612600118908 欧曼废气涡轮增压器件10 61561110227 欧曼废气涡轮增压器件10 61561110227L 欧曼废气涡轮增压器件10 61560116227L 欧曼废气涡轮增压器件10 612600118895 欧曼HX50增压器件10 612600118898 欧曼废气涡轮增压器件10 612600116943 欧曼废气涡轮增压器件10 612600118930 欧曼HX50增压器件12 61560110226 欧曼夹子件13 190320035 欧曼密封圈件14 612600111808 欧曼压气机进气管总成件15 612600111086 欧曼橡胶软管（带织物层）件16 90003989312 欧曼软管卡箍件17 612600110824 欧曼带纤维夹层橡胶软管件20 609E110036 欧曼调整垫圈件21 90003802411 欧曼六角头螺栓件22 612600110317 欧曼卡箍带件23 209190017 欧曼拉紧销件24 1700550013 欧曼张紧销件27 99100570015 欧曼悬臂总成件34 612600110989 欧曼中冷进气管件612600110455 欧曼盖板件61560050046A 欧曼盖板件40 90003802424 欧曼六角头螺栓件十九、排气系统Exhaust System（STEYR）序号图号名称单位备注1 612600111290 欧曼前排气歧管件1 61560110221 欧曼前排气歧管件1 615G60110120 欧曼前排气歧管件1 612600111991 欧曼一二缸排气歧管件1 612600111992 欧曼三四缸排气歧管件1 612600111993 欧曼五六缸排气歧管件2 612600110866 欧曼后排气歧管件2 612600110855 欧曼后排气歧管件2 612600111712 欧曼后排气歧管件2 61560110222 欧曼后排气歧管件2 612600110178 欧曼后排气歧管件2 612600111280 欧曼后排气歧管件3 612600110856 欧曼前隔热罩件4 612600110857 欧曼后隔热罩件6 61260110162 欧曼排气管密封环件7 61560110242 欧曼排气管垫片件8 61560110104 欧曼排气管固定螺栓件9 61560110105 欧曼排气管固定螺栓件13 61560116227 欧曼废气涡轮增压器件13 612600118908 欧曼废气涡轮增压器件13 61561110227 欧曼废气涡轮增压器件13 61561110227L 欧曼废气涡轮增压器件13 61560116227L 欧曼废气涡轮增压器件13 612600118895 欧曼HX50增压器件13 612600118898 欧曼废气涡轮增压器件13 612600116943 欧曼废气涡轮增压器件13 612600118930 欧曼HX50增压器件14 61560110210 欧曼增压器密封垫件15 81560110187 欧曼双头螺柱件17 612600110060 欧曼进油管件18 81560110152 欧曼进油管法兰件19 609E110050 欧曼进油管垫片件20 90003862428 欧曼内六角圆柱头螺钉件21 188250083 欧曼自锁垫片件22 612600110345 欧曼回油管件23 61260110048 欧曼回油管法兰垫片件24 61460070014 欧曼回油管螺栓件26 612600070071 欧曼增压器回油用软管件二十、单缸空气压缩机Single Cylinder Air Compressor序号图号名称单位备注1 612600130177 欧曼空压机总成件1 612600130206 欧曼水冷空压机件1 61800130043 欧曼水冷空压机件5 612600130173 欧曼空压机齿轮件6 609070161 欧曼支撑环件7 612600130001 欧曼六角螺母件612600130124 欧曼传动轴总成件8 612600130122 欧曼传动轴件9 612600130123 欧曼压紧块件10 90003320154 欧曼圆柱滚子轴承件11 61500080158 欧曼径向止推滚珠轴承件12 612600130047 欧曼衬套件13 612600130073 欧曼挡油盘件14 612600130046 欧曼夹紧螺母件15 61500080165 欧曼盖件16 90003802432S 欧曼六角头螺栓件17 AZ1560130064 欧曼喷油泵齿轮件18 409020045 欧曼垫片件19 612600130045 欧曼六角螺母件20 192320002 欧曼密封圈件21 90003070092 欧曼油封件22 61500130097 欧曼油封座件23 90003802561 欧曼六角头螺栓件25 90003800458 欧曼六角头螺栓件26 90003802419 欧曼六角头螺栓件27 90003802415 欧曼六角头螺栓件28 90003932023 欧曼波形弹性垫圈件90003098014 欧曼密封垫圈件二十一、油底壳Oil Sump序号图号名称单位备注612600150229 欧曼油底壳总成件612600150186 欧曼油底壳总成件612600150151 欧曼油底壳总成件61800150015 欧曼油底壳总成件612600150104 欧曼油底壳总成件1 612600150219 欧曼油底壳件1 612600150187 欧曼油底壳件1 612600150163 欧曼油底壳件1 614150038 欧曼油底壳件2 614150004 欧曼密封垫件3 612600150108 欧曼磁性螺塞总成件4 612600150106 欧曼密封垫圈件8 614150046 欧曼油底壳托块件【返回顶部】。

一、气缸体（一）Cylinder Block二、气缸体（二）Cylinder Block132511008002113251100800221325310080001141711008000414171100800141418310007001141831000800114251100800081425110080018142511008000214251100800121425110008001142511000901011319100800031325110080018132511008002513311100800021331110080012133211008000634N0035J 34N003534Q1602J 34Q1449J 34Q144934Q1442J 34Q1470J 34Q1445J 34Q144538Q1256J 38Q125638Q1137J 38Q113744Q124244Q143844N003444Q1406J 44Q140644Q1251J1612600010932正时齿轮室件A 11111111111111111111612600011040正时齿轮室件A 1612600011918正时齿轮室件A 1612600011776正时齿轮室件A 261560010069空压机齿轮盖件A 11111111111111111113614010040空压机齿轮盖垫片件B 11111111111111111114612600010928前油封座件B 1111111111111111111561500010037前油封件B 1111111111111111111590003074473前油封件B 661500010008A 凸轮轴齿轮盖件A 11111111111111111117614010070凸轮轴齿轮盖垫片件B 1111111111111111111890003813429S 双头螺柱件A 1313990003932023波形弹性垫圈件A 121212121212121212121212121212121212121090003909626弹性圆柱销件A 66666666666666666661190003802576六角头螺栓件A 11111111111111111111290003932024波形弹性垫圈件A 11111111111111111111390003800571六角头螺栓件A 