冶金词汇英语翻译

氩弧焊机：TIG welding machine 焊条：electrode电焊机：welding machine砂轮切割机：grinding cutter角磨机：angle grinding machine焊条烤箱：electrode oven气割设备：gas cutting equipment试压泵：pressure testing pump 乙炔：acetylene焊条保温桶：electrode insulation can氩气瓶：argon bottle滚圆机：rolling machine咬边机：edge bending machine 万用表：multimeter倒链：chain block脚手架管：scaffold pipe管件吊篮：lifting basket for pipe 气瓶吊篮：lifting basket for bottle工具箱：tool box陆地人员：manpower onshore 岗位：position项目经理：project manager配管技师：pipe technician焊接技师：welding technician 管工：piper焊工：welder仪表工：instrument worker 打砂工：sand blaster油漆工：painter护栏：handrail风杆：wind bar橡胶垫：rubber cushion不锈钢方管：SS square pipe防滑：antislip片：pcs海上人员：manpower offshore领班/安全：foreman/safty切割管刀片:pipe cutting blade电工：electrician保温/架子工：insulationworker/scaffolder探伤工：NDT operator人数/人员：personnel钳工:fitter热浸镀锌：hot dip galvanization海上调研费:site survey编制：draft审核：approve翻译：translate校对：proofread动复原：MOB报价：quotation大小头（变径器）：reducer面漆：finish coat中间漆：middle paint底漆：primer钢管：steel pipe弯头：elbow法兰：flange盲法兰：blind flange垫片：gasket球阀：ball valve双头螺住/螺母：stud bolts/nuts闸阀：gate valve单向阀：check valve管帽：pipe cap不锈钢管：stainless steel pipe岩棉管：rock wool pipe花纹铝板：checkered Al plate铝箔胶带:Al tape不锈钢带卡子：SS tape clip硅胶：silica gel角钢/铁：angle bar工字钢：I bar不锈钢自攻钉：SS self tappingscrew砂轮切割片：cutting wheel切割片：cutting piece无缝钢管：seamless pipe(大管子用pipe,小管子用tube)打磨片：grinding disk稀释剂：thinner碗型钢丝轮：steel wire wheel(bowl type)自喷漆：银粉：argent powder陆地：onshore海上：offshore滤网：strainer钉：nail滤器：filter篮板：backboard加强圈：目：mesh(量词)钝化液：维修工：maintainer空压机：air compressor岗位：position项目经理：project managertolerance:公差dimensional:空间的screwed pipework:螺旋管道工程管NDE:无损鉴定fabrication:加工,制作riveting:铆工lathe:车床工iron plate：板金工hydraulic:液压工dynamic:动力工氩弧焊机：TIG welding machine焊条：electrode焊丝：welding wire电焊机：welding machine砂轮切割机：grinding cutter角磨机：angle grindingmachine焊条烤箱：electrode oven气割设备：gas cuttingequipment试压泵：pressure testing pump乙炔：acetylene焊条保温桶：electrodeinsulation can氩气瓶：argon bottle滚圆机：rolling machine咬边机：edge bending machine起鼓机：edge band press万用表：multimeter倒链：chain block脚手架管：scaffold pipe管件吊篮：lifting basket for pipe气瓶吊篮：lifting basket forbottle工具箱：tool box陆地人员：manpower onshore岗位：position配管技师：pipe technician焊接技师：welding technician管工：piper焊工：welder仪表工：instrument worker打砂工：sand blaster油漆工：painter护栏：handrail风杆：wind bar橡胶垫：rubber cushion不锈钢方管：SS square pipe防滑：anti-slip片：pcs海上人员：manpower offshore领班/安全：foreman/saefty切割管刀片:pipe cutting blade 电工：electrician保温/架子工：insulation worker/scaffolder探伤工：NDT operator人数/人员：personnel钳工:fitter热浸镀锌：hot dip galvanization 调研费:site survey fee编制：draft审核：approve翻译：translate校对：proofread动复原：mob and demob大小头（变径器）：reducer机修工：mechanic面漆：finish coat中间漆：middle paint底漆：primer钢管：steel pipe弯头：elbow法兰：flange盲法兰：blind flange垫片：gasket球阀：ball valve双头螺住/螺母：studbolts/nuts 闸阀：gate valve单向阀：check valve管帽：pipe cap不锈钢管：stainless steel pipe 岩棉管：rock wool pipe花纹铝板：checkered Al plate铝箔胶带:Al tape不锈钢带卡子：SS tape clip硅胶：silica gel角钢/铁：angle bar工字钢：I bar不锈钢自攻钉：SS self tappingscrew砂轮切割片：cutting wheel切割片：cutting piece无缝钢管：seamless pipe(大管子用pipe,小管子用tube)打磨片：grinding disk稀释剂：thinner碗型钢丝轮：steel wirewheel(bowl type)自喷漆：银粉：argent powder陆地：onshore海上：offshore滤网：strainer钉：nail滤器：filter篮板：backboard加强圈：reinforcement gasket目：mesh(量词)钝化液：维修工：maintainer空压机：air compressor卡套式弯头:slip-on elbow外丝扣：male thread内丝弯头：female thread elbow三通：tee平焊法兰：slip-on flange变径管：reducing pipe由另：union密封垫：gland石墨：graphite螺栓：hexangular bolt镀锌:bethanizing调节阀：control valve/regulatingvalve安全阀：relief valve/safety valve隔断阀：block valve检漏气：leak detection gas单向阀/止回阀：check valve截止阀：globe valve抽风机：exhaust fan防爆：explosion proof送风机：blower装饰板：Decorative board减压阀：depressuring valve空压机：Air compressor橡塑棉：rubber plastic sponge万能胶：multi-purpose adhesive抹布：rag打砂：sand blast入库清单：delivery bill对焊：butt weld下料：cutting无齿锯：grinding wheel saw完工图：complete frame钻床：drill press燃油柜、滑油柜、消声器:fuel oiltank，lubricating oil tank;noisesuppressor单点管汇区:SPM mainfold area涂层：coating合页：hinge索扣：rig耐油：oil resistant六角头螺栓：hexagon head bolt钢丝刷：steel brush辅助工：shifter酸洗：acid pickle耐高温：refractory。

冶金英语词汇（最全）1 总论采矿mining地下采矿underground mining露天采矿open cut mining, open pit mining, surface mining采矿工程mining engineering选矿（学）mineral dressing, ore beneficiation, mineral processing矿物工程mineral engineering冶金（学）metallurgy过程冶金（学）process metallurgy提取冶金（学）extractive metallurgy化学冶金（学）chemical metallurgy物理冶金（学）physical metallurgy金属学Metallkunde冶金过程物理化学physical chemistry of process metallurgy冶金反应工程学metallurgical reaction engineering冶金工程metallurgical engineering钢铁冶金（学）ferrous metallurgy, metallurgy of iron and steel有色冶金(学)nonferrous metallurgy真空冶金(学)vacuum metallurgy等离子冶金(学)plasma metallurgy微生物冶金(学)microbial metallurgy喷射冶金(学)injection metallurgy钢包冶金(学)ladle metallurgy二次冶金(学)secondary metallurgy机械冶金(学)mechanical metallurgy焊接冶金(学)welding metallurgy粉末冶金(学)powder metallurgy铸造学foundry火法冶金(学)pyrometallurgy湿法冶金(学)hydrometallurgy电冶金(学)electrometallurgy氯冶金(学)chlorine metallurgy矿物资源综合利用engineering of comprehensive utilization of mineral resources中国金属学会The Chinese Society for Metals中国有色金属学会The Nonferrous Metals Society of China2 采矿采矿工艺mining technology有用矿物valuable mineral冶金矿产原料metallurgical mineral raw materials矿床mineral deposit特殊采矿specialized mining海洋采矿oceanic mining, marine mining矿田mine field矿山mine露天矿山surface mine地下矿山underground mine矿井shaft矿床勘探mineral deposit exploration矿山可行性研究mine feasibility study矿山规模mine capacity矿山生产能力mine production capacity矿山年产量annual mine output矿山服务年限mine life矿山基本建设mine construction矿山建设期限mine construction period矿山达产arrival at mine full capacity开采强度mining intensity矿石回收率ore recovery ratio矿石损失率ore loss ratio工业矿石industrial ore采出矿石extracted ore矿体orebody矿脉vein海洋矿产资源oceanic mineral resources矿石ore矿石品位ore grade岩石力学rock mechanics岩体力学rock mass mechanics3 选矿选矿厂concentrator, mineral processing plant 工艺矿物学process mineralogy开路open circuit闭路closed circuit流程flowsheet方框流程block flowsheet产率yield回收率recovery矿物mineral粒度particle size粗颗粒coarse particle细颗粒fine particle超微颗粒ultrafine particle粗粒级coarse fraction细粒级fine fraction网目mesh原矿run of mine, crude精矿concentrate粗精矿rough concentrate混合精矿bulk concentrate最终精矿final concentrate尾矿tailings粉碎comminution破碎crushing磨碎grinding团聚agglomeration筛分screening, sieving分级classification富集concentration分选separation手选hand sorting重选gravity separation, gravity concentration 磁选magnetic separation电选electrostatic separation浮选flotation化学选矿chemical mineral processing自然铜native copper铝土矿bauxite冰晶石cryolite磁铁矿magnetite赤铁矿hematite假象赤铁矿martite钒钛磁铁矿vanadium titano-magnetite铁燧石taconite褐铁矿limonite菱铁矿siderite镜铁矿specularite硬锰矿psilomelane软锰矿pyrolusite铬铁矿chromite黄铁矿pyrite钛铁矿ilmennite金红石rutile萤石fluorite高岭石kaolinite菱镁矿magnesite重晶石barite石墨graphite石英quartz方解石calcite石灰石limestone白云石dolomite云母mica石膏gypsum硼砂borax石棉asbestos蛇纹石serpentine阶段破碎stage crushing粗碎primary crushing中碎secondary crushing细碎fine crushing对辊破碎机roll crusher粉磨机pulverizer震动筛vibrating screen筛网screen cloth筛孔screen opening筛上料oversize筛下料undersize粗磨coarse grinding细磨fine grinding球磨机ball mill衬板liner分级机classifier自由沉降free setting沉积sedimentation石灰lime松油pine oil硫化钠sodium sulfide硅酸钠（水玻璃）sodium silicate, water glass过滤filtration过滤机filter给矿，给料feeding给矿机feeder在线分析仪on line analyzer在线粒度分析仪on line size analyzer超声粒度计ultrasonic particle sizer, supersonic particle sizer4 冶金过程物理化学4.1 冶金过程热力学冶金过程热力学thermodynamics of metallurgical processes统计热力学statistical thermodynamics不可逆过程热力学thermodynamics of irreversible processes化学热力学chemical thernodynamics表面热力学surface thermodynamics合金热力学thermodynamics of alloys冶金热力学数据库thermodynamics databank in metallurgy 系system单元系single-componentsystem多元系multicomponent system均相系统homogeneous system广度性质extensive property强度性质intensive property过程process等温过程isothermal process等压过程isobaric process等容过程isochoric process绝热过程adiabatic process可逆过程reversible process不可逆过程irreversible process自发过程spontaneous process自理过程physical process化学过程chemical process冶金过程metallurgical process化学反应chemical reaction化合反应combination reaction分解反应decomposition reaction置换反应displacement reaction可逆反应reversible reaction不可逆反应irreversible reaction电化学反应electrochemical reaction多相反应multiphase reaction固态反应solid state reaction气一金(属)反应gas-metal reaction渣一金（属）反应slag-metal reaction平衡equilibrium化学平衡chemical equilibrium相平衡phase equilibrium热力学平衡thermodynamic equilibrium亚稳平衡metastable equilibrium热力学函数thermodynamic function偏摩尔量partial molar quantity总摩尔量integral molar quantity标准态standard state焓enthalpy生成焓enthalpy of formation反应焓enthalpy of reaction熵entropy吉布斯能Gibbs energy生成吉布斯能Gibbs energy of formation反应吉布斯能Gibbs energy of reaction溶解吉布斯能Gibbs energy of solution吉布斯能函数Gibbs energy function化学位chemical potential热化学thermochemistry热效应heat effect热容heat capacity熔化热heat of fusion汽化热heat of vaporization升华热heat of sublimation相变热heat of phase transformation放热反应exothermic reaction吸热反应endothermic reaction赫斯定律Hess’s law相律phase rule相图phase diagram一元相图single-component phase diagram二元相图binary-component phase diagram三元相图ternary-component phase diagram液相线liquidus固相线solidus共晶点eutectic point杠杆规则lever rule溶液solution溶质solute溶剂solvent固溶体solid solution溶液浓度concentration of solution摩尔分数mole fraction冶金熔体metallurgical melt金属熔体metal melt(炉)渣,熔渣slag熔盐molten salt, fused salt理想溶液ideal solution真实溶液real solution正规溶液regular solution活度activity活度系数activity coefficient拉乌尔定律Raoult’s law亨利定律Henry’s law纯物质标准态pure substance standard质量１％溶液标准(态)1 mass% solution standard无限稀溶液参考态reference state of infinityly dilute solution相互作用系数interaction coefficient化学反应等温式chemical reaction isotherm吉布斯～亥姆霍兹方程Gibbs-Helmholtz equation质量作用定律law of mass action平衡常数equilibrium constant平衡值equilibrium value直接还原direct reduction间接还原indirect reduction金属热还原metallothermic reduction选择性氧化selective oxidation渣碱度basicity of slag光学破度optical basicity酸性氧化物acid oxide碱性氧化物basicoxide两性氧化物amphoteric泡沫渣foaming slag熔渣的分子理论molecular theory of slag熔渣的离子理论ionization theory of slag脱氧平衡deoxidation equilibrium脱氧常数deoxidation constant熔渣脱硫desulfurization by slag气态脱硫desulfurization in the gaseous state硫分配比sulfur partition ratio硫化物容量sulfide capacity氧化脱磷dephosphorization under oxidizing atmosphere磷分配比碳一氧平衡carbon-oxygen equilibrium真空脱碳vacuum decarburization去气degassing去除非金属夹杂(物)elimination of nonmetallic inclusion非金属夹杂(物)变形form modification of nonmetallic inclusion 脱硅desiliconization脱锰demanganization分配平衡distribution law化学气相沉积chemical vapor deposition(CVD)4.2 冶金过程动力学微观动力学microkinetics化学动力学chemical kinetics反应途径reaction path反应机理reaction mechanism基元反应elementary reaction平行反应parallel链反应chain reaction总反应overall reaction反应速率reaction rate反应速率常数reaction rate constant反应级数reaction order零级反应zero order reaction一级反应first order reaction二级反应second order reactionn级反应nth order reaction碰撞理论collision theory活化能activation energy表现活化能apparent activation energy阿伦尼乌斯方程Arrhenius equation半衰期half-life宏观动力学macrokinetics冶金过程动力学kinetics of metallurgical process 传输现象transport phenomena传质mass transfer传热heat transfer动量传输momentum transfer层流laminar flow湍流turbulent flow气泡gas bubble鼓泡bubbling射流jet液滴liquid droplet粘度viscosity边界层boundary layer流率flow rate通量flux扩散diffusion菲克第一扩散定律Fick’s 1st law of diffusion菲克第一扩散定律Fick’s 2nd law of diffusion扩散系数diffusion coefficient传质系数mass transfer coefficient热传导heat conduction热对流heat convection自然对流natural convection强制对流forced convection热辐射heat radiation导热率thermal conductivity传热系数heat transfer coefficient体内浓度bulk concentration未反应核模型unreacted core model扩散控制反应diffusion-controlled reaction化学控制反应chenical-controlled reaction混合控制反应mixed-controlled reaction相似原理priciple of similarity雷诺数Reynolds number固定床fiexed bed填充床packed bed移动床moving bed流态化床fluidized bed混合时间mixing time停留时间residence time, retention time催化catalysis催化剂catalyst表面能surface energy表面张力surface tension界面能interfacial energy界面张力interfacial tension润湿wetting表面活性物质surface-active substance吸收absorption吸附absorption4.3 冶金电化学冶金电化学metallurgical electrochemistry熔盐电化学electrochemistry of fused salts固态离子学solid state ionics电解质溶液electrolyte solution阳离子cation阴离子anion电导conductance电导率conductivity电阻resistance电极electrode阴极cathode阳极anode电镀electroplating固体电解质solid electrolyte稳定的氧化锆stablized zirconia氧传感器oxygen sensor硅传感器silicon sensor定氧测头oxygen probe定硅测头silicon probe4.4 冶金物理化学研究方法冶金物理化学研究方法research methods in metallurgical physical chemistry热电偶thermocouple量热计calorimeter热太平thermobalance热分析thermal analysis差热分析differential thermal analysis,DTA热重法thermogravimetry分子筛molecular sieve5 钢铁冶金5.1 炼焦炼焦coking高温炭化high temperature carbonization塑性成焦机理plastic mechanism of coke formation中间相成焦机理mesophase mechanism of coke formation 选煤coal preparation, coal washing配煤coal blending配煤试验coal blending test炼焦煤coking coal气煤gas coal肥煤fat coal瘦煤lean coal焦炉coke oven焦化室oven chamber焦饼coke cake结焦时间coking time周转时间cycle time装煤coal charging捣固装煤stamp charging推焦coke pushing焦炭熄火coke quenching干法熄焦dry quenching of coke焦台coke wharf装煤车larry car推焦机pushing machine拦焦机coke guide熄焦车quenching car焦炉焖炉banking for coke oven焦炭coke冶金焦metallurgical coke铸造焦foundry coke焦炭工业分析proximate analysis of coke焦炭元素分析ultimate analysis of coke焦炭落下指数shatter index of coke焦炭转鼓指数drum index of coke焦炭热强度hot strength of coke焦炭反应性coke reactivity焦炭反应后强度post-reaction strength of coke焦炭显微强度microstrength of coke焦炉煤气coke oven gas发热值calorific value煤焦油coal tar粗苯crude benzol苯benzene甲苯toluene二甲苯xylene苯并呋喃-茚树脂 coumarone-indene resin精萘refined naphthalene精蒽refined anthracene煤[焦油]沥青 coal tar pitch沥青焦pitch coke针状焦needle coke型焦formcoke5.2 耐火材料耐火材料refractory materials耐火粘土fireclay高岭土kaolin硬质粘土flint clay轻质粘土soft clay陶土pot clay蒙脱石montmorillonite叶蜡石pyrophyllite膨润土bentonite鳞石英tridymite方石英cristobalite砂岩sandstone耐火石firestone莫来石mullite氧化铝alumina烧结氧化铝sintered alumina电熔氧化铝fused alumina刚玉corundum红柱石andalusite蓝晶石kyanite,cyanite硅线石sillimanite橄榄石olivine方镁石periclase镁砂magnesia合成镁砂synthetic sintered magnesia电熔镁砂fused magnesia烧结白云石砂sintered dolomite clinker合成镁铬砂synthetic magnesia chromite clinker尖晶石spinel镁铬尖晶石magnesia chrome spinel,magnesiochromite 硅藻土diatomaceous earth, infusorial earth蛭石vermiculite珍珠岩perlite碳化硅silicon carbide氮化硅silicon nitride氮化硼boron nitride粘土熟料chamotte熟料grog轻烧light burning,soft burning死烧dead burning,hard burning成型模注shaping moulding机压成型mechanical pressing等静压成型isostatic pressing摩擦压砖机friction press液压压砖机hydraulic press捣打成型ramming process熔铸成型fusion cast process砖坯强度green strength,dry strength隧道窑tunnel kiln回转窑rotary kiln倒焰窑down draught kiln耐火砖refractory brick标准型耐火砖standard size refractory brick泡砂石quartzite sandstone酸性耐火材料acid refractory [material]硅质耐火材料siliceous refractory [material]硅砖silica brick,dinas brick熔融石英制品fused quartz product硅酸铝质耐火材料aluminosillicate refractory半硅砖semisilica brick粘土砖fireclay brick,chamotte brick石墨粘土砖graphite clay brick高铝砖high alumina brick硅线石砖sillimanite brick莫来石砖mullite brick刚玉砖corundum brick铝铬砖alumina chrome brick熔铸砖fused cast brick碱性耐火材料basic refractory [material]镁质耐火材料magnesia refractory [material]镁砖magnesia brick镁铝砖magnesia alumina brick镁铬砖magnesia chrome brick镁炭砖magnesia carbon brick中性耐火材料neutral refractory [material]复合砖composite brick铝炭砖alumina carbon brick铝镁炭转alumina magnesia brick锆炭砖zirconia graphite brick镁钙炭砖magnesia clacia carbon brick长水口long