TC6291C (文件编号：S&CIC1159) 电流型DC-DC 升压器IC概述TC6291C 是一款电流模式升压型DC-DC 转换器。
其脉宽调制电路，内置0.2Ω功率场效应管使这个调节器具有高功率效率。
内部补偿网络也减少了多达6个的外部元件。
误差信号放大器的同相输入端连接到0.6V 精密基准电压，内部软启动功能可以减小瞬间突增电流。
TC6291C 可以封装为SOT23-6，在应用中节省了PCB 空间。
特点可调输出高达12V ；内部固定的脉宽调制频率：1.0MHZ 精准反馈参考电压：0.6V （±2%） 内置0.2Ω, 2A, 16V 的功率场效应管关断电流：0.1µA 过温保护功能可调过流保护：0.5A ~ 2.5A封装：SOT23-6应用充电器 LED 显示屏 数码相机 手持设备 便携式产品引脚示意图及说明TC6291C (文件编号：S&CIC1159) 电流型DC-DC 升压器IC功能框图21DCB0.3V0.6V短路比较器误差放大器UVLO关机电路软启动脉宽调制比较器振荡器斜率补偿OT P控制和驱动逻辑可调电流限制电流检测放大器Σ12345610KΩ - 100KΩ2.5A - 0.5A最大额定值参数 符号 测试条件最小值 典型值 最大值 单位 电源电压 Vcc 0 6 V LX 电压 Vlx 0 16 V EN 、FB 电压0 6 V 功耗 Pd SOT23-6@Ta=25℃455 m W 热阻 θJA SOT23-6+220 ℃/W 结温 Tj +150 ℃ 工作温度 Top -40 +85 ℃ 储存温度 Tst -65 +150 ℃ 管脚温度锡焊，10秒+260℃TC6291C(文件编号：S&CIC1159)电流型DC-DC升压器IC 典型工作特性（Vcc=3.3V，Vout=5V，Ta=25℃，除特殊说明外）效率VS输出电流电流限制VS外部电阻（Roc）工作频率VS输入电压工作频率VS温度参考电压VS输入电压参考电压VS输出电流TC6291C(文件编号：S&CIC1159)电流型DC-DC升压器IC 静态电流VS输入电压平均供电电流VS输入电压功能描述操作TC6291C是电流模式升压转换器。
SSB43L and SSB44Vishay Semiconductorsformerly General SemiconductorDocument Number Mounting Pad Layout• Low power loss, high efficiency• Low profile surface mount package • Built-in strain relief• For use in low voltage high frequency inverters, free wheeling, and polarity protection applications • Guardring for overvoltage protection• Plastic package has Underwriters Laboratory Flammability Classification 94V-0Mechanical DataCase:JEDEC DO-214AA molded plastic bodyTerminals:Solder plated, solderable per MIL-STD750,Method 2026High temperature soldering guaranteed: 250°C/10 seconds at terminalsPolarity:Color band denotes cathode end Weight:0.003 oz., 0.093 gDO-214AA (SMB)Maximum Ratings and Thermal Characteristics (TA= 25°C unless otherwise noted)ParameterSymbol SSB43L SSB44Unit Device marking code43L S44Maximum repetitive peak reverse voltage V RRM 3040V Maximum RMS voltage V RMS 2128V Maximum DC blocking voltageV DC 3040V Max. average forward rectified current at T L (See Fig. 1)I F(AV) 4.0A Peak forward surge current 8.3ms single half sine-wave superimposed on rated load (JEDEC Method)I FSM 100A Typical thermal resistance (2)R θJA 70R θJL 23°C/W Voltage rate of change (rated V R )dv/dt 10,000V/µs Operating junction temperature range T J –65 to +150 °C Storage temperature rangeT STG–65 to +150°CElectrical Characteristics (TA= 25°C unless otherwise noted)ParameterSymbol Typ.Max.Typ.Max.Unit Maximum instantaneous T J = 25°C V F0.430.450.450.49Vforward voltage at 4.0A (1)T J = 125°C 0.330.380.370.42Maximum DC reverse current (1)T J = 25°C –0.6–0.4at rated DC blocking voltageT J =125°CI R35452540mANotes:(1) Pulse test: 300µs pulse width, 1% duty cycle(2) Aluminum substrate mountedHigh-Current Density Surface Mount Schottky RectifierNew ProductReverse Voltage 30 & 40VForward Current 4.0ASSB43L and SSB44Vishay Semiconductorsformerly General Semiconductor Document Number 88884Ratings andCharacteristic Curves (T A = 25°C unless otherwise noted)Fig. 5 – Typical JunctionCapacitanceReverse Voltage (V)123456Fig. 1 – Forward CurrentDerating CurveA v e r a g e F o r w a r d C u r r e n t (A )Fig. 2 – Maximum Non-Repetitive Peak Forward Surge Current0.010.10.10.20.30.40.60.70.50.8110100Instantaneous Forward Voltage (V)I n s t a n t a n e o u s F o r w a r d C u r r e n t (A )Percent of Rated Peak Reverse Voltage (%)p F - J u n c t i o n C a p a c i t a n c e11010010010001000010。
发动机零部件名称(中英文对照).Cylinder Black气缸体 ACHA0277Cylinder Black气缸体 ACHA0277Item Fam No Part No Pt name Qty Description图示序号组件号零件号零件名称数量描述1 AC10A 004 T3711K054Z 机体总成 1 Cylinder block assembly2 T3711K054 机体 1 Cylinder block3 T3135X063 气缸套 6 Liner4 T32166329 大瓦螺栓14 Bolt5 T3271H004 介轮轴 1 Idler shaft6 GB879-76 6x26 销 1 Dowel Φ6x267 T3774A004 挺杆腔堵 6 Plug8 T33142111 定位套14 Thimble9 T32418122 碗堵12 Plug10 T3133K041 瓦盖 1 Bearing cap11 T3133K002 瓦盖 2 Bearing cap12 T3133K032 瓦盖 1 Bearing cap13 T3133K031 瓦盖 1 Bearing cap14 T3133K003 瓦盖 1 Bearing cap15 T3133K004 瓦盖 1 Bearing cap16 AC10A 064 T31134165 衬套 1 Bush17 AC10A 115 T32416119 堵 1 Plug18 AC10A 121 T32417134 堵 1 Plug19 AC10A 124 T64404002 堵 1 Plug20 AC10A 325 T32168212 堵 1 Plug21 AC10A 328 T72101002 垫圈 1 Washer22 AC10A 373 T2418F701 后油封壳 1 Rear housing23 AC10A 400 T3211C002 螺栓 6 Screw24 AC10A 439 T3211C002 螺栓 4 ScrewTiming Gear& Camshaft正时齿轮及凸轮轴 ACHA0277Timing Gear& Camshaft正时齿轮及凸轮轴 ACHA0277Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 AC10B 037 T2314H003 螺栓8 Screw2 AC10B 040 T2314H034 螺栓 4 Screw3 AC10B 277 T3716M091B 前盖 1 Front cover4 AC10B 277 T2418F436 密封圈 1 Seal5 AC10B 316 T2314H005 螺栓9 Screw6 AC10B 320 T2314H004 螺栓 1 Screw7 AC10B 325 T2314H034 螺栓 1 Screw8 AC10B 350 T2314H034 螺栓 2 Screw9 AC10B 436 T2314H013 螺栓 6 Screw10 AC10B 508 T62204001 检查盖 1 Inspection cover11 AC10B 508 T62004002 垫 1 Joint12 AC10B 511 T2314F036 螺栓 4 Screw13 AC10B 560 T3781N042 减震垫 1 Damping Joint14 AC10B 561 T3781N043 隔音板 1 Noiseshield Plate15 AC10B 563 T2314F003 螺栓 2 Screw16 AC10J 004 T0500012 键 1 Key17 AC10J 007 T3117C061 齿轮 1 Gear18 AC10J 013 T33426161A 轮毂 1 Hub19 AC10J 031 T4111A013 齿轮组件 1 Gear assy.20 T3117L061 齿轮 1 Gear21 T0050345 衬套 2 Bush22 AC10J 054 T3241H009 板 1 Plate23 AC10J 069 T2314J010 螺栓 3 ScrewTiming Gear& Camshaft正时齿轮及凸轮轴 ACHA0277Timing Gear& Camshaft正时齿轮及凸轮轴 ACHA0277Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述24 AC10J 129 T4111A008 齿轮 1 Gear25 T3117C041 齿轮 1 Gear26 T2511437 衬套 1 Bush27 AC10J 144 T33123125 垫圈 1 Washer28 AC10J 150 T2722A206 卡簧 1 Circlip29 AC10J 183 T33153121 盖板 1 Cover plate30 AC10J 189 T2116053 销子 1 Dowel31 AC10J 195 T0500012 键 1 Key32 AC10J 201 T3117L023 齿轮 1 Gear33 AC10J 207 T2314J606 螺栓 1 Screw34 AC10J 214 T3321A003 垫圈 1 Washer35 AC10J 180 T31416308 凸轮轴 1 Camshaft36 AC10B 001 T3681P009 垫 1 Joint37 AC10B 274 T3681P034 垫 1 Joint38 AC10B 010 T3716C133A 