11111111111111111111490003931122弹簧垫圈件A1111111111111111111序号图号WD61WD615.34WD615.38名称单位易损C 常用B 非常用A三、气缸体（三） Cylinder Block132511008002113251100800221325310080001141711008000414171100800141418310007001141831000800114251100800081425110080018142511008000214251100800121425110008001142511000901011319100800031325110080018132511008002513311100800021331110080012133211008000634N0035J 34N003534Q1602J 34Q1449J 34Q144934Q1442J 34Q1470J 34Q1445J 34Q144538Q1256J 38Q125638Q1137J 38Q113744Q124244Q143844N003444Q1406J 44Q140644Q1251J1612600011654机油冷却器盖件A 1111111111111111111161800010112机油冷却器盖件A 1614010083B 机油冷却器盖件A 2614010084B 机油冷却器盖垫片件B 11111111111111111113615Q0170036飞轮壳件A 11113612600010575飞轮壳件A 1111111111111113612600011618飞轮壳件A 41800210011观察孔盖件A 11111111111111111115612600011910油标尺件A 111115612600010894油标尺件A1115612600010559油标尺件A 111115612600010532油标尺件A 15612600010898油标尺件A 1115612600011412油标尺件A5612600010686油标尺件A 5612600012032油标尺件A 5612600011386油标尺件AWD61序号WD615.34WD615.38单位易损C 常用B 非常用A图号名称四、曲轴飞轮 Crankshaft and Flywheel132511008002113251100800221325310080001141711008000414171100800141418310007001141831000800114251100800081425110080018142511008000214251100800121425110008001142511000901011319100800031325110080018132511008002513311100800021331110080012133211008000634N0035J 34N003534Q1602J 34Q1449J 34Q144934Q1442J 34Q1470J 34Q1445J 34Q144538Q1256J 38Q125638Q1137J 38Q113744Q124244Q143844N003444Q1406J 44Q140644Q1251J61560020029曲轴总成套A 111111111111111111161500020071曲轴总成套A 612600020233曲轴总成套A 612600020373曲轴总成套A 161560020024曲轴件A 1111111111111111111161500020012曲轴件A 1612600020235曲轴件A 2614020038曲轴齿轮件A 11111111111111111112612600020234曲轴齿轮件A 361500020070法兰件A 1111111111111111111490003901418圆柱销 件A 1111111111111111111690003960569普通平键件A 1111111111111111111861560020010减振器件A1111111111111111111易损C 常用B 非常用A序号图号WD61名称单位WD615.34WD615.38五、活塞连杆 Piston and Connecting Rod132511008002113251100800221325310080001141711008000414171100800141418310007001141831000800114251100800081425110080018142511008000214251100800121425110008001142511000901011319100800031325110080018132511008002513311100800021331110080012133211008000634N0035J 34N003534Q1602J 34Q1449J 34Q144934Q1442J 34Q1470J 34Q1445J 34Q144538Q1256J 38Q125638Q1137J 38Q113744Q124244Q143844N003444Q1406J 44Q140644Q1251J1612600030011活塞件B 111111111612600030010活塞件B 1111111111111612600030017活塞件B 1612600030034活塞件B 261560030013活塞销件B 1111111111111111111381560030012活塞销挡圈件B 2222222222222222222461560030047梯形环件B 11111111111111111114612600030035梯形环件B 5612600030019锥面环件B 11111111111111111115612600030036锥面环件B 661560030045油环件B 11111111111111111116612600030037油环件B 61500030009连杆总成套B1111111111111111111序号图号易损C 常用B 非常用A名称单位WD61WD615.38WD615.3461800030041连杆总成套B761500030008连杆体件A1111111111111111111 861500030022连杆盖件A1111111111111111111 961500030077连杆衬套件B1111111111111111111 1061560030033连杆轴瓦套B1111111111111111111 1061800030049连杆轴瓦套B11612600030020连杆轴瓦（上瓦）套B11111111111111111111281500030023连杆螺栓件B2222222222222222222六、气缸盖 Cylinder Head132511008002113251100800221325310080001141711008000414171100800141418310007001141831000800114251100800081425110080018142511008000214251100800121425110008001142511000901011319100800031325110080018132511008002513311100800021331110080012133211008000634N0035J 34N003534Q1602J 34Q1449J 34Q144934Q1442J 34Q1470J 34Q1445J 34Q144538Q1256J 38Q125638Q1137J 38Q113744Q124244Q143844N003444Q1406J 44Q140644Q1251J61560040058气缸盖总成件A 6666612600040284气缸盖总成件A 666666666666666612600040296气缸盖总成件A 612600040298气缸盖分总成件A 161560040040B 气缸盖件A 11111612600040283气缸盖件A 11111612600040282气缸盖件A 