nozzle浸入式水口immersion nozzle,submerged nozzle定径水口metering nozzle氧化铝-碳化硅-炭砖 Al2O3-SiC-C brick透气砖gas permeable brick,porous brick滑动水口slide gate nozzle水口砖nozzle brick塞头砖stopper绝热耐火材料insulating refractory轻质耐火材料light weight refractory袖砖sleeve brick格子砖checker brick,chequer brick陶瓷纤维ceramic fiber耐火纤维refractory fiber耐火浇注料refractory castable耐火混凝土refractory concrete荷重耐火性refractoriness under load抗渣性slagging resistance耐磨损性abrasion resistance5.3 碳素材料[含]碳[元]素材料 carbon materials无定形碳amorphous carbon金刚石diamond炭相[学]carbon micrography炭黑carbon black石油沥青petroleum pitch石油焦炭petroleum coke石墨化graphitization石墨化电阻炉electric resistance furnace for graphitization 石墨纯净化处理purification treatment of graphite炭砖carbon brick炭块carbon block碳化硅基炭块SiC-based carbon block炭电极carbon electrode连续自焙电极Soderberg electrode石墨电极graphite electrode超高功率石墨电极ultra-high power graphite electrode 石墨电极接头graphite electrode nipple石墨电极接头孔graphite electrode socket plug电极糊electrode paste石墨坩埚graphite crucible石墨电阻棒graphite rod resistor炭刷carbon brush高纯石墨high purity graphite5.4 铁合金铁合金ferroalloy硅铁ferrosilicon硅钙calcium silicon金属硅silicon metal锰铁ferromangnanese低碳锰铁low carbon ferromanganese硅锰silicomanganese金属锰manganese metal铬铁ferrochromium低碳铬铁low carbon ferrochromium微碳铬铁extra low carbon ferrochromium硅铬silicochromium金属铬chromium metal钨铁ferrotunsten钼铁ferromolybdenum钛铁ferrotitanium硼铁ferroboron铌铁ferroniobium磷铁ferrophosphorus镍铁ferronickel锆铁ferrozirconium硅锆silicozirconium稀土硅铁rare earth ferrosilicon稀土镁硅铁rare earth ferrosilicomagnesium成核剂nucleater孕育剂incubater,inoculant球化剂nodulizer蠕化剂vermiculizer中间铁合金master alloy复合铁合金complex ferroalloy电碳热法electro-carbothermic process电硅热法electro-silicothermic process铝热法aluminothermic process,thermit process电铝热法electro-aluminothermic process开弧炉open arc furnace埋弧炉submerged arc furnace半封闭炉semiclosed furnace封闭炉closed furnace矮烟罩电炉electric furnace with low hood矮炉身电炉low-shaft electric furnace5.5 烧结与球团人造块矿ore agglomerates烧结矿sinter压块矿briquette球团[矿] pellet针铁矿goethite自熔性铁矿self-fluxed iron ore复合铁矿complex iron ore块矿lump ore粉矿ore fines矿石混匀ore blending配矿ore proportioning矿石整粒ore size grading返矿return fines储矿场ore stockyard矿石堆料机ore stocker匀矿取料机ore reclaimer熔剂flux消石灰slaked lime活性石灰quickened lime有机粘结剂organic binder烧结混合料sinter mixture烧结铺底料hearth layer for sinter烧结sintering烧结热前沿heat front in sintering烧结火焰前沿flame front in sintering渣相粘结slag bonding扩散粘结diffusion bonding带式烧结机Dwight-Lloyd sintering machine环式烧结机circular travelling sintering machine 烧结梭式布料机shuttle conveyer belt烧结点火料sintering ignition furnace烧结盘sintering pan烧结锅sintering pot烧结冷却机sinter cooler带式冷却机straight-line cooler环式冷却机circular cooler,annular cooler生球green pellet,ball生球长大聚合机理ball growth by coalescence生球长大成层机理ball growth by layering生球长大同化机理ball growth by assimilation精矿成球指数balling index for iron ore concentrates 生球转鼓强度drum strength of green pellet生球落下强度shatter strength of green pellet生球抗压强度compression strength of green pellet生球爆裂温度cracking temperature of green pellet圆筒造球机balling drum圆盘造球机balling disc竖炉陪烧球团shaft furnace for pellet firing带式机陪烧球团traveling grate for pellet firing链算机-回转窑陪烧球团grate-kiln for pellet firing 环式机陪烧球团circular gates for pellet firing冷固结球团cold bound pellet维式体wustite铁橄榄石fayalite铁尖晶石hercynite铁黄长石ferrogehlenite铁酸半钙calcium diferrite铁酸钙calcium ferrite铁酸二钙dicalcium ferrite锰铁橄榄石knebelite钙铁橄榄石kirschsteinite钙铁辉石hedenbergite钙铁榴石andradite钙长石anorthite钙镁橄榄石monticellite钙钛矿perovskite硅灰石wollastonite硅酸二钙dicalcium silicate硅酸三钙tricalcium silicate镁橄榄石forsterite镁黄长石akermanite镁蔷薇辉石manganolite钙铝黄长石gehlenite钛辉石titanaugite枪晶石cuspidine预还原球团pre-reduced pellet金属化球团metallized pellet转鼓试验drum test,tumbler test落下试验shatter test5.6 高炉炼铁炼铁iron making高炉炼铁[法] blast furnace process高炉blast furnace鼓风炉blast furnace炉料charge, burden矿料ore charge焦料coke charge炉料提升charge hoisting小车上料charge hoisting by skip吊罐上料charge hoisting by bucket皮带上料charge hoisting by belt conveyer装料charging装料顺序charging sequence储料漏斗hopper双料钟式装料two-bells system charging无料钟装料bell-less charging布料器distributor炉内料线stock line in the furnace探料尺gauge rod利用系数utilization coefficient冶炼强度combustion intensity鼓风blast风压blast pressure风温blast temperature鼓风量blast volume鼓风湿度blast humidity全风量操作full blast慢风under blowing休风delay喷吹燃料fuel injection喷煤coal injection喷油oil injection富氧鼓风oxygen enriched blast,oxygen enrichment 置换比replacement ratio喷射器injector热补偿thermal compensation焦比coke ratio,coke rate燃料比fuel ratio,fuel rate氧化带oxidizing zone风口循环区raceway蒸汽鼓风humidified blast混合喷吹mixed injection脱湿鼓风dehumidified blast炉内压差pressure drop in furnace煤气分布gas distribution煤气利用率gas utilization rate炉况furnace condition顺行smooth running焦炭负荷coke load,ore to coke ratio软熔带cohesive zone,softening zone渣比slag to iron ratio,slag ratio上部[炉料]调节burden conditioning下部[鼓风]调节blast conditioning高炉作业率operation rate of blast furnace 休风率delay ratio高炉寿命blast furnace campaign悬料hanging崩料slip沟流channeling结瘤scaffolding炉缸冻结hearth freeze-up开炉blow on停炉blow off积铁salamander炉型profile,furnace lines炉喉throat炉身shaft,stack炉腰belly炉腹bosh炉缸hearth炉底 bottom炉腹角bosh angle炉身角stack angle有效容积effective volume工作容积working bolume铁口iron notch, slag notch渣口cinder notch, slag notch风口tuyere窥视孔peep hole风口水套tuyere cooler渣口水套slag notch cooler风口弯头tuyere stock热风围管bustle pipe堵渣机stopper泥炮mud gun,clay gun开铁口机iron notch drill铁水hot metal铁[水]罐iron ladle鱼雷车torpedo car主铁沟sow出铁沟casting house铁沟iron runner渣沟slag runner渣罐cinder ladle, slag ladle撇渣器skimmer冷却水箱cooling plate冷却壁cooling stave汽化冷却vaporization cooling热风炉hot blast stove燃烧室combustion chamber燃烧器burner热风阀hot blast valve烟道阀chimney valve冷风阀cold blast valve助燃风机burner blower切断阀burner shut-off valve旁通阀by-pass valve混风阀mixer selector valve送风期on blast of stove,on blast燃烧期on gas of stove, on gas换炉stove changing放散阀blow off valve内燃式热风炉Cowper stove外燃式燃烧炉outside combustion stove顶燃式热风炉top combustion stove炉顶放散阀bleeding valve放散管bleeder上升管gas uptake放风阀snorting valve均压阀equalizing valve高压调节阀septum valve炉顶高压elevated top pressure铸铁机pig-casting machine铸铁模pig mold冲天炉cupola水渣granulating slag水渣池granulating pit渣场slag disposal pit高炉煤气top gas,blast furnace gas高炉煤气回收topgas recovery,TGR非焦炭炼铁non-coke iron making直接还原炼铁[法]direct reduction iron making直接还原铁directly reduced iron,DRI竖炉直接炼铁direct reduction in shaft furnace流态化炼铁fluidized-bed iron making转底炉炼铁rotary hearth iron making米德雷克斯直接炼铁[法]Midrex processHYL直接炼铁[法] HYL process克虏伯回转窑炼铁[法] Krupp rotary kiln iron-making 熔态还原smelting reduction铁溶法iron-bath process科雷克斯法COREX process生铁pig iron海绵铁sponge iron镜铁spiegel iron清铁法H-rion process5.7 炼钢钢steel炼钢steelmaking钢水liquid steel,molten steel钢semisteel沸腾钢rimming steel,rimmed steel镇静钢killed steel半镇静钢semikilled steel压盖沸腾钢capped steel坩埚炼钢法crucible steelmaking双联炼钢法duplex steelmaking process连续炼钢法continuous steelmaking process直接炼钢法direct steelmaking process混铁炉hot metal machine装料机charging machine装料期charging machine加热期heating period熔化期melting period造渣期slag forming period精炼期refining period熔清melting down脱氧deoxidation预脱氧preliminary dexidation还原渣reducing slag酸性渣acid slag碱性渣basic slag脱碳decarburization增碳recarburization脱磷dephosphorization回磷rephosphorization脱硫desulfurization回硫resulfurization脱氮denitrogenation过氧化overoxidation出钢tapping冶炼时间duration of heat出钢样tapping sample浇铸样casting sample不合格炉次off heat熔炼损耗melting loss铁损iron loss废钢scrap废钢打包baling of scrap造渣材料slag making materials添加剂addition reagent脱氧剂deoxidizer脱硫剂desulfurizer冷却剂coolant回炉渣return slag喷枪lance浸入式喷枪submerged lance钢包ladle出钢口top hole出钢槽pouring lining炉顶furnace roof炉衬furnace lining炉衬侵蚀lining erosion渣线slag line炉衬寿命lining life分区砌砖zoned lining补炉fettling热修hot repair喷补gunning火焰喷补flame gunning转炉converter底吹转炉bottom-blown converter酸性空气底吹转炉air bottom-blown acid converter碱性空气底吹转炉air bottom-blown basic converter侧吹转炉side-blown converter卡尔多转炉Kaldo converter氧气炼铁oxygen steelmaking氧气顶吹转炉top-blown oxygen converter,LI converter氧气底吹转炉bottom-blown oxygen converter quiet basic oxygen furnace,QBOF顶底复吹转炉top and bottom combined blown converter喷石灰粉顶吹氧气转炉法oxygen lime process底吹煤氧的复合吹炼法Klockner-Maxhutte steelmaking process,KMS 住友复合吹炼法Sumitomo top and bottom blowing process,STB LBE复吹法lance bubbling equilibrium process,LBE顶枪喷煤粉炼钢法Arved lance carbon injection process,ALCI蒂森复合吹炼法Thyssen Blassen Metallurgical process,TBM面吹surface blow软吹soft blow硬吹hard blow补吹reblow过吹overblow后吹after blow目标碳aim carbon终点碳end point carbon高拉碳操作catch carbon practice增碳操作recarburization practice单渣操作single-slag operation双渣操作double-slag operation渣乳化slag emulsion二次燃烧postcombustion吹氧时间oxygen blow duration吹炼终点blow end point倒炉turning down喷渣slopping喷溅spitting静态控制static control动态控制dynamic control氧枪oxygen lance氧枪喷孔nozzle of oxygen lance多孔喷枪multi-nozzle lance转炉炉体converter body炉帽upper cone炉口mouth,lip ring装料大面impact pad活动炉底removable bottom顶吹氧枪top blow oxygen lance副枪sublance多孔砖nozzle brick单环缝喷嘴single annular tuyere双环缝喷嘴double annular tuyere挡渣器slag stopper挡渣塞floating plug电磁测渣器electromagnetic slag detector废气控制系统off gas control system,OGCS平炉open-hearth furnace平炉炼钢open-hearth steelmaking冷装法cold charge practice热装法hot charge practice碳沸腾carbon boil石灰沸腾lime boil炉底沸腾bottom boil再沸腾reboil有效炉底面积effective hearth area酸性平炉acid open-hearth furnace碱性平炉basic open-hearth furnace固定式平炉stationary open-hearth furnace倾动式平炉tilting open-hearth furnace双床平炉twin-hearth furnace顶吹氧气平炉open-hearth furnace with roof oxygen lance蓄热室regenerator沉渣室slag pocket电炉炼钢electric steelmaking电弧炉electric arc furnace超高功率电弧炉ultra-high power electric arc furnace直流电弧炉direct current electric arc furnace双电极直流电弧炉double electrode direct current arc furnace 竖窑式电弧炉shaft arc furnace电阻炉electric resistance furnace工频感应炉line frequency induction furnace中频感应炉medium frequency induction furnace高频感应炉high frequency induction furnace电渣重熔electroslag remelting,ESR电渣熔铸electroslag casting,ESC电渣浇注Bohler electroslag tapping,BEST真空电弧炉重熔vacuum arc remelting,VAR真空感应炉熔炼vacuum induction melting,VIM电子束炉重熔electron beam remelting,EBR等离子炉重炼plasma-arc remelting,PAR水冷模电弧熔炼cold-mold arc melting等离子感应炉熔炼plasma induction melting,PIM等离子连续铸锭plasma progressive casting,PPC等离子凝壳铸造plasma skull casting,PSC能量优化炼钢炉energy optimizing furnace,EOF氧燃喷嘴oxygen-fuel burner氧煤助熔accelerated melting by coal-oxygen burner氧化期oxidation period还原期reduction period长弧泡沫渣操作弧长控制 long arc foaming slag operation白渣white slag电石渣carbide slag煤氧喷吹coal-oxygen injection炉壁热点hot spots on the furnace wall偏弧arc bias透气塞porous plug出钢到出钢时间tap-to-tap time虹吸出钢siphon tapping偏心炉底出钢eccentric bottom tapping,EBT中心炉底出钢centric bottom tapping,CBT侧面炉底出钢side bottom tapping,SBT滑动水口出钢slide fate tapping5.8 精炼、浇铸及缺陷铁水预处理hot metal pretreatment机械搅拌铁水脱硫法KR process torpedo desulfurization鱼雷车铁水脱磷torpedo dephosphorization二次精炼secondary refining钢包精炼ladle refining合成渣synthetic slag微合金化microalloying成分微调trimming钢洁净度steel cleanness钢包炉ladle furnace,LF直流钢包炉DC ladle furnace真空钢包炉LF-vacuum真空脱气vacuum degassing真空电弧脱气vacuum arc degassing,VAD真空脱气炉vacuum degassing furnace,VDF真空精炼vacuum refining钢流脱气stream degassing提升式真空脱气法 Dortmund Horder vacuum degassing process,DH 循环式真空脱气法 Ruhstahl-Hausen vacuum degassing process,RH 真空浇铸vacuum casting吹氧RH操作RH-oxygen blowing,RH-OB川崎顶吹氧RH操作 RH-Kawasaki top blowing,RH-KTB喷粉RH操作RH-poowder blowing,TH-PB喷粉法powder injection process喷粉精炼injection refining蒂森钢包喷粉法Thyssen Niederhein process,TN瑞典喷粉法Scandinavian Lancer process,SL君津真空喷粉法vacuum Kimitsu injection process密封吹氩合金成分调整法composition adjustment by sealed argon bubbling,CAS吹氧提温CAS法CAS-OB process脉冲搅拌法pulsating mixing process,PM电弧加热电磁搅拌钢包精炼法ASEA-SKF process真空吹氧脱碳法vacuum oxygen decarburization process ,VOD 氩氧脱碳法argon-oxygen decarburization process,AOD蒸汽氧精炼法Creusot-Loire Uddelholm process,CLU无渣精炼slag free refining摇包法shaking ladle process铝弹脱氧法aluminium bullet shooting,ABS钢锭ingot铸锭ingot casting坑铸pit casting车铸car casting钢锭模ingot mold保温帽hot top下铸bottom casting上铸top casting补浇back pour,back feeding浇注速度pouring speed脱模ingot stripping发热渣exoslag防再氧化操作reoxidation protection连续浇注continuous casting连铸机continuous caster,CC,continuous casting machine,CCM 弧形连铸机bow-type continuous caster立弯式连铸机vertical-bending caster立式连铸机vertical caster水平连铸机horizontal caster小方坯连铸机billet caster大方坯连铸机bloom caster板坯连铸机slab caster薄板坯连铸机thin-slab casting薄带连铸机strip caster近终型浇铸near-net-shape casting单辊式连铸机single-roll caster单带式连铸机single-belt caster双带式连铸机twin-belt caster倾斜带式连铸机inclined conveyer type caster[连铸]流strand铸流间距strand distance注流对中控制stream centering control钢包回转台ladle turret中间包tundish回转式中间包swiveling tundish倾动式中间包tiltable tundish中间包挡墙weir and dam in tundish引锭杆dummy bar刚性引锭杆rigid dummy bar挠性引锭杆flexible dummy bar结晶器mold直型结晶器straight mold弧形结晶器curved mold组合式结晶器composite mold多级结晶器multi-stage mold调宽结晶器adjustable mold结晶器振动mold oscillation结晶器内钢液顶面meniscus,steel level钢液面控制技术steel level control technique 保护渣casting powder,mold powder凝壳shell液芯liquid core空气隙air gap一次冷却区peimary cooling zone二次冷却区secondary cooling zone极限冷却速度critical cooling rate浇铸半径casting radius渗漏bleeding拉坯速度casting speed拉漏breaking out振动波纹oscillation mark水口堵塞nozzle clogging气水喷雾冷却air mist spray cooling分离环separating ring拉辊withdrawal roll立式导辊vertical guide roll弯曲辊bending roll夹辊pinch roll矫直辊straightening roll驱动辊driving roll导向辊装置roller apron切割定尺装置cut-to-length device钢流保护浇注shielded casting practice多点矫直multipoint straightening电磁搅拌electromagnetic stirring,EMS浇注周期casting cycle多炉连浇sequence casting事故溢流槽emergercy launder菜花头cauliflower top。