正时齿轮室 1 Timing caseCrankshaft Pistons & Connecting Rods曲轴，活塞及连杆 ACHA0277Crankshaft Pistons & Connecting Rods曲轴，活塞及连杆 ACHA0277Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 AC10C 005 T3131H022 曲轴 1 Crankshaft2 AC10C 044 T3111V005 轴瓦 1 Bearing3 AC10C 046 T3111V014 轴瓦 1 Bearing4 AC10C 049 T3111V005 轴瓦 4 Bearing5 AC10C 052 T3111V014 轴瓦 4 Bearing6 AC10C 055 T3111X011 轴瓦 1 Bearing7 AC10C 058 T3111X005 轴瓦 1 Bearing8 AC10C 061 T3111V005 轴瓦 1 Bearing9 AC10C 064 T3111V014 轴瓦 1 Bearing10 AC10C 067 T31137551 止推片 2 Thrust washer11 AC10C 070 T31137561 止推片 2 Thrust washer12 AC10D 005 T3135J181ETC 活塞 6 Piston13 AC10D 008 T4181A026 活塞环组件 6 Piston ring assy.14 T3136J051 气环 1 Compression ring15 T3136X021 气环 1 Compression ring16 T3137N021 油环 1 Scrape ring17 AC10D 019 T3313T005 活塞销 6 Piston pin18 AC10D 022 T2721332 卡簧12 Circlip19 AC10D 028 T4115C211 连杆组件 6 Connecting rod assy.20 T3133R001 连杆 1 Connecting rod21 T3133V001 盖 1 Cover22 T32186142 螺栓 2 Screw23 T2135A001 定位销 2 Thimble24 T3112E005 衬套 1 Bush25 AC10D 055 T31132011 轴承12 BearingCylinder Head气缸盖 ACHA02772Cylinder Head气缸盖 ACHA0277Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 AC10E 004 T3681H208A 缸盖垫 1 JointAC10E 004 T72505009 缸盖垫 1 Joint2 AC10E 005 TC3712L042Z 缸盖总成 1 Cylinder head assy.3 T3712L042 缸盖 1 Cylinder head4 T3342E003 进气阀座 6 Inlet valve seat5 T3314A122 排气阀座6 Exhaust valve seat6 T2431154 堵 2 Plug7 T0650586 堵 6 Plug8 T0650203 堵 1 Plug9 T2411157 垫圈 1 Washer10 T0650710 碗堵 3 Plug11 T32417156 出沙孔堵 6 Plug12 AC10E 037 T3343F041 气门导管 6 Guide13 AC10E 040 T3343J021 气门导管 6 Guid14 AC10E 064 T2114A046 定位套 2 Thimble15 AC10E 100 T32166219 螺栓12 Screw16 AC10E 103 T32166221 螺栓18 Screw17 AC10E 106 T32166222 螺栓 2 ScrewRocker Shaft摇臂轴 ACHA0277Rocker Shaft摇臂轴 ACHA0277Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 AC10F 001 T3142L072 进气阀 6 Inlet valve2 AC10F 004 T33817117 密封套 6 Seal3 AC10F 007 T31745122 弹簧 6 Spring4 AC10F 010 T31744133 弹簧 6 Spring5 AC10F 013 T33415118 垫圈6 Washer6 AC10F 016 T33424107 进气阀弹簧座 6 V alve cap7 AC10F 019 T33173108 气门锁夹12 Cotter8 AC10F 025 T3142A051 排气阀 6 Exhaust valve9 AC10F 028 T33817117 密封套 6 Seal10 AC10F 031 T31745122 弹簧 6 Spring11 AC10F 034 T31744133 弹簧 6 Spring12 AC10F 037 T33415118 垫圈 6 Washer13 AC10F 043 T33424107 排气阀弹簧座 6 V alve cap14 AC10F 046 T33173108 气门锁夹12 Cotter15 AC10F 052 T2313H331 双头螺栓 4 Stud16 AC10F 058 T2318A605 螺母 4 Nut17 AC10F 061 T2314J607 螺栓 2 Screw18 AC10F 070 T3818X901 支架 6 Bracket19 AC10F 082 T31411147 摇臂轴 1 Rocker shaft20 AC10F 091 T0650507 堵 2 Plug21 AC10F 103 T4115R306 左摇臂组件 6 Rocker level LH22 AC10F 109 T4115R305 右摇臂组件 6 Rocker level RH23 AC10F 127 T32114145 螺栓12 ScrewRocker shaft摇轴轴 ACHA0277Rocker shaft摇臂轴 ACHA0277Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述24 AC10F 130 T0576052 螺母12 Nut25 AC10F 133 T31744123 弹簧 4 Spring26 AC10F 136 T31743108 弹簧 2 Spring27 AC10F 163 T33117434 垫圈 2 Washer28 AC10F 166 T0170151 卡簧 2 Circlip29 AC10J 239 T3142U031 挺柱12 Tappet30 AC10J 257 T31434307 推杆12 Push rod31 AC20N 011 T3775E012 接头 1 Connection32 AC20N 020 T2233022 螺栓 1 Screw33 AC20N 023 T33811113 橄榄体 1 Olive34 AC20N 025 T3311K015 垫片 2 WasherLubricating Oil Pump润滑油泵 ACHA0277Lubricating Oil Pump润滑油泵 ACHA0277Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 AC20B 007 T4132F057 机油泵 1 Lub.Oil Assy.T3771M085 泵体 1 BodyT3753R101 盖板 1 Cover plateT2314C044 螺栓 4 ScrewT3117A038 齿轮 1 GearT2511852 衬套 1 BushT2488C509 转子 1 Rotor2 AC20B 175 T2314H004 螺栓 2 Screw3 AC20B 179 T2314H002 螺栓 1 Screw4 AC20D 046 T4138A033 限压阀 1 Relief valve5 T32712726 柱塞 1 Plunger6 T31744151 弹簧 1 Spring7 T32712111 弹簧座 1 Seat8 T2721130 卡簧 1 Circlip9 T3775L044 泵体 1 Body10 AC20D 127 T2314K161 螺栓 2 Screw11 AC20G 001 T3571C045 油管 1 Oil pipe12 T3617A005 法兰 1 FlangeT2415H496 O 型圈O Ring14 T3571C046 管 1 Pipe15 AC20G 076 T2314H004 螺栓 2 Screw16 AC20G 084 T2314H004 螺栓 2 Screw17 AC20L 456 T3861A027 冷却喷嘴 6 Cooling Jet18 T3317A009 喷嘴 1 NozzleLubricating Oil Pump润滑油泵 ACHA0277Lubricating Oil Pump润滑油泵 ACHA0277Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述19 AC20L 500 T4138A017 冷却喷嘴阀 6 Cooling Jet V alve20 T33537008 阀体 1 Body21 T3174A004 弹簧 1 Spring22 T2538753 球 1 Ball23 T3271A003 座 1 RetainerFuel Injection Equipment燃油喷射系统 ACHA0277Fuel Injection Equipment燃油喷射系统 ACHA0277Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 AF**** T73208265 喷油泵 1 Drive gear2 AF**** T3117L113G 齿轮 1 Fuel pump3 AF**** T33828108A 垫 2 Joint4 AF**** T3821D014A 支架 1 Bracket5 AF**** T3821A014B 支架 1 Bracket6 AF**** T2314J002 螺栓M10X20 2 Screw7 AF**** T2314J003 螺栓M10X25 2 Screw8 AF**** T2131A008A 垫圈 1 Washer9 AF**** T2314H005 螺栓M8X30 1 Screw10 AF**** Q1201030F3S 双头螺柱 4 Stud11 AF**** GB6170-86M10 螺母M10 4 Nut12 AF**** GB93-87D10 垫圈10 4 Washer13 AF**** T63806001B 喷油泵润滑油管 1 Lubricating oil pipe14 AF17M 002 T4184K012F 油管 1 High pressure pipe15 AF33G 030 T4126K081B 补偿管 1 Compensating pipe16 AF33G 041 T0201047 弯管头 1 Connection17 AF**** T33225412 螺母 1 Nut18 AF**** T33811112 橄榄体 1 Olive19 AF17N 001 T3558X039 油管 1 Oil return pipe20 AF17N 034 T3218R005 过油螺栓 5 Oil-pass screw21 AF17N 043 T3355V002 过油螺栓 1 Oil-pass screw22 AF17N 049 T2411101 垫圈12 Washer23 QD30Z 001 T3355M005B 三通接头 1 Connection24 QD30Z 002 T0920155 垫片 2 WasherFuel Injection Equipment燃油喷射系统 ACHA0277Fuel Injection Equipment燃油喷射系统 ACHA0277Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 AF17E 001 T63301004 喷油器总成 6 Atomizer assy.2 AF17E 004 T3662K002 压板 6 Clamp3 AF17E 008 T2314H006 螺栓12 Screw4 AF17E 007 T0921173 垫圈 6 Washer5 AF17E 037 T33813131 密封圈6 Seal6 AF17E 035 T33813129 隔圈 6 Spacerlywheel Hosing飞轮壳 CDH00865Flywheel Hosing飞轮壳 CDH00865Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 CD**** T73639002 飞轮壳 1 Flywheel housing2 CD**** T36843154 密封条 1 Seal3 CD**** T73631005 盖板 1 Cover plate4 CD**** GB5783-86M6X10 