11111111111612600040295气缸盖件A 261560040057进气门座件A 11111111381560040037排气门座件A 111111114612600040113气门导管件A 222222225406060010环状密封圈件A11111111WD61易损C 常用B 非常用A序号图号名称单位WD615.38WD615.34七、配气机构 Valve Train132511008002113251100800221325310080001141711008000414171100800141418310007001141831000800114251100800081425110080018142511008000214251100800121425110008001142511000901011319100800031325110080018132511008002513311100800021331110080012133211008000634N0035J 34N003534Q1602J 34Q1449J 34Q144934Q1442J 34Q1470J 34Q1445J 34Q144538Q1256J 38Q125638Q1137J 38Q113744Q124244Q143844N003444Q1406J 44Q140644Q1251J161500050096凸轮轴件A 111111111612600050085凸轮轴件A 111111111111111612600050087凸轮轴件A 2614050053凸轮轴正时齿轮件A 1111111111111111111261800050144凸轮轴正时齿轮件A 3614050133凸轮轴止推片件A 1111111111111111111461560050044中间齿轮轴件A 1111111111111111111561560050053中间齿轮总成件B 1111111111111111111561800050098中间齿轮总成件B 661560050058轴件A 1111111111111111111761560050045挡板件A 1111111111111111111890003120602密封圈件A1111111111111111111WD61WD615.34序号图号名称单位WD615.38易损C 常用B 非常用A八、冷却系统 Cooling System132511008002113251100800221325310080001141711008000414171100800141418310007001141831000800114251100800081425110080018142511008000214251100800121425110008001142511000901011319100800031325110080018132511008002513311100800021331110080012133211008000634N0035J 34N003534Q1602J 34Q1449J 34Q144934Q1442J 34Q1470J 34Q1445J 34Q144538Q1256J 38Q125638Q1137J 38Q113744Q124244Q143844N003444Q1406J 44Q140644Q1251J161560060050水泵总成件B 1111111111111111111161800061007水泵总成件B 1612600060569水泵总成件B 3612600060446φ640环形风扇件B 11111111111111113612600060215φ640环形风扇件B 113612600060123塑料风扇件B 13612600060567塑料风扇件B 4614060024水管接头垫片件A 1111111111111111111561560060022A 水管接头件A1111111111111111111WD61易损C 常用B 非常用A序号图号名称单位WD615.38WD615.34990003989308软管卡箍件A4444444444444444444 1061000060276胶管件B1111111111111111111 11614060135节温器总成件B111111111111111111 1161500060116节温器总成件B1161800060172节温器总成件B12612600060518冷却水软管件B1111111111111111111 136********水泵密封垫件B1111111111111111111166********空压机齿轮盖垫片件B11111111111111111111761560010069空压机齿轮盖件A1111111111111111111 1861560060069张紧轮总成件A1111111111111111111 1990011400001六角法兰面螺栓件A1111111111111111111 2199100590009右支架件A111111 2390003802424六角头螺栓件A17171717171717171717171717171717171717 2490003800467六角头螺栓件A555555555555555555525900038884522型全金属六角锁紧螺母件A333333333333333333326900038884512型全金属六角锁紧螺母件A66666666666666666662790003932023波形弹性垫圈件A12121212121212121212121212121212121212 2890003931102弹簧垫圈件A33333333九、水泵 Water Pump132511008002113251100800221325310080001141711008000414171100800141418310007001141831000800114251100800081425110080018142511008000214251100800121425110008001142511000901011319100800031325110080018132511008002513311100800021331110080012133211008000634N0035J 34N003534Q1602J 34Q1449J 34Q144934Q1442J 34Q1470J 34Q1445J 34Q144538Q1256J 38Q125638Q1137J 38Q113744Q124244Q143844N003444Q1406J 44Q140644Q1251J61560060050水泵总成件B 111111111111111111161800061007水泵总成件B 612600060569水泵总成件B 161500060234水泵体件A 1111111111111111111261500060249叶轮件A 1111111111111111111361500060124皮带轮件A 11111111111111111114612600060539水封总成件A1111111111111111111WD61WD615.38易损C 常用B 非常用A名称单位WD615.34序号图号5612600060584水泵加黄油装置件A1111111111111111111 661500060248泵轴件A1111111111111111111 761500060251支撑套件A1111111111111111111 8612600060538锥端紧定螺钉件A2222222222222222222 990003310067向心球轴承件A2222222222222222222 1090016040012圆柱滚子轴承件A1111111111111111111 1161500060237防护圈件A1111111111111111111十、张紧轮 Tensioning