冶金英语词汇（最全）1 总论采矿mining地下采矿underground mining露天采矿open cut mining, open pit mining, surface mining采矿工程mining engineering选矿（学）mineral dressing, ore beneficiation, mineral processing矿物工程mineral engineering冶金（学）metallurgy过程冶金（学）process metallurgy提取冶金（学）extractive metallurgy化学冶金（学）chemical metallurgy物理冶金（学）physical metallurgy金属学Metallkunde冶金过程物理化学physical chemistry of process metallurgy冶金反应工程学metallurgical reaction engineering冶金工程metallurgical engineering钢铁冶金（学）ferrous metallurgy, metallurgy of iron and steel有色冶金(学)nonferrous metallurgy真空冶金(学)vacuum metallurgy等离子冶金(学)plasma metallurgy微生物冶金(学)microbial metallurgy喷射冶金(学)injection metallurgy钢包冶金(学)ladle metallurgy二次冶金(学)secondary metallurgy机械冶金(学)mechanical metallurgy焊接冶金(学)welding metallurgy粉末冶金(学)powder metallurgy铸造学foundry火法冶金(学)pyrometallurgy湿法冶金(学)hydrometallurgy电冶金(学)electrometallurgy氯冶金(学)chlorine metallurgy矿物资源综合利用engineering of comprehensive utilization of mineral resources中国金属学会The Chinese Society for Metals中国有色金属学会The Nonferrous Metals Society of China2 采矿采矿工艺mining technology有用矿物valuable mineral冶金矿产原料metallurgical mineral raw materials矿床mineral deposit特殊采矿specialized mining海洋采矿oceanic mining, marine mining矿田mine field矿山mine露天矿山surface mine地下矿山underground mine矿井shaft矿床勘探mineral deposit exploration矿山可行性研究mine feasibility study矿山规模mine capacity矿山生产能力mine production capacity矿山年产量annual mine output矿山服务年限mine life矿山基本建设mine construction矿山建设期限mine construction period矿山达产arrival at mine full capacity开采强度mining intensity矿石回收率ore recovery ratio矿石损失率ore loss ratio工业矿石industrial ore采出矿石extracted ore矿体orebody矿脉vein海洋矿产资源oceanic mineral resources矿石ore矿石品位ore grade岩石力学rock mechanics岩体力学rock mass mechanics3 选矿选矿厂concentrator, mineral processing plant 工艺矿物学process mineralogy开路open circuit闭路closed circuit流程flowsheet方框流程block flowsheet产率yield回收率recovery矿物mineral粒度particle size粗颗粒coarse particle细颗粒fine particle超微颗粒ultrafine particle粗粒级coarse fraction细粒级fine fraction网目mesh原矿run of mine, crude精矿concentrate粗精矿rough concentrate混合精矿bulk concentrate最终精矿final concentrate尾矿tailings粉碎comminution破碎crushing磨碎grinding团聚agglomeration筛分screening, sieving分级classification富集concentration分选separation手选hand sorting重选gravity separation, gravity concentration 磁选magnetic separation电选electrostatic separation浮选flotation化学选矿chemical mineral processing自然铜native copper铝土矿bauxite冰晶石cryolite磁铁矿magnetite赤铁矿hematite假象赤铁矿martite钒钛磁铁矿vanadium titano-magnetite铁燧石taconite褐铁矿limonite菱铁矿siderite镜铁矿specularite硬锰矿psilomelane软锰矿pyrolusite铬铁矿chromite黄铁矿pyrite钛铁矿ilmennite金红石rutile萤石fluorite高岭石kaolinite菱镁矿magnesite重晶石barite石墨graphite石英quartz方解石calcite石灰石limestone白云石dolomite云母mica石膏gypsum硼砂borax石棉asbestos蛇纹石serpentine阶段破碎stage crushing粗碎primary crushing中碎secondary crushing细碎fine crushing对辊破碎机roll crusher粉磨机pulverizer震动筛vibrating screen筛网screen cloth筛孔screen opening筛上料oversize筛下料undersize粗磨coarse grinding细磨fine grinding球磨机ball mill衬板liner分级机classifier自由沉降free setting沉积sedimentation石灰lime松油pine oil硫化钠sodium sulfide硅酸钠（水玻璃）sodium silicate, water glass过滤filtration过滤机filter给矿，给料feeding给矿机feeder在线分析仪on line analyzer在线粒度分析仪on line size analyzer超声粒度计ultrasonic particle sizer, supersonic particle sizer4 冶金过程物理化学4.1 冶金过程热力学冶金过程热力学thermodynamics of metallurgical processes 统计热力学statistical thermodynamics不可逆过程热力学thermodynamics of irreversible processes 化学热力学chemical thernodynamics表面热力学surface thermodynamics合金热力学thermodynamics of alloys冶金热力学数据库thermodynamics databank in metallurgy 系system单元系single-componentsystem多元系multicomponent system均相系统homogeneous system广度性质extensive property强度性质intensive property过程process等温过程isothermal process等压过程isobaric process等容过程isochoric process绝热过程adiabatic process可逆过程reversible process不可逆过程irreversible process自发过程spontaneous process自理过程physical process化学过程chemical process冶金过程metallurgical process化学反应chemical reaction化合反应combination reaction分解反应decomposition reaction置换反应displacement reaction可逆反应reversible reaction不可逆反应irreversible reaction电化学反应electrochemical reaction多相反应multiphase reaction固态反应solid state reaction气一金(属)反应gas-metal reaction渣一金（属）反应slag-metal reaction平衡equilibrium化学平衡chemical equilibrium相平衡phase equilibrium热力学平衡thermodynamic equilibrium亚稳平衡metastable equilibrium热力学函数thermodynamic function偏摩尔量partial molar quantity总摩尔量integral molar quantity标准态standard state焓enthalpy生成焓enthalpy of formation反应焓enthalpy of reaction熵entropy吉布斯能Gibbs energy生成吉布斯能Gibbs energy of formation反应吉布斯能Gibbs energy of reaction溶解吉布斯能Gibbs energy of solution吉布斯能函数Gibbs energy function化学位chemical potential热化学thermochemistry热效应heat effect热容heat capacity熔化热heat of fusion汽化热heat of vaporization升华热heat of sublimation相变热heat of phase transformation放热反应exothermic reaction吸热反应endothermic reaction赫斯定律Hess’s law相律phase rule相图phase diagram一元相图single-component phase diagram二元相图binary-component phase diagram三元相图ternary-component phase diagram液相线liquidus固相线solidus共晶点eutectic point杠杆规则lever rule溶液solution溶质solute溶剂solvent固溶体solid solution溶液浓度concentration of solution摩尔分数mole fraction冶金熔体metallurgical melt金属熔体metal melt(炉)渣,熔渣slag熔盐molten salt, fused salt理想溶液ideal solution真实溶液real solution正规溶液regular solution活度activity活度系数activity coefficient拉乌尔定律Raoult’s law亨利定律Henry’s law纯物质标准态pure substance standard质量１％溶液标准(态)1 mass% solution standard无限稀溶液参考态reference state of infinityly dilute solution相互作用系数interaction coefficient化学反应等温式chemical reaction isotherm吉布斯～亥姆霍兹方程Gibbs-Helmholtz equation质量作用定律law of mass action平衡常数equilibrium constant平衡值equilibrium value直接还原direct reduction间接还原indirect reduction金属热还原metallothermic reduction选择性氧化selective oxidation渣碱度basicity of slag光学破度optical basicity酸性氧化物acid oxide碱性氧化物basicoxide两性氧化物amphoteric泡沫渣foaming slag熔渣的分子理论molecular theory of slag熔渣的离子理论ionization theory of slag脱氧平衡deoxidation equilibrium脱氧常数deoxidation constant熔渣脱硫desulfurization by slag气态脱硫desulfurization in the gaseous state硫分配比sulfur partition ratio硫化物容量sulfide capacity氧化脱磷dephosphorization under oxidizing atmosphere磷分配比碳一氧平衡carbon-oxygen equilibrium真空脱碳vacuum decarburization去气degassing去除非金属夹杂(物)elimination of nonmetallic inclusion非金属夹杂(物)变形form modification of nonmetallic inclusion 脱硅desiliconization脱锰demanganization分配平衡distribution law化学气相沉积chemical vapor deposition(CVD)4.2 冶金过程动力学微观动力学microkinetics化学动力学chemical kinetics反应途径reaction path反应机理reaction mechanism基元反应elementary reaction平行反应parallel链反应chain reaction总反应overall reaction反应速率reaction rate反应速率常数reaction rate constant反应级数reaction order零级反应zero order reaction一级反应first order reaction二级反应second order reactionn级反应nth order reaction碰撞理论collision theory活化能activation energy表现活化能apparent activation energy阿伦尼乌斯方程Arrhenius equation半衰期half-life宏观动力学macrokinetics冶金过程动力学kinetics of metallurgical process 传输现象transport phenomena传质mass transfer传热heat transfer动量传输momentum transfer层流laminar flow湍流turbulent flow气泡gas bubble鼓泡bubbling射流jet液滴liquid droplet粘度viscosity边界层boundary layer流率flow rate通量flux扩散diffusion菲克第一扩散定律Fick’s 1st law of diffusion 菲克第一扩散定律Fick’s 2nd law of diffusion 扩散系数diffusion coefficient传质系数mass transfer coefficient热传导heat conduction热对流heat convection自然对流natural convection强制对流forced convection热辐射heat radiation导热率thermal conductivity传热系数heat transfer coefficient体内浓度bulk concentration未反应核模型unreacted core model扩散控制反应diffusion-controlled reaction化学控制反应chenical-controlled reaction混合控制反应mixed-controlled reaction相似原理priciple of similarity雷诺数Reynolds number固定床fiexed bed填充床packed bed移动床moving bed流态化床fluidized bed混合时间mixing time停留时间residence time, retention time催化catalysis催化剂catalyst表面能surface energy表面张力surface tension界面能interfacial energy界面张力interfacial tension润湿wetting表面活性物质surface-active substance吸收absorption吸附absorption4.3 冶金电化学冶金电化学metallurgical electrochemistry熔盐电化学electrochemistry of fused salts固态离子学solid state ionics电解质溶液electrolyte solution阳离子cation阴离子anion电导conductance电导率conductivity电阻resistance电极electrode阴极cathode阳极anode电镀electroplating固体电解质solid electrolyte稳定的氧化锆stablized zirconia氧传感器oxygen sensor硅传感器silicon sensor定氧测头oxygen probe定硅测头silicon probe4.4 冶金物理化学研究方法冶金物理化学研究方法research methods in metallurgical physical chemistry热电偶thermocouple量热计calorimeter热太平thermobalance热分析thermal analysis差热分析differential thermal analysis,DTA热重法thermogravimetry分子筛molecular sieve5 钢铁冶金5.1 炼焦炼焦coking高温炭化high temperature carbonization塑性成焦机理plastic mechanism of coke formation中间相成焦机理mesophase mechanism of coke formation 选煤coal preparation, coal washing配煤coal blending配煤试验coal blending test炼焦煤coking coal气煤gas coal肥煤fat coal瘦煤lean coal焦炉coke oven焦化室oven chamber焦饼coke cake结焦时间coking time周转时间cycle time装煤coal charging捣固装煤stamp charging推焦coke pushing焦炭熄火coke quenching干法熄焦dry quenching of coke焦台coke wharf装煤车larry car推焦机pushing machine拦焦机coke guide熄焦车quenching car焦炉焖炉banking for coke oven焦炭coke冶金焦metallurgical coke铸造焦foundry coke焦炭工业分析proximate analysis of coke焦炭元素分析ultimate analysis of coke焦炭落下指数shatter index of coke焦炭转鼓指数drum index of coke焦炭热强度hot strength of coke焦炭反应性coke reactivity焦炭反应后强度post-reaction strength of coke焦炭显微强度microstrength of coke焦炉煤气coke oven gas发热值calorific value煤焦油coal tar粗苯crude benzol苯benzene甲苯toluene二甲苯xylene苯并呋喃-茚树脂coumarone-indene resin精萘refined naphthalene精蒽refined anthracene煤[焦油]沥青coal tar pitch沥青焦pitch coke针状焦needle coke型焦formcoke5.2 耐火材料耐火材料refractory materials耐火粘土fireclay高岭土kaolin硬质粘土flint clay轻质粘土soft clay陶土pot clay蒙脱石montmorillonite叶蜡石pyrophyllite膨润土bentonite鳞石英tridymite方石英cristobalite砂岩sandstone耐火石firestone莫来石mullite氧化铝alumina烧结氧化铝sintered alumina电熔氧化铝fused alumina刚玉corundum红柱石andalusite蓝晶石kyanite,cyanite硅线石sillimanite橄榄石olivine方镁石periclase镁砂magnesia合成镁砂synthetic sintered magnesia电熔镁砂fused magnesia烧结白云石砂sintered dolomite clinker合成镁铬砂synthetic magnesia chromite clinker尖晶石spinel镁铬尖晶石magnesia chrome spinel,magnesiochromite 硅藻土diatomaceous earth, infusorial earth蛭石vermiculite珍珠岩perlite碳化硅silicon carbide氮化硅silicon nitride氮化硼boron nitride粘土熟料chamotte熟料grog轻烧light burning,soft burning死烧dead burning,hard burning成型模注shaping moulding机压成型mechanical pressing等静压成型isostatic pressing摩擦压砖机friction press液压压砖机hydraulic press捣打成型ramming process熔铸成型fusion cast process砖坯强度green strength,dry strength隧道窑tunnel kiln回转窑rotary kiln倒焰窑down draught kiln耐火砖refractory brick标准型耐火砖standard size refractory brick泡砂石quartzite sandstone酸性耐火材料acid refractory [material]硅质耐火材料siliceous refractory [material]硅砖silica brick,dinas brick熔融石英制品fused quartz product硅酸铝质耐火材料aluminosillicate refractory半硅砖semisilica brick粘土砖fireclay brick,chamotte brick石墨粘土砖graphite clay brick高铝砖high alumina brick硅线石砖sillimanite brick莫来石砖mullite brick刚玉砖corundum brick铝铬砖alumina chrome brick熔铸砖fused cast brick碱性耐火材料basic refractory [material]镁质耐火材料magnesia refractory [material]镁砖magnesia brick镁铝砖magnesia alumina brick镁铬砖magnesia chrome brick镁炭砖magnesia carbon brick中性耐火材料neutral refractory [material]复合砖composite brick铝炭砖alumina carbon brick铝镁炭转alumina magnesia brick锆炭砖zirconia graphite brick镁钙炭砖magnesia clacia carbon brick长水口long nozzle浸入式水口immersion nozzle,submerged nozzle定径水口metering nozzle氧化铝-碳化硅-炭砖Al2O3-SiC-C brick透气砖gas permeable brick,porous brick滑动水口slide gate nozzle水口砖nozzle brick塞头砖stopper绝热耐火材料insulating refractory轻质耐火材料light weight refractory袖砖sleeve brick格子砖checker brick,chequer brick陶瓷纤维ceramic fiber耐火纤维refractory fiber耐火浇注料refractory castable耐火混凝土refractory concrete荷重耐火性refractoriness under load抗渣性slagging resistance耐磨损性abrasion resistance5.3 碳素材料[含]碳[元]素材料carbon materials无定形碳amorphous carbon金刚石diamond炭相[学]carbon micrography炭黑carbon black石油沥青petroleum pitch石油焦炭petroleum coke石墨化graphitization石墨化电阻炉electric resistance furnace for graphitization 石墨纯净化处理purification treatment of graphite炭砖carbon brick炭块carbon block碳化硅基炭块SiC-based carbon block炭电极carbon electrode连续自焙电极Soderberg electrode石墨电极graphite electrode超高功率石墨电极ultra-high power graphite electrode 石墨电极接头graphite electrode nipple石墨电极接头孔graphite electrode socket plug电极糊electrode paste石墨坩埚graphite crucible石墨电阻棒graphite rod resistor炭刷carbon brush高纯石墨high purity graphite5.4 铁合金铁合金ferroalloy硅铁ferrosilicon硅钙calcium silicon金属硅silicon metal锰铁ferromangnanese低碳锰铁low carbon ferromanganese硅锰silicomanganese金属锰manganese metal铬铁ferrochromium低碳铬铁low carbon ferrochromium微碳铬铁extra low carbon ferrochromium硅铬silicochromium金属铬chromium metal钨铁ferrotunsten钼铁ferromolybdenum钛铁ferrotitanium硼铁ferroboron铌铁ferroniobium磷铁ferrophosphorus镍铁ferronickel锆铁ferrozirconium硅锆silicozirconium稀土硅铁rare earth ferrosilicon稀土镁硅铁rare earth ferrosilicomagnesium成核剂nucleater孕育剂incubater,inoculant球化剂nodulizer蠕化剂vermiculizer中间铁合金master alloy复合铁合金complex ferroalloy电碳热法electro-carbothermic process电硅热法electro-silicothermic process铝热法aluminothermic process,thermit process电铝热法electro-aluminothermic process开弧炉open arc furnace埋弧炉submerged arc furnace半封闭炉semiclosed furnace封闭炉closed furnace矮烟罩电炉electric furnace with low hood矮炉身电炉low-shaft electric furnace5.5 烧结与球团人造块矿ore agglomerates烧结矿sinter压块矿briquette球团[矿] pellet针铁矿goethite自熔性铁矿self-fluxed iron ore复合铁矿complex iron ore块矿lump ore粉矿ore fines矿石混匀ore blending配矿ore proportioning矿石整粒ore size grading返矿return fines储矿场ore stockyard矿石堆料机ore stocker匀矿取料机ore reclaimer熔剂flux消石灰slaked lime活性石灰quickened lime有机粘结剂organic binder烧结混合料sinter mixture烧结铺底料hearth layer for sinter烧结sintering烧结热前沿heat front in sintering烧结火焰前沿flame front in sintering渣相粘结slag bonding扩散粘结diffusion bonding带式烧结机Dwight-Lloyd sintering machine环式烧结机circular travelling sintering machine 烧结梭式布料机shuttle conveyer belt烧结点火料sintering ignition furnace烧结盘sintering pan烧结锅sintering pot烧结冷却机sinter cooler带式冷却机straight-line cooler环式冷却机circular cooler,annular cooler生球green pellet,ball生球长大聚合机理ball growth by coalescence生球长大成层机理ball growth by layering生球长大同化机理ball growth by assimilation精矿成球指数balling index for iron ore concentrates 生球转鼓强度drum strength of green pellet生球落下强度shatter strength of green pellet生球抗压强度compression strength of green pellet 生球爆裂温度cracking temperature of green pellet 圆筒造球机balling drum圆盘造球机balling disc竖炉陪烧球团shaft furnace for pellet firing带式机陪烧球团traveling grate for pellet firing链算机-回转窑陪烧球团grate-kiln for pellet firing环式机陪烧球团circular gates for pellet firing冷固结球团cold bound pellet维式体wustite铁橄榄石fayalite铁尖晶石hercynite铁黄长石ferrogehlenite铁酸半钙calcium diferrite铁酸钙calcium ferrite铁酸二钙dicalcium ferrite锰铁橄榄石knebelite钙铁橄榄石kirschsteinite钙铁辉石hedenbergite钙铁榴石andradite钙长石anorthite钙镁橄榄石monticellite钙钛矿perovskite硅灰石wollastonite硅酸二钙dicalcium silicate硅酸三钙tricalcium silicate镁橄榄石forsterite镁黄长石akermanite镁蔷薇辉石manganolite钙铝黄长石gehlenite钛辉石titanaugite枪晶石cuspidine预还原球团pre-reduced pellet金属化球团metallized pellet转鼓试验drum test,tumbler test落下试验shatter test5.6 高炉炼铁炼铁iron making高炉炼铁[法] blast furnace process高炉blast furnace鼓风炉blast furnace炉料charge, burden矿料ore charge焦料coke charge炉料提升charge hoisting小车上料charge hoisting by skip吊罐上料charge hoisting by bucket皮带上料charge hoisting by belt conveyer装料charging装料顺序charging sequence储料漏斗hopper双料钟式装料two-bells system charging无料钟装料bell-less charging布料器distributor炉内料线stock line in the furnace探料尺gauge rod利用系数utilization coefficient冶炼强度combustion intensity鼓风blast风压blast pressure风温blast temperature鼓风量blast volume鼓风湿度blast humidity全风量操作full blast慢风under blowing休风delay喷吹燃料fuel injection喷煤coal injection喷油oil injection富氧鼓风oxygen enriched blast,oxygen enrichment 置换比replacement ratio喷射器injector热补偿thermal compensation焦比coke ratio,coke rate燃料比fuel ratio,fuel rate氧化带oxidizing zone风口循环区raceway蒸汽鼓风humidified blast混合喷吹mixed injection脱湿鼓风dehumidified blast炉内压差pressure drop in furnace煤气分布gas distribution煤气利用率gas utilization rate炉况furnace condition顺行smooth running焦炭负荷coke load,ore to coke ratio软熔带cohesive zone,softening zone渣比slag to iron ratio,slag ratio上部[炉料]调节burden conditioning下部[鼓风]调节blast conditioning高炉作业率operation rate of blast furnace 休风率delay ratio高炉寿命blast furnace campaign悬料hanging崩料slip沟流channeling结瘤scaffolding炉缸冻结hearth freeze-up开炉blow on停炉blow off积铁salamander炉型profile,furnace lines炉喉throat炉身shaft,stack炉腰belly炉腹bosh炉缸hearth炉底bottom炉腹角bosh angle炉身角stack angle有效容积effective volume工作容积working bolume铁口iron notch, slag notch渣口cinder notch, slag notch风口tuyere窥视孔peep hole风口水套tuyere cooler渣口水套slag notch cooler风口弯头tuyere stock热风围管bustle pipe堵渣机stopper泥炮mud gun,clay gun开铁口机iron notch drill铁水hot metal铁[水]罐iron ladle鱼雷车torpedo car主铁沟sow出铁沟casting house铁沟iron runner渣沟slag runner渣罐cinder ladle, slag ladle撇渣器skimmer冷却水箱cooling plate冷却壁cooling stave汽化冷却vaporization cooling热风炉hot blast stove燃烧室combustion chamber燃烧器burner热风阀hot blast valve烟道阀chimney valve冷风阀cold blast valve助燃风机burner blower切断阀burner shut-off valve旁通阀by-pass valve混风阀mixer selector valve送风期on blast of stove,on blast燃烧期on gas of stove, on gas换炉stove changing放散阀blow off valve内燃式热风炉Cowper stove外燃式燃烧炉outside combustion stove顶燃式热风炉top combustion stove炉顶放散阀bleeding valve放散管bleeder上升管gas uptake放风阀snorting valve均压阀equalizing valve高压调节阀septum valve炉顶高压elevated top