螺栓 2 Screw5 CD**** GB93-87D6 弹簧垫圈6 2 Washer6 CD30A T2314J204 飞轮壳螺栓 6 Screw7 CD30A T2314J607 螺栓 2 Screw8 CD30A T0350025 销子 2 Dowel9 CD30A GB5783-86M12X45 飞轮壳螺栓 2 Screw10 CD30A GB93-87D16 弹簧垫圈 6 Washer11 CD30A GB93-87D12 弹簧垫圈 2 Washer1006-6TRTK01/KA01 Flywheel & Starter Ring1006-6TRTK01/KA01 飞轮及启动齿圈 DDH01188Flywheel & Starter Ring飞轮及启动齿圈 DDH01188Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 DD30B 004 T73639100K1 飞轮部 1 Flywheel assy.2 T73639001 飞轮 1 Flywheel3 T31162121B 齿圈 1 Starter ring4 DD30B 019 T2185103 飞轮螺栓10 Screw5 DD30B 031 T33117127 垫圈10 Washer6 DD**** GB/T276-94-6304-2Z 轴承6205 1 Bearing1006-6TRTN01/NA01 Flywheel & Starter Ring1006-6TRTN01/NA01飞轮及启动齿圈 DDH01188Flywheel & Starter Ring飞轮及启动齿圈 DDH01188Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 DD30B 004 T73639100 飞轮部 1 Flywheel assy.2 T73639001 飞轮 1 Flywheel3 T31162121 齿圈 1 Starter ring4 DD30B 019 T2185103 飞轮螺栓10 Screw5 DD30B 031 T33117127 垫圈10 Washer6 DD**** GB/T276-94-6304-2Z 轴承6205 1 BearingGenerator启动电机 EDGenerator启动电机 EDItem Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 ED**** T2313C077 双头螺栓 3 Stud2 ED**** GB6170-86M10 螺母3 Nut3 ED**** GB93-87-10 弹簧垫圈 3 Spring washer4 ED**** T63701007 起动电机 1 GeneratorFan Drive风扇驱动装置 FBH00001Fan Drive风扇驱动装置 FBH00001Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 FB10B *** T4113H052 风扇驱动支架 1 Bracket2 FB10B *** T2314J014 螺栓 4 Screw3 FB10B *** T63906002 皮带轮 1 Pulley4 FB10B 034 T74402030 皮带 2 Belt5 MD22B T64406012 风扇 1 Fan6 MD22B T3748W241 隔圈 1 Extention7 MD22B 014 T2314H020 螺栓 4 Screw8 MD22B 014 GB93-87D8 垫圈8 4 WasherLubricating Oil Sump润滑油底壳 GBH01372Lubricating Oil Sump GBH01372润滑油底壳Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 GB10A 025 T3627P024 桥架 1 Bridge piece2 GB10A 035 T2311D039 螺栓 2 Screw3 GB20A 043 T2431A016 堵 1 Plug4 GB20A 052 T32186405 堵 2 Drain plug5 GB20A 059 T2415715 O型圈 2 O Ring6 GB20A 088 T3681M007 油底垫 1 Joint7 GB20A 001 T73803103A 油底 1 Oil sump8 GB**** GB5783-86M16X45 螺栓 6 Screw9 GB20A 200 T2314H006A 螺栓 2 Screw10 GB20A 205 T2314H008A 螺栓7 Screw11 GB20A 208 T2314H009A 螺栓 4 Screw12 GB20A 211 T2314H012A 螺栓 5 Screw13 GB20A 200 T2314H023A 螺栓 6 Screw14 GB20A 205 T2314H026A 螺栓 4 Screw15 GB20F 013 T3575K006 吸油管 1 Suction pipe16 GB20F 025 T3683H005 垫 1 Joint17 GB20F 034 T2314H004 螺栓 2 Screw18 GB20F 055 T2314H002 螺栓 1 Screw19 GB33V 004 T3577A125 油尺管 1 Dipstick tube20 GB33V 022 T33812116 橄榄体 1 Clive21 GB33V 130 T3178C076 油尺 1 Dipstick22 ZZ****** T76001041 左支脚 123 ZZ****** T76001042 右支脚 124 ZZ****** T73802112 过渡板 1Cover Plate盖板 ZJH00440Cover Plate盖板 ZJH00440Item Fam No Part No Part name Qty Description图示参号组件号零件号零件名称数量描述1 ZZ23F 004 T0650586 堵 1 Plug2 HB10B 586 T3617A001 板 1 Plate3 HB10B 586 T3683H006 垫 1 Washer4 HB10B 589 T2314H003 螺栓 2 Screw5 HB10B 220 T74001002 加油口 1 Filler6 HB10B 220 T74001003 加油口盖 1 Filler cap7 HB10B 583 T3683H006 加油口垫 1 Joint8 HB10B 241 T2314H010 螺栓 1 Screw9 HB10B 241 T2314H007 螺栓 1 Screw10 HB10B GB1235-76D38X3.1 O型圈 1 O ring11 HB**** GB93-87D8 垫圈8 2 WasherCylinder Head Cover气缸盖罩 HBH02617Cylinder Head Cover气缸盖罩 HBH02617Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 HB10G 001 T3681C001 垫 1 Joint2 HB10G 006 T3718X717 缸盖罩(总成) 1 Cylinder head cover3 HB10G 040 T3274A003 螺母4 Nut4 HB10G 042 T0920009 垫圈 4 Washer5 HB10G 043 T33817135 密封垫 4 Seal6 HB10G 142 T3381J002 密封圈 1 O ring7 HB10G 145 T3781A003 加油口盖 1 Oil filler cover8 HB10G 146 T74001211 油气分离器 1 Oil air separator9 HB10G 147 T74001212 支架 1 Bracket10 HB10G 148 T2314H002 螺栓 2 Screw11 HB10G 149 T2318A603 螺母 2 Nut12 HB10G 150 T74001214 胶管 1 Hose13 HB10G 151 T2481877A 卡子 3 Clip14 HB10G 152 T73802115 胶管 1 Hose15 HB10G 153 T0180063A 卡子 2 Clip16 HB10G 154 T74001215 胶管 1 Hose17 HB10G 156 T73802114 接头 1 Connection18 HB10G 157 T73802101 垫圈 1 Washer19 HB10G 159 T73802103 铰接螺栓 1 Screw20 HB15D 443 T36241123 支架 1 Bracket21 HB20K 001 T3571C014 油管 1 Oil pipe22 HB20K 004 T36833152 垫 1 Joint23 HB20K 007 T2314H003 螺栓 2 ScrewLubricating Oil Filter润滑油滤清器 JBH01149Lubricating Oil Filter润滑油滤清器 JBH01149Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 JB20C 016 T64101001 机油滤清器2 Lub.oil filter2 JB20C 064 T3687W006 垫 1 Joint3 JB20C 079 T4134E031 机滤座 1 Lub.oil head4 JB20C 106 T2314J003 螺栓5 Screw5 JB20L 156 T3686T006 垫 1 Joint6 JB20L 182 T3766P092 接头 1 Adaptor7 JB20L 185 T2314J007 螺栓 1 Screw8 JB20L 187 T2314J003 螺栓 3 Screw9 JB20M 230 T3686A511 垫 1 Joint10 JB20M 233 T2418F602 密封垫 2 Seal11 JB20M 235 T75004281 油管 1 Oil pipe12 JB20M 236 T75004282 油管 1 Oil pipe13 JB20M 240 T2314H004 螺栓 3 Screw14 JB20M 245 T3751K121 法兰 4 Flange15 JB20M 246 T2318A603 螺母 4 Nut16 JB22H 001 T2486A993 油冷器 1 Oil cooler17 JB22H 337 T3688X008 密封垫 2 Joint18 JB22H 338 T2486A990 油冷器壳 1 Oil cooler housing19 JB22H 340 T3684N028 垫 1 Joint20 JB22H 347 T2314H002 螺栓11 Screw21 JB22H 348 T0920146 垫圈14 Washer22 ZA**** T73201640 油门拉线支架 1 Bracket23 ZA**** T2314H034 螺栓 2 Screw24 ZA**** T33134427 隔块 2 SpacerFront End Drive Input前端驱动输入 KBH00575Front End Drive Input前端驱动输入 KBH00575Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量英文描述1 KB10L 013 T0500005 键 1 Key2 KB10L 019 T3115T043 皮带轮 1 Pulley3 KB10L 080 T3311X002 隔圈 1 Spacer4 KB10L 083 T2417711 锁片 1 Cotter5 KB10L 086 T32418313 止推块 1 Block6 KB10L 089 T2415638 O 型圈 1 O Ring7 KB10L 092 T32186137 螺栓 3 ScrewWater Pump & Thermostat水泵及节温器 LBH01659Water Pump & Thermostat水泵及节温器 LBH01659Item Fam No Part No Part name Qty Description图示参号组件号零件号零件名称数量英文描述1 LB10E 140 T3685R005 垫 1 Joint2 LB10E 143 T3755k007 盖板 1 Cover plate3 LB10E 156 T2314H002 螺栓 3 Screw4 LB22C 049 T4131E011C 水泵 1 Water pump5 T2531A112 轴 1 Shaft6 T2415B155 O型圈 1 O Ring7 T3771D045 泵体 1 Body8 T2418M006A 密封圈 1 Seal9 T3117A035 齿轮 1 Gear10 T3746X055A 叶轮 1 Impeller11 T3243C002 盖 1 Cover12 LB22C 143 T2415H494 O 型圈 1 O Ring13 LB22C 145 T2314H015 