Roller13251100800213251100800221325310080001141711008000414171100800141418310007001141831000800114251100800081425110080018142511008000214251100800121425110008001142511000901011319100800031325110080018132511008002513311100800021331110080012133211008000634N0035J 34N003534Q1602J 34Q1449J 34Q144934Q1442J 34Q1470J 34Q1445J 34Q144538Q1256J 38Q125638Q1137J 38Q113744Q124244Q143844N003444Q1406J 44Q140644Q1251J61560060069张紧轮总成件A 1111111111111111111161560060070张紧轮件A 1111111111111111111461560060074防护圈件A 2222222222222222222590016020017深沟球轴承件B 1111111111111111111661560060073隔套件A 1111111111111111111易损C 常用B 非常用AWD615.34WD615.38WD61序号图号名称单位十一、机油泵 Oil Pump132511008002113251100800221325310080001141711008000414171100800141418310007001141831000800114251100800081425110080018142511008000214251100800121425110008001142511000901011319100800031325110080018132511008002513311100800021331110080012133211008000634N0035J 34N003534Q1602J 34Q1449J 34Q144934Q1442J 34Q1470J 34Q1445J 34Q144538Q1256J 38Q125638Q1137J 38Q113744Q124244Q143844N003444Q1406J 44Q140644Q1251JAZ1500070021A 机油泵总成件A 111111111111111111161800071010机油泵总成件A 6614070055机油泵垫片件A 1111111111111111111761500070082集滤器总成件A 111111111117612600070180集滤器总成件A 111111761800070051集滤器总成件A 7612600070125集滤器总成件A图号名称单位易损C 常用B 非常用AWD615.34WD615.38WD61序号8614070078垫片件A1111111111111111111 9614070061机油泵中间齿轮件A1111111111111111111 1090003311410向心球轴承件A2222222222222222222 11614070049中间隔圈件A1111111111111111111290003934732带凸齿的孔用挡圈件A1111111111111111111136140756中间齿轮轴件A1111111111111111111 14614070155密封圈件A1111111111111111111AZ1500070097机油泵限压阀总成件A111111111111111111115AZ1500070096阀体件A1111111111111111111 16407070032限压阀件A1111111111111111111 174139070059弹簧件A1111111111111111111 2290003802578S六角头螺栓件A1111111111111111111 2490003802523S六角头螺栓件A1112590003930271平垫圈件A22222222222222222222690003862443内六角圆柱头螺钉件A22222222222222222222890003931122弹簧垫圈件A1111111111111111111十二、机油滤清器和机油冷却器 Oil Filter and Oil Cooler13251 10080 02113251100800221325310080001141711008000414171100800141418310007001141831000800114251100800081425110080018142511008000214251100800121425110008001142511000901011319100800031325110080018132511008002513311100800021331110080012133211008000634N00 35J 34N003534Q1602J34Q1449J34Q144934Q1442J34Q1470J34Q1445J34Q144538Q1256J38Q125638Q1137J38Q113744Q124244Q143844N003444Q1406J44Q140644Q1251J161500070051机油滤清器底座组件件A1111111111111111111261000070005旋转式机油滤芯总成件B2222222222222222222WD61WD615.34WD615.38序号图号名称单位易损C常用B非常用A361500010334机油冷却器（8片）件A1111111111111111111361800010113机油冷却器芯总成(9片)件A481400010032密封圈件B2222222222222222222590003962051轻型六角头圆柱螺塞件B11111111111111111117614070068安全阀弹簧件B1111111111111111111 8614070069安全阀件B1111111111111111111AZ1500070097主油道限压阀总成件B11111111111111111119AZ1500070096阀体件B1111111111111111111 124139070059弹簧件B1111111111111111111 134********弹簧座件B1111111111111111111 14AZ9003930012弹性挡圈件B11111111111111111111590003862443内六角圆柱头螺钉件B22222222222222222221690003932023波形弹性垫圈件B121212121212121212121212121212121212121790003862482内六角圆柱头螺钉件B2222222222222222222十三、喷油泵和高压油管 Injection pump and Injection Pipes13251 10080 021132511008002213253100800011417110080004141711008001414183100070011418310008001142511008000814251100800181425110080002142511008001214251100080011425110009010113191008000313251100800181325110080025133111008000213311100800121332110080006WD61WD615.38WD615.34序号图号易损C常用B非常用A 名称单位常用B 位非常用A十四、油管 Fuel Line十五、联轴器 Coupling十六、电气系统 Electrical System十七、火焰预热系统 Flame Starter System132511008002113251100800221325310080001141711008000414171100800141418310007001141831000800114251100800081425110080018142511008000214251100800121425110008001142511000901011319100800031325110080018132511008002513311100800021331110080012133211008000634N0035J 