pressure铸铁机pig-casting machine铸铁模pig mold冲天炉cupola水渣granulating slag水渣池granulating pit渣场slag disposal pit高炉煤气top gas,blast furnace gas高炉煤气回收topgas recovery,TGR非焦炭炼铁non-coke iron making直接还原炼铁[法]direct reduction iron making直接还原铁directly reduced iron,DRI竖炉直接炼铁direct reduction in shaft furnace流态化炼铁fluidized-bed iron making转底炉炼铁rotary hearth iron making米德雷克斯直接炼铁[法]Midrex processHYL直接炼铁[法] HYL process克虏伯回转窑炼铁[法] Krupp rotary kiln iron-making 熔态还原smelting reduction铁溶法iron-bath process科雷克斯法COREX process生铁pig iron海绵铁sponge iron镜铁spiegel iron清铁法H-rion process5.7 炼钢钢steel炼钢steelmaking钢水liquid steel,molten steel钢semisteel沸腾钢rimming steel,rimmed steel镇静钢killed steel半镇静钢semikilled steel压盖沸腾钢capped steel坩埚炼钢法crucible steelmaking双联炼钢法duplex steelmaking process连续炼钢法continuous steelmaking process直接炼钢法direct steelmaking process混铁炉hot metal machine装料机charging machine装料期charging machine加热期heating period熔化期melting period造渣期slag forming period精炼期refining period熔清melting down脱氧deoxidation预脱氧preliminary dexidation还原渣reducing slag酸性渣acid slag碱性渣basic slag脱碳decarburization增碳recarburization脱磷dephosphorization回磷rephosphorization脱硫desulfurization回硫resulfurization脱氮denitrogenation过氧化overoxidation出钢tapping冶炼时间duration of heat出钢样tapping sample浇铸样casting sample不合格炉次off heat熔炼损耗melting loss铁损iron loss废钢scrap废钢打包baling of scrap造渣材料slag making materials添加剂addition reagent脱氧剂deoxidizer脱硫剂desulfurizer冷却剂coolant回炉渣return slag喷枪lance浸入式喷枪submerged lance钢包ladle出钢口top hole出钢槽pouring lining炉顶furnace roof炉衬furnace lining炉衬侵蚀lining erosion渣线slag line炉衬寿命lining life分区砌砖zoned lining补炉fettling热修hot repair喷补gunning火焰喷补flame gunning转炉converter底吹转炉bottom-blown converter酸性空气底吹转炉air bottom-blown acid converter碱性空气底吹转炉air bottom-blown basic converter侧吹转炉side-blown converter卡尔多转炉Kaldo converter氧气炼铁oxygen steelmaking氧气顶吹转炉top-blown oxygen converter,LI converter氧气底吹转炉bottom-blown oxygen converter quiet basic oxygen furnace,QBOF顶底复吹转炉top and bottom combined blown converter喷石灰粉顶吹氧气转炉法oxygen lime process底吹煤氧的复合吹炼法Klockner-Maxhutte steelmaking process,KMS 住友复合吹炼法Sumitomo top and bottom blowing process,STB LBE复吹法lance bubbling equilibrium process,LBE顶枪喷煤粉炼钢法Arved lance carbon injection process,ALCI蒂森复合吹炼法Thyssen Blassen Metallurgical process,TBM面吹surface blow软吹soft blow硬吹hard blow补吹reblow过吹overblow后吹after blow目标碳aim carbon终点碳end point carbon高拉碳操作catch carbon practice增碳操作recarburization practice单渣操作single-slag operation双渣操作double-slag operation渣乳化slag emulsion二次燃烧postcombustion吹氧时间oxygen blow duration吹炼终点blow end point倒炉turning down喷渣slopping喷溅spitting静态控制static control动态控制dynamic control氧枪oxygen lance氧枪喷孔nozzle of oxygen lance多孔喷枪multi-nozzle lance转炉炉体converter body炉帽upper cone炉口mouth,lip ring装料大面impact pad活动炉底removable bottom顶吹氧枪top blow oxygen lance副枪sublance多孔砖nozzle brick单环缝喷嘴single annular tuyere双环缝喷嘴double annular tuyere挡渣器slag stopper挡渣塞floating plug电磁测渣器electromagnetic slag detector废气控制系统off gas control system,OGCS平炉open-hearth furnace平炉炼钢open-hearth steelmaking冷装法cold charge practice热装法hot charge practice碳沸腾carbon boil石灰沸腾lime boil炉底沸腾bottom boil再沸腾reboil有效炉底面积effective hearth area酸性平炉acid open-hearth furnace碱性平炉basic open-hearth furnace固定式平炉stationary open-hearth furnace倾动式平炉tilting open-hearth furnace双床平炉twin-hearth furnace顶吹氧气平炉open-hearth furnace with roof oxygen lance蓄热室regenerator沉渣室slag pocket电炉炼钢electric steelmaking电弧炉electric arc furnace超高功率电弧炉ultra-high power electric arc furnace直流电弧炉direct current electric arc furnace双电极直流电弧炉double electrode direct current arc furnace 竖窑式电弧炉shaft arc furnace电阻炉electric resistance furnace工频感应炉line frequency induction furnace中频感应炉medium frequency induction furnace高频感应炉high frequency induction furnace电渣重熔electroslag remelting,ESR电渣熔铸electroslag casting,ESC电渣浇注Bohler electroslag tapping,BEST真空电弧炉重熔vacuum arc remelting,V AR真空感应炉熔炼vacuum induction melting,VIM电子束炉重熔electron beam remelting,EBR等离子炉重炼plasma-arc remelting,PAR水冷模电弧熔炼cold-mold arc melting等离子感应炉熔炼plasma induction melting,PIM等离子连续铸锭plasma progressive casting,PPC等离子凝壳铸造plasma skull casting,PSC能量优化炼钢炉energy optimizing furnace,EOF氧燃喷嘴oxygen-fuel burner氧煤助熔accelerated melting by coal-oxygen burner氧化期oxidation period还原期reduction period长弧泡沫渣操作弧长控制long arc foaming slag operation白渣white slag电石渣carbide slag煤氧喷吹coal-oxygen injection炉壁热点hot spots on the furnace wall偏弧arc bias透气塞porous plug出钢到出钢时间tap-to-tap time虹吸出钢siphon tapping偏心炉底出钢eccentric bottom tapping,EBT中心炉底出钢centric bottom tapping,CBT侧面炉底出钢side bottom tapping,SBT滑动水口出钢slide fate tapping5.8 精炼、浇铸及缺陷铁水预处理hot metal pretreatment机械搅拌铁水脱硫法KR process torpedo desulfurization鱼雷车铁水脱磷torpedo dephosphorization二次精炼secondary refining钢包精炼ladle refining合成渣synthetic slag微合金化microalloying成分微调trimming钢洁净度steel cleanness钢包炉ladle furnace,LF直流钢包炉DC ladle furnace真空钢包炉LF-vacuum真空脱气vacuum degassing真空电弧脱气vacuum arc degassing,V AD真空脱气炉vacuum degassing furnace,VDF真空精炼vacuum refining钢流脱气stream degassing提升式真空脱气法Dortmund Horder vacuum degassing process,DH 循环式真空脱气法Ruhstahl-Hausen vacuum degassing process,RH 真空浇铸vacuum casting吹氧RH操作RH-oxygen blowing,RH-OB川崎顶吹氧RH操作RH-Kawasaki top blowing,RH-KTB喷粉RH操作RH-poowder blowing,TH-PB喷粉法powder injection process喷粉精炼injection refining蒂森钢包喷粉法Thyssen Niederhein process,TN瑞典喷粉法Scandinavian Lancer process,SL君津真空喷粉法vacuum Kimitsu injection process密封吹氩合金成分调整法composition adjustment by sealed argon bubbling,CAS吹氧提温CAS法CAS-OB process脉冲搅拌法pulsating mixing process,PM电弧加热电磁搅拌钢包精炼法ASEA-SKF process真空吹氧脱碳法vacuum oxygen decarburization process ,VOD 氩氧脱碳法argon-oxygen decarburization process,AOD蒸汽氧精炼法Creusot-Loire Uddelholm process,CLU无渣精炼slag free refining摇包法shaking ladle process铝弹脱氧法aluminium bullet shooting,ABS钢锭ingot铸锭ingot casting坑铸pit casting车铸car casting钢锭模ingot mold保温帽hot top下铸bottom casting上铸top casting补浇back pour,back feeding浇注速度pouring speed脱模ingot stripping发热渣exoslag防再氧化操作reoxidation protection连续浇注continuous casting连铸机continuous caster,CC,continuous casting machine,CCM 弧形连铸机bow-type continuous caster立弯式连铸机vertical-bending caster立式连铸机vertical caster水平连铸机horizontal caster小方坯连铸机billet caster大方坯连铸机bloom caster板坯连铸机slab caster薄板坯连铸机thin-slab casting薄带连铸机strip caster近终型浇铸near-net-shape casting单辊式连铸机single-roll caster单带式连铸机single-belt caster双带式连铸机twin-belt caster倾斜带式连铸机inclined conveyer type caster[连铸]流strand铸流间距strand distance注流对中控制stream centering control钢包回转台ladle turret中间包tundish回转式中间包swiveling tundish倾动式中间包tiltable tundish中间包挡墙weir and dam in tundish引锭杆dummy bar刚性引锭杆rigid dummy bar挠性引锭杆flexible dummy bar结晶器mold直型结晶器straight mold弧形结晶器curved mold组合式结晶器composite mold多级结晶器multi-stage mold调宽结晶器adjustable mold结晶器振动mold oscillation结晶器内钢液顶面meniscus,steel level钢液面控制技术steel level control technique 保护渣casting powder,mold powder凝壳shell液芯liquid core空气隙air gap一次冷却区peimary cooling zone二次冷却区secondary cooling zone极限冷却速度critical cooling rate浇铸半径casting radius渗漏bleeding拉坯速度casting speed拉漏breaking out振动波纹oscillation mark水口堵塞nozzle clogging气水喷雾冷却air mist spray cooling分离环separating ring拉辊withdrawal roll立式导辊vertical guide roll弯曲辊bending roll夹辊pinch roll矫直辊straightening roll驱动辊driving roll导向辊装置roller apron切割定尺装置cut-to-length device钢流保护浇注shielded casting practice多点矫直multipoint straightening电磁搅拌electromagnetic stirring,EMS浇注周期casting cycle多炉连浇sequence casting事故溢流槽emergercy launder菜花头cauliflower top。

科目专业英语专业冶金工程姓名仲光绪学号1045562137HISTORY OF THE BASIC OXYGEN STEELMAKING PROCESSBasic Oxygen Steelmaking is unquestionably the "son of Bessemer", the original pneumatic process patented by Sir Henry Bessemer in 1856. Because oxygen was not available commercially in those days, air was the oxidant. It was blown through tuyeres in the bottom of the pear shaped vessel. Since air is 80% inert nitrogen, which entered the vessel cold but exited hot, removed so much heat from the process that the charge had to be almost 100% hot metal for it to be autogenous. The inability of the Bessemer process to melt significant quantities of scrap became an economic handicap as steel scrap accumulated. Bessemer production peaked in the U.S. in 1906 and lingered until the 1960s.There are two interesting historical footnotes to the original Bessemer story:William Kelly was awarded the original U.S. patent for pneumatic steelmaking over Bessemer in 1857. However, it is clear that Kelly's "air boiling" process was conducted at such low blowing rates that the heat generation barely offset the heat losses. He never developed a commercial process for making steel consistently.Most European iron ores and therefore hot metal was high in sulfur and phosphorus and no processes to remove these from steel had been developed in the 1860s. As a result, Bessemer's steel suffered from both "hot shortness" (due to sulfur) and "cold shortness" (due to phosphorus) that rendered it unrollable. For his first commercial plant in Sheffield, 1866, Bessemer remelted cold pig iron imported from Sweden as the raw material for his hot metal. This charcoal derived pig iron was low in phosphorus and sulfur, and (fortuitously) high in manganese which acted as a deoxidant. In contrast the U.S. pig iron was produced using low sulfur charcoal and low phosphorus domestic ore. Therefore, thanks to the engineering genius of Alexander Holley, two Bessemer plants were in operation by 1866. However, the daily output of remotely located charcoal blast furnaces was very low. Therefore, hot metal was produced by remelting pig iron in cupolas and gravity feeding it to the 5 ton Bessemer vessels.The real breakthrough for Bessemer occurred in 1879 when Sidney Thomas, a young clerk from a London police court, shocked the metallurgical establishment by presenting data on a process to remove phosphorus (and also sulfur) from Bessemer's steel. He developed basic linings produced from tar-bonded dolomite bricks. These were eroded to form a basic slag that absorbed phosphorus and sulfur, although the amounts remained high by modern standards. The Europeans quickly took to the "Thomas Process" because of their very high-phosphorus hot metal, and as a bonus, granulated the phosphorus-rich molten slag in water to create a fertilizer. In the U.S., Andrew Carnegie, who was present when Thomas presented his paper in London, befriended the young man and cleverly acquired the U.S. license, which squelched any steelmaking developments in the South where high phosphorus ores are located.Although Bessemer's father had jokingly suggested using pure oxygen instead of air, this possibility was to remain a dream until "tonnage oxygen" became available at a reasonable cost. A 250 ton BOF today needs about 20 tons of pure oxygen every 40 minutes. Despite its high cost, oxygen was used in Europe to a limited extent in the 1930's to enrich the air blast for blast furnaces and Thomas converters. It was also used in the U.S for scarfing and welding.The production of low cost tonnage oxygen was stimulated in World War II by the German V2 rocket program. After the war, the Germans were denied the right to manufacture tonnage oxygen, but oxygen plants were shipped to other countries. The bottom tuyeres used in the Bessemer and Thomas processes could not withstand even oxygen-enriched air, let alone pure oxygen. In the late 1940s, Professor Durrer in Switzerland pursued his prewar idea of injecting pure oxygen through the top of the vessel. Development now moved to neighboring Austria where developers wanted to produce low nitrogen, flat-rolled sheet, but a shortage of scrap precluded open hearth operations. Following pilot plant trials at Linz and Donawitz, a top blown pneumatic process for a 35 ton vessel using pure oxygen was commercialized by Voest at Linz in 1952. The nearby Dolomite Mountains also provided an ideal source of material for basic refractories.The new process was officially dubbed the "LD Process" and because of its high productivity was seen globally as a viable, low capital process by which the war torn countries of Europe could rebuild their steel industries. Japan switched from a rebuilding plan based on open hearths to evaluate the LD, and installed their first unit at Yawata in 1957.Two small North American installations started at Dofasco and McLouth in 1954. However, with the know-how and capital invested in 130 million tons of open hearth capacity, plans for additional open hearth capacity well along, cheap energy, and heat sizes greater by an order of magnitude (300 versus 30 tons), the incentive to install this untested, small-scale process in North America was lacking. The process was acknowledged as a breakthrough technically but the timing, scale, and economics were wrong for the time. The U.S，which manufactured about 50% of the world's total steel output, needed steel for a booming post-war economy.There were also acrimonious legal actions over patent rights to the process and the supersonic lance design, which was now multihole rather than single hole. Kaiser Industries held the U.S. patent rights but in the end, the U.S. Supreme Court supported lower court decisions that considered the patent to be invalid.Nevertheless, the appeal of lower energy, labor, and refractory costs for the LD process could not be denied and although oxygen usage in the open hearth delayed the transition to the new process in the U.S., oxygen steelmaking tonnage grew steadily in the 1960's. By 1969, it exceeded that of the open hearth for the first time and has never relinquished its position as the dominant steelmaking process in the U.S. but the name LD never caught on in the U.S.Technical developments over the years include improved computer models and instrumentation for improved turn-down control, external hot metal desulfurization, bottomblowing and stirring with a variety of gases and tuyeres, slag splashing, and improved refractories.INTRODUCTIONAccounting for 60% of the world's total output of crude steel, the Basic Oxygen Steelmaking (BOS) process is the dominant steelmaking technology. In the U.S., that figure is 54% and slowly declining due primarily to the advent of the "Greenfield" electric arc furnace (EAF)flat-rolled mills. However, elsewhere its use is growing.There exist several variations on the BOS process: top blowing, bottom blowing, and a combination of the two. This study will focus only on the top blowing variation.The Basic Oxygen Steelmaking process differs from the EAF in that it is autogenous, orself-sufficient in energy. The primary raw materials for the BOP are 70-80% liquid hot metal from the blast furnace and the balance is steel scrap. These are charged into the Basic Oxygen Furnace (BOF) vessel. Oxygen (>99.5% pure) is "blown" into the BOF at supersonic velocities. It oxidizes the carbon and silicon contained in the hot metal liberating great quantities of heat which melts the scrap. There are lesser energy contributions from the oxidation of iron, manganese, and phosphorus. The post