螺栓 1 Screw14 LB22C 176 T2314N043 螺栓 3 Screw15 LB22C 177 T2314H008 螺栓 1 Screw16 LB22C 178 T2314H006 螺栓 1 Screw17 LB22D 007 T74405005 节温器 2 Thermostat18 LB22D 028 T3685F005 垫 1 Joint19 LB22D 124 T2314J013 螺栓 2 Screw20 LB22D 136 T2314H015 螺栓 1 Screw21 LB22D 160 T2314H008 螺栓 2 Screw22 LB22P 095 T3781D041C 接头 1 ConnectionLB22P 095 T3764E061 接头 1 Connection23 LB22P T2431154 堵 1 Plug24 LB22P 097 T3683N004 垫 1 JointWater Pump & Thermostat水泵及节温器 ACHA0277Water Pump & Thermostat水泵及节温器 ACHA0277Item Fam No Part No Part name Qty Description图示参号组件号零件号零件名称数量英文描述25 LB22P 100 T2314H004 螺栓 2 Screw26 LB22P 110 T33854114 胶管 1 Hose27 LB22P 112 T0180067 卡子 2 Clip28 LD**** T62204004 接头 1 Connection29 XB10E 004 T2314J002 螺栓 2 Screw30 XB22D 007 T2314J004 螺栓 2 Screw31 LB22P T2431154 堵 1 Plug32 LB22D 040 T3771K121E 节温器壳体 1 Thermostat housing body Water Outlet & Inlet水出口及入口 LDH00439Water Outlet & Inle水出口及入口 LDH00439Item Fam No Part No Part name Qty Description图示参号组件号零件号零件名称数量英文描述1 LD22P 006 T3771K043 出水口 1 Water outlet2 LD22P 007 T3684A004 垫 1 Joint3 LD22P 040 T2314H010 螺栓4 Screw4 LD22P 041 T2314H008 螺栓 2 Screw1006-6TRT125N01/NA01 Alternator & Generator1006-6TRT125N01/NA01 交流发电机及发电机 NDH01533Alternator & Generator交流发电机及发电机 NDH01533Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 ND10B 008 T2314H013 螺栓 1 Screw2 ND24A 004 T64501023 发电机 1 Alterator3 ND24A 054 T2314H007 螺栓 1 Screw4 ND24A 109 T0920497 垫圈 4 Washer5 ND24B 136 GB93-87D8 弹簧垫圈8 2 Spring washer6 ND24B 136 GB6170-86M8 螺母 2 Nut7 ND24A 94 T2314H008 螺栓 1 Screw8 ND24A 133 T2314J006 螺栓M10X40 Screw9 ND24B 136 T2131A010 平垫10 1 Washer10 ND24A 136 GB6170-86M10 螺母M10 Nut11 ND24B 004 T74502206B 支架 1 Bracket12 ND24B 016 T3827H025B 支架 1 Bracket13 ND24B 127 T2314J003 螺栓 1 Screw14 ND24B 165 T2314H002 螺栓 4 Screw15 ND24B 322 T3753V014B 调节杆 1 Adjustment level16 ND24B 192 T3753V016 支架 1 Bracket17 ND24B 367 T2314J004 螺栓 1 Screw18 ND**** T2314H018 螺栓 2 Screw19 ND**** T2314H008 螺栓 2 Screw1006-6TRT125K01/KA01 Alternator & Generator1006-6TRT125K01/KA01 交流发电机及发电机 NDH01533Alternator & Generator交流发电机及发电机 NDH01533Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 ND24A 004 T64501023 发电机 1 Alterator2 ND24A 054 T2314H005 螺栓 1 Screw3 ND24A 094 T2314H005 螺栓 1 Screw4 ND***** T74601112 支架 4 Bracket5 ND24B 127 T2314J003 螺栓12 Screw6 ND24A 008 T2314H013 螺栓 2 Screw7 ND***** T74502152 调节杆 1 Adjustment level8 ND24A 133 T2314H006 螺栓M8X45 Screw9 ND24B 136 T2314J006 平垫10X40 1 Washer10 ND24A 136 GB6170-86M8 螺母M8 Nut11 ND24A 136 GB6170-86M10 螺母M10 NutAir Compressor空气压缩机 QDH01356Air Compressor空气压缩机 QDH01356Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 QD10T 070 T3272X021 轮毂 1 Hub2 QD10T 073 T2415H213 O型圈 1 O-ring3 QD10T 076 T3117C161 齿轮 1 Gear4 QD10T 079 T2551A289 轴承 1 Bearing5 QD10T 082 T3241H011 盖板 1 Cover plate6 QD10T 085 T2314H002 螺栓 3 Screw7 QD10T 091 T3753R241 支架 1 Bracket8 QD10T 096 T2311D081 螺栓 3 Screw9 QD10T 098 T2311D560 螺栓 4 Screw1006-6TRT125K01/KA0 1Air Compressor1006-6TRT125K01/KA01 空气压缩机 QDH01356Air Compressor空气压缩机 QDH01356Item Fam No Part No Part name Qty Part name图示参号组件号零件号零件名称数量零件名称1 ND*** T74600123 空压机 1 AIR COMPRESSOR2 ND*** T2314J006 螺栓 1 SCREW3 ND*** T2314A604 螺母 1 NUT4 ND*** 169 T0180063A 喉箍 2 HOSE CLIP5 QD40L 010 T0470672 接头 1 CONNECTION6 QD40L 019 T3355A017 接头 1 CONNECTION7 QD40L T2411157 垫圈 1 WASHER8 QD40L T0470672 接头 2 CONNECTION9 QD40L T3355A017 接头 1 CONNECTION10 QD**** T2411157 垫圈 2 WASHER11 QD**** T0180063A 喉箍 1 HOSE CLIP12 QD**** T64601109 胶管 1 HOSEING13 QD**** T2481877A 喉箍 2 HOSE CLIP14 QD**** T74602321 胶管 2 HOSEING15 QD**** T74602322 胶管 1 HOSEING16 QD**** T64612103B 接头 1 CONNECTION17 QD30Z T64612104 锁母 118 QD20U 034 T64612105 垫片 1 WASHER19 QD10B T0206002 接头 1 CONNECTION20 QD10B T73201647 过油螺栓 2 SCREW21 QD10B T74806022 回油接头 1 CONNECTION22 QD**** T73209521 油管 1 PIPE23 QD**** T73209522 油管 1 PIPE1006-6TRT125K01/KA01 Cover Plate1006-6TRT125K01/KA01 盖板 QDH01131Cover Plate盖板 QDH01131Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 QD *** T74001209 盖板 1 COVER PLA TE2 QD *** T2314J001 螺栓 1 SCREW3 QD *** T64605001A 垫片 2 WASHERGear Drive Auxiliary Drive Option齿轮驱动/转向助力选用 QDH01131Gear Drive Auxiliary Drive Option齿轮驱动/转向助力选用 QDH01131Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 QD10B *** T4113H068A 驱动总成 1 Drive Assy2 T3751K071A 壳体 1 Housing3 GB276-82-208 轴承 1 Bearing4 T2721A537 卡簧 1 Circlip5 T3117A016A 齿轮 1 Gear6 GB276-82-106 轴承 1 Bearing7 QD10B 133 T2415H461 O型圈 1 O Ring8 QD10B 162 T2313H321 双头螺栓 1 Stud9 QD10B 164 T3254T001 双头螺栓 1 Stud10 QD10B 166 T2318A605 螺母 3 NutManifolds & Air Charge Cooler进、排气歧管及空气冷却器 SBH00616Manifolds & Air Charge Cooler进、排气歧管及空气冷却器 SBH00616Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 SB15A 010 T3777U031 进气管 1 Inducion manifold2 SB15A 016 T3688C028 垫 1 Joint3 SB15A 020 T2314J009 螺栓 6 Screw4 SB15A 022 T2314J019 螺栓 2 Screw5 SB16A 002 T3211P018 双头螺栓 4 Stud6 SB16A 003 T2313M083 双头螺栓 2 Stud7 SB16A 003 T2313M083 双头螺栓 2 Stud8 SB16A 004 T2318A634 螺母8 Nut9 SB16A 013 T3688C017 垫 1 Joint10 SB16A 014 T36862191 垫 2 Joint11 SB16A 016 T3778P001/A 排气管 1 Exhaust manifold12 SB15F 001 T3766P241 进气弯管 1 Elbow13 SB15F 031 T2314J014 螺栓 4 Screw14 SB15F 028 T3684N008 垫 1 JointManifolds & Air Charge Cooler进、排气歧管及空气冷却器 SBH00616Manifolds & Air Charge Cooler进、排气歧管及空气冷却器 SBH00616Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 SB15C 006 T3688A006 垫 1 Joint2 SB15C 007 T2674A082 增压器 1 Turbocharger3 SB15C 022 T3211P007 丝对4 Stud5 SB15C 031 T2318A634 螺母 4 Nut6 SB20K 100 T3683D006 垫 1 Joint7 SB20K 118 T2314H003 螺栓 2 Screw8 SB20K 136 T3383A024 胶管 1 Hose9 SB20K 139 T2481877 卡子 2 Clip10 SB20K 152 T3571F016D 增压器回油管 1 Oil return pipe11 SB20L 305 T3583M007 增压器进油管 1 Oil feed pipe12 SB20L 311 T36832138 垫 1 Joint13 SB20L 323 T2314H004 螺栓 2 Screw14 SB20L 