34N003534Q1602J 34Q1449J 34Q144934Q1442J 34Q1470J 34Q1445J 34Q144538Q1256J 38Q125638Q1137J 38Q113744Q124244Q143844N003444Q1406J 44Q140644Q1251J1612600090080温度传感器件B 1111111111614090067温度传感器件B 2612600090082电磁阀件B 1111111113612600090081火焰预热电热塞件B 222222222790003962607空心螺栓件B 222222222881560080212空心螺栓件B 1111111119609E110070联接螺栓件B 11111111113612600090075角形支架件A111111111易损C 常用B 非常用AWD615.34WD615.38序号图号名称单位WD61十八、进气系统 Air Intake System（STEYR）十九、排气系统 Exhaust System（STEYR）132511008002113251100800221325310080001141711008000414171100800141418310007001141831000800114251100800081425110080018142511008000214251100800121425110008001142511000901011319100800031325110080018132511008002513311100800021331110080012133211008000634N0035J 34N003534Q1602J 34Q1449J 34Q144934Q1442J 34Q1470J 34Q1445J 34Q144538Q1256J 38Q125638Q1137J 38Q113744Q124244Q143844N003444Q1406J 44Q140644Q1251J1612600111290前排气歧管件A 1111111111111161560110221前排气歧管件A 111111615G60110120前排气歧管件A 11612600111991一二缸排气歧管件A 1612600111992三四缸排气歧管件A 1612600111993五六缸排气歧管件A 2612600110866后排气歧管件A 1112612600110855后排气歧管件A 1111112612600111712后排气歧管件A 1111261560110222后排气歧管件A 111112612600110178后排气歧管件A 12612600111280后排气歧管件A 3612600110856前隔热罩件A 11111111111114612600110857后隔热罩件A 1111111111111661260110162排气管密封环件A 4444444444444444444761560110242排气管垫片件A 6666666666666666666861560110104排气管固定螺栓件A 11111111111111111111111111111111111111961560110105排气管固定螺栓件A 111111361560116227废气涡轮增压器件A111111名称单位易损C 常用B 非常用AWD615.34WD61WD615.38序号图号二十、单缸空气压缩机 Single Cylinder Air Compressor132511008002113251100800221325310080001141711008000414171100800141418310007001141831000800114251100800081425110080018142511008000214251100800121425110008001142511000901011319100800031325110080018132511008002513311100800021331110080012133211008000634N0035J 34N003534Q1602J 34Q1449J 34Q144934Q1442J 34Q1470J 34Q1445J 34Q144538Q1256J 38Q125638Q1137J 38Q113744Q124244Q143844N003444Q1406J 44Q140644Q1251J1612600130177空压机总成件A 11111111111111111111612600130206水冷空压机件A 161800130043水冷空压机件A 5612600130173空压机齿轮件A 11111111111111111116609070161支撑环件A 11111111111111111117612600130001六角螺母件A 1111111111111111111 612600130124传动轴总成件A 11111111111111111118612600130122传动轴件A 11111111111111111119612600130123压紧块件A 11111111111111111111090003320154圆柱滚子轴承件A 11111111111111111111161500080158径向止推滚珠轴承件A 111111111111111111112612600130047衬套件A 111111111111111111113612600130073挡油盘件A 111111111111111111114612600130046夹紧螺母件A 11111111111111111111561500080165盖件A 11111111111111111111690003802432S 六角头螺栓件A4444444444444444444WD615.34WD61WD615.38易损C 常用B 非常用A序号图号名称单位。

DHP10Q0168前言为使WP10系列柴油机在使用、维护等工作上的方便特汇编本图册以供我方与用户在使用中查阅参考。

该图册基本上按组绘出了各个零件的图形相互关系。

图序号、件号、数量、中文名称、英文名称等列于明细表栏内。

随着技术和生产的不断发展柴油机的变形将增多故本图册的内容将有所更新。

变化不再另行通知特请用户注意。

用户为获取最新产品信息应咨询潍柴动力股份有限公司。

FOREWORDThis illustrated parts manual is specially prepared for customers to facilitate the use of WP10series diesel engine in operation and tenance.It only includes the main models manufactured in the works at present,with regard to other models,the customers may refer to this catalogue.The illustrations are grouped under the heading of each assembly and numbered individually.Part.No.,Quantity,Model,English designation,Chinese designation and so on are written in the parts listWith the development of technology and production,the versions of the diesel engine will be increased, so the catalogue will be revised.Please pay attention to our revised edition.If you want to get the most newly information about the products,please visit the Website:.