combustion of carbon monoxide as it exits the vessel also transmits heat back to the bath.The product of the BOS is molten steel with a specified chemical anlaysis at 2900°F-3000°F. From here it may undergo further refining in a secondary refining process or be sent directly to the continuous caster where it is solidified into semifinished shapes: blooms, billets, or slabs.Basic refers to the magnesia (MgO) refractory lining which wears through contact with hot, basic slags. These slags are required to remove phosphorus and sulfur from the molten charge.BOF heat sizes in the U.S. are typically around 250 tons, and tap-to-tap times are about 40 minutes, of which 50% is "blowing time". This rate of production made the process compatible with the continuous casting of slabs, which in turn had an enormous beneficial impact on yields from crude steel to shipped product, and on downstream flat-rolled quality.BASIC OPERATIONBOS process replaced open hearth steelmaking. The process predated continuous casting. As a consequence, ladle sizes remained unchanged in the renovated open hearth shops and ingot pouring aisles were built in the new shops. Six-story buildings are needed to house the Basic Oxygen Furnace (BOF) vessels to accommodate the long oxygen lances that are lowered and raised from the BOF vessel and the elevated alloy and flux bins. Since the BOSprocess increases productivity by almost an order of magnitude, generally only two BOFs were required to replace a dozen open hearth furnaces.Some dimensions of a typical 250 ton BOF vessel in the U.S. are: height 34 feet, outside diameter 26 feet, barrel lining thickness 3 feet, and working volume 8000 cubic feet. A control pulpit is usually located between the vessels. Unlike the open hearth, the BOF operation is conducted almost "in the dark" using mimics and screens to determine vessel inclination, additions, lance height, oxygen flow etc.Once the hot metal temperature and chemical analaysis of the blast furnace hot metal are known, a computer charge models determine the optimum proportions of scrap and hot metal, flux additions, lance height and oxygen blowing time.A "heat" begins when the BOF vessel is tilted about 45 degrees towards the charging aisle and scrap charge (about 25 to 30% of the heat weight) is dumped from a charging box into the mouth of the cylindrical BOF. The hot metal is immediately poured directly onto the scrap from a transfer ladle. Fumes and kish (graphite flakes from the carbon saturated hot metal) are emitted from the vessel's mouth and collected by the pollution control system. Charging takes a couple of minutes. Then the vessel is rotated back to the vertical position and lime/dolomite fluxes are dropped onto the charge from overhead bins while the lance is lowered to a few feet above the bottom of the vessel. The lance is water-cooled with a multi-hole copper tip. Through this lance, oxygen of greater than 99.5% purity is blown into the mix. If the oxygen is lower in purity, nitrogen levels at tap become unacceptable.CONCLUSIONThe BOS has been a pivotal process in the transformation of the U.S. steel industry since World War II. Although it was not recognized at the time, the process made it possible to couple melting with continuous casting. The result has been that melt shop process and finishing mill quality and yields improved several percent, such that the quantity of raw steel required per ton of product decreased significantly.The future of the BOS depends on the availability of hot metal, which in turn depends on the cost and availability of coke. Although it is possible to operate BOFs with reduced hot metal charges, i.e. < 70%, there are productivity penalties and costs associated with the supply of auxiliary fuels. Processes to replace the blast furnace are being constantly being unveiled, and the concept of a hybrid BOF-EAF is already a reality at the Saldahna Works in South Africa. However, it appears that the blast furnace and the BOS will be with us for many decades into the future.The American Iron and Steel Institute acknowledges, with thanks, the contributions of Teresa M. Speiran, Senior Research Engineer, Refractories and Bruce A. Steiner, Senior Environmental Advisor, Collier Shannon Scott PLLC.氧气转炉炼钢氧气转炉炼钢工艺的历史氧气转炉炼钢无疑是“贝塞麦法的衍生”，气动原件过程由爵士亨利柏麦在1856年申请了专利。

冶金词汇英语翻译utilization factor 燃料利用系数fugacity 逸散能fugitiveness 逸散能full aging 完全时效full fusion thermit welding 熔化铝热焊full hardening 穿透硬化full length bore 穿孔full pattern 整体铸型full penetration 全熔透fuller's earth 漂白土fullering 压槽锤击fulminating gold 雷酸金fulminating mercury 雷汞fulminating platinum 雷酸铂fulminating silver 雷酸银fume 烟fuming furnace 烟化炉fuming process 烟化法function 函数funnel 漏斗;浇口杯furnace 炉furnace aisle 炉子跨furnace atmosphere 炉气氛furnace bay 炉子跨furnace black 炉黑furnace body 炉体furnace bottom 炉底furnace brazing 炉内钎焊furnace burdening 配炉料furnace campaign 炉子寿命furnace capacity 炉子容量furnace charge 炉料furnace coiler 炉用卷取机furnace coke 高炉焦炭furnace cooling 炉冷furnace end 炉头furnace gas 炉气furnace grate 炉篦furnace life 炉龄furnace lines 炉子内型furnace lining 炉衬furnace platform 炉台furnace roof 炉顶拱furnace run 冶炼进程furnace scale 炉内氧化皮furnace shaft 炉身furnace stack 炉身furnace top 炉顶furnace top platform 炉顶平台furnace transformer 电炉变压器fused cast basic brick 熔铸碱性砖fused electrolyte 熔融电解质fused flux 熔融态熔剂fused refractory 熔融耐火材料fused salt 熔融盐fused salt electrolysis 熔盐电解fusibility 可熔性fusible alloy 易熔合金fusible cone 测温锥fusing agent 熔剂fusion 熔化fusion cast brick 熔铸碱性砖fusion curve 熔化曲线fusion cutting 熔切fusion heat 熔化热fusion line 熔合线fusion penetration 焊透;焊透深度fusion point 熔点fusion temperature 熔化温度fusion thermit welding 铝热熔焊fusion welding 熔焊fusion zone 熔化带gadolinite 硅铍钇矿钕gadolinium 钆gage 尺度;计gage pressure 计示压力gage reduction 厚度压减gage rod 探尺gagging 矫正gahnite 锌尖晶石galactite 乳石galena 方铅矿galenite 方铅矿galling 磨损gallium 镓gallon 加仑galvanic coating 电镀galvanic corrosion 电化腐蚀galvanization 电镀galvanized prestressed steel 预应力镀锌钢galvanized sheet 镀锌薄板galvanized tube 镀锌管galvanized wire 镀锌丝galvanizing 镀锌galvanizing line 镀锌线galvanizing pot 镀锌槽galvanoplastics 电铸galvanoplasty 电铸galvanostegy 电镀gamma iron 铁gamma ray test 射线探伤gamma rays 射线gamma solid solution 固溶体gamma thickness gage 射线测厚仪gangue 脉石ganister 致密硅石gantry crane 龙门式起重机gap adjustment 轧辊间隙蝶garnierite 硅镁镍矿garret reel 加勒特式线材卷取机gas 气体gas absorption 气体吸收gas analyser 气体分析器gas analysis 气体分析gas analysis apparatus 气体分析装置gas atmosphere 气氛gas atomization 气体雾化gas black 气黑gas blower 煤气鼓风机gas boriding 气体渗硼gas brazing 焰炬加热断焊gas bubble 气泡gas burner 煤气燃烧器gas calorimeter 煤气量热器gas carbonitriding 气体碳氮共渗gas carburizing 气体渗碳gas cavity 气孔gas chromatographic analysis 气相色谱分析gas chromatography 气体色谱法gas cleaner 净气器gas cleaning 煤气净化gas coal 气煤gas coke 气化焦炭gas compressor 煤气压缩机gas conduit 煤气导管gas constant 气体常数gas cooler 气体冷却器gas corrosion 气体腐蚀gas curtain 气体帘幕gas cutter 气割器gas cutting 氧气切断gas cutting machine 火焰切割机gas cylinder 气瓶gas distribution 气体分布gas down take 煤气降下管gas dynamics 气体动力学gas environment 气氛gas evolution 气体析出gas expelling 脱气gas fired furnace 煤气燃烧炉gas flue 煤气通道gas furnace 煤气炉gas gate valve 煤气闸阀gas generator 煤气发生炉gas gouging 火焰刨槽gas heating 煤气加热gas impermeability 不透气性gas injection 吹气gas line 煤气管线gas line pipe 煤气管线用管gas mixture 气体混合物gas nitriding 气体氮化gas nitrocarburizing 气体共渗氮碳gas permeability 透气性gas pickling 气体浸蚀gas pipe 气管gas pocket 气阱gas porosity 气孔性gas port 煤气喷口gas pressure 煤气压力gas pressure welding 气体压力焊接gas producer 煤气发生炉gas purification 煤气净化gas purifier 净气器gas quenching 气体零火gas reforming 煤气变换gas release 气体放出gas removal 脱气gas scrubbing 煤气洗涤gas seal 气封gas separation 气体分离gas separator 气体分离器gas shielded arc welding 气体保护弧焊gas siliconizing 气体渗硅gas stirring 气体搅拌gas supply 煤气供应gas thermometer 气体温度计gas up take 煤气上升管gas valve 煤气阀gas washer 洗气器gas washing 煤气洗涤gas welder 气焊工gas welding 气焊gas welding equipm ent 气焊装置gaseous carburization 气体渗碳gaseous corrosion 气体腐蚀gaseous fuel 气体燃料gaseous phase 气相gasholder 储煤气柜gasification 气化gasket 密封垫gasket cement 填密料gassing 放气gate 闭锁器gate stick 浇口棒gated pattern 带浇口的铸模gathering table 收集辊道gating system 浇铸系统gauss 高斯gear 齿轮gear box 齿轮箱gear case 齿轮箱gear drive 齿轮传动gel 凝胶gelatin 煤general corrosion 全面腐蚀general waviness 总波纹generator 发电机generator furnace 煤气发生炉generator gas 发生炉煤气gentleman 软焊料用旋转机germ 核german silver 锌白铜germanite 锗石germanium 锗gersdorffite 辉砷镍矿getter 吸气剂ghost lines 鬼线gibbs free energy 自由焓gibbs thermodynamic potential 等压等温位gibbsite 水铝矿gilding 镀金gilsonite 硬沥青gilt 镀金girder 梁girder mill 钢梁轧机girth welding 环缝焊接glance coal 亮煤glass extrusion 玻璃润滑热挤压glass wool 玻璃棉glassy feldspar 透长石glauber's salt 芒硝glauberite 钙芒硝glaucodot 铁硫砷钴矿glauconite 海绿石glazed pig 高硅生铁glazing 抛光glazy pig 高硅生铁glide 滑移glide dislocation 滑移位错glide plane 滑移面glissile dislocation 滑动位错globular cementite 粒状渗碳体globular inclusion 球状夹杂物globular perlite 球状珠光体globular structure 球状结构globule 小球;珠滴globulites 球雏晶globurizing 球状化glow discharge 辉光放电glow discharge boriding 辉光放电渗硼glow discharge carbonitriding 辉光放电碳氮化glow discharge nitriding 辉光放电氮化glut weld v 形焊缝gneiss 片麻岩goethite 针铁矿gold 金gold amalgam 金汞膏gold beating 金箔制造gold bronze 金青铜gold bullion 金块gold chloride 氯化金gold cyanide 氰化金gold dust 金粉gold foil 金箔gold leaf 金箔gold ore 金矿石gold plating 镀金gold point 金点gold telluride 二碲化金goldschmidt's process 高氏铝热还原法goldsmithing 金饰工术goniometer 测角仪gooseneck 鹅颈管goslarite 皓矾goss texture 高斯织构gothic groove 弧边菱形孔型gothic pass 弧边菱形孔型gouging 开槽governor valve 第阀grab crane 抓斗起重机grade of steel 钢种gradient 梯度grading 分级grading analysis 粒度分析graduation 刻度grain 粒grain boundary 晶界grain boundary attack 晶界腐蚀grain boundary corrosion 晶界腐蚀grain boundary diffusion 晶界扩散grain boundary dislocation 晶界位错grain boundary migration 晶界移动grain boundary porosity 晶界气孔grain boundary precipitates 晶界沉淀物grain boundary segregation 晶界偏析grain boundary slip 晶界滑动grain composition 粒度组成grain fineness 细晶粒度grain growth 晶粒长大grain growth annealing 晶粒长大退火grain orientation 晶粒取向grain refining 细晶化grain segregation 晶内偏析grain size 粒度grain size analysis 粒度分析grain size number 粒度号数grain structure 晶粒结构graining 粒化granular cementite 粒状渗碳体granular powder 粒状粉granular structure 粒状组织granularity 粒度granulated copper 粒状铜granulated iron 粒化生铁granulated metal 粒状金属granulated powder 粒状粉granulated slag 水碎炉渣granulating 成粒granulating basin 水渣池granulating machine 制粒机granulating pit 水渣池granulation 成粒granule 细粒granulometric composition 粒度组成granulometric curve 粒度曲线graph 曲线图graphite 黑铅状碳素graphite brick 石墨砖graphite bronze 石墨青铜graphite carbon 石墨碳graphite crucible 石墨坩埚graphite electrode 石墨电极graphite eutectic 石墨共晶graphite metal 铅基轴承合金graphitic carbon 黑铅状碳素graphitic cast iron 灰铸铁graphitic corrosion 石墨腐蚀graphitic embrittlement 石墨脆性graphitic nitralloy 石墨氮化graphitic pig iron 灰口铁graphitic steel 石墨钢graphitizable steel 可石墨化钢graphitization 石墨化graphitizator 石墨化剂graphitized steel 石墨钢graphitizer 石墨化剂graphitizing 石墨化graphitizing annealing 石墨化退火grate 格子grate bar 炉篚grate stoker 链笥煤机grate surface 炉箧grating 炉篦gravimetric analysis 重量分析gravimetric method 重量法gravity casting 重力浇注gravity concentration 重力选矿gravity segregation 重力偏析gravity separation 重力选矿gray body 灰体gray forge pig 可锻灰生铁gray iron 灰铸铁;灰生铁gray slag 灰色矿渣gray tin 灰锡grease marks 油痕green anode 生阳极green brick 不烧砖green compact 生坯压坯green core 湿砂型芯green density 生跑度green gold 绿金green molding 湿砂造型green pellets 生球团green permeability 生砂通气度green sand 湿型砂green sand mold 湿砂型green sludge 绿色淤渣green strength 生趴度green vitriol 绿矾green volume 生佩积greenawalt pan 格林纳瓦尔特盘式烧结机greenockite 硫镉矿grena 原矿grid method 网络法griffith's crack 格里菲思脆性裂纹grindability 粉碎能力grinder 磨床grinding 粉碎grinding machine 磨床grinding paste 研磨膏grinding wheel 研磨砂轮gripper 夹钳gripping 咬入gripping angle 咬入角grit 碎石grit blasting 喷丸清理grizzly 栅筛grog 熟料groove 凹槽;孔型groove angle 坡口角度groove cutting 切槽groove face 坡口面groove rolling 孔型轧制grooved roll 有槽轧辊grooving 孔型设计gross calorific value 总热值gross heating value 总热值group drive 集体传动group teeming car 成盘浇注车growth front 生长阵面guard 导板guard plate 保护板guard valve 安全阀guide 导向装置guide bar 导杆guide box 导板箱guide fittings 轧辊导卫装置guide marks 导卫划痕guide mill 带围板的轧机guide pin 导销guide pulley 导轮guide roll 导辊guide scratch 导卫划痕guillotine shears 铡刀式剪切机guinier preston zone 纪尼埃普雷斯顿区gummite 脂铅铀矿gun 焊枪gun bronze 炮铜gun iron 钢性铸铁gun metal 炮铜gunning mix 喷补混合物gutter 鳞gypsum 石膏gypsum molding 石膏造型gypsum pattern 石膏模型gyratory breaker 旋回破碎机gyratory crusher 旋回破碎机锻造用钢forging stock 锻坯forging tool 锻造用工具fork truck 叉式自动装卸车form drawing 成形拉伸form factor 形状系数form of groove 孔型外形formability 可成形性formed coke 型焦formed section 冷弯型钢former pass 预轧孔型forming 成形forming mill 成形机forming roll 成形辊forming stand 成形机座forsterite 镁橄榄石forsterite refractory 镁橄榄石耐火材料forvacuum 预抽真空forward extrusion 正挤压forward pull 前张力forward slip 前滑forward slip zone 前滑区forward welding 左向焊fosse 铸坑fossil fuel 化石燃料foucault currents 涡流foul electrolyte 废电解液founding 铸造;熔解foundry alloy 中间合金foundry blacking 铸模涂料foundry coke 铸造焦炭foundry iron 铸造用生铁foundry ladle 浇桶foundry pattern 铸造模型foundry pit 铸坑foundry sand 型砂foundry scrap 铸造废钢foundry stove 铸型干燥炉four component alloy 四元合金four component system 四元系four high cold mill 四辊式冷轧机four high finishing stand 四辊精轧机座four high hot mill 四辊式热轧机four high mill 四辊式轧机four high stand 四辊式机座four part alloy 四元合金four plate mold 组合式结晶器four roll pass 四辊孔型four stand mill 四机架轧机fraction 部分fractional column 分馏塔fractional condensation 分级凝缩fractional crystallization 分步结晶fractional dissolution 分步熔解fractional distillation 分级蒸馏fractional extraction 分步萃取fractional precipitation 分级沉淀fractional sublimation 分级升华fractionating column 分馏塔fractionation 分级fractography 断口金相学fracture 断口fracture criterion 断裂指标fracture load 破坏载荷fracture mechanics 断裂力学fracture mechanism 断裂机理fracture nucleation 断裂成核fracture speed 裂纹扩展速度fracture stress 破裂应力fracture test 断口试验fracture toughness 破裂韧性fragility 脆性fragment 碎片fragmentation of grains 细晶化fragmented powder 碎片状粉fragmentized scrap 碎裂废金属frame filter press 框式压滤机francium 钫frank dislocation 弗兰克位错frank read source 弗兰克瑞德源fraze 毛边freckle type segregation 斑点状偏析free carbon 游离碳free cementite 自由渗碳体free convection 自然对流free cutting alloy 易切舷金free cutting brass 易掀铜free cutting property 易切显能free cutting steel 易切钢free cyanide 游离氰化物free energy 自由能free energy of mixing 混合自由能free enthalpy 自由焓free ferrite 自由铁素体free forging 自由锻造free gold 自然金free moisture 游离水分free settling 自由沉降free spread 自由宽展freeze drying 冷冻干燥freezing 冻结freieslebenite 柱硫锑铅银矿frenkel defect 夫伦克耳缺陷frenkel vacancy 夫伦克耳空位frequency 频率frequency curve 频率曲线frequency polygon 频度多边形fretting corrosion 摩擦腐蚀friction 摩擦friction angle 摩擦角friction coefficient 摩擦系数friction drive 摩擦传动friction factor 摩擦系数friction heat 摩擦热friction losses 摩损friction press 摩擦压机friction resistance 摩擦阻力friction saw 摩擦锯friction sawing 摩擦锯切断friction surface 摩擦面friction transmission 摩擦传动friction welding 摩擦焊接frictional force 摩擦力frictional wear 摩擦磨损frictional work 摩擦功fritted hearth 烧结炉床fritting 烧结front mill table 输入辊道front pull 前张力front side 进料侧front wall 前墙frosting 磨砂froth 泡沫froth flotation 泡沫浮选frother 起泡剂frothing 起泡frothing agent 起泡剂fuel 燃料fuel burner 燃料燃烧器fuel cell 