343 T0206008 接头 1 Connection15 SB20L 344 T0576116 螺母 1 Nut16 SB20L 350 T0566007 橄榄体 1 Olive17 SB15F 004 T3383E008 胶管 1 Hose18 SB15F 007 T0180070A 喉箍 2 ClipManifolds & Air Charge Cooler进、排气歧管及空气冷却器 SBH00616Manifolds & Air Charge Cooler进、排气歧管及空气冷却器 SBH00616Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 SB***** T33415509 垫 1 Joint2 SB***** T3688C011 垫 2 Joint3 SB***** T74707107 排气弯管 1 Elbow4 SB***** T74707108 排气弯管 1 Elbow5 SB***** T74707106 排气弯管 1 Elbow6 SB***** T74703008 排气弯管支架 1 Bracket7 SB***** T74703009 排气弯管支架 1 Bracket8 SB***** GB5783-86 螺栓M12X1.5X25 4 Screw9 SB***** GB93-87D12 弹垫12 4 Spring washer10 SB***** T2314H006 螺栓12 Screw11 SB***** T2318A633 螺母12 Nut12 SB***** GB97.1-85D12 垫 4 Washer13 SB***** T2314J003 螺栓12 Screw14 SB16D 002 T2313F059 丝对 6 Stud15 SB16A 004 T2318A633 螺母 6 NutLow Pressure Fuel System低压燃油系统 VBH01457Low Pressure Fuel System低压燃油系统 VBH01457Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 VB17C 003 T64102002A 滤清器 1 Fuel filter2 VB**** T64102003 柴滤器滤芯 23 ZE25B 311 T0650204 堵 2 Plug4 ZE25B 312 T73274309 垫圈 2 Washer5 VB17C 040 T2314J006 螺栓 2 Screw6 VB17C 070 T2318A604 螺母 2 Nut7 VB17C 220 T3818D013 支架 1 Bracket8 VB17C 295 T2314J002 螺栓 1 Screw9 VB****** T4121C031F 油管Pipe (Lift Pump to filter)10 VB****** T63201702B 油管Pipe (Filter to pump)11 VB****** T63302029 油管Pipe (Pump to filter)12 VB17N 100 T3425M006 油管 1 Pipe (Atomizer to pump)13 VB17N 118 T33225412 螺母 2 Nut14 VB17N 121 T33811112 橄榄体 2 Olive15 VB17N 148 T73217019 接头 1 Connection16 VB17N 151 T0095344A 过油螺栓 1 Nut17 VB17N 154 T73208144 密封垫 2 Nut18 V e****** T65005001A 回油管 1 Pipe19 VB17N 283 T0576113 螺母 1 Nut20 VB17N 286 T0566004 橄榄体 1 OliveBlanking Plates盖板 VBH02136Blanking Plates盖板 VBH02136Item Fam No Part No Part name Qty Description图示参号组件号零件号零件名称数量描述1 VB**** GB5783-86M8X20 螺栓 4 Screw2 VB**** GB93-87D8 弹簧垫圈 4 Washer3 VB**** T36856104A 垫片 1 Washer4 VB**** T63207003A 盖板 1 Cover plateCold Start System冷起动系统 WDH00033Cold Start System冷起动系统 WDH00218Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 ZE25B 094 T4124E022 进气加热管 1 Pipe2 ZE25B 097 T33225412 螺母 1 Nut3 ZE25B 103 T33811112 橄榄体 1 Olive4 WD15B 010 T2666106 加热器 1 HeaterEngine Lifting发动机提升 XBH00314Engine Lifting发动机提升 XBH00314Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 XB31D 001 T74502130 吊耳 1 Left brackt2 XB31D 007 T2314J003 螺栓 3 Screw3 XB31E 004 T3654W003 吊耳 1 Left brackt4 XB31E 010 T2314J003 螺栓 2 ScrewThe Plate垫板 XBH00315The Plate垫板 XBH00315Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 ND***** T73203325 垫板 1 Plate2 ND***** T74502220 支架 1 Bracket3 ND***** T2314J003 螺栓 3 Screw4 ND***** T2318A604 螺母 3 Nut5 ND***** T75701020 支架 1 Bracket7 ND***** T74502132 空调压缩机调解杆 1 Adjustment level8 ND***** T2314J005 螺栓 1 Screw9 ND***** T2318A604 螺母M10 1 Nut10 ND***** T2314H006 螺栓 1 Screw11 ND***** T2318A603 螺母M8 1 Nut12 ND***** T74502133 隔块 1 Spacer block13 ND***** GB97.1-85D8 垫圈8 2 Washer14 ND***** T2314H019 螺栓 1 ScrewWater temperature sensor水温传感器 ZJH00440Water temperature sensor水温传感器 ZJH00440Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 ZL33Q 025 T65204003B 水温传感器 1 Sensor2 ZZ*** 001 T62204003 放水阀 1 Water drain valve3 ZL*** T64403007 放水管 1 Water drain pipe4 ZL*** T64403008 支架 1 Bracket5 ZL*** T0180063 喉箍 1 Clip6 ZL*** 001 T32161114 水堵 1 Plug7 QD30Z 003 T0650594 螺堵 1 PlugMountings支撑 ZCH00878Mountings支撑 ZCH00878Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 zz****** T2313C125 丝对8 Stud2 zz****** GB6170-86M16 螺母8 Nut3 zz****** GB97.1-85D16 平垫16 Washer4 zz****** GB93-87D16 弹簧垫圈16 Spring washerJoints & Gaskets-Top Service Kit垫及垫片（顶部维修组件） SACA0140Joints & Gaskets-Top Service Kit垫及垫片（顶部维修组件） SACA0140Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 TU5LT0179 顶部垫片 1 Top Joint2 T3681H208 气缸盖垫 1 Joint3 T3681C001 气缸盖罩垫 1 Joint4 T3685R005 垫 1 Joint5 T3685F005 垫 1 Joint6 T3684N008 垫 1 Joint7 T3688C017 排气管垫 1 Joint8 T36862191 排气歧管垫 2 Joint9 T3684A004 垫 1 Joint10 T36832138 垫 1 Joint11 T3683D006 垫 1 Joint12 T3683N004 垫 1 Joint13 T3688A006 增压器到排气管垫 1 Joint14 T0921173 喷油器垫圈 6 Seal15 T33817117 气门油封12 Seal16 T33813131 密封 6 Seal17 T3688C028 进气歧管垫 1 JointJoints & Gaskets-Bottom Service Kit垫及垫片（底部维修组件） SACA0140Joints & Gaskets-Bottom Service Kit垫及垫片（底部维修组件） SACA0140Item Fam No Part No Part name Qty Description图示序号组件号零件号零件名称数量描述1 TU5LBO158 底部垫片 1 Bottom Joint2 T3681M007 油底壳垫 1 Joint3 T3688X008 油冷器罩垫 1 Joint4 T3681P009 正室齿轮室垫 1 Joint5 T3681P034 垫 1 Joint6 T3686T006 垫 1 Joint7 T36856104A 垫 1 Joint8 T36833152 垫 1 Joint9 T3683D006 垫 1 Joint10 T3683H006 垫 1 Joint11 T2415H461 Ｏ型密封圈 1 ＯRing21。
FEATURES FUNCTIONAPPLICATIONSGNDOUTVDDCDVC4VC1VC312VC2345678DCT PACKAGE(TOP VIEW)VC1VC2VC3GNDOUTVDDCDVC4PW PACKAGE(TOP VIEW) DESCRIPTIONbq29410,bq29411,bq29412bq29413,bq29414,bq29415SLUS669D–AUGUST2005–REVISED OCTOBER2006 VOLTAGE PROTECTION FOR2-,3-,OR4-CELL Li-Ion BATTERIES(2nd-LEVEL PROTECTION)•2-,3-,or4-Cell Secondary Protection Each cell in a multiple-cell pack is compared to aninternal reference voltage.If one cell reaches an •Low Power Consumption I CC<2µAovervoltage condition,the protection sequence [VCELL(ALL)<V(PROTECT)]begins.The bq2941x device starts charging an •Fixed High Accuracy Overvoltage Protectionexternal capacitor through the CD pin.When the CD Threshold pin voltage reaches 1.2V,the OUT pin changes–bq29410=4.35V from a low level to a high level.