目录CONTENTS机体结合组(Engine Block Group) (1)气缸体预装配(Pre-assembled cylinder block) (3)正时齿轮室组件() (5)曲轴结合组(Crankshaft Group) (7)曲轴总成(Crankshaft assembly) (9)活塞连杆结合组(Piston and Connecting Rod Group) (11)连杆总成(Connecting rod assembly) (13)活塞环组件(Piston ring assembly) (15)气缸盖结合组(Cylinder head assembly) (17)气缸盖分总成(Cylinder head subassembly) (19)配气机构结合组(Valve Train Group) (21)凸轮轴总成(Camshaft assembly) (25)EVB排气摇臂组件(EVB Exhaust Rocker Arm Set) (27)进气门摇臂总成(Intake valve rocker arm) (29)中间齿轮总成(Intermediate gear assembly) (31)机油泵结合组(Oil pump assembly) (33)机油泵中间齿轮组件(Oil Pump Idle Gear Assembly) (35)机油冷却器结合组(Oil cooler assembly) (37)共轨系统结合组() (39)电控单元组件() (41)高压油泵结合组(High pressure pump assembly) (43)高压油管组件(High pressure pipe assembly) (45)端盖结合组() (47)油气分离器结合组(Oil-gas Separator Group) (49)油气分离器总成(Oil-gas separator assembly) (51)油尺结合组(Dipstick Group) (53)油标尺总成(Oil dipstick assembly) (55)加油管结合组(Oil Tilling Tube Group) (57)飞轮壳结合组(Flywheel Housing Group) (59)机油冷却器盖组件() (61)飞轮结合组(Flywheel Group) (63)曲轴皮带轮结合组(Crankshaft Pulley Group) (65)气缸盖罩组件() (67)出水管结合组(Water Outlet Pipe Group) (69)节温器结合组(Thermostat Group) (71)水泵结合组(Water pump assembly) (73)水管接头结合组(Water Pipe Connector Group) (75)风扇及轮毂结合组(Fan and Hub Group) (77)涨紧轮及皮带结合组() (79)机油集滤器结合组(Oil Suction Strainer Group) (81)机油滤清器结合组(Oil filter assembly) (83)机油滤清器总成(Oil filter assembly) (85)燃油滤清器结合组(Fuel Filter Group) (87)燃油精滤器组件() (89)精滤器(Fine filter) (91)燃油粗滤器组件() (93)燃油粗滤器(Primary fuel filter) (95)低压油管结合组(Low Pressure Oil pipe Group) (97)电控线束及传感器结合组(Electronic Control System Harness and Sensor Group) (99)电控线束及传感器结合组(Electronic Control System Harness and Sensor Group) (101)转速传感器组件() (103)机油压力传感器组件(Oil Pressure Sensor Set) (105)喷油器结合组(Injector assembly) (107)发电机结合组(Generator Group) (109)发电机支架结合组(Generator Bracket Group) (111)空调压缩机结合组(Air Conditionning Compressor Group) (113)起动机结合组(Starter Motor Group) (115)进气管结合组(Intake Manifold Group) (117)进气管总成(Air inlet pipe assembly) (119)排气管结合组(Exhaust Manifold Group) (121)增压器结合组(Turbocharger assembly) (123)增压器润滑油管结合组(Turbocharger Oil pipe Group) (125)压气机管路结合组(Compressor Pipeline Group) (127)中冷器结合组(Intercooler assembly) (129)空压机结合组(Air Compressor Group) (131)空压机总成(Air compressor assembly) (133)液压泵结合组(Hydraulic Pump Group) (135)油底壳结合组(Oil Pan Group) (137)油底壳总成(Oil pan assembly) (139)发动机支架结合组(Engine Bracket Group) (141)直送零件结合组() (143)WP多级复合沙尘滤() (145)零件箱总成(Parts Kit Assembly) (147)16孔诊断接口插接件(方形)() (149)双油门踏板传感器插接件(主机厂用)(Dual accelerator pedal sensor connecting part) (151)V4插接件(主机厂用)() (153)起动机接插件总成() (155)电磁风扇线圈2插件() (157)燃油水寒宝(Fuel System Protector) (159)图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation1615000101856气缸盖螺栓Cylinder head bolt 26126000107353复合垫圈Washer 3614600700111主油道后螺塞Plug 4900039892881碗形塞Corehole plug 5615000101001后油封Rear oil seal 66126000701601六角螺塞Hexagon plug 76140700681安全阀弹簧Safety valve spring 86140700691安全阀Safety valve 96126300100156气缸套Cylinder liner 109000386242822内六角圆柱头螺钉Inner hexagon screw 116126*********喷嘴总成Nozzle assembly 12900030980156密封垫圈Seal washer 13900039626216空心螺栓Hollow bolt 14900039620501内六角螺塞Inner hexagon plug15AZ150********主油道限压阀总成Pressure limiting valve assembly ofmain oil passage16900038024935六角头螺栓Hexagon bolt 1718825008322自锁垫圈Washer 186126000139182下止推片Thrust washer(lower) 196126000139172上止推片Thrust washer(upper) 20814000100322密封圈Seal washer 21815000100467主轴瓦组件Main Bearing Set 226126000139351气缸体预装配Pre-assembled cylinder block 23900039016046圆柱销Straight pin 24900039096266弹性圆柱销Spring