燃料电池fuel gas 燃气fuel oil 燃料油fuel oil injection 燃油喷吹fuel rate 燃料比fuel rod 燃料棒fuelflatness 平直度flats 扁钢flattener 矫直机flattening 矫平flattening test 压扁试验flatting mill 轧扁机flaw 缺陷flaw detection 探伤flaw detector 探伤器flaw echo 缺陷的回波信号flection 弯曲flexibility 挠性flexible coupling 弹性联轴节flexible dummy bar 可挠引锭杆flexural rigidity 抗挠刚度flexural strain 挠曲应变flexural strength 挠曲强度flexural stress 挠曲应力flexure 挠曲floating die 浮沉模floating hot top 浮游式保温帽floating mandrel 游动芯棒floating plug 浮动塞棒floating plug drawing 游动顶头拔制floating zone melting 悬浮区域熔炼flocculant 凝聚剂flocculation 凝聚flocculation agent 凝聚剂flood basin 浇口杯floor 平台floor mold 地坑铸型floss hole 烟道清灰口flotation 浮选flotation agent 浮选剂flotation cell 浮选槽flotation concentrate 浮选精矿flotation machine 浮选机flotation process 浮选法flotation pulp 浮选矿桨flotation tailings 浮选尾矿flow chart 撂图flow lines 吕德斯线flow structure 塑变组织flow welding 浇焊flowability 怜性fluctuation 波动flue 烟道flue dust 炉顶灰flue gas 烟气flue gas path 烟道fluid bed 怜床fluid bed smelting 怜床溶炼fluid extrusion 静液力挤压fluid film lubrication 液模润滑fluid friction 铃摩擦fluidity 怜性fluidity spiral 旋涡怜试样fluidity test piece 旋涡怜试样fluidization 连化fluidized bed patenting 怜体淬火fluidized bed process 怜床法fluidized bed reduction 连化床还原fluidized bed roaster 连化床焙烧炉fluidized bed roasting 怜床焙烧fluorescent flaw detection 荧光探伤fluorescent penetrant inspection 荧光渗透检验fluorescent x ray spectroscopy x 射线荧光光谱分析fluorhydric acid 氟酸fluoride 氟化物fluorination 氟化fluorine 氟fluorite 萤石fluorspar 萤石fluosolid roaster 连化床焙烧炉fluosolid roasting 怜床焙烧flush off 排渣flush weld 辖补强焊缝flushing 出渣fluted sheet 波纹钢板fluted tube 沟槽管fluting 开槽flux 熔剂flux backing 焊药垫flux cored electrode 含熔剂芯焊条flux cored wire 含熔剂芯焊条flux cutting 氧熔剂切割flux density 磁通量密度flux oxygen cutting 氧熔剂切割fluxed briquette 自熔性团块fluxed charge 助熔炉料fluxed pellets 自熔性球团fluxible anode 助熔性阳极fluxing agent 熔剂fluxmeter 磁通计fly ash 飘尘flying saw 飞锯flying shears 飞剪flyspun electrode 绕丝焊条flywheel 飞轮foam 泡沫foam flotation 泡沫浮选foamed slag 泡沫渣foamer 起泡剂foaming 起泡foaming agent 起泡剂foamy slag 泡沫渣focused collision 聚焦碰撞focuson 聚焦碰撞fog quenching 喷雾淬火foil 箔foil metal 金属箔foil rolling mill 箔材轧机fold 压折follower plate 挤压垫forced aerated cooling bed 强制通风冷却床forced circulation 强制循环forced convection 强制对流forced cooling 强制冷却forced draught 强制通风fore pump 预真空泵forehand welding 左向焊forehearth 前炉foreign atom 杂质原子foreign nucleus 外来核foreplate 导卫板forest of dislocations 位错林forge 锻造车间forge furnace 锻造炉forge hammer 锻锤forge hearth 锻工炉forge iron 搅炼生铁forge pig 搅炼生铁forge rolling machine 轧锻机forge scale 锻造氧化皮forge welding 锻焊forgeability 可锻性forged roll 锻造辊forged steel 锻钢forging 锻造;锻件forging brass 可锻黄铜forging die 锻模forging furnace 锻造炉forging hammer 锻锤forging ingot 锻造用钢锭forging machine 锻造机forging manipulator 锻造操纵机forging press 锻压机forging property 可锻性forging ratio 锻造比forging rolls 轧锻机forging steel。

iron and steel industry 钢铁工业ironworks 铁厂foundry 铸造车间steelworks, steel mill 钢厂coking plant 炼焦厂electrometallurgy 电冶金学powder metallurgy 粉末冶金学blast furnace 鼓风炉mouth, throat 炉口hopper, chute 料斗stack 炉身belly 炉腰bosh 炉腹crucible 炉缸slag tap 放渣口taphole 出铁口，出渣口pig bed 铸床mould 铸模（美作：mold）tuyere, nozzle 风口ingot mould 锭模（美作：ingot mold）floor 平台hearth 炉底charger 装料机ladle 铁水包，钢水包dust catcher 除尘器washer 洗涤塔converter 转炉hoist 卷扬机compressor 压缩机tilting mixer 可倾式混铁炉regenerator 蓄热室heat exchanger 热交换器gas purifier 煤气净化器turbocompressor 涡轮压缩机burner 烧嘴cupola 化铁炉，冲天炉emptier 排空装置trough 铁水沟，排渣沟skip 料车rolling mill 轧机，轧钢机blooming mill 初轧机roller 辊bed 底座rolling-mill housing 轧机机架drawbench 拔管机，拉丝机drawplate 拉模板shaft furnace 竖炉refining furnace 精炼炉reverberatory furnace 反射炉hearth furnace 床式反射炉firebrick lining 耐火砖衬retort 反应罐muffle 马弗炉roof, arch 炉顶forge 锻造press 压锻pile hammer 打桩锤drop hammer 落锤die 拉模blowlamp 吹炬（美作：blowtorch）crusher 破碎机iron ore 铁矿石coke 焦炭bauxite 铁钒土alumina 铝cryolite 冰晶石flux 熔剂limestone flux 石灰石溶剂haematite 赤铁矿（美作：hematite）gangue 脉石cast iron 铸铁cast iron ingot 铸铁锭slag 炉渣soft iron 软铁pig iron 生铁wrought iron 熟铁iron ingot 铁锭puddled iron 搅炼熟铁round iron 圆铁scrap iron 废铁steel 钢crude steel 粗钢mild steel, soft steel 软钢，低碳钢hard steel 硬钢cast steel 坩埚钢，铸钢stainless steel 不锈钢electric steel 电工钢，电炉钢high-speed steel 高速钢moulded steel 铸钢refractory steel 热强钢，耐热钢alloy steel 合金钢plate, sheet 薄板corrugated iron 瓦垅薄钢板tinplate, tin 马口铁finished product 成品，产品semifinished product 半成品，中间产品ferrous products 铁制品coiled sheet 带状薄板bloom 初轧方坯metal strip, metal band 铁带，钢带billet 坯锭，钢坯shavings 剃边profiled bar 异型钢材shape, section 型钢angle iron 角钢frit 烧结wire 线材ferronickel 镍铁elinvar 镍铬恒弹性钢ferrite 铁氧体，铁醇盐cementite 渗碳体，碳化铁pearlite 珠光体charging, loading 装料，炉料fusion, melting, smelting 熔炼remelting 再熔化，重熔refining 精炼casting 出铁to cast 出铁tapping 出渣，出钢，出铁to insufflate, to inject 注入heating 加热preheating 预热tempering 回火temper 回火hardening 淬水annealing 退火reduction 还原cooling 冷却decarbonization, decarburization 脱碳coking 炼焦slagging, scorification 造渣carburization 渗碳case hardening 表面硬化cementation 渗碳fritting, sintering 烧结puddling 搅炼pulverization 粉化，雾化nitriding 渗氮alloy 合金floatation, flotation 浮选patternmaking 制模moulding 成型（美作：molding）calcination 煅烧amalgamation 汞齐化rolling 轧制drawing 拉拔extrusion 挤压wiredrawing 拉丝stamping, pressing 冲压die casting 拉模铸造forging 锻造turning 车削milling 铣削machining, tooling 加工autogenous welding, fusion welding 氧炔焊arc welding 电弧焊electrolysis 电解trimming 清理焊缝blowhole 气孔weld 焊接采矿mining地下采矿underground mining露天采矿open cut mining, open pit mining, surface mining 采矿工程mining engineering选矿（学）mineral dressing, ore beneficiation, mineral processing矿物工程mineral engineering冶金（学）metallurgy过程冶金（学）process metallurgy提取冶金（学）extractive metallurgy化学冶金（学）chemical metallurgy物理冶金（学）physical metallurgy金属学Metallkunde冶金过程物理化学physical chemistry of process metallurgy 冶金反应工程学metallurgical reaction engineering冶金工程metallurgical engineering钢铁冶金（学）ferrous metallurgy, metallurgy of iron and steel 有色冶金(学)nonferrous metallurgy真空冶金(学)vacuum metallurgy等离子冶金(学)plasma metallurgy微生物冶金(学)microbial metallurgy喷射冶金(学)injection metallurgy钢包冶金(学)ladle metallurgy二次冶金(学)secondary metallurgy机械冶金(学)mechanical metallurgy焊接冶金(学)welding metallurgy粉末冶金(学)powder metallurgy铸造学foundry火法冶金(学)pyrometallurgy湿法冶金(学)hydrometallurgy电冶金(学)electrometallurgy氯冶金(学)chlorine metallurgy矿物资源综合利用engineering of comprehensive utilization of mineralresources中国金属学会The Chinese Society for Metals中国有色金属学会The Nonferrous Metals Society of China2 采矿采矿工艺mining technology有用矿物valuable mineral冶金矿产原料metallurgical mineral raw materials矿床mineral deposit特殊采矿specialized mining海洋采矿oceanic mining, marine mining矿田mine field矿山mine露天矿山surface mine地下矿山underground mine矿井shaft矿床勘探mineral deposit exploration矿山可行性研究mine feasibility study矿山规模mine capacity矿山生产能力mine production capacity矿山年产量annual mine output矿山服务年限mine life矿山基本建设mine construction矿山建设期限mine construction period矿山达产arrival at mine full capacity开采强度mining intensity矿石回收率ore recovery ratio矿石损失率ore loss ratio工业矿石industrial ore采出矿石extracted ore矿体orebody矿脉vein海洋矿产资源oceanic mineral resources矿石ore矿石品位ore grade岩石力学rock mechanics岩体力学rock mass mechanics3 选矿选矿厂concentrator, mineral processing plant 工艺矿物学process mineralogy开路open circuit闭路closed circuit流程flowsheet方框流程block flowsheet产率yield回收率recovery矿物mineral粒度particle size粗颗粒coarse particle细颗粒fine particle超微颗粒ultrafine particle粗粒级coarse fraction细粒级fine fraction网目mesh原矿run of mine, crude精矿concentrate粗精矿rough concentrate混合精矿bulk concentrate最终精矿final concentrate尾矿tailings粉碎comminution破碎crushing磨碎grinding团聚agglomeration筛分screening, sieving分级classification富集concentration分选separation手选hand sorting重选gravity separation, gravity concentration 磁选magnetic separation电选electrostatic separation浮选flotation化学选矿chemical mineral processing 自然铜native copper铝土矿bauxite冰晶石cryolite磁铁矿magnetite赤铁矿hematite假象赤铁矿martite钒钛磁铁矿vanadium titano-magnetite 铁燧石taconite褐铁矿limonite菱铁矿siderite镜铁矿specularite硬锰矿psilomelane软锰矿pyrolusite铬铁矿chromite黄铁矿pyrite钛铁矿ilmennite金红石rutile萤石fluorite高岭石kaolinite菱镁矿magnesite重晶石barite石墨graphite石英quartz方解石calcite石灰石limestone白云石dolomite云母mica石膏gypsum硼砂borax石棉asbestos蛇纹石serpentine阶段破碎stage crushing粗碎primary crushing中碎secondary crushing细碎fine crushing对辊破碎机roll crusher粉磨机pulverizer震动筛vibrating screen筛网screen cloth筛孔screen opening筛上料oversize筛下料undersize粗磨coarse grinding细磨fine grinding球磨机ball mill衬板liner分级机classifier自由沉降free setting沉积sedimentation石灰lime松油pine oil硫化钠sodium sulfide硅酸钠（水玻璃）sodium silicate, water glass过滤filtration过滤机filter给矿，给料feeding给矿机feeder在线分析仪on line analyzer在线粒度分析仪on line size analyzer超声粒度计ultrasonic particle sizer, supersonic particle sizeroscillation摆动, 振动outlet 输出；出口；引出线，电源插座output 产量, 输出, 输出量out yawing外偏航oval nail椭圆钉over speed过速overaging超龄的；老朽的；旧式的over current protection过电流保护overhead-valve engine 顶阀发动机,预置气门发动机overheat加热过度使发展过快，使过热overlap重叠，覆盖overload 超载，过载，过负荷overpressure过压overproduction生产过剩overspeed 超速over voltage过电压oxidation氧化[作用]；氧化层oxyacetylene welding氧乙炔焊风电词汇中英文对照表-IIsaddle. 鞍, 鞍状物safety 安全, 保险, 安全设备, 保险装置sample. 标本, 样品, 例子sand blasting沙暴sander 沙, 沙子, [pl. ] 沙滩, 沙地sandingsandpaper砂纸sandwich夹层，层状[夹心]结构satisfactory符合要求的；合适的saturate. 使饱和, 浸透, 使充满saw 锯sawing machinescaffolding 脚手架scale 刻度，标度；比例尺，标尺；尺度，规模；【动】定标；换算；【WIN,NT】数值，缩放(比例scalene trangle不等边的（三角形）scarringscraper刮器，擦具；鞋刮子；刮刀，刮漆刀scratch 划痕，刻痕；【动】擦除；【修】临时screen 屏(幕,面),荧光屏；筛选；屏蔽；网screw螺丝钉, 螺旋, 螺杆, 螺孔, 螺旋桨, screw callipersscrew clampscrew driverscrew extractor拉马screw jack 螺旋千斤顶screw pitch gaugescrew tap 螺丝攻screw thread. 螺纹screwdriver 螺丝刀,起子scriber划线器, 描绘标记的用具scribing block划线笔sealing密封seam welding接合焊seat座, 座位, 所在地, 场所, 席位secger plierrsecure安全，可靠，保密securedsecurity 安全(性)，保密(性)，安全措施segregation分离，分凝法self-starter自动点火装置；自动启动器self-tapping screw自攻螺丝sensitivity 敏感, 灵敏(度), 灵敏性sensor 传感器，检测器；读出器，感测器；敏感元件sentsequence 顺序，时序；数列；定序，排序，序列series connectionservice 服务，服务程序；业务；维修，维护set screwset squaresetting设置[定]值；设置settle稳定，固定；调整，调度shackle 手铐, 脚镣, 桎梏, 束缚物shaft 轴, 杆状物shank 胫, 腿骨shaping machineshaping toolsharpness锐利shears 剪, 修剪, 剪切sheartubeshicknessshield屏蔽，罩；防护，庇护shim 垫片；填隙片shimming 摇动,震颤,晃动shock 冲击；震动shock absorber 减震器，震动吸收器short circuit. 短路shovel 铲, 铁铲shrink缩小，收缩shutdown 停止系统运行，停工[机]，关机shutter 遮挡板，光闸，光阀；快门shuttle 梭；航天飞机，宇宙飞船，空间渡船；往返空间sidelight侧面射进来的光线, 侧灯,舷灯, 拾零, 杂闻, 间接说明side-valve enginesight glasssimultaneous同时的, 同时发生的sine wave正弦波single phase单相singnalsink 散热器，接收器，转接器；吸收(电流等)；沟(半导体耗尽层的)；汇点，收点；宿，汇集sintering烧结siphon 虹吸管site-mixedskew wind 歪斜，偏斜，扭斜[曲，动]；相位偏移；变形，时滞(同一脉冲通过不同电路的时差)；不齐，不齐量，偏离；【修】歪，斜，扭skin-halveskip 跳跃(进位)；跳行[越，过]；空指令slag. 矿渣, 炉渣, 火山岩渣sledge hammer大锤, 有压服力的东西sleeve 套筒，套管slide 滑动触头；【动】使滑动slide caliperrslide rule计算尺slide valve滑阀sliding滑动，活动；可调整slight 轻微的, 微小的slipping clutchslope 斜坡, 斜面, 倾斜slot 插槽，存储槽，(页)槽；槽口；开缝，存取窗口；裂缝[口]，切口，沟；时间段，时间片slow-running screwsmelting熔炼smooth平稳，平滑snips 剪断socket 插座[槽，孔，口]；管座；套接字(报文包的)；【SunOS】网络界面[接口]；【网】报路[SK]socket spanner套筒扳手soft cut in软切入software软件，软设备soldering 焊料，焊锡；焊接，结合soldering iron 烙铁solenoid螺线管solenoid valve电磁阀solitary单独，唯一solvent溶媒, 溶剂, 解决方法spacer. 取间隔的装置, 逆电流器，衬垫，衬套，衬片spade 铲, 铁锹spanner扳手；活络扳手；扳子sparking plug 火花塞spigot 插口；插头，塞子；(水)龙头spindle 主轴，心轴spinner 微调控制项spiral gear螺旋齿spirit level 水平仪spirit varnishsplash. 溅, 飞溅, 斑点spline方栓, 齿条, 止转楔, 花键splined shaftsplint夹板，托板split bearing分离轴承split pinspokeshave辐刀spot 斑点，点；地点；点焊spot welding点焊sprayer 喷出水沫者, 喷雾, 喷雾器sprig图钉spring 弹簧；【动】弹出spring balance弹簧秤spring washer弹垫spring-bow compasssprocket 链轮齿spur gear正齿轮spur wheel gear正齿轮square 平方；方块；【修】矩形[SQ]，正方形的, 四方的,直角的, 正直的, 公平的, 结清的, 平方的, 彻底的square nut 四方螺母, 螺帽square thread矩形螺纹square-head bolt方头螺栓stabilizer稳定器；平衡器；安定剂stable稳定，稳态stage 级；阶段，程度；【动】登台，升级stain 着色，染色；着色剂；污点stainless 纯洁的, 无瑕疵的, 不锈的stall失速，使失速standard标准(型)，规范，准则；【印】常身；正常体standing 直立的, 停滞的, 固定的, 常备的, 标准的, 常设的standstill静止状态；停顿star drillstart up 发动, 开动starter motor马达启动startup 启动steam engine 蒸汽机steam roller蒸汽压路机, 高压手段steam turbine 蒸汽轮机steel sheet scissorsteel wool钢丝线steering box舵盘steering gear方向齿steering wheel舵轮，方向盘step-down(up) transformer降压器stiffen 变粘, 变硬, 变猛烈stillson wrenchstipulate 规定, 保证stock 库存, 股票, 股份, 托盘, 祖先, 血统, 原料stoker 司炉, 烧炉工人, 加煤机stopcock管闩, 活塞, 活栓, 旋塞阀stoppage 中断, 填塞store 存储，存储器straight edge直刃strange陌生的, 生疏的, 前所未知的, 奇怪的, 奇异的, 不惯的strap 短接，跨接strap wrench绑扎带streak 条纹，拖尾strike 打, 打击, 罢工, 抓, 敲, 搏动, 打动, 穿透strip 条，带，(跨接)片；剥离，脱去，去除striplightstructure结构，构造，构件；structure结构，构造，构件；【C】(数据类型)结构，结构体[STRUC]stub axlestudstuffing box填充体sturdy 强健的, 坚定的, 毫不含糊的substantial 坚固的, 实质的, 真实的, 充实的substation变电所，分站，支局subsynchronous 次[再]同步suck 吸, 吮, 吸取suction. 吸入, 吸力, 抽气, 抽气机, 抽水泵, 吸引summation 求和，总和，加法sump润滑油槽；油盘；机油箱superheated 过热supervise监控，监督support 支援，支持(程序，软件)；配套[SU] surface 表面，曲面；【修】表面，外部surplus 过剩，余量surrounding 围绕物, 环境suspension 吊, 悬浮, 悬浮液, 暂停, 中止, 悬而未决, 延迟，挂起；暂停，中止suspension systemsweating. 出汗的, 吃力的swept planeswitch 开关，转[交，切]换，翻转；接线器switch box开关柜switch off 切断switch over 转变symmetry对称，对称性synchronous同时的, [物]同步的synthetic合成的, 人造的, 综合的Ttachometer转速计，转速器tacktailstocktamperproof 防止窜改，可防止乱摆弄tangent 正切；切线，接触的, 切线的, 相切的, 离题的tank 储能电路；槽，箱，容器；油箱tap 分接头，抽头，三通头,, 活栓, 水龙头tap extractortap wrenchtap-drilltapdrill extensiontape 磁带，纸带；【修】带状tape decktape recordertaper 圆锥；递减；【修】分等级tappet 梃杆, 凸子tarmac 停机坪telephoto lens 远摄镜头,长焦镜头telescopic shaft伸缩轴television 电视, 电视机temperature 温度tempering 回火template样板，金属模片temporary暂时的, 临时的, 临时性tenon凸榫，雄榫，榫舌tenon sawtensile可拉长的, 可伸长的, [物]张力的, 拉力的tension压力, 张力, 牵力, 电压terminal point端子terminate 端接；终止test nipple测试嘴test piecetesthose for manomentert-head bolt T形头螺栓T-head bolt T型螺栓theodolite经纬仪thermal热的；热量的；热力的thermistor热敏电阻，热控管thermocouple温差电偶，热电偶thermograph温度记录器, 热录像仪thermometer . 温度计, 体温计thermostat自动调温器，恒温器thinner稀释剂，冲淡剂thread线, 细丝, 线索, 思路, 螺纹，线索；线程three way switch三路开关three-jaw chuckthrottle valve节流阀throttles节流阀；节流圈；风门thrust bearing推力轴承thyristor硅控整流器，半导体闸流管tie beamtime switch定时开关timing chain调速链timing gear调速齿tip尖头，技巧，端头，触点；忠告，提示toggle joint双态元件，触发器；(乒乓)开关；轮转，(来回)切换tolerance公差，容差[限，许]，允许误差；容错度tolerate忍受, 容忍tommy bar撬棒,螺丝钻tongs钳子, 夹具tongue and groovetooqh强硬的tool box工具箱tool post工具站toolbox工具箱top dead-centretopmost最顶层，最高，最上面torch手电筒，火把；火炬torque arm力臂torque spanner力矩扳手torque wrench力矩扳手torsion扭(转)；扭力；挠率；转矩torsion bar力矩杆torus 环形圆纹曲面，(圆)环面touch 触力；【动】按，揿，触toward. 向, 对于, 为了Towertower crane塔式吊车track rod磁棒tractor. 拖拉机， (履带式)输[进]纸器trailing (轨)迹；跟踪；【WIN】指针train 串，列，系列；链；列车trammel 拘束, 阻碍物, 束缚物transformer变压器transistor 晶体管transmission 传输，发送，传送TransmissionTransmitter发射器，变送器transport 运输；运输工具transverse横切的，横轴transverse engine水平机trapezium梯形travelling crane移动式吊车tread踩，踏treadle踏板trestle架，架柱triac 三端双向可控硅开关元件triangle三角(形)trigger触发trimming清理焊缝triple三层的，三倍的triple phase三相tripod三角架trowel泥刀, 小铲子try square曲尺, 检验角尺t-square丁字尺tubular管状的，管形的turbojet涡轮喷气飞机turbongeneratorturning 旋转, 转向, 转弯处turnstile 十字转门turntable转车, 转盘turret lathe 六角车床twist . 盘旋；缠绕twisting缠绕two-handed sawtwo-stroke engine二冲程发动机Uu-bolt U形螺栓ultrasonic超声波unbalance不平衡unconditional. 无条件地uncritical不加批判的, 无批判力的, 不严厉的under load switch底载荷开关under voltage低电压underfeed stokerundershot wheelundulate起伏uniform一样的union联合；联合会，团结unit单元，部件，单位(符号)；装置，设备，器件universal coupling万向联轴节,万向连接器universal joint万向接头,万向节universal pliers万能手钳unloading卸,去载unscrew从...旋出螺丝, 旋开, 旋松unsymmetry不匀称untwisting拆开(搓合的绳,线等), 解开update更新；修改；校正；重新编辑upstairs楼上的upward向上的upwind迎风,顶风,上升气流Vvacuum真空, 空间vacuum brake真空制动闸vacuum gauge真空计vacuum pump真空泵，真空抽气机vacuum tube真空管，电子管value价值,值valve . 