–bq29411=4.40V–bq29412=4.45V–bq29413=4.50V–bq29414=4.55V–bq29415=4.60V•Programmable Delay Time of Detection•High Power Supply Ripple Rejection•Stable During Pulse Charge Operation•2nd-Level Overvoltage Protection in Li-IonBattery Packs in:–Notebook Computers–Portable Instrumentation–Portable EquipmentThe bq2941x is a secondary overvoltage protectionIC for2-,3-,or4-cell lithium-ion battery packs thatincorporates a high-accuracy precision overvoltagedetection circuit.It includes a programmable delaycircuit for overvoltage detection time.Please be aware that an important notice concerning availability,standard warranty,and use in critical applications of TexasInstruments semiconductor products and disclaimers thereto appears at the end of this data sheet.ABSOLUTE MAXIMUM RATINGSPACKAGE DISSIPATION RATINGSbq29410,bq29411,bq29412bq29413,bq29414,bq29415SLUS669D–AUGUST 2005–REVISED OCTOBER 2006These devices have limited built-in ESD protection.The leads should be shorted together or the device placed in conductive foam during storage or handling to prevent electrostatic damage to the MOS gates.ORDERING INFORMATION (1)PACKAGE (3)T AV (PROTECT)(2)MSOP (DCT)SYMBOLSSOP (PW)bq29410DCT3Rbq29410PW bq29410PWR 4.35Vbq29410DCTR CJGbq29410PWG4bq29410PWRG4bq29410DCTT bq29411DCT3Rbq29411PW bq29411PWR 4.40Vbq29411DCTR CJHbq29411PWG4bq29411PWRG4bq29411DCTT bq29412DCT3Rbq29412PW bq29412PWR –40°C to 110°C4.45Vbq29412DCTR CJJbq29412PWG4bq29412PWRG4bq29412DCTTbq29413DCTR 4.50V CJk bq29413PW bq29413PWR bq29413DCTT bq29414DCTR (4)4.55V CJL bq29414PW (4)bq29414PWR (4)bq29414DCTT (4)bq29415DCTR (4)4.60VCJMbq29415PW (4)bq29415PWR (4)bq29415DCTT (4)(1)For the most current package and ordering information,see the Package Option Addendum at the end of this document,or see the TI Web site at .(2)Contact your local Texas Instruments representative or sales office for alternative overvoltage threshold options.(3)The "R"suffix indicates tape-and-reel packaging.(4)Product Previewover operating free-air temperature range unless otherwise noted (1)(2)UNITSupply voltage range VDD–0.3V to 28V VC1,VC2,VC3,VC4–0.3V to 28V Input voltage range VC1TO VC2,VC2TO VC3,VC3TO VC4,VC4TO GND –0.3V to 8V OUT –0.3V to 28V Output voltage rangeCD–0.3V to 28VContinuous total power dissipation See Dissipation Rating TableStorage temperature range,T stg –65°C to 150°CLead temperature (soldering,10s)300°C(1)Stresses beyond those listed under "absolute maximum ratings"may cause permanent damage to the device.These are stress ratings only,and functional operation of the device at these or any other conditions beyond those indicated under "recommended operating conditions"is not implied.Exposure to absolute-maximum-rated conditions for extended periods may affect device reliability.(2)All voltages are with respect to ground of this device except the differential voltage of VC1-VC2,VC2-VC3,VC3-VC4,and VC4-GND.T A =25°C DERATING FACTOR T A =70°C T A =85°C PACKAGE POWER RATINGABOVE T A =25°CPOWER RATINGPOWER RATINGDCT 412mW 3.3mW/°C 264mW 214mW PW525mW4.2mW/°C336mW273mWRECOMMENDED OPERATING CONDITIONS ELECTRICAL CHARACTERISTICSbq29410,bq29411,bq29412bq29413,bq29414,bq29415 SLUS669D–AUGUST2005–REVISED OCTOBER2006MIN NOM MAX UNITV DD Supply voltage425VVC1,VC2,VC3,VC40V DDV I Input voltage range VVCn–VC(n=1),(n=1,2,3),VC4–GND05t d(CD)Delay time capacitance0.22µF R IN Voltage-monitor filter resistance1001kΩC IN Voltage-monitor filter capacitance0.010.1µF R VD Supply-voltage filter resistance01kΩC VD Supply-voltage filter capacitance0.1µF T A Operating ambient temperature range–40110°Cover recommended operating free-air temperature range,TA=25°C(unless otherwise noted)PARAMETER TEST CONDITION MIN NOM MAX UNITT A=25°C2535 Overvoltage detectionV(OA)T A=–20°C to85°C2550mV accuracyT A=–40°C to110°C80bq29410 4.35bq29411 4.40bq29412 4.45 OvervoltageV(PROTECT)V detection voltage(1)bq29413 4.50bq29414 4.55bq29415 4.60Overvoltage detectionV hys300mV hysteresis(1)V2,V3,VC4input,V DD=VC1I IN Input current0.3µAVC1=VC2=VC3=VC4=3.5V(see Figure1)Overvoltage detection delayt D1V DD=VC1,CD=0.22µF1 1.52S timeI(CD_dis)CD GND clamp current V DD=VC1,CD=1V512µAV DD=VC1,VC1–VC2=VC2–VC3=VC3–VC4=VC4–GND=3.5V23(see Figure1)I CC Supply currentµAV DD=VC1,VC1–VC2=VC2–VC3=VC3–VC4=VC4–GND=2.3V 1.5 2.5(see Figure1)VC1–VC2=VC2–VC3=VC3–VC4=VC4–GND=7V(PROTECT)Max,V DD=VC1,I OH=0mAV(OUT)OUT pin drive voltage VVC1=VC2=VC3=VC4=V(PROTECT)Max,1.522.5V DD=4.3V,T A=0°C to70°C,I OH=40µAOUT=3V,I OH High-level output current–1mAVC1=VC2=VC3=VC4=4.7VOUT=0.1V,V DD=VC1,I OL Low-level output current5µAVC1–VC2=VC2–VC3=VC3–VC4=VC4–GND=3.5V(1)Levels of the overvoltage detection and the hysteresis can be adjusted.For assistance,contact a Texas Instruments salesrepresentative.bq29410,bq29411,bq29412bq29413,bq29414,bq29415SLUS669D–AUGUST 2005–REVISED OCTOBER 2006Figure 1.I CC ,I IN Measurement (DCT Package)Terminal FunctionsTERMINALDESCRIPTIONMSOPTSSOP NAME (DCT)(PW)81VC1Sense voltage input for most positive cell 72VC2Sense voltage input for second most positive cell 63VC3Sense voltage input for third most positive cell 54GND Ground pin45VC4Sense voltage input for least positive cell36CD An external capacitor is connected to determine the programmable delay time 27VDD Power supply 18OUTOutputOVERVOLTAGE PROTECTION DELAY TIME CALCULATIONt d+ƪ1.2V C(DELAY)ƫI CDC(DELAY)+ƪt d I CDƫ1.2Vbq29410,bq29411,bq29412bq29413,bq29414,bq29415SLUS669D–AUGUST2005–REVISED OCTOBER2006 FUNCTIONAL BLOCK DIAGRAMWhen one of the cell voltages exceeds V(PROTECT),an internal current source begins to charge the capacitor, C(DELAY),connected to the CD pin.If the voltage at the CD pin,V CD,reaches1.2V,the OUT pin is activated and transitions high.An externally connected NCH FET is activiated and blows the external fuse in the positive battery rail;see the functional block diagram.If all cell voltages fall below V(PROTECT)before the voltage at pin CD reaches1.2V,the delay time does not run out.An internal switch clamps the CD pin to GND and discharges the capacitor,C(DELAY),and secures the full delay time for the next occurring overvoltage