dowel pin 256126000108931气缸盖螺栓Cylinder head bolt 2661500010185S7气缸盖螺栓Cylinder head bolt 27612600012189S7预涂胶紧定螺钉图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation1900039821214碗形塞Corehole plug 26126000134372拉铆钉Tensioned rivet 36126000137471气缸体Cylinder block 4900039892153碗形塞Corehole plug 5900039892894碗形塞Corehole plug 66126000137901曲轴箱Crankshaft case 76140102174主轴承螺栓Main bearing bolt 861401011410主轴承螺栓Main bearing bolt 96126000100513内螺纹圆柱销Inner hexagon pin 106126000109901凸轮轴衬套Camshaft bushing 11615600100296凸轮轴衬套Camshaft bushing 12900039892041碗形塞Corehole plug 13900039892106碗形塞Corehole plug正时齿轮室组件()正时齿轮室组件()图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation1610000101341密封圈Seal washer 22887300611O型密封圈O shaped seal washer 36126000121221正时齿轮室Timing gear case 4900039014182圆柱销Straight pin 5900114300083六角法兰面承面带齿螺栓Hexagon Flange Bolt 66126000134836六角法兰面承面带齿螺栓Hexagon Flange Bolt 7900039620512六角螺塞Hexagon plug 86126000107352复合垫圈Washer 9615000100371前油封Oil seal(front)图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation16126000203731曲轴总成Crankshaft assembly图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation1900039014181圆柱销Straight pin 26126000208651曲轴Crankshaft 36126000203116堵塞Plug46126000200401平键Flat key56126000200361曲轴正时齿轮Timing gear of crankshaft 66126000203351法兰Flange图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation 18156003001212活塞销挡圈Piston pin retainer 2615600300136活塞销Piston pin36126000300206连杆上瓦Connecting Rod Upper Shell 4615600300336连杆下瓦Connecting Rod Lower Shell 5615000300096连杆总成Connecting rod assembly 66126000300686活塞Piston76126000300536活塞环组件Piston ring assembly图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation1615000300771连杆衬套Connecting rod bushing 2615000300081连杆体Connecting rod body 3615000300221连杆盖Connecting rod cover 4815000300232连杆螺栓Connecting rod bolt活塞环组件(Piston ring assembly)活塞环组件(Piston ring assembly)图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation16126000300351梯形桶面环Taper-sided ring 26126000300361扭曲锥面环Conical ring 36126000300371螺旋撑簧油环Spiral spring oil ring图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation 1900114300284六角法兰面承面带齿螺栓Hexagon Flange Bolt 26126000403841后吊板Rear hanger plate 36126000404534气缸盖主螺栓Cylinder head main bolt 46120004003414带肩螺母Nut5612000400274夹紧块Clamping block 661260004011412气门阀杆密封套Seal washer of valve stem 76126000403626气缸盖分总成Cylinder head subassembly 86126000403556气缸盖衬垫Cylinder head gasket 96120004002310夹紧块Clamping block 1061260004045220气缸盖主螺栓Cylinder head main bolt 116126*********前吊板Front hanger plate图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation16126000402356喷油器衬套Injector bushing 26126000402406密封圈Seal washer 36126000402286拉铆钉Tensioned rivet 49000398929424碗形塞Corehole plug 5615600400576进气门座Intake valve seat 6815600400376排气门座Exhaust valve seat 76126000403616气缸盖Cylinder head 8900039897216碗形塞片Corehole plug 9900039892776碗形塞片Corehole plug 10900039897256碗形塞片Corehole plug 1161260004011312气门导管Valve guide图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation19001135006712六角头螺栓Hexagon bolt26126000500286支撑臂Carrying arm36126000500273气门摇臂座总成Valve rocker arm seat assembly 46126000501776进气门摇臂总成Intake valve rocker arm 56150005010512气门帽Valve cap66150005002524气门锁夹Valve collet76150005010912气门弹簧上座Valve spring seat(upper) 86150005000112气门内弹簧Inner valve spring 96150005000212气门外弹簧Outer valve spring 106140500176进气门弹簧下座Intake valve spring seat(lower) 116126000500736进气门Intake valve 1261260005021012推杆Push rod 136150005003212气门挺柱Tappet 146126000500871凸轮轴总成Camshaft