阀, [英] 电子管, 真空管vapour蒸汽, 水蒸气variable resistor可变电阻varistor可变电阻varnish清漆,上漆vat大桶,大槽veebelt V形皮带vehicle交通(运输)工具，飞船，车辆，机动车；步行机器人vencervenn diagram维恩图ventilation通风装置,通风venturi tube文氏管,文丘里管vernier calliper gauge游标尺vernier scale游标尺vertex顶点,角顶,台风转向点via . 道,通路，经过,经由viaduct高架桥vibration颤动，振动；摆动vibration switch0振动开关vice老虎钳,台钳vicinity附近,邻近viewfinder寻像器,取景器viscosity粘度, 粘性visible 可见的,显著的visual可视的，直观，图象，可见[视]，视觉[象]，形象化voltage电压，电位差voltmeter电压表，伏特计volume卷，册，体积，容量；音量v-thread V形螺纹Wwall-shuttering百叶窗wankel engine凡克尔发动机warp弯曲，翘曲，扭曲wash洗涤,冲刷,冲冼washer垫片，垫圈waspalloy瓦斯帕洛伊变形镍基耐热合金waste oil container废油容器watch表,值班water wheel水轮water-antioxidant抗氧化剂water-cooled engine水冷内燃机water-resistant水电阻wave band switch波段开关waveguide波导；波导管wavelength波长wax蜡；蜡状物weaving织；编，编法,摆动weft纬线weighbridge称量台,台秤,桥秤weighing machine称量器weights重量,砝码welding焊接,焊缝wet湿的,湿气,水分whctstonewheel湿的,湿气,水分wheel brace齿轮架wheelbarrow手推车wheelbase轴距whistling号笛,鸣笛，汽笛winch绞车,绞盘wind nut风机用螺母wind vane风向标winding线圈,绕组windscreen挡风玻璃,风挡windscreen wiper风档刮水器,风档雨雪刷windward风档刮水器,风档雨雪刷wing nut蝶型螺母wipe擦，消除wipe off擦掉,抹掉wire导线,电线,金属线wire brush电刷wire dowelwire gaugewire nail线卡wire wool线圈wiredrawing拉丝,拨丝,使延长wire-stripping pliers剥线钳wiring布线,接线wood screw木螺丝wooden block木块wording用语work scissor工作剪workbench工作台workshop车间,工厂worm gear蜗杆螺杆,蜗杆齿wrench扳手,扳子wristwatch手表Xx-axis X轴,横坐标轴xerox静电复印机Yyaw偏航,航偏角Yawy-axis纵坐标，Ｙ轴yield成品；成品率，合格率；输出，产生，得到；屈服Zzink spray镀锌zoom lens 变焦镜头电力系统 power system发电机 generator 励磁 excitation励磁器 excitor 电压 voltage 电流 current升压变压器 step-up transformer 母线 bus 变压器 transformer 空载损耗：no-load loss 铁损：iron loss 铜损：copper loss空载电流：no-load current 有功损耗：reactive loss 无功损耗：active loss输电系统 power transmission system高压侧 high side 输电线 transmission line高压: high voltage 低压：low voltage 中压：middle voltage 功角稳定 angle stability 稳定 stability 电压稳定 voltage stability暂态稳定 transient stability 电厂 power plant 能量输送power transfer交流 AC 直流 DC 电网 power system落点 drop point 开关站 switch station 调节 regulation高抗high voltage shunt reactor 并列的：apposable 裕度margin故障 fault 三相故障 three phase fault 分接头：tap切机generator triping 高顶值high limited value 静态static (state)动态 dynamic (state) 机端电压控制 AVR 电抗 reactance电阻 resistance 功角 power angle 有功（功率） active power 电容器：Capacitor 电抗器：Reactor 断路器：Breaker电动机：motor 功率因数：power-factor 定子：stator阻抗电压：阻抗：impedance 功角：power-angle 电压等级：voltage grade有功负载: active load PLoad 无功负载：reactive load 档位：tap position电阻：resistor 电抗：reactance 电导：conductance电纳：susceptance 上限:upper limit 下限：lower limit正序阻抗：positive sequence impedance 负序阻抗：negative sequence impedance 零序阻抗：zero sequence impedance无功（功率） reactive power 功率因数 power factor 无功电流reactive current斜率 slope 额定 rating 变比 ratio参考值 reference value 电压互感器 PT 分接头 tap仿真分析 simulation analysis 下降率 droop rate 传递函数transfer function框图 block diagram 受端 receive-side 同步 synchronization 保护断路器 circuit breaker 摇摆 swing 阻尼 damping无刷直流电机：Brusless DC motor 刀闸(隔离开关)：Isolator 机端 generator terminal变电站 transformer substation永磁同步电机：Permanent-magnet Synchronism Motor异步电机：Asynchronous Motor三绕组变压器：three-column transformer ThrClnTrans双绕组变压器：douBLE-COLUMN TRANSFORMER DBLCLMNTRANS固定串联电容补偿FIXED SERIES CAPACITOR COMPENSATION双回同杆并架 DOUBLE-CIRCUIT LINES ON THE SAME TOWER单机无穷大系统 ONE MACHINE - INFINITY BUS SYSTEM励磁电流：MAGNETIZING CURRENT 补偿度 DEGREE OF COMPENSATION ELECTROMAGNETIC FIELDS 电磁场失去同步LOSS OF SYNCHRONIZATION装机容量INSTALLED CAPACITY 无功补偿REACTIVE POWER COMPENSATION故障切除时间 FAULT CLEARING TIME 极限切除时间 CRITICAL CLEARING TIME强行励磁 REINFORCED EXCITATION 并联电容器：SHUNT CAPACITOR < 下降特性 DROOP CHARACTERISTICS 线路补偿器 LDC(LINE DROP COMPENSATION)电机学 ELECTRICAL MACHINERY 自动控制理论 AUTOMATIC CONTROL THEORY电磁场 ELECTROMAGNETIC FIELD微机原理 PRINCIPLE OF MICROCOMPUTER电工学 ELECTROTECHNICS PRINCIPLE OF CIRCUITS 电路原理ELECTRICAL MACHINERY 电机学电力系统稳态分析 STEADY-STATE ANALYSIS OF POWER SYSTEM电力系统暂态分析 TRANSIENT-STATE ANALYSIS OF POWER SYSTEM 电力系统继电保护原理 PRINCIPLE OF ELECTRICAL SYSTEM'S RELAY PROTECTION电力系统元件保护原理 PROTECTION PRINCIPLE OF POWER SYSTEM 'S ELEMENT电力系统内部过电压 PAST VOLTAGE WITHIN POWER SYSTEM模拟电子技术基础 BASIS OF ANALOGUE ELECTRONIC TECHNIQUE数字电子技术 DIGITAL ELECTRICAL TECHNIQUE电路原理实验LAB. OF PRINCIPLE OF CIRCUITS电气工程讲座 LECTURES ON ELECTRICAL POWER PRODUCTION电力电子基础BASIC FUNDAMENTALS OF POWER ELECTRONICS高电压工程HIGH VOLTAGE ENGINEERING电子专题实践TOPICS ON EXPERIMENTAL PROJECT OF ELECTRONICS 电气工程概论INTRODUCTION TO ELECTRICAL ENGINEERING电子电机集成系统ELECTRONIC MACHINE SYSTEM电力传动与控制ELECTRICAL DRIVE AND CONTROL电力系统继电保护 POWER SYSTEM RELAYING PROTECTION NEUTRAL POINT EARTHING 中性点接地RESISTANCE EARTHING 电阻接地ARC EXTINCTION COILS 消弧线圈ELECTRIC NETWORK 电网REACTIVE COMPENSATION 无功补偿QUALITY OF POWER 电能质量WUHAN IRON & STEEL CROUP CO. 武汉钢铁集团POWER SUPPLY PLANT 供电厂POWER DIVISION 能源动力公司SUBSTATION 变电站EARTHING NETWORK 地网AIR COMPRESSOR 空压机MAIN DRIVING SYSTEM 主传动CONVERTER 转炉制氧 OXYGEN MAKING轧钢 STEEL ROLLING生产线 PRODUCTION LINE冷轧厂 COLD ROLLING PLANT上海冶金设计研究院SHANGHAI INSTITUTE OF METALLURGY DESIGNING RESEARCH高效节能 ENERGY SAVING OF HIGH EFFICIENCY循环冷却 CIRCULATION COOLING高炉鼓风机 BLAST FURNACE BLOWER汽轮机 TURBINE风机 BLOWER检修 MAINTENANCE基柱 FOUNDATION PILLAR立柱 VERTICAL POST煤气混合加压站 GAS MIXING AND PRESSURING STATION文档简写说明:DFT: DRY FILM THICKNESS干薄片厚度TOWDOC: TOWERDOC.VESTAS.CM网站名称NDT: NON-DESTRUCTIVE TEST非破坏性测试UT : ULTRASONIC INSPECTION超声波测试MT: MAGNETIC PARTICAL EXAMATION磁场微粒测试VMP: VESTAS MULTI-PROCESSOR CONTROLLER VESTAS多功能处理控制系统.VCS： VESTAS CONVERTER SYSTEM VESTAS变频系统F.S.造模法;流砂造模法 F.S. process(fluid sand mixture molding process)面板 face plate护面罩 face shield面心立方格子 face-centered cubic lattice粗晶面(铸疵) facet fracture上涂料 facing涂料 facing materials面砂 facing sand消退 fading消退时限 fading time华氏标度 Fahrenheit scale落砂(铸疵) fall1.合模记号2.假中间模箱 false cheek假上模箱 false cope假模箱 false part风扇 fan高黏土砂 fat sand疲劳 fatigue疲劳裂痕 fatigue crack疲劳破损 fatigue failure疲劳限界 fatigue limit疲劳强度 fatigue strength疲劳试验 fatigue test不良铸造 faulty casting飞边(铸件) feather1.补给2.进料3.补浇 feed冒口,补给头 feed head补给环 feed ring补给用冒口 feed riser补给口(冒口) feeder补给口套 feeder bush补给口效果 feeder effect冒口;补给头 feeder head缩颈冒口 feeder head with Washburn core 冒口捣棒;补给口捣棒 feeder rod补浇(冒口) feeding补给口发热剂(冒口) feeding compound补给距离 feeding distance冒口颈;补给颈 feeding neck冒口捣棒;补给口捣棒 feeding ro补给口带 feeding zone长石 feldspar1.肥粒铁2.肥粒体 ferrite肥粒铸铁 ferritic cast iron铸合金 ferro-alloy硼铁 ferro-boron铬铁 ferro-chromium锰铁 ferro-manganese钼铁 ferro-molybdenum磷铁 ferro-phosphorus矽铁 ferro-silicon铁水静压力 ferro-static pressure钛铁 ferro-titanium钨铁 ferro-tungsten二氧化铁(FeO2) ferrous oxide钒铁 ferro-vanadium清理(清砂,去毛边等) fettle打磨(磨毛边,打浇冒口等) fettle shagging 清理工 fettler清理 fettling清理门 fettling door清理场 fettling shop清理工具 fettling tool纤维状滑石 fibrous talc自然腐蚀试验 field test液面花纹 figure1.填隙料2.埋筋 filler1.填砂2.背砂 filler sand内圆角 fillet带铁 fillet iron灌模能力(浇铸) filling capacity埋入砂心 filling core填砂框 filling frame填砂 filling in填入口;浇口 filling port埋入法(砂心) filling up埋入砂心 filling up core过滤器 filter滤袋 filter bag滤层 filter bed滤布 filter cloth带色防护镜 filter glass滤纸 filter paper滤液 filtrate过滤 filtration过滤式集尘器 filtration dust collector 1.凸片 2.飞边 fin精密研光 fine lapping细密波来铁 fine pearlite细土粉;细泥 fine silt粒度 fineness粒度指数 fineness number砂粒度 fineness of sand指形进模口 finger gate最后加工 finish加工裕度 finish allowance成品铸件区 finished castings department 完工面 finished surface1.铸件清理2.最后加工 finishing加工裕度 finishing allowance细锉刀 finishing file细泥砂浆 finishing loam铸件修整 finishing of castings精轧辊 finishing of roll凸片气缸 finned cylinder凸片管 finned tube飞边现象(合模或模裂形成) finning固定磨轮机(法飞边) fioor grinder枞木 fir火箱 fire box耐火砖 fire brick耐火泥 fire clay粘土质耐火砖 fire clay brick炉栅;炉篦 fire grate炉条 fire grate bar燃点 fire point耐火砂 fire sand火铲 fire shovel耐火石 fire stone炉板(铸件) fireback炉板(铸件) fireback烧裂 fire-crack乾模 fired mold乾模砂 fired mold sand火星罩 fire-spark arrester点火 firing鱼油 fish oil鱼嘴栅 fishmouth gate固定碳 fixed carbon固定环 fixed collar固定模;固定压铸模 fixed die固定模板;固定压铸模板 fixed die plate 定盘式混砂机 fixed pan mill固定板 fixed plate片 flake片状石墨 flake graphite片状石墨铸铁 flake graphite cast iron 火焰退火 flame annealing火焰熔刮 flame gouging火焰硬化 flame hardening凸缘 flange凸缘抹片 flange sleeker表面烘乾砂模 flared mold1.飞边2.闪光 flash手电筒 flash light飞边清除 flash removal砂箱;模箱 flask砂箱隔条 flask bar砂箱夹 flask clamp砂箱手柄 flask handle有箱造模法 flask molding合箱销子 flask pins震箱清砂机 flask shanker无箱造模法 flaskless molding扁刷 flat brush扁凿 flat chisel扁形进模口 flat gate平木纹 flat grain平底舂;平底捣杆 flat rammer平头镘刀 flat trowel瑕疵 flaw瑕疵位置 flaw location瑕疵大小 flaw size击落浇冒口 flogging固定磨轮机(去飞边) floor grinder地模 floor mold地模法;地面造模法 floor molding1.地面砂2.背砂 floor sand1.上浮(石墨)2.浮悬法 flotation流程图 flow chart流通式冷却器 flow cooler溢放口 flow off溢流道 flow through铸砂流动性 flowability of sand流量计 flowmeter烟道气 flue gas流砂(造模用) fluid sand流砂造模法;F.S.造模法fluid sand mixture molding process(F.S. process)流动型自硬性砂模 fluid self-hardening mold sand流动性 fluidity流动性旋涡形试片 fluidity spiral流动性试验 fluidity test流动性直棒形试片 fluidity test bar piece流动性试模 fluidity test mold流体化床 fluidized bed流体化床上涂料 fluidized bed coating流体化床冷却器 fluidized bed cooler流砂(造模用) fluidized sand流砂造模法 fluidized sand molding助流剂 fluidizer萤光 fluorescence萤光探伤法 fluorescent crack detection氟(F) fluorine萤石(CaF2) fluorite萤光镜 fluoroscope萤光透视法(检查);萤光镜试) fluoroscopy萤石(CaF2) fluorspar出铁口熔渣 flush slag1.吹气2.通气处理(金属液)3.冲洗 flushing熔剂;助熔剂 flux熔剂覆盖法 flux-covering1.熔剂处理2.助熔 fluxing飞灰 fly ashF-M造模法;全模法 F-M process(full-mold process) 泡沫洗净器 foam scrubber泡沫塑胶模型 foamed plastic pattern喷雾淬火 fog quenching嵌合模型 follow board〔pattern〕压力通风 forced draft空吹(熔铁炉) fore blow(cupola)前炉 fore-hearth forge(receiver)1.鍜工场2.鍜造炉 forge鍜铁锈皮 forge scale1.鍜造2.鍜件 forging抬动浇桶 fork ladle堆高机 fork lift truck粒形 form of grain模样(砌炉衬用) former成形 forming成形性 forming property铸工 founder铸造 founding铸造方案 founding method1.铸造厂2.铸造 foundry黑色涂料 foundry blacking铸焦 foundry coke铸疵;铸造缺陷 foundry defects浇桶 foundry ladle铸损 foundry losses铸造从业员 foundry man铸造用钉 foundry nails铸造用生铁 foundry pig iron铸坑 foundry pit回炉料 foundry returns铸砂 foundry sand铸砂处理 foundry sand preparation铸砂处理工场 foundry sand preparation plant 铸造废料 foundry scrap断口金相检验 fractography1.破裂2.断口 fracture断口检验 fracture test1.框2.架 frame框架隔条 frame cross piece框架吊柄 frame lift框形砂心盒 framed core box翻转脱模式造模机 frame-rollover machine松扣 free单体碳 free carbon单体雪明碳铁 free cementite单体肥粒铁 free ferrite清水砂 free sand自由水 free water凝固 freezing1.凝固点2.冰点 freezing point凝固范围 freezing range频率变换器;周波变换器 frequency converter磨损;侵蚀 fretting熔砂;烧毁铸砂 fritted sand前端出渣 front slagging燃料 fuel燃料气 fuel gas燃料油 fuel oil燃料比 fuel ratio完全退火 full annealing足尺 full size全模法;F-M造模法 full-mold process(F-M process) 烟气(有害的) fume抽烟气设备 fume extraction equipment*喃系 furan*喃树脂 furan resin*喃树脂黏结剂 furan resin binder*喃(甲)糠醛 furfural糠醛酒精 furfuryl alcohol炉 furnace炉内蒙气 furnace atmosphere炉体 furnace body炉用铸件 furnace castings高炉焦 furnace coke炉内冷却 furnace cooling炉支架 furnace cradle炉气 furnace gas炉衬 furnace lining炉工(美语) furnace tender炉工 furnace-man熔成菱镁石 fused magnesite融砂;熔砂 fused sand1.可熔性2.熔度 fusibility易熔合金 fusible alloy熔锥 fusible cone填料熔接 fusion of packing materials融砂;熔砂 fusion of sand渗透融结(铸疵);渗透熔接 fusion penetration1.熔点2.软化点 fusion point。

金属学与热处理专业英语词汇English:In the field of metallurgy and heat treatment, a comprehensive understanding of specialized English vocabulary is essential for effective communication and comprehension. Key terms include "alloying elements" which are substances added to a base metal to enhance its properties such as strength or corrosion resistance. "Annealing" refers to a heat treatment process that involves heating a material to a specific temperature and then cooling it slowly to relieve internal stresses and increase ductility. "Quenching" is a rapid cooling process typically used to harden metals by immersing them in a quenching medium such as water or oil. "Tempering" follows quenching and involves reheating the metal to a lower temperature to reduce brittleness and improve toughness. "Grain refinement" is the process of reducing the size of grains within a metal structure to enhance its mechanical properties. "Carburizing" involves introducing carbon into the surface of a metal to increase its hardness. "Nitriding" is a similar process but involves introducing nitrogen instead of carbon. "Precipitation hardening" is a heat treatment technique that involves heating a metal to a specifictemperature, holding it there to allow precipitates to form, and then cooling it to trap these precipitates, resulting in increased strength. "Welding" is a joining process that involves melting and fusing materials together to form a strong bond. "Creep" refers to the gradual deformation of a material under constant stress at elevated temperatures over time. "Fatigue" is the weakening of a material due to repeated loading and unloading cycles. "Corrosion" is the deterioration of a material, often a metal, due to chemical reactions with its environment. Understanding these terms is crucial for metallurgists and heat treatment specialists to effectively discuss processes, properties, and phenomena related to metals and their treatments.中文翻译:在冶金和热处理领域，全面了解专业英语词汇对于有效沟通和理解至关重要。