event.Once the pin OUT is activated,it transitions back from high to low after all battery cells reach V(PROTECT)–V hys. The delay time is calculated as follows:Where I(CD)=CD current source=0.18µACell Voltage (VCn - VC(n-1),VC4 - GND)CDOUT- V hysd DELAY CDAPPLICATION INFORMATIONBATTERY CONNECTIONSbq29410,bq29411,bq29412bq29413,bq29414,bq29415SLUS669D–AUGUST 2005–REVISED OCTOBER 2006Figure 2.Timing for Overvoltage SensingThe following diagrams show the DCT package device in different cell configurations.Figure 3.4-Series Cell ConfigurationFigure 4.3-Series Cell Configuration(Connect together VC1and VC2)CELL CONNECTIONSbq29410,bq29411,bq29412bq29413,bq29414,bq29415SLUS669D–AUGUST 2005–REVISED OCTOBER 2006APPLICATION INFORMATION (continued)Figure 5.2-Series Cell ConfigurationTo prevent incorrect output activation,the following connection sequences must be used.4-Series Cell Configuration•VC1(=VDD)→VC2→VC3→VC4→GND or •GND →VC4→VC3→VC2→VC1(=VDD)3-Series Cell Configuration•VC1(=VC2=VDD)→VC3→VC4→GND or •GND →VC4→VC3→VC1(=VC2=VDD)2-Series Cell Configuration•VC1(=VC2=VC3=VDD)→VC4→GND or •GND →VC4→VC1(=VC2=VC3=VDD)PACKAGING INFORMATIONOrderable DeviceStatus (1)Package Type Package Drawing Pins Package Qty Eco Plan (2)Lead/Ball FinishMSL Peak Temp (3)BQ29410DCT3R ACTIVE SM8DCT 83000Pb-Free (RoHS)CU SNBI Level-1-260C-UNLIM BQ29410DCT3RE6ACTIVE SM8DCT 83000Pb-Free (RoHS)CU SNBI Level-1-260C-UNLIM BQ29410DCTR ACTIVE SM8DCT 83000Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29410DCTRG4ACTIVE SM8DCT 83000Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29410DCTT ACTIVE SM8DCT 8250Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29410DCTTG4ACTIVE SM8DCT 8250Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29410PW ACTIVE TSSOP PW 8150TBD CU NIPDAU Level-1-220C-UNLIM BQ29410PWR ACTIVE TSSOP PW 82000TBDCU NIPDAU Level-1-220C-UNLIM BQ29410PWRG4ACTIVE TSSOP PW 82000Green (RoHS &no Sb/Br)CU NIPDAU Level-2-260C-1YEAR BQ29411DCT3R ACTIVE SM8DCT 83000Pb-Free (RoHS)CU SNBI Level-1-260C-UNLIM BQ29411DCT3RE6ACTIVE SM8DCT 83000Pb-Free (RoHS)CU SNBI Level-1-260C-UNLIM BQ29411DCTR ACTIVE SM8DCT 83000Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29411DCTRG4ACTIVE SM8DCT 83000Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29411DCTT ACTIVE SM8DCT 8250Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29411DCTTG4ACTIVE SM8DCT 8250Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29411PW ACTIVE TSSOP PW 8150TBD CU NIPDAU Level-1-220C-UNLIM BQ29411PWR ACTIVE TSSOP PW 82000TBDCU NIPDAU Level-1-220C-UNLIM BQ29411PWRG4ACTIVE TSSOP PW 82000Green (RoHS &no Sb/Br)CU NIPDAU Level-2-260C-1YEAR BQ29412DCT3R ACTIVE SM8DCT 83000Pb-Free (RoHS)CU SNBI Level-1-260C-UNLIM BQ29412DCT3RE6ACTIVE SM8DCT83000Pb-Free (RoHS)CU SNBI Level-1-260C-UNLIM BQ29412DCT3T PREVIEW 8TBDCall TI Call TIBQ29412DCTR ACTIVE SM8DCT 83000Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29412DCTRG4ACTIVE SM8DCT 83000Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29412DCTT ACTIVE SM8DCT 8250Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29412DCTTG4ACTIVE SM8DCT 8250Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29412PW ACTIVE TSSOP PW 8150TBD CU NIPDAU Level-1-220C-UNLIM BQ29412PWG4ACTIVETSSOPPW8150Green (RoHS &no Sb/Br)CU NIPDAULevel-2-260C-1YEAR12-Jan-2007OrderableDevice Status (1)Package Type Package Drawing Pins Package Qty Eco Plan (2)Lead/Ball Finish MSL Peak Temp (3)BQ29412PWR ACTIVE TSSOP PW 82000TBDCU NIPDAU Level-1-220C-UNLIM BQ29412PWRG4ACTIVE TSSOP PW 82000Green (RoHS &no Sb/Br)CU NIPDAU Level-2-260C-1YEAR BQ29413DCTR ACTIVE SM8DCT 83000Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29413DCTRG4ACTIVE SM8DCT 83000Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29413DCTT ACTIVE SM8DCT 8250Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29413DCTTG4ACTIVE SM8DCT 8250Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29413PW ACTIVE TSSOP PW 8150Green (RoHS &no Sb/Br)CU NIPDAU Level-2-260C-1YEAR BQ29413PWG4ACTIVE TSSOP PW 8150Green (RoHS &no Sb/Br)CU NIPDAU Level-2-260C-1YEAR BQ29413PWR ACTIVE TSSOP PW 82000Green (RoHS &no Sb/Br)CU NIPDAU Level-2-260C-1YEAR BQ29413PWRG4ACTIVE TSSOP PW 82000Green (RoHS &no Sb/Br)CU NIPDAU Level-2-260C-1YEAR BQ29414DCTR ACTIVE SM8DCT 83000Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29414DCTRG4ACTIVE SM8DCT 83000Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29414DCTT ACTIVE SM8DCT 8250Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29414DCTTG4ACTIVE SM8DCT 8250Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29414PW ACTIVE TSSOP PW 8150Green (RoHS &no Sb/Br)CU NIPDAU Level-2-260C-1YEAR BQ29414PWG4ACTIVE TSSOP PW 8150Green (RoHS &no Sb/Br)CU NIPDAU Level-2-260C-1YEAR BQ29414PWR ACTIVE TSSOP PW 82000Green (RoHS &no Sb/Br)CU NIPDAU Level-2-260C-1YEAR BQ29414PWRG4ACTIVE TSSOP PW 82000Green (RoHS &no Sb/Br)CU NIPDAU Level-2-260C-1YEAR BQ29415DCTR ACTIVE SM8DCT 83000Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29415DCTRG4ACTIVE SM8DCT 83000Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29415DCTT ACTIVE SM8DCT 8250Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29415DCTTG4ACTIVE SM8DCT 8250Green (RoHS &no Sb/Br)CU NIPDAU Level-1-260C-UNLIM BQ29415PW ACTIVE TSSOP PW 8150Green (RoHS &no Sb/Br)CU NIPDAU Level-2-260C-1YEAR BQ29415PWG4ACTIVE TSSOP PW 8150Green (RoHS &no Sb/Br)CU NIPDAU Level-2-260C-1YEAR BQ29415PWR ACTIVE TSSOP PW 82000Green (RoHS &no Sb/Br)CU NIPDAU Level-2-260C-1YEAR BQ29415PWRG4ACTIVETSSOPPW82000Green (RoHS &no Sb/Br)CU NIPDAULevel-2-260C-1YEAR12-Jan-2007(1)The marketing status values are defined as follows:ACTIVE:Product device recommended for new designs.LIFEBUY:TI has announced that the device will be discontinued,and a lifetime-buy period is in effect.NRND:Not recommended for new designs.Device is in production to support existing customers,but TI does not recommend using this part in a new design.PREVIEW:Device has been announced but is not in production.Samples may or may not be available.OBSOLETE:TI has discontinued the production of the device.