assembly 156140500531凸轮轴正时齿轮Camshaft timing gear 16612600050145S4六角头螺栓Hexagon bolt 1761560050059S4六角头螺栓Hexagon bolt 18615600500451垫片Gasket 19615600500581轴Shaft 20615600500531中间齿轮总成Intermediate gear assembly 2190003802399S2六角头螺栓Hexagon bolt 226140501331凸轮轴止推片Camshaft thrust 23615600500441中间齿轮轴Intermediate gear shaft 246126000500411螺纹接头Screw joint 256126000500391空心螺栓Hollow bolt 2661260005004213密封垫圈Seal washer 276126000501231EVB进油长管EVB fuel inlet pipe assembly(long)图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation 286126000501071空心螺栓接头Hollow bolt adapter 29900039320231波形弹性垫圈Wave spiral washer 306126000500885进油短管总成Fuel inlet pipe assembly(short) 316126000500404空心螺栓接头Hollow bolt adapter 326126000500256排气门Exhaust valve 33615000400146排气门弹簧下座Exhaust valve spring seat(lower) 346126*********EVB排气摇臂组件EVB Exhaust Rocker Arm Set 356126000500386调节螺栓总成Adjustment bolt assembly 3621300500656气门间隙调整螺母Valve adjusting nut 37900038024111六角头螺栓Hexagon bolt凸轮轴总成(Camshaft assembly)凸轮轴总成(Camshaft assembly)图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation16126000500241凸轮轴Camshaft 2900039014091圆柱销Straight pin图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation121300500656气门间隙调整螺母Valve adjusting nut 26126000500596排气门摇臂组件Exhaust valve rocker arm 36126000500436气门间隙调节螺钉Valve Adjusting Bolt图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation121300500656气门间隙调整螺母Valve adjusting nut 26140500486进气摇臂Intake Rocker Arm 36140500106气门间隙调整螺钉Valve Adjusting Bolt图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation1615600500521中间齿轮Intermediate gear 2615600500511衬套Bushing图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation16140700551机油泵垫片Oil pump gasket 26126000704841机油泵Oil pump36126000704111六角法兰面承面带齿螺栓Hexagon Flange Bolt 4900114300081六角法兰面承面带齿螺栓Hexagon Flange Bolt 56126000703641机油泵中间齿轮组件Oil Pump Idle Gear Assembly 66140701551密封圈Seal washer761407561中间齿轮轴Intermediate gear shaft 890003802578S1六角头螺栓Hexagon bolt机油泵中间齿轮组件(Oil Pump Idle Gear Assembly)机油泵中间齿轮组件(Oil Pump Idle Gear Assembly)图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation 1900033114102向心球轴承Centripetal ball bearing 2900039347321带凸齿的孔用挡圈Circlip with Teeth for Hole 36140700611机油泵中间齿轮Oil pump intermediate gear 461407491中间隔圈Spacer ring图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation1814000100322密封圈Seal washer 2615000103341机油冷却器Oil cooler 3900039320234波形弹性垫圈Wave spiral washer 490003862419S4内六角圆柱头螺钉Inner hexagon screw图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation16126000806611支架Bracket 2900039311223弹簧垫圈Spring washer 3900038025233六角头螺栓Hexagon bolt 46126300800381共轨管Common rail pipe 5900039320233波形弹性垫圈Wave spiral washer 6900038024373六角头螺栓Hexagon bolt 76126000806601螺钉Screw 86126300801101电控单元组件96126390000504六角头螺栓Hexagon bolt 106126000806591螺钉Screw图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation 1900038623272内六角圆柱头螺钉Inner hexagon screw 26126300800071电控单元ECU36126300802311ECU接地线ECU earthing line 46126300801041ECU线束支架ECU harness wiring bracket 5900039320082波形弹性垫圈Wave spiral washer 69000387123221型六角螺母Hexagon nut(I)图序号件号数量中文名称英文名称Pos.Teile.Number Amount Denomination Designation16126000804521喷油泵齿轮Injection pump gear 26126000804001密封圈Seal washer 390003813532S7双头螺柱Stud46126000804861喷油泵法兰Injection pump flange59000388845272型全金属六角锁紧螺母Prevailing Torque Type All-metalHexagon Nut,66126390000472空心螺栓Hollow bolt 76126000802464密封垫圈Seal washer 86126000703091润滑油进油管组件Oil inlet pipe assembly 96126000806741共轨喷油泵Injection pump高压油管组件(High pressure pipe assembly)。