加工方法Manufacturing Method 拉力强度Tensile Strength 机械性能Mechanical Properites低碳钢或铁基层金属Iron & Low Carbon as Base Metal 镀镍Nickel Plated 镀黄铜Brass Plated马氏铁体淬火Marquenching 退火Annealing 淬火Quenching高温回火High Temperature Tempering 应力退火温度Stress –relieving Annealing Temperature晶粒取向(Grain-Oriented)和非晶粒取向(Non-Oriented硬磁材料Hard Magnetic Material表面处理Surface Finish硬度Hardness 电镀方法Plating type 锌镀层质量Zinc Coating Mass表面处理Surface Treatment 拉伸应变Stretcher Strains焊接Welding 防止生锈Rust Protection硬度和拉力Hardness & Tensile strength test 连续铸造法Continuous casting process珠光体Pearlite 单相金属Single Phase Metal Ferrite渗碳体Cementitle奥氏体Austenite软磁Soft Magnetic硬磁Hard Magnetic疲劳测试Impact Test热膨胀系数Coefficient of thermal expansion 比重Specific gravity化学性能Chemical Properties物理性能Physical Properties 再结晶Recrystallization硬化Work Hardening包晶反应Peritectic Reaction包晶合金Peritectic Alloy 共晶Eutectic临界温度Critical temperature 自由度Degree of freedom相律Phase Rule金属间化物Intermetallic compound 固熔体Solid solution 置换型固熔体Substitutional type solid solution米勒指数Mill's Index晶体结构Crystal structure金属与合金Metal and Alloy金属特性Special metallic featuresStrength抗腐蚀和耐用Corrosion & resistance durability强度Strengthen 无机非金属inorganic nonmetallic materials 燃料电池fuel cell新能源new energy resources材料科学专业学术翻译必备词汇材料科学专业学术翻译必备词汇编号中文英文1 合金alloy2 材料material3 复合材料properties4 制备preparation5 强度strength6 力学mechanical7 力学性能mechanical8 复合composite9 薄膜films10 基体matrix11 增强reinforced12 非晶amorphous13 基复合材料composites14 纤维fiber15 纳米nanometer16 金属metal17 合成synthesis 18 界面interface19 颗粒particles20 法制备prepared21 尺寸size22 形状shape23 烧结sintering24 磁性magnetic25 断裂fracture26 聚合物polymer27 衍射diffraction 28 记忆memory29 陶瓷ceramic30 磨损wear31 表征characterization32 拉伸tensile33 形状记忆memory34 摩擦friction35 碳纤维carbon36 粉末powder37 溶胶sol-gel38 凝胶sol-gel39 应变strain40 性能研究properties41 晶粒grain42 粒径size43 硬度hardness44 粒子particles45 涂层coating46 氧化oxidation47 疲劳fatigue48 组织microstructure49 石墨graphite50 机械mechanical51 相变phase52 冲击impact53 形貌morphology54 有机organic55 损伤damage56 有限finite57 粉体powder58 无机inorganic59 电化学electrochemical60 梯度gradient61 多孔porous62 树脂resin63 扫描电镜sem64 晶化crystallizatio n65 记忆合金memory66 玻璃glass67 退火annealing68 非晶态amorphous 69 溶胶-凝胶sol-gel70 蒙脱土montmorillon ite71 样品samples 72 粒度size73 耐磨wear74 韧性toughness75 介电dielectric76 颗粒增强reinforced77 溅射sputtering78 环氧树脂epoxy79 纳米tio tio80 掺杂doped81 拉伸强度strength82 阻尼damping83 微观结构microstructure84 合金化alloying85 制备方法preparation86 沉积deposition87 透射电镜tem88 模量modulus89 水热hydrothermal90 磨损性wear91 凝固solidification92 贮氢hydrogen93 磨损性能wear94 球磨milling95 分数fraction96 剪切shear97 氧化物oxide98 直径diameter99 蠕变creep100弹性模量modulus留纞銅雀樓12:53:02101储氢hydrogen102压电piezoelectric103电阻resistivity104纤维增强composites 105纳米复合材料preparation 106制备出prepared107磁性能magnetic 108导电conductive 109晶粒尺寸size110弯曲bending111光催化tio 112非晶合金amorphous 113铝基复合材料composites 114金刚石diamond115沉淀precipitation116分散dispersion117电阻率resistivity118显微组织microstructure119sic复合材料sic120硬质合金cemented121摩擦系数friction122吸波absorbing123杂化hybrid124模板template125催化剂catalyst126塑性plastic127晶体crystal128sic颗粒sic129功能材料materials130铝合金alloy131表面积surface132填充filled133电导率conductivity134控溅射sputtering135金属基复合材料composites136磁控溅射sputtering137结晶crystallization138磁控magnetron139均匀uniform140弯曲强度strength141纳米碳carbon142偶联coupling143电化学性能electrochemical144和性能properties 145al复合材料composite 146高分子polymer147本构constitutive 148晶格lattice149编织braided150断裂韧性toughness 151尼龙nylon152摩擦磨损性friction 153耐磨性wear154摩擦学tribological 155共晶eutectic156聚丙烯polypropylene157半导体semiconductor158偶联剂coupling159泡沫foam160前驱precursor161高温合金superalloy162显微结构microstructure163氧化铝alumina164扫描电子显微镜sem165时效aging166熔体melt167凝胶法sol-gel168橡胶rubber169微结构microstructure170铸造casting171铝基aluminum172抗拉强度strength173导热thermal174透射电子显微镜tem175插层intercalation176冲击强度impact177超导superconducting178记忆效应memory179固化curing180晶须whisker181溶胶-凝胶法制sol-gel182催化catalytic183导电性conductivity184环氧epoxy185晶界grain186前驱体precursor 187机械性能mechanical 188抗弯strength189粘度viscosity190热力学thermodyna mic191溶胶-凝胶法制备sol-gel 192块体bulk 193抗弯强度strength194粘土clay 195微观组织microstructu re 196孔径pore197玻璃纤维glass198压缩compression199摩擦磨损wear200马氏体martensitic留纞銅雀樓12:53:57201制得prepared202复合材料性能composites203气氛atmosphere204制备工艺preparation205平均粒径size206衬底substrate207相组成phase208表面处理surface209杂化材料hybrid210材料中materials211断口fracture212增强复合材料composites213马氏体相变transformation214球形spherical215混杂hybrid216聚氨酯polyurethane217纳米材料nanometer218位错dislocation219纳米粒子particles220表面形貌surface221试样samples222电学properties223有序ordered224电压voltage225析出phase226拉伸性tensile227大块bulk 228立方cubic229聚苯胺polyaniline 230抗氧化性oxidation 231增韧toughening 232物相phase233表面改性modification 234拉伸性能tensile235相结构phase 236优异excellent237介电常数dielectric238铁电ferroelectric239复合材料力学性能composites240碳化硅sic241共混blends242炭纤维carbon243复合材料层composite244挤压extrusion245表面活性剂surfactant246阵列arrays247高分子材料polymer248应变率strain249短纤维fiber250摩擦学性能tribological251浸渗infiltration252阻尼性能damping253室温下room254复合材料层合板composite255剪切强度strength256流变rheological257磨损率wear258化学气相沉积deposition259热膨胀thermal260屏蔽shielding261发光luminescence262功能梯度functionally263层合板laminates264器件devices265铁氧体ferrite266刚度stiffness 267介电性能dielectric 268xrd分析xrd269锐钛矿anatase270炭黑carbon271热应力thermal272材料性能properties 273溶胶-凝胶法sol-gel 274单向unidirectiona l275衍射仪xrd 276吸氢hydrogen277水泥cement278退火温度annealing279粉末冶金powder280溶胶凝胶sol-gel281熔融melt282钛酸titanate283磁合金magnetic284脆性brittle285金属间化合物intermetallic286非晶态合金amorphous287超细ultrafine288羟基磷灰石hydroxyapatite289各向异性anisotropy290镀层coating291颗粒尺寸size292拉曼raman293新材料materials294tic颗粒tic295孔隙率porosity296制备技术preparation297屈服强度strength298金红石rutile299采用溶胶-凝胶sol-gel300电容量capacity301热电thermoelectric302抗菌antibacterial303聚酰亚胺polyimide304二氧化硅silica305放电容量capacity306层板laminates 307微球microspheres 308熔点melting309屈曲buckling 310包覆coated311致密化densification 312磁化强度magnetizatio n313疲劳寿命fatigue314本构关系constitutive 315组织结构microstructure316综合性能properties317热塑性thermoplastic318形核nucleation319复合粒子composite320材料制备preparation321晶化过程crystallization322层间interlaminar323陶瓷基ceramic324多晶polycrystalline325纳米结构nanostructures326纳米复合composite327热导率conductivity328空心hollow329致密度density330x射线衍射仪xrd331层状layered332矫顽力coercivity333纳米粉体powder334界面结合interface335超导体superconductor336衍射分析diffraction337纳米粉powders338磨损机理wear339泡沫铝aluminum340进行表征characterized341梯度功能gradient342耐磨性能wear343平均粒particle344聚苯乙烯polystyrene 345陶瓷基复合材料composites 346陶瓷材料ceramics 347石墨化graphitizatio n348摩擦材料friction 349熔化melting 350多层multilayer留纞銅雀樓12:55:33 351和其性能properties 352酚醛树脂resin353电沉积electrodeposition354分散剂dispersant355相图phase356复合材料界面interface357壳聚糖chitosan358抗氧化性能oxidation359钙钛矿perovskite360分层delamination361热循环thermal362氢量hydrogen363蒙脱石montmorillonite364接枝grafting365导率conductivity366放氢hydrogen367微粒particles368伸长率elongation369延伸率elongation370烧结工艺sintering371层合laminated372纳米级nanometer373莫来石mullite374磁导率permeability375填料filler376热电材料thermoelectric377射线衍射ray378铸造法casting379粒度分布size380原子力afm381共沉淀coprecipitation382水解hydrolysis 383抗热thermal 384高能球ball385干摩擦friction 386聚合物基polymer 387疲劳裂纹fatigue388分散性dispersion 389硅烷silane390弛豫relaxation 391物理性能properties 392晶相phase 393饱和磁化强度magnetization394凝固过程solidification395共聚物copolymer396光致发光photoluminescence397薄膜材料films398导热系数conductivity399居里curie400第二相phase401复合材料制备composites402多孔材料porous403水热法hydrothermal404原子力显微镜afm405压电复合材料piezoelectric406尼龙6nylon407高能球磨milling408显微硬度microhardness409基片substrate410纳米技术nanotechnology411直径为diameter412织构texture413氮化nitride414热性能properties415磁致伸缩magnetostriction416成核nucleation417老化aging418细化grain419压电材料piezoelectric420纳米晶amorphous421si合金si422复合镀层composite 423缠绕winding 424抗氧化oxidation 425表观apparent 426环氧复合材料epoxy 427甲基methyl428聚乙烯polyethylene 429复合膜composite 430表面修饰surface431大块非晶amorphous 432结构材料materials 433表面能surface434材料表面surface435疲劳性能fatigue436粘弹性viscoelastic437基体合金alloy438单相phase439梯度材料material440六方hexagonal441四方tetragonal442蜂窝honeycomb443阳极氧化anodic444塑料plastics445超塑性superplastic446sem观察sem447烧蚀ablation448复合薄膜films449树脂基resin450高聚物polymer451气相vapor452电子能谱xps453硅烷偶联coupling454团聚particles455基底substrate456断口形貌fracture457抗压强度strength458储能storage459松弛relaxation460拉曼光谱raman461孔率porosity462沸石zeolite463熔炼melting464磁体magnet465sem分析sem466润湿性wettability 467电磁屏蔽shielding 468升温heating469致密dense470沉淀法precipitation 471差热分析dta472成功制备prepared 473复合体系composites 474浸渍impregnation 475力学行为behavior 476复合粉体powders 477沥青pitch478磁电阻magnetoresistance479导电性能conductivity480光电子能谱xps481材料力学mechanical482夹层sandwich483玻璃化glass484衬底上substrates485原位复合材料composites486智能材料materials487碳化物carbide488复相composite489氧化锆zirconia490基体材料matrix491渗透infiltration492退火处理annealing493磨粒wear494氧化行为oxidation495细小fine496基合金alloy497粒径分布size498润滑lubrication499定向凝固solidification500晶格常数lattice留纞銅雀樓12:56:20501晶粒度size502颗粒表面surface503吸收峰absorption504磨损特性wear505水热合成hydrothermal506薄膜表面films507性质研究properties 508试件specimen 509结晶度crystallinity 510聚四氟乙烯ptfe511硅烷偶联剂silane 512碳化carbide 513试验机tester514结合强度bonding 515薄膜结构films516晶型crystal517介电损耗dielectric 518复合涂层coating519压电陶瓷piezoelectric520磨损量wear521组织与性能microstructure522合成法synthesis523烧结过程sintering524金属材料materials525引发剂initiator526有机蒙脱土montmorillonite527水热法制hydrothermal528再结晶recrystallization529沉积速率deposition530非晶相amorphous531尖端tip532淬火quenching533亚稳metastable534穆斯mossbauer535穆斯堡尔mossbauer536偏析segregation537种材料materials538先驱precursor539物性properties540石墨化度graphitization541中空hollow542弥散particles543淀粉starch544水热法制备hydrothermal545涂料coating546复合粉末powder547晶粒长大grain548sem等sem549复合材料组织microstructu re550界面结构interface 551煅烧calcined 552共混物blends553结晶行为crystallizatio n554混杂复合材料hybrid 555laves相laves556摩擦因数friction 557钛基titanium558磁性材料magnetic559制备纳米nanometer560界面上interface561晶粒大小size562阻尼材料damping563热分析thermal564复合材料层板laminates565二氧化钛titanium566沉积法deposition567光催化剂tio568余辉afterglow569断裂行为fracture570颗粒大小size571合金组织alloy572非晶形成amorphous573杨氏模量modulus574前驱物precursor575过冷alloy576尖晶石spinel577化学镀electroless578溶胶凝胶法制备sol-gel579本构方程constitutive580磁学magnetic581气氛下atmosphere582钛合金titanium583微粉powder584压电性piezoelectric585晶须sic586应力应变strain587石英quartz588热电性thermoelectric589相转变phase590合成方法synthesis 591热学thermal 592气孔率porosity 593永磁magnetic 594流变性能rheological 595压痕indentation 596热压烧结sintering 597正硅酸乙酯teos 598点阵lattice599梯度功能材料fgm 600带材tapes601磨粒磨损wear602碳含量carbon603仿生biomimetic604快速凝固solidification605预制preform606差示dsc607发泡foaming608疲劳损伤fatigue609尺度size610镍基高温合金superalloy611透过率transmittance612溅射法制sputtering613结构表征characterization614差示扫描dsc615通过semsem616水泥基cement617木材wood618分析tem619量热calorimetry620复合物composites621铁电薄膜ferroelectric622共混体系blends623先驱体precursor624晶态crystalline625冲击性能impact626离心centrifugal627断裂伸长率elongation628有机-无机organic-inorganic629块状bulk630相沉淀precipitation631织物fabric632因数coefficient 633合成与表征synthesis 634缺口notch635靶材target636弹性体elastomer 637金属氧化物oxide 638均匀化homogenizati on639吸收光谱absorption 640磨损行为wear641高岭土kaolin 642功能梯度材料fgm643滞后hysteresis644气凝胶aerogel645记忆性memory646磁流体magnetic647铁磁ferromagnetic648合金成分alloy649微米micron650蠕变性能creep留纞銅雀樓12:56:46651聚氯乙烯pvc652湮没annihilation653断裂力学fracture654滑移slip655差示扫描量热dsc656等温结晶crystallization657树脂基复合材料composite658阳极anodic659退火后annealing660发光性properties661木粉wood662交联crosslinking663过渡金属transition664无定形amorphous665拉伸试验tensile666溅射法sputtering667硅橡胶rubber668明胶gelatin669生物相容性biocompatibility670界面处interface671陶瓷复合材料composite 672共沉淀法制coprecipitatio n673本构模型constitutive 674合金材料alloy675磁矩magnetic 676隐身stealth677比强度strength 678改性研究modification 679采用粉末powder 680晶粒细化grain681抗磨wear682元合金alloy683剪切变形shear684高温超导superconducting685金红石型rutile686晶化行为crystallization687催化性能catalytic688热挤压extrusion689微观microstructure690tem观察tem691缺口冲击impact692生物材料biomaterials693涂覆coating694纳米氧化nanometer695x射线光电子能谱xps696硅灰石wollastonite697摩擦条件friction698衍射峰diffraction699块体材料bulk700溶质solute701冲击韧性impact702锐钛矿型anatase703凝固组织microstructure704磨损试验机tester705丙烯酸甲酯pmma706光谱raman707减振damping708聚酯polyester709体材料materials 710航空aerospace 711光吸收absorption 712韧化toughening 713疲劳裂纹扩展fatigue 714超塑superplastic 715凝胶法制备gel716半导体材料semiconduct or717剪应力shear718发光材料luminescence 719凝胶法制gel720甲基丙烯酸甲酯pmma721硬质hard722摩擦性能friction723电致变色electrochromic724超细粉powder725增强相reinforced726薄带ribbons727结构弛豫relaxation728光学材料materials729sic陶瓷sic730纤维含量fiber731高阻尼damping732镍基nickel733热导thermal734奥氏体austenite735单轴uniaxial736超导电性superconductivity737高温氧化oxidation738树脂基体matrix739含能energetic740粘着adhesion741穆斯堡尔谱mossbauer742脱层delamination743反射率reflectivity744单晶高温合金superalloy745粘结bonded746快淬quenching747熔融插层intercalation748外加applied749钙钛矿结构perovskite750减摩friction751复合氧化物oxide21 / 21。

冶金专业英语词汇（N）naegite 苗水石nail rod 制钉用铁nantokite 铜盐native copper 自然铜native gold 自然金native iron 自然铁native lead 天然铅native magnet 天然磁铁native mercury 自然汞native metal 自然金属native platinum 自然铂natrium aluminate 铝酸盐natrolite 钠沸石natural aging 自然时效natural amalgam 天然汞膏natural bonded sand 天然粘结砂natural convection 自然对流natural cooling 自然冷却natural draught 自然通风natural gas 天然煤气natural gas injection 天然气体喷入natural graphite 天然石墨natural magnet 天然磁铁natural powder 天然粉natural uranium 天然铀naturally alloyed iron 天然铁合金naturally alloyed steel 天然合金钢naumannite 硒银矿navy bronze 海军青铜necking 形成细颈needle crystal 针状结晶needle type martensite 针状马氏体negative adsorption 负吸附negative allowance 负公差negative catalyst 负催化剂thermocouple pyrometer 热电偶高温计negative crystal 负晶体negative edge dislocation 负刀型位错negative electrode 阴极negative hardening 反淬火negative ion 阴离子negative polarity 逆极性negative pressure 负压negative segregation 反偏析negative strip 负速拉坯negative terminal 负极端子neodymium 钕nepheline 霞石nephelite 霞石nephelometric analysis 浊度分析neptunium 镎net structure 网状组织net weight 净重neumann bands 纽曼带neutral angle 中性角neutral atmosphere 中性气氛neutral flame 中性焰neutral leaching 中性浸出neutral medium 中性介质neutral plane 中性面neutral point 中性点neutral refractory 中性耐火材料neutral salt 中性盐neutral slag 中性炉渣neutral solution 中性液neutral zone 中性区neutrality 中性neutralization 中和neutralization heat 中和热neutralizer 中和剂neutralizing agent 中和剂neutron diffraction 中子衍射neutron irradiation 中子照射neutron radiography 中子射线照相术newton's metal 牛顿易熔合金newtonian viscosity 牛顿粘度ni resist iron 高镍耐热耐蚀合金nicaro process 尼加罗炼镍法niccolite 红砷镍矿nichrome 尼克洛姆镍铬耐热合金nichrome wire 镍铬丝nickel 镍nickel alloy 镍合金nickel base alloy 镍基合金nickel brass 镍黄铜nickel bronze 镍青铜nickel carbonate 碳酸镍nickel carbonyl 羰基镍nickel chloride 氯化镍nickel electrolyte 镍电解液nickel hydroxide 氢氧化镍nickel manganese steel 镍锰钢nickel matte 镍冰铜nickel nitrate 硝酸镍nickel olivine 硅镍矿nickel ore 镍矿nickel oxide 氧化镍nickel plating 镀镍nickel protoxide 氧化亚镍nickel pyrite 镍黄铁矿nickel shot 镍粒nickel steel 镍钢nickel sulfate 硫酸镍nickelin 铜镍锰合金nickeling 镀镍nickelizing 镍电解淀积处理nicking 刻痕nicolayite 硅铝钍铀矿nicrosilal 镍铬硅铸铁nimonic 尼莫尼克合金niobic acid 铌酸niobide 铌化物niobite 铌铁矿niobium 铌niobium oxide 氧化铌nipple 内接头niresist 耐蚀镍合金nital 硝酸化乙醇腐蚀液niter 硝石nitralizing 熔融硝酸钠处理nitralloy 渗氮钢nitrate 硝酸盐nitrating 掺氮nitric acid leaching 硝酸浸出nitride 氮化物nitride inclusion 氮化物夹杂nitride layer 氮化层nitrided case 渗氮层nitrided case depth 渗氮层厚度nitrided ferrochrome 氮铬铁nitriding 氮化nitriding atmosphere 氮化气氛nitriding depth 渗氮层厚度nitriding steel 渗氮钢nitrocarburizing 气体碳氮化nitrogen 氮nitrogen alloyed austenite steel 含氮奥氏钢nitrogen hardening 氮化nitrogenized manganese 氮化锰nitrogenous ferrochrome 氮铬铁nitromuriatic acid 王水no slip region 粘着区no twist rolling 无扭轧制nobelium 锘noble metal 贵金属nodular fire clay 球状耐火粘土nodular graphite 球状石墨nodular powder 球状粉末nodular troostite 细珠光体nodule 球状夹杂物nominal upset force 公称镦锻力nonaging steel 无时效钢noncaking coal 非结焦煤noncoking coal 非结焦煤nonconservative motion 非守恒运动nonconsumable electrode 非自耗电极noncontinuous cooling 断续冷却noncorrosive steel 不锈钢nondeforming steel 不变形钢nondestructive inspection 非破坏检查nondestructive test 非破坏试验nonelectrolyte 非电解质nonferrous alloy 非铁合金nonferrous electrode 有色金属焊条nonferrous metal 非铁金属nonferrous metallurgy 非铁金属冶金nonferrous welding 有色金属焊接nonideal solution 非理想溶液nonintegrated steelworks 非联合的钢铁厂nonmagnetic alloy 非磁性合金nonmagnetic material 非磁体nonmagnetic steel 无磁性钢nonmagnetic substance 非磁体nonmetal 非金属nonmetallic inclusion 非金属夹杂物nonmetallic phase 非金属相nonmiscibility 非混溶性nonoxidizing heating 无氧化加热nonpolar compound 非极性化合物nonrefractory alloy 非耐热合金nonreversibility 不可逆性nonreversing mill 非可逆式轧机nonsizing 尺寸走样nonslip point 中性点nontarnishing alloy 抗变色合金nonuniform deformation 非均匀变形nonuniformity 不均匀性nonvariant system 不变系nonwaste technology 无废料生产工艺normal distribution 正态分布normal electrode 标准电极normal element 标准电池normal force 法向力normal polarity 正极性normal segregation 正偏析normal solution 规度溶液normal state 标准状态normal stress 法向应力normal swelling 正常膨张normal thermometer 标准温度计thermocouple pyrometer 热电偶高温计normalization 规格化normalized steel 正火钢normalizing 正火normalizing furnace 正火炉notch 缺口notch bar bending test 缺口弯曲试验notch brittleness 缺口脆性notch effect 缺口效应notch fatigue factor 缺口疲劳系数notch impact strength 缺口冲煌度notch root 缺口根部notch sensitivity 缺口灵感度notch specimen 缺口试样notched bar impact test 缺口冲辉验notched bar toughness 缺口韧性notched bending test 缺口弯曲试验notching 缺口nozzle 喷嘴nucleant 成核剂nuclear corrosion 核腐蚀nuclear fuel 核燃料nuclear magnetic resonance 核磁共振nuclear metallurgy 核燃料冶金nuclear reaction 核反应nuclear steelmaking 核炼钢nucleating agent 成核剂nucleation 核生成nucleation catalyst 成核剂nucleation rate 成核率nucleus 核nucleus of crystallization 晶核nugget 天然块金。