(2)Eco Plan -The planned eco-friendly classification:Pb-Free (RoHS),Pb-Free (RoHS Exempt),or Green (RoHS &no Sb/Br)-please check /productcontent for the latest availability information and additional product content details.TBD:The Pb-Free/Green conversion plan has not been defined.Pb-Free (RoHS):TI's terms "Lead-Free"or "Pb-Free"mean semiconductor products that are compatible with the current RoHS requirements for all 6substances,including the requirement that lead not exceed 0.1%by weight in homogeneous materials.Where designed to be soldered at high temperatures,TI Pb-Free products are suitable for use in specified lead-free processes.Pb-Free (RoHS Exempt):This component has a RoHS exemption for either 1)lead-based flip-chip solder bumps used between the die and package,or 2)lead-based die adhesive used between the die and leadframe.The component is otherwise considered Pb-Free (RoHS compatible)as defined above.Green (RoHS &no Sb/Br):TI defines "Green"to mean Pb-Free (RoHS compatible),and free of Bromine (Br)and Antimony (Sb)based flame retardants (Br or Sb do not exceed 0.1%by weight in homogeneous material)(3)MSL,Peak Temp.--The Moisture Sensitivity Level rating according to the JEDEC industry standard classifications,and peak solder temperature.Important Information and Disclaimer:The information provided on this page represents TI's knowledge and belief as of the date that it is provided.TI bases its knowledge and belief on information provided by third parties,and makes no representation or warranty as to the accuracy of such information.Efforts are underway to better integrate information from third parties.TI has taken and continues to take reasonable steps to provide representative and accurate information but may not have conducted destructive testing or chemical analysis on incoming materials and chemicals.TI and TI suppliers consider certain information to be proprietary,and thus CAS numbers and other limited information may not be available for release.In no event shall TI's liability arising out of such information exceed the total purchase price of the TI part(s)at issue in this document sold by TI to Customer on an annualbasis.12-Jan-2007IMPORTANT NOTICETexas Instruments Incorporated and its subsidiaries (TI) reserve the right to make corrections, modifications, enhancements, improvements, and other changes to its products and services at any time and todiscontinue any product or service without notice. Customers should obtain the latest relevant informationbefore placing orders and should verify that such information is current and complete. All products are soldsubject to TI’s terms and conditions of sale supplied at the time of order acknowledgment.TI warrants performance of its hardware products to the specifications applicable at the time of sale inaccordance with TI’s standard warranty. Testing and other quality control techniques are used to the extentTI deems necessary to support this warranty. Except where mandated by government requirements, testingof all parameters of each product is not necessarily performed.TI assumes no liability for applications assistance or customer product design. Customers are responsiblefor their products and applications using TI components. To minimize the risks associated with customerproducts and applications, customers should provide adequate design and operating safeguards.TI does not warrant or represent that any license, either express or implied, is granted under any TI patentright, copyright, mask work right, or other TI intellectual property right relating to any combination, machine,or process in which TI products or services are used. Information published by TI regarding third-partyproducts or services does not constitute a license from TI to use such products or services or a warranty orendorsement thereof. Use of such information may require a license from a third party under the patents orother intellectual property of the third party, or a license from TI under the patents or other intellectualproperty of TI.Reproduction of information in TI data books or data sheets is permissible only if reproduction is withoutalteration and is accompanied by all associated warranties, conditions, limitations, and notices.Reproduction of this information with alteration is an unfair and deceptive business practice. TI is notresponsible or liable for such altered documentation.Resale of TI products or services with statements different from or beyond the parameters stated by TI forthat product or service voids all express and any implied warranties for the associated TI product or serviceand is an unfair and deceptive business practice. TI is not responsible or liable for any such statements.Following are URLs where you can obtain information on other Texas Instruments products and applicationsolutions:Products ApplicationsAmplifiers Audio /audioData Converters Automotive /automotive/broadbandBroadbandDSP DigitalControl /digitalcontrol Interface Military /military Logic Power Mgmt Optical Networking /opticalnetworkSecurity /security Microcontrollers Low Power Wireless /lpw Telephony /telephonyVideo & Imaging /video/wirelessWirelessMailing Address: Texas InstrumentsPost Office Box 655303 Dallas, Texas 75265Copyright © 2007, Texas Instruments Incorporated。
